Truvox valet tub vac, VALET User Manual

03-8193-0000 Issue 5 07-13

ORIGINAL INSTRUCTIONS

CAUTION – READ THESE INSTRUSTIONS BEFORE USING THE MACHINE

Valet Tub Vac

Commercial Vacuum Cleaner

USER MANUAL EN

Truvox International

31-70 2

Introduction

The following instructions contain important information
about the machine and safety advice for the operator.
Equipment must be operated, serviced and maintained in
accordance with the manufacturer’s instructions. If in doubt
contact the supplier of your machine.

Read all instructions before using
the machine

Product information

This vacuum cleaner is designed for the collection of dust in
indoor areas. This machine is for indoor use only. The
machine is intended for commercial use, for example in
hotels, schools, hospitals, factories, shops, offices, rental
businesses and other than normal housekeeping purposes.

Technical Specifications

IMPORTANT SAFETY ADVICE

The safety information described in this manual provides
basic precautions and supplements standards in force in the
country where the machine is used.

This symbol warns the operator of hazards and
unsafe practices which could result in severe
personal injury or death.
WARNING – to reduce the risk of injury, electric
shock or fire.

1. This machine must only be used for the manufacturer’s
approved application as described in this manual.

2. Operators must be fully trained in the use of the machine
in accordance with these

instructions, able to perform
regular user maintenance and the correct selection of
accessories.

3. Only genuine accessories and spare parts provided with
the machine or those approved by the manufacturer
should be used. All repairs must be performed by a
qualified service agent.

4. Do not use without filters or dust bags in place.

5. Do not modify the machine from its original design.

6. This machine is not intended for use by persons
(including children) with reduced physical, sensory or
mental capabilities, or lack of experience and knowledge,
unless they have been given supervision or instruction
concerning use of the machine by a person responsible
for their safety.

7. Keep children and unauthorised persons away from the
machine when i

n use. Do not use as a toy.

8. The machine must be kept clean and in good condition
with regular inspections of the power supply cord and
plug for signs of any damage. If any parts are damaged
they shall only be replaced by an approved part by the
manufacturer, its service agent or a similar qualified
person in order to avoid a hazard.

9. CAUTION - This machine is for dry indoor use only and
should not be used or stored outdoors in wet conditions.

10. DO NOT use where hazardous dust is present.

11. DO NOT use in an explosive atmosphere.

12. DO NOT pick up or use near flammable or combustible
fluids, dusts or vapours.

13. DO NOT use to pick up moisture or any liquids.

14. DO NOT use to clean up any burning or lighted materials
such as cigarettes, matches, ashes or other combustible
objects.

15.

DO NOT use the appliance to vacuum tiny particles like
cement or plaster dust as this will shorten life of the
motors.

16. Take care when using a machine near the top of stairs to
avoid overbalancing.

17. DO NOT put any object into openings. DO NOT use with
any opening blocked; keep free of dust, debris and
anything that may reduce airflow.

18. Keep hair, loose clothing, hands, feet and all other parts
of the body away from openings and moving parts.

19. This machine should always be connected to a fully
earthed power supply of the right voltage and frequency.

20. DO NOT leave the machine connected to the electricity
supply when not in use; always remove the plug from the
socket outlet. DO NOT leave machine running
unattended.

21. Switch off the machine before removing the plug.

22. When unpluggi

ng, pull the plug, not the supply cord.

23. The plug of the power supply cord must be removed
from the socket-outlet when not in use and before
commencing cleaning of the machine or undertaking
maintenance operations.

24. DO NOT pull or carry by the supply cord. DO NOT use
cord as a handle, close door on cord or pull cord around
sharp edges or corners.

Model Valet Tub Vac

Voltage AC (~)/
Frequency

V/ Hz 220-240/50

Construction class II

Protection class IP 20

Vacuum motor power W 1400

Vacuum mmwg/kPa 1730/17

Productivity rate m²/h 232

Airflow rate l/s 35

Filtration

4-stage (including HEPA 10
filter)

01 l yticapaC

Sound noise dB(A)

Dimensions (L x W x H) cm 51 x 35 x 35

5.8 gk thgieW

Hose length m 1.9

Cable length m 10

raey 1 ytnarraW

Waste Electrical & Electronic Equipment
(WEEE)

Do not dispose of this device with unsorted
waste. Improper disposal may be harmful to the
environment and human health. Please refer to
your local waste authority for information on
return and collection systems in your area.

EC DECLARATION OF CONFORMITY

Machine Type: Commercial vacuum cleaner
Model:VTV…
This machine is in conformity with the following EU directives:

Machinery Directive: 2006/42/EC
The EMC Directive: 2004/108/EC

Applied harmonised standards:

EN60335-1, EN60335-2-69, EN55014-1, EN55014-2,
EN610003-2, EN610003-3, EN62233

Truvox International Limited
Third Avenue, Millbrook
Southampton, SO15 0LE, Malcolm Eneas
Hampshire, England Operations Manager

Southampton, 11/07/2013

LpA:72±3;LwA:82±3

Vibration m/s² ≤

2.5

Truvox International

3 07-13

25. WARNING: Keep the power supply cord clear of moving
parts. During operation hazard may occur when running
the machine over the power supply cord.

26. DO NOT kink or twist the power cord and keep cord
away from heated surfaces.

27. DO NOT operate switches or touch the mains plug with
wet hands as this may cause electric shock.

28. The power supply cord plus any extension leads should
not exceed 30 metres in total. The cross section of an
extension cable wiring must be at least 2.5mm².

Transporting the machine

Incorrect lifting techniques may result in personal injury. We
advise that the manual handling regulations are followed.
Carefully wrap the power cord and store in dry indoor
location. Do not expose the machine to rain or moisture. Lift
the machine by the carrying handle to transport.

UK Model only

The cord is equipped with a 13 amp fuse. If replacing fuse,
use a 13 amp fuse confirming to BS1362. Do not use the
machine if fuse cover is missing.

After sales service
Truvox machines are high quality machines that have been
tested for safety by authorised technicians. It is always
apparent that after longer working periods, electrical and
mechanical components will show signs of wear and tear or
ageing. To maintain operational safety and reliability the
following service interval has been defined: Every year or
after 250 hours. Under extreme or specialised conditions
and/or insufficient maintenance, shorter maintenance
intervals are necessary. Use only original Truvox spare
parts. Use of other spare parts will invalidate all warranty and
liability claims. Should you require after sales service please
contact the supplier from whom you purchased the machine,
who will arrange service. Repairs and servicing of Truvox
products should only be performed by trained staff. Improper
repairs can cause considerable danger to the user.

Guarantee

Your product is guaranteed for one year from the date of
original purchase, or hire purchase, against defects in
materials or workmanship during manufacture. Within the
guarantee period we undertake at our discretion, to repair or
replace free of charge to the purchaser, any part found to be
defective, subject to the following conditions:

C

ONDITIONS

1. Claims made under the terms of the guarantee must be
supported by the original invoice/bill of sale issued at the
time of sale, or the machine Serial No.

2. For claims under this guarantee contact the supplier from
whom you purchased the product who will arrange the
appropriate action. Do not initially return the product as
this could result in transit damage.

3. Neither Truvox nor its distributor shall be liable for any
incidental or consequential loss.

4. This guarantee is governed by the laws of England.

5. This guarantee does not cover any of the following:

 Periodic maintenance, and repair or replacement

of parts due to normal wear and tear.

 Damage caused by accident, misuse or neglect, or

the fitting of other than genuine Truvox parts.

 Defects in other than genuine Truvox parts, or

repairs, modifications or adjustments performed by
other than a Truvox service engineer or authorised
service agent.

 Costs and risks of transport relating directly or

indirectly to the guarantee of this product.

 Consumable items such as, brushes, drive discs,

filters and vacuum skirts.

 This guarantee does not affect your statutory rights, or

your rights against the supplier arising from their sales or
purchase contract. Truvox International Limited policy is
one of continual product development and we reserve the
right to alter specifications without prior notice.

Recommended Spares & Accessories

Fault diagnosis

The following simple checks may be performed by the operator:

* If the fuse blows several times, the machine should be checked by an authorises Service Agent

Part No. Item

96-0107-0000 Cord Assembly
20-0192-0000 HEPA Filter + Pre Filter (inclusive of HEPA Holder + 1 x HEPA 13 filter + 5 x Vac inlet filter)
20-0174-0000 Cloth Filter
20-0172-0000 Dust bag (Pack of 10)
20-0168-0000 Hose
20-0169-0000 Telescopic wand

RD270 Floor tool

DS-076 Crevice tool

Trouble Reason Remedy

Machine not working

 Lack of voltage/electrical supply



Check fuse *, supply cord, plug and socket

outlet

Loss of suction

 Bag full
 Blocked hose or wand
 Motor not working



Replace bag

 Remove obstruction
 Contact supplier

Motor is not running

 Broken switch
 Defective power cord
 Defective motor



Contact supplier

Truvox International

4 07-13

1 2 3 4 5 1 2 1 2

3