Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs and 8 Digital PNP Outputs 2 A
TBEN-L4-8DIP-8DOP
Type designation TBEN-L4-8DIP-8DOP
Ident-No. 6814010
Supply
Supply voltage 24 VDC
Admissible range 18…30 VDC
Total current max. 9 A per voltage group
Total current V1 + V2 max. 11 A
Voltage supply connection 4-pin male 7/8" connector X1
Sensor/Actuator supply V
Sensor/Actuator supply V
Electrical isolation galvanic isolation of the voltage groups V1 and V2,
AUX1
AUX2
supply of ports C0-C3 from V1
short-circuit proof, 120 mA per port
supply of ports C4-C7 from V2
short-circuit proof, 120mA per port
voltages up to 500 VAC
■ PROFINET® device, EtherNet/IP™ de-
vice or Modbus® TCP slave
■ Integrated Ethernet switch
■ Supports 10 Mbps/100 Mbps
■ 2x M12, 4-pin, D-coded, Ethernet field-
bus connection
■ 7/8" connector for power supply, 4-pin
■ Separated power groups for safety
shutdown
■ Input diagnostics per port
■ Max. 2 A per output
■ Output diagnostics per channel
■ FLC/ARGEE programmable
■ Glass-fiber reinforced housing
■ Shock and vibration tested
■ Fully potted module electronics
■ Protection classes IP65 / IP67 / IP69K
System data
Fieldbus transmission rate 10 Mbps/100 Mbps
Fieldbus connection technology 2 x M12, 4-pin, D-coded
Protocol detection automatic
Web server Default: 192.168.1.254
Service interface Ethernet via P1 or P2
Field Logic Controller (FLC)
Supported from firmware version 3.2.9.0
Released from ARGEE version 2.0.24.0
Modbus TCP
Addressing Static IP, DHCP
Supported function codes FC1, FC2, FC3, FC4, FC5, FC6, FC15, FC16, FC23
Number of TCP connections 8
Input register start address 0 (0x0000 hex)
Output register start address 2048 (0x0800 hex)
EtherNet/IP™
Addressing acc. to EtherNet/IP™ specification
Quick Connect (QC) < 150 ms
Device Level Ring (DLR) supported
Class 3 connections 3
Class 1 connections 10
Input Assembly Instance 101
Output Assembly Instance 116
Configuration Assembly Instance 1
Edition • 2019-01-21T18:54:21+01:00
1 / 5 TURCK Inc.
Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs and 8 Digital PNP Outputs 2 A
TBEN-L4-8DIP-8DOP
PROFINET
Addressing DCP
Conformance class B (RT)
MinCycleTime 1 ms
Fast Start-Up (FSU) < 150 ms
Diagnostics acc. to PROFINET alarm handling
Topology detection supported
Automatic addressing supported
Media Redundancy Protocol (MRP) supported
Digital inputs
Number of channels 8
Connectivity inputs M12, 5-pin
Input type PNP
Type of input diagnostics Group diagnostics
Switching threshold EN 61131-2 Typ 3, PNP
Low level signal voltage < 5 V
High level signal voltage > 11 V
Low level signal current < 1.5 mA
High level signal current > 2 mA
Input delay 2.5 ms
Electrical isolation galvanic isolation to P1/P2
, voltages up to 500 VDC
Digital outputs
Number of channels 8
Connectivity outputs M12, 5-pol
Output type PNP
Type of output diagnostics Channel diagnostics
Output voltage 24 VDC from potential group
Output current per channel 2.0 A, short-circuit proof, max. 2.0 A per port
Output delay 1.3 ms
Load type EN 60947-5-1: DC-13
Short-circuit protection yes
Electrical isolation galvanic isolation to P1/P2
, voltages up to 500 VDC
Standard/Directive conformity
Vibration test acceleration to 20 g
acc. to EN 60068-2-6
Shock test acc. to EN 60068-2-27
Drop and topple acc. to EN 60068-2-31/IEC 60068-2-32
Electromagnetic compatibility acc. to EN 61131-2
Approvals and certificates CE, FCC
UL Certificate cULus LISTED 21 W2, Encl.Type 1 IND.CONT.EQ.
General Information
Dimensions (W x L x H) 60.4 x 230.4 x 39mm
Operating temperature -40…+70 °C
Storage temperature -40…+85 °C
Altitude max. 5000 m
Protection class IP65
IP67
IP69K
MTTF 205 years acc. to SN 29500 (Ed. 99) 20 °C
Housing material PA6-GF30
Housing color Black
Window material Lexan
Material screw 303 stainless steel
Material label Polycarbonate
Halogen-free yes
Mounting 2 mounting holes � 6.3 mm
Note the numbering of the IO range:
From firmware version 3.2.9.0 and higher ports C0
to C7 and channels CH0 to CH15 are counted. The
process data image is unchanged. For more details
Edition • 2019-01-21T18:54:21+01:00
2 / 5 TURCK Inc.
on the corresponding change see manual.
Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs and 8 Digital PNP Outputs 2 A
TBEN-L4-8DIP-8DOP
Accessories
Ethernet cable (example):
RSSD RSSD 441-2M
Ident no. U-02482
Accessories
Accessories:
Connection cable , 2-channel (example):
RK 4.4T-2-RS 4.4T
Ident no. U2445
Splitter, 1-channel (example):
YB2-FSM 4.5-2FKM 4.5
Ident no. U0875-78
M12 x 1 Ethernet
M12 x 1 Input
Output M12 x 1
Accessories
Power supply cable (example):
RSM RKM 40-2M
Ident no. U2280-0
Edition • 2019-01-21T18:54:21+01:00
3 / 5 TURCK Inc.
7/8'' Power Supply
Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs and 8 Digital PNP Outputs 2 A
TBEN-L4-8DIP-8DOP
Module LED Status
LED Color Status Description
ETH1 / ETH2 Green ON Ethernet link (100 Mbps)
flashing Ethernet communication (100 Mbps)
Yellow ON Ethernet link (10 Mbps)
flashing Ethernet communication (10 Mbps)
OFF No Ethernet link
BUS Green ON Active connection to a master
Flashing Steady flashing: Ready
Sequence of 3 flashes in 2 seconds: FLC/ARGEE active
Red ON IP address conflict or Restore Mode or Modbus timeout
Flashing Blink/Wink command active
Green/red Alternating Autonegotiation and/or waiting for DHCP/Boot-P addressing
OFF Power off
ERR Green ON Diagnostics disabled
Red ON Diagnostics enabled
V2 undervoltage diagnosis is parameter-dependent
PWR
LED response parameter (PWR) at V2 Undervoltage = "red"
Green ON V1 and V2 power on
Red ON V2 power off or below defined tolerance of 18 V
OFF V1 power off or below defined tolerance of 18 V
LED response parameter (PWR) at V2 Undervoltage = "green"
Green ON V1 and V2 power on
Flashing V2 power off or below defined tolerance of 18 V
OFF V1 power off or below defined tolerance of 18 V
LED Status I/O
LED Color Status Description
LED 0…7 Green ON Input active
Red flashing Power overload at the corresponding port. Both port LEDs are flashing.
OFF Input inactive
LED 8 … 15 Green ON Output active
Red ON Output active with overload/short circuit
flashing Power overload at the corresponding port. Both port LEDs are flashing.
OFF Output inactive
Edition • 2019-01-21T18:54:21+01:00
4 / 5 TURCK Inc.
Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs and 8 Digital PNP Outputs 2 A
TBEN-L4-8DIP-8DOP
Process Data Mapping of the Single Protocols
For more details on the corresponding protocols see manual.
Modbus TCP Register Mapping
Reg Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
Inputs (RO) 0x0000 DI7
Status (RO) 0x0001 - FCE - - CFG COM V1 - V2 - - - - - - Diag
Diag (RO) 0x0002 - - - - - - - - - - - - - - - I/O
Inputs (RW) 0x0800 DI7
Outputs (RW) 0x0800 DO15
I/O Diag (RO) 0xA000 SCO15 SCO14 SCO13 SCO12 SCO11 SCO10 SCO9 SCO8 SCS7 SCS6 SCS5 SCS4 SCS3 SCS2 SCS1 SCS0
EtherNet/IP™ data mapping with activated scheduled diagnostics, default settings
Word Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
Input data (station -> scanner)
GW status 0 - FCE - - CFG COM V1 - V2 - - - - - - Diag
Inputs 1 DI7
Diag 1 2 - - Sched
Diag
Diag 2 3 SCO15 SCO14 SCO13 SCO12 SCO11 SCO10 SCO9 SCO8 SCS7 SCS6 SCS5 SCS4 SCS3 SCS2 SCS1 SCS0
Output data (scanner -> station)
Control 0 reserved
Outputs
EtherNet/IP™ data mapping with activated summarized diagnostics
Input data (station -> scanner)
GW status 0 - FCE - - CFG COM V1 - V2 - - - - - - Diag
Inputs 1 DI7
Diag 1 2 - I/O
Output data (scanner -> station)
Control 0 reserved
Outputs
PROFINET process data
Inputs 0 DI8
Outputs 0 DO8
Key:
DIx Digital input channel x CFG I/O Configuration error
DOx Digital output channel x FCE I/O-ASSISTANT Force Mode active
Cx Port x I/ODiag I/O diagnostics connected
Px Pin x SchedDiag Manufacturer-specific diagnostics configured and active
DiagWarn Diagnostic at least on 1 channel SCSx Short-circuit at port x
V1 Undervoltage V1 SCG1 Short-circuit supply ports C0-C3
V2 Undervoltage V2 SCG2 Short-circuit supply ports C4-C7
COM Communication error on internal module bus SCOx Short-circuit output channel x
Edition • 2019-01-21T18:54:21+01:00
5 / 5 TURCK Inc.
1 DO15
Word Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
1 DO15
Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
C4P2
C8P2
- - - - - - - - - - - - I/O
DI7
C4P4
DO7
C8P4
DI6
C3P2
DO6
C7P2
DI5
C3P4
DO5
C7P4
C3P2
C3P2
C7P2
C3P2
C7P2
C3P2
C7P2
DI4
C2P2
DO4
C6P2
DI6
C3P4
DI6
C3P4
DO14
C7P4
DI6
C3P4
DO14
C7P4
DI6
C3P4
DO14
C7P4
DI5
C2P2
DI5
C2P2
DO13
C6P2
DI5
C2P2
DO13
C6P2
DI5
C2P2
DO13
C6P2
DI3
C2P4
DO3
C6P4
DI4
C2P4
DI4
C2P4
DO12
C6P4
DI4
C2P4
DO12
C6P4
DI4
C2P4
DO12
C6P4
DI3
C1P2
DI3
C1P2
DO11
C5P2
DI3
C1P2
DO11
C5P2
DI3
C1P2
DO11
C5P2
DI2
C1P2
DO2
C5P2
DI2
C1P4
DI2
C1P4
DO10
C5P4
DI2
C1P4
DO10
C5P4
DI2
C1P4
DO10
C5P4
DI1
C0P2
DI1
C0P2
DO9
C4P2
DI1
C0P2
DO9
C4P2
DI1
C0P2
DO9
C4P2
DI0
C0P4
Warn
Diag
DI0
C0P4
DO8
C4P4
Warn
DI0
C0P4
Diag
DO8
C4P4
Warn
DI0
C0P4
Diag
DO8
C4P4
DI1
C1P4
DO1
C5P4
Loading...