Compact Multiprotocol I/O Module for Ethernet
16 Universal Digital Channels, Configurable as PNP Inputs or 2 A Outputs
TBEN-L5-16DXP
■ PROFINET® device, EtherNet/IP™ de-
vice or Modbus® TCP slave
■ Integrated Ethernet switch
■ Supports 10 Mbps/100 Mbps
■ 2x M12, 4-pin, D-coded, Ethernet field-
bus connection
■ 7/8" connector for power supply, 5-pin
■ Separated power groups for safety
shutdown
■ Input diagnostics per port
■ Max. 2 A per output
■ Output diagnostics per channel
■ Two freely selectable digital channels
per port
Type designation TBEN-L5-16DXP
Ident-No. 6814088
Supply
Supply voltage 24 VDC
Admissible range 18…30 VDC
Total current max. 9 A per voltage group
Total current V1 + V2 max. 11 A
Voltage supply connection 5-pin male 7/8" connector X1
Sensor/Actuator supply V
Sensor/Actuator supply V
Electrical isolation galvanic isolation of the voltage groups V1 and V2,
AUX1
AUX2
supply of ports C0-C3 from V1
short-circuit proof, 120 mA per port
supply of ports C4-C7 from V2
short-circuit proof, 120 mA per port
voltages up to 500 VAC
■ FLC/ARGEE programmable
■ Glass-fiber reinforced housing
■ Shock and vibration tested
■ Fully potted module electronics
■ Protection classes IP65 / IP67 / IP69K
System data
Fieldbus transmission rate 10 Mbps/100 Mbps
Fieldbus connection technology 2 x M12, 4-pin, D-coded
Protocol detection automatic
Web server Default: 192.168.1.254
Service interface Ethernet via P1 or P2
Field Logic Controller (FLC)
Supported from firmware version 3.2.9.0
Released from ARGEE version 2.0.24.0
Modbus TCP
Addressing Static IP, DHCP
Supported function codes FC1, FC2, FC3, FC4, FC5, FC6, FC15, FC16, FC23
Number of TCP connections 8
Input register start address 0 (0x0000 hex)
Output register start address 2048 (0x0800 hex)
EtherNet/IP™
Addressing acc. to EtherNet/IP™ specification
Quick Connect (QC) < 150 ms
Device Level Ring (DLR) supported
Class 3 connections 3
Class 1 connections 10
Input Assembly Instance 101
Output Assembly Instance 116
Configuration Assembly Instance 1
Edition • 2019-01-21T19:37:08+01:00
1 / 6 TURCK Inc.
Compact Multiprotocol I/O Module for Ethernet
16 Universal Digital Channels, Configurable as PNP Inputs or 2 A Outputs
TBEN-L5-16DXP
PROFINET
Addressing DCP
Conformance class B (RT)
MinCycleTime 1 ms
Fast Start-Up (FSU) < 150 ms
Diagnostics acc. to PROFINET alarm handling
Topology detection supported
Automatic addressing supported
Media Redundancy Protocol (MRP) supported
Digital inputs
Number of channels 16
Connectivity inputs M12, 5-pin
Input type PNP
Type of input diagnostics Group diagnostics
Switching threshold EN 61131-2 Typ 3, PNP
Low level signal voltage < 5 V
High level signal voltage > 11 V
Low level signal current < 1.5 mA
High level signal current > 2 mA
Input delay 2.5 ms
Electrical isolation galvanic isolation to P1/P2
, voltages up to 500 VDC
Digital outputs
Number of channels 16
Connectivity outputs M12, 5-pol
Output type PNP
Type of output diagnostics Channel diagnostics
Output voltage 24 VDC from potential group
Output current per channel 2.0 A, short-circuit proof, max. 2.0 A per port
Output delay 1.3 ms
Load type EN 60947-5-1: DC-13
Short-circuit protection yes
Electrical isolation galvanic isolation to P1/P2
, voltages up to 500 VDC
Standard/Directive conformity
Vibration test acceleration to 20 g
acc. to EN 60068-2-6
Shock test acc. to EN 60068-2-27
Drop and topple acc. to EN 60068-2-31/IEC 60068-2-32
Electromagnetic compatibility acc. to EN 61131-2
Approvals and certificates CE, FCC
UL Certificate cULus LISTED 21 W2, Encl.Type 1 IND.CONT.EQ.
General Information
Dimensions (W x L x H) 60.4 x 230.4 x 39mm
Operating temperature -40…+70 °C
Storage temperature -40…+85 °C
Altitude max. 5000 m
Protection class IP65
IP67
IP69K
MTTF 148 years acc. to SN 29500 (Ed. 99) 20 °C
Housing material PA6-GF30
Housing color Black
Window material Lexan
Material screw 303 stainless steel
Material label Polycarbonate
Halogen-free yes
Mounting 2 mounting holes Ø 6.3 mm
Edition • 2019-01-21T19:37:08+01:00
2 / 6 TURCK Inc.
Compact Multiprotocol I/O Module for Ethernet
16 Universal Digital Channels, Configurable as PNP Inputs or 2 A Outputs
TBEN-L5-16DXP
Accessories
Ethernet cable (example):
RSSD RSSD 441-2M
Ident no. U-02482
Accessories
Accessories:
Connection cable , 2-channel (example):
RK 4.4T-2-RS 4.4T
Ident no. U2445
Splitter, 1-channel (example):
YB2-FSM 4.5-2FKM 4.5
Ident no. U0875-78
M12 x 1 Ethernet
M12 x 1 I/O Port
Accessories
Power supply cable (example):
RSM RKM 50-2M
Ident no. U2282-0
7/8'' Power Supply
Edition • 2019-01-21T19:37:08+01:00
3 / 6 TURCK Inc.
Compact Multiprotocol I/O Module for Ethernet
16 Universal Digital Channels, Configurable as PNP Inputs or 2 A Outputs
TBEN-L5-16DXP
Module LED Status
LED Color Status Description
ETH1 / ETH2 Green ON Ethernet link (100 Mbps)
flashing Ethernet communication (100 Mbps)
Yellow ON Ethernet link (10 Mbps)
flashing Ethernet communication (10 Mbps)
OFF No Ethernet link
BUS Green ON Active connection to a master
Flashing Steady flashing: Ready
Sequence of 3 flashes in 2 seconds: FLC/ARGEE active
Red ON IP address conflict or Restore Mode or Modbus timeout
Flashing Blink/Wink command active
Green/red Alternating Autonegotiation and/or waiting for DHCP/Boot-P addressing
OFF Power off
ERR Green ON Diagnostics disabled
Red ON Diagnostics enabled
V2 undervoltage diagnosis is parameter-dependent
PWR
LED response parameter (PWR) at V2 Undervoltage = "red"
Green ON V1 and V2 power on
Red ON V2 power off or below defined tolerance of 18 V
OFF V1 power off or below defined tolerance of 18 V
LED response parameter (PWR) at V2 Undervoltage = "green"
Green ON V1 and V2 power on
Flashing V2 power off or below defined tolerance of 18 V
OFF V1 power off or below defined tolerance of 18 V
LED Status I/O
LED Color Status Description
LED 0 … 15 Green ON Input or output active
ON Output active with overload/short circuitRed
flashing Power overload at the corresponding port. Both port LEDs are flashing.
OFF Input or output inactive
Edition • 2019-01-21T19:37:08+01:00
4 / 6 TURCK Inc.
Compact Multiprotocol I/O Module for Ethernet
16 Universal Digital Channels, Configurable as PNP Inputs or 2 A Outputs
TBEN-L5-16DXP
Process Data Mapping of the Single Protocols
For more details on the corresponding protocols see manual.
Modbus TCP Register Mapping
Reg Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
Inputs (RO) 0x0000 DI15
Status (RO) 0x0001 - FCE - - CFG COM V1 - V2 - - - - - - Diag
Diag (RO) 0x0002 - - - - - - - - - - - - - - - I/O
Outputs (RW) 0x0800 DO15
I/O Diag (RO) 0xA000 SCO7 SCO6 SCO5 SCO4 SCO3 SCO2 SCO1 SCO0 SCS7 SCS6 SCS5 SCS4 SCS3 SCS2 SCS1 SCS0
I/O Diag (RO) 0xA001 - - - - - - - - SCO15 SCO14 SCO13 SCO12 SCO11 SCO10 SCO9 SCO8
EtherNet/IP™ data mapping with activated scheduled diagnostics, default settings
Word Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
Input data (station -> scanner)
GW status 0 - FCE - - CFG COM V1 - V2 - - - - - - Diag
Inputs 1 DI15
Diag 1 2 - - Sched
Diag 2 3 SCO7 SCO6 SCO5 SCO4 SCO3 SCO2 SCO1 SCO0 SCS7 SCS6 SCS5 SCS4 SCS3 SCS2 SCS1 SCS0
Diag 3 4 - - - - - - - - SCO15 SCO14 SCO13 SCO12 SCO11 SCO10 SCO9 SCO8
Output data (scanner -> station)
Control 0 reserved
Outputs
EtherNet/IP™ data mapping with activated summarized diagnostics
Input data (station -> scanner)
GW status 0 - FCE - - CFG COM V1 - V2 - - - - - - Diag
Inputs 1 DI15
Diag 1 2 - I/O
Output data (scanner -> station)
Control 0 reserved
Outputs
PROFINET process data
Inputs
Outputs
Key:
DIx Digital input channel x CFG I/O Configuration error
DOx Digital output channel x FCE I/O-ASSISTANT Force Mode active
Cx Port x I/ODiag I/O diagnostics connected
Px Pin x SchedDiag Manufacturer-specific diagnostics configured and active
DiagWarn Diagnostic at least on 1 channel SCSx Short-circuit at port x
Edition • 2019-01-21T19:37:08+01:00
V1 Undervoltage V1 SCG1 Short-circuit supply ports C0-C3
5 / 6 TURCK Inc.
1 DO15
Word Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
1 DO15
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0 DI8
1 DI16
0 DO8
1 DO16
C7P2
C7P2
C7P2
C7P2
C7P2
C7P2
C4P2
C8P2
C4P2
C8P2
DI14
C7P4
DO14
C7P4
DI14
C7P4
DO14
C7P4
DI14
C7P4
DO14
C7P4
DI13
C6P2
DO13
C6P2
DI13
C6P2
Diag
DO13
C6P2
DI13
C6P2
DO13
C6P2
DI12
DI11
DI10
DI9
DI8
DI7
DI6
DI5
DI4
DI3
DI2
C6P4
C5P2
C5P4
C4P2
C4P4
C3P2
C3P4
C2P2
C2P4
C1P2
C1P4
DO12
DO11
DO10
DO9
DO8
DO7
DO6
DO5
DO4
DO3
DO2
C6P4
C5P2
C5P4
C4P2
C4P4
C3P2
C3P4
C2P2
C2P4
C1P2
C1P4
DI12
DI11
DI10
DI9
DI8
DI7
DI6
DI5
DI4
DI3
DI2
C6P4
C5P2
C5P4
C4P2
C4P4
C3P2
C3P4
C2P2
C2P4
C1P2
C1P4
- - - - - - - - - - - - I/O
DO12
DO11
DO10
DO9
DO8
DO7
DO6
DO5
DO4
DO3
DO2
C6P4
C5P2
C5P4
C4P2
C4P4
C3P2
C3P4
C2P2
C2P4
C1P2
C1P4
DI12
DI11
DI10
DI9
DI8
DI7
DI6
DI5
DI4
DI3
DI2
C6P4
C5P2
C5P4
C4P2
C4P4
C3P2
C3P4
C2P2
C2P4
C1P2
C1P4
DO12
DO11
DO10
DO9
DO8
DO7
DO6
DO5
DO4
DO3
DO2
C6P4
C5P2
C5P4
C4P2
C4P4
C3P2
C3P4
C2P2
C2P4
C1P2
C1P4
DI7
C4P4
DI15
C8P4
DO7
C4P4
DO15
C8P4
DI6
C3P2
DI14
C7P2
DO6
C3P2
DO14
C7P2
DI5
C3P4
DI13
C7P4
DO5
C3P4
DO13
C7P4
DI4
C2P2
DI12
C6P2
DO4
C2P2
DO12
C6P2
DI3
C2P4
DI11
C6P4
DO3
C2P4
DO11
C6P4
DI2
C1P2
DI10
C5P2
DO2
C1P2
DO10
C5P2
DI1
C0P2
DO1
C0P2
DI1
C0P2
DO1
C0P2
DI1
C0P2
DO1
C0P2
DI0
C0P4
Warn
Diag
DO0
C0P4
Warn
DI0
C0P4
Diag
DO0
C0P4
Warn
DI0
C0P4
Diag
DO0
C0P4
DI1
C1P4
DI9
C5P4
DO1
C1P4
DO9
C5P4
Compact Multiprotocol I/O Module for Ethernet
16 Universal Digital Channels, Configurable as PNP Inputs or 2 A Outputs
TBEN-L5-16DXP
V2 Undervoltage V2 SCG2 Short-circuit supply ports C4-C7
COM Communication error on internal module bus SCOx Short-circuit output channel x
Edition • 2019-01-21T19:37:08+01:00
6 / 6 TURCK Inc.
Loading...