Turbo Air TOM48DXBSPN, TOM40BSPAN, TOM50BSPN, TOM50BSPAN, TOM36DXBN User Manual

...

Turbo Air Speeds up the Pace of Innovation

Open Display Merchandiser Installation and Operation Manual

Please read this manual completely before attempting to install or operate this equipment.

Extra Deep

TOM-36-DX*-**-*-N TOM-48-DX*-**-*-N TOM-60-DX*-**-*-N TOM-72-DX*-**-*-N TOM-96-DX*-**-*-N

Full Heights

TOM-40*-**-*-N TOM-50*-**-*-N

Mid Heights

TOM-40M*-**-*-N TOM-50M*-**-*-N

Vertical Air Curtain

TOM-36E*-**-*-N TOM-48E*-**-*-N TOM-60E*-**-*-N TOM-72E*-**-*-N TOM-96E*-**-*-N

www.turboairinc.com

CONTENTS

PAGE

INTRODUCTION

SPECIFICATIONS

INSTALLATION

Damage inspection

Location of display

Leveling of display

OPERATING INSTRUCTIONS

Power switch Light switch Temperature control Thermometer Placing the product

MAINTENANCE & CLEANING

Condenser coil

TROUBLESHOOTING

Merchandiser not functioning Merchandiser is warm Lights are not working

11~12

WARRANTY

NOTE

19~22

NOTICE

• This equipment is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge unless they have been given supervision or instructions concerning the use of this equipment and the hazards involved by a person responsible for their safety.

• Special instructions for those persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, are not included in this manual and are not required to be included.

• Children shall not play with the appliance.

• Cleaning and user maintenance shall not be made by children without supervi sion.

This manual uses the following safety symbols. These safety symbols with the words of DANGER, WARNING or CAUTION alert users of the potential hazards that could cause injury or even death.

DANGER

WARNING

CAUTION

Indicates hazards of death or serious injury, if the instructions are not followed.

Indicates dangers of death or serious injury, if the instructions are not followed.

Indicates risks of personal injury or material damage, if the instructions are not followed.

FOR HYDROCARBON REFRIGERATION UNITS

WARNING

This unit uses R-290 (propane), or R-600a (isobutane) as a refrigerant. These hydrocarbon refrigerants are highly environmentally compatible but also are flammable and combustible. Please read this manuel thoroughly before installing and operating the unit. Please take cautious measures to avoid risk of fire or explosion.

PLEASE REFER TO THE LABEL INSIDE THE CABINET TO CHECK

REFRIGERATION TYPE AND VOLUME.

DANGER - Risk of fire or explosion. Flammable refrigerant used. Do

not use mechanical devices to defrost refrigerator. Do not puncture refrigerant tubing.

DANGER - Risk of fire or explosion. Flammable refrigerant used. To be repaired only by trained service personnel. Do not puncture refrigerant tubing.

CAUTION - Risk of fire or explosion. Dispose of properly in accordance with federal or local regulations. Flammable refrigerant used.

CAUTION - Risk of fire or explosion. Flammable refrigerant used. Consult repair manual/owner’s guide before attempting to service this product. All safety precautions must be followed.

CAUTION - Risk of fire or explosion due to puncture of refrigerant tubing; follow handling instructions carefully. Flammable refrigerant used.

WARNING

- Keep ventilation openings in the appliance enclosure or in the built-in structure, clear of obstruction.

- Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.

- Do not damage the refrigerant circuit.

- Do not use electrical appliances inside the food storage compartments of the appliance unless they are of a type recommended by the manufacturer.

FOR HYDROCARBON REFRIGERATION UNITS

WARNING

• Handle the unit with care in order to avoid any serious damage to the refrigeration system.

• The refrigerant tubing, condenser, and evaporator coils are easily prone to damage while handling, moving, installing, and cleaning the unit, which may lead to fire or even explosion.

• Refrigerant squirting out of the pipes could ignite or cause an eye injury. If a leak is detected, avoid any naked flames or potential sources of ignition and air the room in which the appliance is standing for several minutes.

• In order to avoid the creation of a flammable gas-air mixture in case of a leak in the refrigerating circuit, the size of the room in which the appliance is placed

depends on the amount of refrigerant used. The room must be 35.31ft for every 0.28oz (8g) of R-290 refrigerant inside the appliance. The amount of refrigerant in your particular appliance is shown on the label inside the cabinet.

1m³ in size

This appliance contains a small amount of propane (R-290) or isobutane (R-600a) refrigerant, a natural gas with high environmental compatibility, but which is also combustible. When transporting and installing the appliance, care should be taken to ensure that no part of the refrigerating circuit is damaged.

• Never start up an appliance showing any signs of damage. If in doubt, contact a qualified service professional.

• In case of any hazardous activities such as fire or explosion, move the unit away from any source of ignition to a well ventilated area.

• Further service and repair must be done by a qualified technician who is familiar with the safety standards, and also has thorough understanding and knowledge of the flammable refrigerants.

• Any and all technicians handling these units must be equipped with proper personal protection and equipment and follow applicable safety measures and precautions to avoid risk of fire or explosion.

IMPORTANT SAFETY INFORMATION

SAFETY PRECAUTIONS

To avoid any risk of fire, explosion, electric shock, personal injury, material damage or incorrect use of the appliance, be sure to observe the following safety precautions. (After reading these owner’s manual instructions, please keep the manual booklet in a safe place for reference. Remember to hand it over to any subsequent owners)

WARNING

• The unit must be installed and located in accordance with the manufacturer’s installation instructions.

• Installation work must be performed in accordance with the National Electric Code by qualified and authorized personnel only.

• Repairs and replacement work must be performed by a qualified and authorized service professional only using genuine replacement parts.

• Do not use an extension cord or an adapter plug. Because of the potential safety hazards under certain conditions, we strongly recommend against any use of an extension cord or an adapter plug.

• Do not, under any circumcetances, cut or remove the ground prong from the power cord. For personal safety, this appliance must be properly grounded.

• Do not store volatile and flammable substances in the refrigerator. The storage of benzene, thinner, alcohol, ether, LP gas, or other explosive substances may cause an explosion.

• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this appliance as well as any other appliances.

• The appliance is not intended for use by children without supervision.

• Do not allow children to climb, stand, or hang on the refrigerator doors or shelves in the refrigerators. They could damage the refrigerator and seriously injure themselves.

• To prevent suffocation and entrapment hazards to children, remove the doors and seals from the refrigerator before disposing of it or discontinuing its use.

IMPORTANT SAFETY INFORMATION

INSTALLATION & USAGE

WARNING

• Do not install the unit in a damp place where it could be splashed with water. Incorrect insulation of the electrical parts may cause fire or electric shock.

• Do not plug several appliances into the same sockets. This could cause overheating and risk start of a fire.

• Keep the power plug away from the rear of the cabinet. A damaged power plug may cause fire due to overheating.

• Do not spray water directly to the interior or exterior of the appliance. There is a risk of fire or electric shock.

• Do not place any containers filled with water on top of the appliance. If the water spills onto any electrical parts, it may lead to fire or electric shock.

• Do not attempt to repair, disassemble or alter the appliance. It may cause fire or abnormal operations which may lead to injury.

• Unplug the refrigerator before making repairs, replacing a light bulb, or cleaning.

• Plug into a grounded 3-prong outlet. Do not remove the ground prong.

CAUTION

• Do not store too much food in the appliance. When you open the door, an item may fall out and cause personal injury or material damage.

• Do not put bottles or any kind of glass in the freezer. The container may break and cause personal injury.

• Do not disconnect the power cord by pulling on it. This may disconnect a wire and cause a short circuit.

IMPORTANT SAFETY INFORMATION

INSTALLATION & USAGE

CAUTION

• There is a risk of death from suffocation if a child puts the packing materials on his or her head.

• Do not store any articles on top of the appliance. Articles may fall while opening or closing the door, and could cause personal injury or material damage.

• Do not store pharmaceutical products, scientific materials or other temperature-sensitive products in the refrigerator. Products that require strict temperature controls must not be stored in the refrigerator.

• Do not let children hang on the door.

• Do not touch any cold surfaces or food containers in the freezer with damp or wet hands. Skin may stick to these extremely cold surfaces and may cause frostbite.

• Remove any foreign matter from the power plug pins. Otherwise, there is a risk of fire.

• Do not insert your hand into the bottom area of appliance. Any sharp edges may cause personal injury.

• After unplugging the appliance, wait at least five minutes before plugging it back in. Abnormal operation of the freezer may cause material damage.

• If the appliance is not used for a long period of time, unplug it from the power supply. Any deterioration in the insulation may cause fire.

• Do not let children touch or play with the control panel on the front of the appliance.

- Do not allow children to play with this appliance.

- Do not stand or lean on the base panel, pull-out parts, or doors.

- Repairs and maintenance of the appliance should only be performed by a qualified

technician. Incorrect repairs done by an unqualified person may be a potential source of danger that could have critical consequences for the user of the appliance.

- Never put ice cubes or ice pops straight from the freezer into your mouth. The low temperature may cause cold burns.

+ 16 hidden pages