True Manufacturing Company GDIM-26NT, GDIM-49, GDIM-26 User Manual

............ www.truemfg.com ............

TABLE OF CONTENTS

Safety Information

Safety Precautions 1 Do’s and Don’ts 2 Proper Disposal 3 Connecting Electricity 4 Adapter Plugs 4

Installation / Operation Instructions

Ownership 5 Required Tools 5 Uncrating 5 Locating & Installation of Leg/Castors 6 Leveling Cabinet 7 Wire Gauge Chart 8 Sealing Cabinet to Floor & Electrical Inst. 9 Start-up and Light Switch Location 10 Defrost Time Clock Operation (Grasslin) 11 Field Troubleshooting 12-13

Maintenance, Care & Cleaning

Cleaning Condenser Coil 14-15 Cabinet Cleaning 16-17 Light Bulb Replacement 17 Warranty (U.S.A. & Canada Only!) 18

INSTALLATION MANUAL FOR GDIM

(GLASS DOOR ICE MERCHANDISERS)

GDIM - GLASS DOOR

ICE MERCHANDISERS

TRUE FOOD SERVICE EQUIPMENT, INC.

2001 East Terra Lane • P.O. Box 970 • O’Fallon, Missouri 63366

(636)-240-2400 • FAX (636)272-2408 • INT’L FAX (636)272-7546 • (800)325-6152

Parts Department (800)424-TRUE • Parts Department FAX# (636)272-9471

CONGRATULATIONS!

You have just purchased the finest commercial

freezer available. You can expect many years of

trouble-free operation.

GDIM-26

GDIM-26NT

GDIM-49

6/6/08-500 SB #897013

*Spanish, German, French and Dutch versions included.

............ www.truemfg.com ............

True Food Service Equipment, Inc.

............ www.truemfg.com ............

SAFETY INFORMATION

True Food Service Equipment, Inc.

1

This freezer must be properly installed and located in accordance with the Installation Instructions before it is used.

Do not allow children to climb, stand or hang on the shelves in the freezer. They could damage the freezer and seriously injure themselves.

Do not touch the cold surfaces in the freezer compartment when hands are damp or wet. Skin may stick to these extremely cold surfaces.

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

Keep fingers out of the “pinch point”areas; clearances between the doors and between the doors and cabinet are necessarily small; be careful closing doors when children are in the area.

NOTE: We strongly recommend that any servicing be preformed by a qualified individual.

Unplug the freezer before cleaning and making repairs.

Setting temperature controls to the 0 position does not remove power to the light circuit, perimeter heaters, or evaporator fans.

WARNING!

Use this appliance for its intended purpose as described in this Owner Manual.

How to Maintain Your Freezer

to Receive the Most Efficient and

Successful Operation

You have selected one of the finest commercial freezer units made. It is

manufactured under strict quality controls with only the best quality materials

available. Your TRUE freezer when properly maintained will give you many

years of trouble-free service.

SAFETY PRECAUTIONS

When using electrical appliances, basic safety precautions should be followed, including the following:

............ www.truemfg.com ............

True Food Service Equipment, Inc.

SAFETY INFORMATION

2

............ www.truemfg.com ............

True Food Service Equipment, Inc.

3

SAFETY INFORMATION

PROPER DISPOSAL OF THE REFRIGERATOR

DANGER!

RISK OF CHILD ENTRAPMENT

USE OF EXTENSION CORDS

NEVER USE AN EXTENSION CORD! TRUE will not warranty any freezer that has been connected to an extension cord.

Child entrapment and suffocation are not problems of the past. Junked or abandoned refrigerators are still dangerous… even if they will sit for “just a few days.” If you are getting rid of your old refrigerator, please follow the instructions below to help prevent accidents.

Before You Throw Away Your Old Refrigerator or Freezer:

Take off the doors.

Leave the shelves in place so that children may not easily climb inside.

Refrigerant Disposal

Your old refrigerator may have a cooling system that uses “Ozone Depleting ” chemicals. If you are throwing away your old refrigerator, make sure the refrigerant is removed for proper disposal by a qualified service technician. If you intentionally release any refrigerants you can be subject to fines and imprisonment under provisions of the environmental regulations.

............ www.truemfg.com ............

True Food Service Equipment, Inc.

4

The power cord of this appliance is equipped with a 3-prong (grounding) plug which mates with a standard 3-prong (grounding) wall outlet to minimize the possibility of electric shock hazard from this appliance.

Have the wall outlet and circuit checked by a qualified electrician to make sure the outlet is properly grounded.

If the outlet is a standard 2-prong outlet, it is your personal responsibility and obligation to have it replaced with the properly grounded 3-prong wall outlet.

The freezer should always be plugged into it’s own individual electrical circuit, which has a voltage rating that matches the rating plate.

This provides the best performance and also prevents overloading building wiring circuits which

could cause a fire hazard from overheated wires.

Never unplug your freezer by pulling on the power cord. Always grip plug firmly and pull straight out from the outlet.

Repair or replace immediately all power cords that have become frayed or otherwise damaged. Do not use a cord that shows cracks or abrasion damage along its length or at either end.

When removing the freezer away from the wall, be careful not to roll over or damage the power cord.

HOW TO CONNECT ELECTRICITY

Do not, under any circumstances, cut or remove the third (ground) prong from the power cord. For personal safety, this appliance must be properly grounded.

WARNING!

The incoming power source to the cabinet including any adapters used must have the adequate power available and must be properly grounded.

USE OF ADAPTER PLUGS

NEVER USE AN ADAPTER PLUG! Because of potential safety hazards under certain conditions, we strongly recommend against the use of an adapter plug.

SAFETY INFORMATION

North America Use Only!

NEMA plugs

TRUE uses these types of plugs.

If you do not have the right outlet

have a certified electrician install

the correct power source.