Turbo Air TFG-49F Installation Manual

CAUTION!

SIGN PANEL

SIGN PANEL

FLUORESCENT
LAMP

DOOR
ASSEMBLY

DOOR
ASSEMBLY

SHELF

BACK
SPACER

EVAPORATOR
COIL

EVAPORATOR
FAN MOTOR

EVAPORATOR FAN
MOTOR BLADE

POWER SWITCH
LAMP SWITCH

BOTTOM
GRILLE

CASTER
(WITH BRAKE)

CONDENSER
COIL

COMPRESSOR
CONDENSER

FAN MOTOR

SIDE VIEWFRONT VIEWFRONT VIEW

CASTER

DOOR
HANDLE

BEFORE OPERATING FREEZER
PLEASE KEEP POWER SWITCH ON
AFTER TURNING ON THE POWER, THE FLUORESCENT
LAMP WILL COME ON IN A FEW MINUTES.

Freezer
Installation and Operation Manual

Please read this manual completely before attempting to install or operate this equipment!

Model No. :

TGF-23F
TGF-49F
TGF-72F

SIGN PANEL

DOOR
ASSEMBLY

CASTER
(WITH BRAKE)

EVAPORATOR FAN
MOTOR BLADE

SHELF

DOOR
HANDLE

BOTTOM
GRILLE

CONDENSER
COIL

EVAPORATOR
FAN MOTOR

COMPRESSOR
CONDENSER

FAN MOTOR

SIDE VIEWFRONT VIEW

EVAPORATOR
COIL

BACK
SPACER

CASTER

CONTENTS

1. SPECIFICATIONS

PAGE

.......................................................................................

2

2. SERIAL NUMBER

........................................................................................

3. INSTALLATION............................................................................................ 3

4. CLEANING

5. BASIC OPERATION

6. BEFORE REQUESTING SERVICE

7. WARRANTY

...................................................................................................

................................................................................

5~9

...........................................................

.........................................................................................

11~12

10

SPECIFICATIONS

Freezer

MODEL COMP H.P. V/Hz REFRIGERANT AMPS

CRA TED
WEIGHT

2

4

TGF-23F
TGF-49F 1.5 115V / (208-220)V / 60Hz R-404A 11A 595 lbs
TGF-72F 1.5X2 115V / (208-220)V / 60Hz R-404A 18A 900 lbs

3/4 115V/60Hz R-404A 8.2A 419 lbs

SERIAL NUMBER

The serial number is located on the rating label inside.
Please retain the unit’s serial number for service purpose.

2

Turbo air

INSTALLA TION

1. GOOD AIR CIRCULATION

- Be sure to avoid any object which will restrict exhaust air flow.

- Be sure that there is ample air space so that air can flow through the rear of the unit.

- Turbo Air recommends that the rear of the unit be no less than 5 inches from the wall.

2. PLACE ON STRONG GR OUND

- Be sure the location chosen has a floor strong enough to support the total weight of
the cabinet and contents.

3. DO NOT PLA CE NEAR HEAT

- Be sure to avoid hot corners and locations near stoves.

- High ambient temperature will make cooling efficiency lower.

4. INDOOR USAGE ONLY

- Be sure to install this unit indoor, so it will not get wet from the rain.

5. STABILIZING

- Make sure the unit is installed in a stable condition with the front wheels locked
while in use.

6. LEVELING

- Be sure that the unit is leveled from front to back and side to side.

7. UNIT SHOULD BE ON DEDICA TED OUTLET.

3

Turbo air

CLEANING

WH

E

BK RD

1. CLEANING THE INTERIOR AND EXTERIOR

- The interior and exterior of the unit can be cleaned using warm water with soap.

- Do not use an abrasive cleaner because it will scratch the surface.

2. CLEANING THE CONDENSER FINS

- To maintain proper refrigeration performace, the Condenser coil must be free of dust,

dirt, and grease.
This will require periodic cleaning. Condenser fins should be cleaned at least every
three months (90 days) or as needed.

3. CLEAN THE GASKET

- The door gasket should be cleaned frequently to maintain proper sealing.

4. CHECK AFTER CLEANING

- Check the unit again for safety.

- Check that the unit is operating properly.

CA UTION

1. POWER CORD

- Be sure that the power cord is connected to the proper voltage.

- A protected circuit of the correct voltage and amperage must be run for connection of
the line cord.

- Turn ‘off’ the power switch before disconnecting the power cord,
whenever performing maintenance functions or cleaning the
refrigerated cabinet.

- Dual voltage freezer (TGF-49F, TGF-72F) requires receptacle as
shown the right sides.

- Compressor warranties are void if compressor burns out due to low
voltage.

2. RE-STARTING

- If disconnected, wait for 5 minutes before re-starting.

4

Turbo air