Ethernet Spanner
Master to master data exchange, NAT router, 16 digital PNP inputs
TBEN-L4-EN1
Type designation TBEN-L4-EN1
Ident-No. 6814037
Supply
Supply voltage 24 VDC
Admissible range 18…30 VDC
Total current max. 9 A per voltage group V1
Voltage supply connection 4-pin male 7/8" connector X1
Sensor/Actuator supply V
Electrical isolation galvanic isolation of the voltage groups V1 and V2,
AUX1
supply of ports C0-C7 from V1
short-circuit proof, 120 mA per port
voltages up to 500 VAC
■ Two separate, electrically isolated Eth-
ernet interfaces
■ Bi-directional data exchange between
two networks
■ Protocol conversion between Ether-
Net/IP™, Modbus® TCP and Profinet®
■ PROFInet® is supported on P2 Ethernet
port
■ 1:1 NAT router
■ 10 Mbps/100 Mbps supported
■ 2x M12, 4-pin, D-coded, Ethernet field-
bus connection
■ 7/8" connector for power supply, 4-pin
■ Input diagnostics per port
■ Glass-fiber reinforced housing
■ Shock and vibration tested
■ Fully potted module electronics
■ Protection classes IP65 / IP67 / IP69K
System data
Fieldbus transmission rate 10 Mbps/100 Mbps
Fieldbus connection technology 2 x M12, 4-pin, D-coded
Web server default: 192.168.1.254
Service interface Ethernet via P1
Modbus TCP
Addressing Static IP, BOOTP, DHCP
Supported function codes FC1, FC2, FC3, FC4, FC5, FC6, FC15, FC16, FC23
Number of TCP connections 8
EtherNet/IP™
Addressing acc. to EtherNet/IP™ specification
Class 1 connections 3
Digital inputs
Number of channels 16
Connectivity inputs M12, 5-pin
Input type PNP
Type of input diagnostics Group diagnostics
Switching threshold EN 61131-2 Typ 3, PNP
Low level signal voltage < 5 V
High level signal voltage > 11 V
Low level signal current < 1.5 mA
High level signal current > 2 mA
Input delay 2.5 ms
Electrical isolation galvanic isolation to P1/P2
, voltages up to 500 VDC
Standard/Directive conformity
Vibration test acceleration to 20 g
acc. to EN 60068-2-6
Shock test acc. to EN 60068-2-27
Drop and topple acc. to EN 60068-2-31/IEC 60068-2-32
Electromagnetic compatibility acc. to EN 61131-2
Approvals and certificates CE, FCC
UL Certificate cULus LISTED 21 W2, Encl.Type 1 IND.CONT.EQ.
Edition • 2019-01-21T19:17:06+01:00
1 / 5 TURCK Inc.
Ethernet Spanner
Master to master data exchange, NAT router, 16 digital PNP inputs
TBEN-L4-EN1
General Information
Dimensions (W x L x H) 60.4 x 230.4 x 39mm
Operating temperature -40…+70 °C
Storage temperature -40…+85 °C
Altitude max. 5000 m
Protection class IP65
IP67
IP69K
MTTF 205 years acc. to SN 29500 (Ed. 99) 20 °C
Housing material PA6-GF30
Housing color Black
Window material Lexan
Material screw 303 stainless steel
Material label Polycarbonate
Halogen-free yes
Mounting 2 mounting holes � 6.3 mm
Note the numbering of the IO range:
From firmware version 3.0.11.0 and higher, ports C0
to C7 and channels CH0 to CH7 are counted. For
more details on the corresponding change see man-
ual.
Edition • 2019-01-21T19:17:06+01:00
2 / 5 TURCK Inc.
Ethernet Spanner
Master to master data exchange, NAT router, 16 digital PNP inputs
TBEN-L4-EN1
Accessories
Ethernet cable (example):
RSSD RSSD 441-2M
Ident no. U-02482
Accessories
Accessories:
Connection cable , 2-channel (example):
RK 4.4T-2-RS 4.4T
Ident no. U2445
Splitter, 1-channel (example):
YB2-FSM 4.5-2FKM 4.5
Ident no. U0875-78
Accessories
Power supply cable (example):
RSM RKM 40-2M
Ident no. U2280-0
M12 x 1 Ethernet
M12 x 1 Input
7/8'' Power Supply
Edition • 2019-01-21T19:17:06+01:00
3 / 5 TURCK Inc.
Ethernet Spanner
Master to master data exchange, NAT router, 16 digital PNP inputs
TBEN-L4-EN1
Module LED Status
LED Color Status Description
ETH1 / ETH2 Green ON Ethernet link (100 Mbps)
flashing Ethernet communication (100 Mbps)
Yellow ON Ethernet link (10 Mbps)
flashing Ethernet communication (10 Mbps)
OFF No Ethernet link
BUS Green ON Active connection to a master
flashing Ready
Red ON Network error or Restore Mode or Modbus timeout
flashing Blink/Wink command active
OFF Power off
ERR Green ON Diagnostics disabled
Red ON Diagnostics enabled
V2 undervoltage diagnosis is parameter-dependent
PWR Green ON Power supply V1 OK
OFF V1 power off or below defined tolerance of 18 V
LED Status I/O
LED Color Status Description
LED 0 … 15 Green ON Input active
Red flashing Power overload at the corresponding port. Both port LEDs are flashing.
OFF Input inactive
Edition • 2019-01-21T19:17:06+01:00
4 / 5 TURCK Inc.
Ethernet Spanner
Master to master data exchange, NAT router, 16 digital PNP inputs
TBEN-L4-EN1
Process Data Mapping of the Single Protocols
For more details on the corresponding protocols see manual.
Modbus TCP Register Mapping
The address ranges are valid for both networks.
Reg Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
Inputs (RO) 0x0000 DI15
Status (RO) 0x0001 - FCE SPE1 SPE2 CFG COM V1 - V2 - - - - - - Diag
Diag (RO) 0x0002 - - - - - - - - - - - - - - - I/O
Spanner Input
Data (RO)
Spanner Output
Data (WR)
I/O Diag (RO) 0xA000 SCS7 SCS6 SCS5 SCS4 SCS3 SCS2 SCS1 SCS0
EtherNet/IP™ data mapping with activated scheduled diagnostics, default settings
The address ranges are valid for both networks.
Input Data (Station -> Scanner)
GW Status 0 - FCE SPE1 SPE2 CFG COM V1 - V2 - - - - - - Diag
Inputs 1 DI15
Diag 1 2 - - - - - - - - - - - - - - - I/O
Diag 2 3 SCS7 SCS6 SCS5 SCS4 SCS3 SCS2 SCS1 SCS0
Spanner 4-243 580 bytes
Output Data (Scanner -> Station)
Spanner 4-243 580 bytes
PROFINET process data
Inputs 0 DI7
Key:
DIx Digital input channel x CFG I/O configuration error
DOx Digital output channel x FCE I/O-ASSISTANT Force Mode active
Cx Port x I/ODiag I/O diagnostics connected
Px Pin x SchedDiag Manufacturer-specific diagnostics configured and active
DiagWarn Diagnostic at least on 1 channel SCSx Short-circuit at port x
V1 Undervoltage V1 SCG1 Short-circuit supply ports C0-C3
V2 Undervoltage V2 SCG2 Short-circuit supply ports C4-C7
COM Communication error on internal module bus SCOx Short-circuit output channel x
SPEx Spanner port active
0x3000 -
0x30EF
0X3400 -
0x34EF
Word Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
0-3 reserved
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
1 DI15
580 Bytes
580 Bytes
C7P2
C7P2
C3P2
C72
DI14
C7P4
DI14
C7P4
DI13
C6P2
DI13
C6P2
DI6
C3P4
DI14
C7P4
DI12
C6P4
DI12
C6P4
DI11
C5P2
DI11
C5P2
DI5
C2P2
DI13
C6P2
DI10
C5P4
DI10
C5P4
DI9
C4P2
DI9
C4P2
DI4
C2P4
DI12
C6P4
DI8
C4P4
DI8
C4P4
DI7
C3P2
DI7
C3P2
DI3
C1P2
DI10
C5P2
DI6
C3P4
DI6
C3P4
DI5
C2P2
DI5
C2P2
DI2
C1P4
DI9
C5P4
DI4
C2P4
DI4
C2P4
DI3
C1P2
DI3
C1P2
DI1
C0P2
DI8
C4P2
DI2
C1P4
DI2
C1P4
DI1
C0P2
DI1
C0P2
DI0
C0P4
Warn
Diag
Warn
DI0
C0P4
Diag
DI0
C0P4
DI7
C4P4
Edition • 2019-01-21T19:17:06+01:00
5 / 5 TURCK Inc.
Loading...