Pressure sensor
With Analog Output and PNP/NPN Transistor Switching Output
output 2 reprogrammable as switching output
PS003V-304-LI2UPN8X- H1141
Type designation PS003V-304-LI2UPN8X- H1141
Ident-No. 6833441
Pressure range
Relative pressure -1…2.5 bar rel.
-14.5…36.26 psi
-0.1…0.25 MPa
Admissible overpressure
Burst pressure
Response time < 3 ms
Power supply
Operating voltage 18…30 VDC
Current consumption
Voltage drop at I
Protective measure SELV; PELV according to EN 50178
Short-circuit/reverse polarity protection yes / yes
Protection type and class IP67/IP69K / III
e
ð 12 bar
ï 12 bar
ð 50 mA
ð 2 V
■ Rigid process connection, non-rotat-
able body
■ Reading of adjusted values without tool
■ Recessed pushbutton and keylock for
secure programming
■ Permanent indication of pressure (bar,
psi, kPa, MPa, misc)
■ Peak pressure memory
■ Pressure range -1…2.5 bar rel.
Wiring Diagram
Functional principle
The pressure sensors of the PS series operate with piezo-resistive ceramic measuring
cells. The ceramic diaphragm is unbalanced
in proportion to the pressure applied. Depending on the sensor type, the voltage produced
is made available either as switching or analog output signal. Non-rotatable and rotatable
sensors, numerous thread types, front-flush or
dead-zone free diaphragms and an accuracy
of 0.5% of full scale guarantee highest flexibility and safe process interfacing.
Outputs
Output 1 Switching output or IO-Link mode
Output 2 analog or switching output
Switching output
Output function NO/NC, PNP/NPN
Accuracy switching output ± 0.5 % v. E. BSL
Rated operational current 0.2 A
Switching frequency
Switching point distance
Switch point: (min + 0.005 x range) up to 100% f.s.
Release point(s) min up to (SP - 0.005 x range)
Switching cycles
Analog output
Current output 4…20 mA
Voltage output 0…10V
Operating range 4…20/0…20 mA , 0…10 V/0…5 V (3-wire)
Load
Accuracy LHR analog output ± 0.5 % FS BSL
IO-Link
IO-Link Specification Specified acc. to version 1.0
Programming FDT / DTM
Transmission physics corresponds to 3-wire physics (PHY2)
Transmission rate COM 2 / 38.4 kbps
Process data width 16 bit
Measured value information 14 bit
Switchpoint information 2 bit
Frame type 2.2
Genauigkeit ± 0.5 % of final value BSL
Edition • 2018-04-11T19:01:56+02:00
1 / 4 TURCK Inc.
ð 180 Hz
ï 0.5 %
ï 100 mil.
ð 0.5 kò
Pressure sensor
With Analog Output and PNP/NPN Transistor Switching Output
output 2 reprogrammable as switching output
PS003V-304-LI2UPN8X- H1141
Temperature behaviour
Medium temperature -40…+85 °C
Temperature coefficient zero point Tk0 ± 0.15 % of full scale/10 K
Temperature coefficient span T
Ambient conditions
Ambient temperature -40…+80 °C
Storage temperature -40…+80 °C
Vibration resistance 20 g (9…2000 Hz), according to IEC 68-2-6
Shock resistance 50 g (11 ms) , according to IEC 61508
EMC EN 61000-4-2 ESD:4 kV CD / 8 kV AD
Housing
Housing material Stainless-steel/Plastic, V2A (1.4305)
Pressure connection material Stainless steel A2 1.4305 (AISI 303)
Pressure transducer material Ceramics AI2O
Sealing material FPM spez.
Process connection G¼" male thread
Wrench size pressure connection / coupling nut 21
Electrical connection Connector, M12 × 1
Max. tightening torque housing nut 35 Nm
kS
± 0.15 % of full scale/10 K
EN 61000-4-3 HF radiated: 15 V/m
EN 61000-4-4 Burst: 2 kV
EN 61000-4-5 Surge: 1000 V, 42 Ohm
EN 61000-4-6 HF cable bound: 10 V
3
Reference conditions acc. to IEC 61298-1
Temperature 15…+25 °C
Atmospheric pressure 860…1060 hPa abs.
Humidity 45…75 % rel.
Auxiliary power 24 VDC
Display 4-digit 7-segment display, rotatable by 180°, disen-
gageable
Switching state 2 × LEDs,Yellow
Programming options start/end value analog output; switch/release points;
PNP/NPN; NO/NC contact; hysteresis/window
mode; damping; pressure unit; peak pressure mem-
ory
Unit display 5 x LEDs green (bar, psi, kPa, MPa, misc)
MTTF 242 years acc. to SN 29500 (Ed. 99) 40 °C
Edition • 2018-04-11T19:01:56+02:00
2 / 4 TURCK Inc.
Pressure sensor
With Analog Output and PNP/NPN Transistor Switching Output
output 2 reprogrammable as switching output
PS003V-304-LI2UPN8X- H1141
Accessories
Type code Ident-No. Description
PTS-COVER A9350 Closure cap
Wiring accessories
Type code Ident-No. Description
RKC4.4T-2/TXL 6625503 Connection cable, female M12, straight, 4-pin, cable length: 2
m, sheath material: PUR, black; cULus approval; other cable
lengths and qualities available, see www.turck.com
WKC4.4T-2/TXL 6625515 Connection cable, female M12, angled, 4-pin, cable length: 2
m, sheath material: PUR, black; cULus approval; other cable
lengths and qualities available, see www.turck.com
RKC4.4T-2/TEL 6625013 Connection cable, female M12, straight, 4-pin, cable length: 2
m, sheath material: PVC, black; cULus approval; other cable
lengths and qualities available, see www.turck.com
WKC4.4T-2/TEL 6625025 Connection cable, female M12, angled, 4-pin, cable length: 2
m, sheath material: PVC, black; cULus approval; other cable
lengths and qualities available, see www.turck.com
Edition • 2018-04-11T19:01:56+02:00
3 / 4 TURCK Inc.
Pressure sensor
With Analog Output and PNP/NPN Transistor Switching Output
output 2 reprogrammable as switching output
PS003V-304-LI2UPN8X- H1141
Wiring accessories
Type code Ident-No. Description
RKC4.4T-P7X2-10/TXL 6626184 Connection cable, female M12, angled, 4-pin, cable length:
10m, sheath material: PUR, black; cULus approval; other ca-
ble lengths and qualities available, see www.turck.com
Function accessories
Type code Ident-No. Description
TBEN-S2-4IOL 6814024 Compact multiprotocol I/O module, 4 IO-Link Master 1.1
Class A, 4 universal PNP digital channels 0.5 A
Edition • 2018-04-11T19:01:56+02:00
4 / 4 TURCK Inc.
Loading...