TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S /
TIH 900 S / TIH 1100 S
EN
OPERATING MANUAL
INFRARED HEATING PANEL
EN This product is only designed for
use inside well insulated rooms or
for occasional use.
TRT-BA-TIH300S-TIH400S-TIH500S-TIH700S-TIH900S-TIH1100S-TC-003-EN
Table of contents
Notes regarding the operating manual................................. 1
Safety .....................................................................................2
You can download the current version of the operating manual
and the EU declaration of conformity via the following link:
Information about the device................................................4
Transport and storage...........................................................5
Assembly and installation.....................................................5
Operation ...............................................................................7
Available accessories............................................................7
Errors and faults....................................................................7
Maintenance ..........................................................................8
Technical annex.....................................................................9
Disposal ...............................................................................12
Notes regarding the operating manual
Symbols
Warning of electrical voltage
This symbol indicates dangers to the life and health of
persons due to electrical voltage.
TIH 300 S
https://hub.trotec.com/?id=40358
TIH 400 S
https://hub.trotec.com/?id=40359
TIH 500 S
https://hub.trotec.com/?id=40364
Warning of hot surface
This symbol indicates dangers to the life and health of
persons due to hot surface.
Warning
This signal word indicates a hazard with an average
risk level which, if not avoided, can result in serious
injury or death.
Caution
This signal word indicates a hazard with a low risk
level which, if not avoided, can result in minor or
moderate injury.
Notice
This signal word indicates important information
(e.g. material damage), but does not indicate hazards.
Info
Information marked with this symbol helps you to carry
out your tasks quickly and safely.
Follow the manual
Information marked with this symbol indicates that the
operating manual must be observed.
TIH 700 S
https://hub.trotec.com/?id=40365
TIH 900 S
https://hub.trotec.com/?id=40360
TIH 1100 S
https://hub.trotec.com/?id=40366
1 EN
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Safety
Read this manual carefully before starting or using the
device. Always store the manual in the immediate vicinity
of the device or its site of use!
Warning
Read all safety warnings and all instructions.
Failure to follow the warnings and instructions may
result in electric shock, fire and/ or serious injury.
Save all warnings and instructions for future
reference.
This appliance can be used by children aged from
8years and above and persons with reduced physical,
sensory or mental capabilities or lack of experience
and knowledge if they have been given supervision or
instruction concerning use of the appliance in a safe
way and understand the hazards involved.
Children shall not play with the appliance. Cleaning and
user maintenance shall not be made by children
without supervision.
Warning
Children of less than 3years should be kept away
unless continuously supervised.
Children aged from 3years and less than 8years shall
only switch on/off the appliance provided that it has
been placed or installed in its intended normal
operating position and they have been given
supervision or instruction concerning use of the
appliance in a safe way and understand the hazards
involved.
Children aged from 3years and less than 8years shall
not plug in, regulate and clean the appliance or
perform user maintenance.
Warning
Do not use the device in small rooms if persons are
present who cannot leave the room independently and
who are not under constant supervision.
• Do not use the device in potentially explosive rooms.
• Do not use the device in aggressive atmosphere.
• Set the device up in an upright and stable position.
• Let the device dry out after a wet clean. Do not operate it
when wet.
• Do not use the device with wet or damp hands.
• Do not expose the device to directly squirting water.
• Never insert any objects or limbs into the device.
• Do not cover or transport the device during operation.
• Do not sit on the device.
• This appliance is not a toy! Keep away from children and
animals. Do not leave the device unattended during
operation.
• Check accessories and connection parts for possible
damage prior to every use of the device. Do not use any
defective devices or device parts.
• Ensure that all electric cables outside of the device are
protected from damage (e.g. caused by animals). Never
use the device if electric cables or the power connection
are damaged!
• The electrical connection must correspond to the
specifications in chapter Technical data.
• Insert the mains plug into a properly secured mains
socket.
• Observe the device's power input, cable length and
intended use when selecting extensions to the power
cable. Completely unroll extension cables. Avoid electrical
overload.
• Before carrying out maintenance, care or repair work on
the device, remove the mains plug from the mains socket.
Hold onto the mains plug while doing so.
• Switch the device off and disconnect the power cable from
the mains socket when the device is not in use.
• Do not under any circumstances use the device if you
detect damages on the mains plug or power cable.
If the supply cord is damaged, it must be replaced by the
manufacturer, its service agent or similarly qualified
persons in order to avoid a hazard.
Defective power cables pose a serious health risk.
• During the installation of the device observe the minimum
distances from walls and other objects as well as the
storage and operating conditions specified in the Technical
data chapter.
• Never drill into the heating panel.
• Do not use the device in immediate proximity to curtains.
• Do not place the device on combustible ground.
• Do not transport the device during operation.
• Allow the device to cool down before transport and/ or
maintenance work.
• Do not use this device near bathtubs, shower trays,
swimming pools or other water containers. Risk of electric
shock!
• The device must be set up in a way that the switches and
controllers cannot be touched by a person in a bathtub or
shower.
EN 2
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Intended use
This product is only designed for use inside well insulated
rooms or for occasional use.
Only use the device for heating surfaces indoors.
Intended use comprises:
• Heating surfaces
– in living spaces,
– in storage facilities,
– in salesrooms,
– in construction areas,
– in containers.
Improper use
• Do not use the device outdoors.
• Do not place the device on wet or flooded ground.
• Do not place any objects, e.g. clothing, on the device.
• Do not use the device for heating in vehicles.
• Do not use this device in the vicinity of fuel, solvents,
varnishes or other easily inflammable vapours or in rooms
where these substances are stored.
• The device may not be used as a heating device for
babies / children or animals.
• The device may not be installed inside a shower or directly
above a bathtub.
• The device must not be used near swimming pools.
• Do not use this device in the immediate vicinity of sinks,
bathtubs or other water containers.
Never immerse the device in water.
• Any operation other than as described in this manual is
prohibited. Non-observance renders all claims for liability
and guarantee null and void.
Any unauthorised changes, modifications or alterations to the
device are forbidden.
Personnel qualifications
People who use this device must:
• be aware of the dangers that occur when working with
electric devices in damp areas.
• have read and understood the operating manual, especially
the Safety chapter.
Symbols on the device
Residual risks
Warning of electrical voltage
Work on the electrical components must only be
carried out by an authorised specialist company!
Warning of electrical voltage
Before any work on the device, remove the mains plug
from the mains socket!
Hold onto the mains plug while pulling the power cable
out of the mains socket.
Warning of hot surface
Some parts of this product can become very hot and
cause burns. Particular attention has to be given where
children and vulnerable people are present!
Warning of hot surface
The surface of the device warms up during operation.
Do not touch the device surface during operation and
observe the minimum distance!
Warning
A falling device can cause injuries! Always transport
and assemble the device with the help of other
persons. Never stand below the device when it is
suspended. Ensure adequate stability of the device's
wall fixing.
Warning
Dangers can occur at the device when it is used by
untrained people in an unprofessional or improper way!
Observe the personnel qualifications!
Warning
The device is not a toy and does not belong in the
hands of children.
Warning
Risk of suffocation!
Do not leave the packaging lying around. Children may
use it as a dangerous toy.
Warning
Risk of injury due to infrared radiation!
Do not stay in the device's immediate vicinity for too
long. Do not look directly into the device for too long.
Observe the minimum distances.
Symbols Meaning
This symbol located on the device indicates that it
is prohibited to place objects (such as towels,
clothes etc.) above or directly in front of the
device.
Warning
Improper installation or mounting entails a risk of fire.
Warning
In order to avoid overheating and fire hazards, the
heater must not be covered.
In order to avoid overheating and fire hazards, the
heater must not be covered.
3 EN
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Behaviour in the event of an emergency
1
3
3
2
4
1. Switch the device off.
2. In an emergency, disconnect the device from the mains
feed-in: Hold onto the mains plug while pulling the power
cable out of the mains socket.
3. Do not reconnect a defective device to the mains.
Information about the device
Device description
The device TIH 300 S / TIH 400 S / TIH 500 S / TIH 700 S /
TIH 900 S / TIH 1100 S is used to quickly generate instant heat.
The device is based on the functional principle of heat
generation by infrared radiation. Persons or objects are heated
directly.
The heating panels ensure an even heat distribution in the room.
Info
The illustrations in this operating manual feature the
device TIH700S by way of example. However, the
depicted operating steps and explanations also apply to
the devices TIH300S, TIH400S, TIH500S, TIH900S
and TIH1100S unless otherwise mentioned.
Device depiction
No. Designation
1 Heating element
2 Operating control lamp
3 Wall attachment
4 Power cable
EN 4
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Transport and storage
Notice
If you store or transport the device improperly, the
device may be damaged.
Note the information regarding transport and storage of
the device.
Transport
Before transporting the device, proceed as follows:
• Hold onto the mains plug while pulling the power cable out
of the mains socket.
• Allow the device to cool down sufficiently.
Storage
Before storing the device, proceed as follows:
• Allow the device to cool down sufficiently.
When the device is not being used, observe the following
storage conditions:
• dry and protected from frost and heat
• protected from dust and direct sunlight
• with a cover to protect it from invasive dust if necessary
• Place no further devices or objects on top of the device to
prevent it from being damaged.
1. Spread out a suitable template over the back of the device
and mark the positions for the bore holes.
2. Attach the template to the wall using adhesive tape or
similar.
3. Drill the holes into the wall at the positions marked on the
template.
Assembly and installation
Scope of delivery
• 1 x IR heating panel
• 4 x Screw
• 4 x Dowel
• 1 x Manual
Unpacking the device
1. Open the cardboard box and take the device out.
2. Completely remove the packaging.
3. Fully unwind the power cable. Make sure that the power
cable is not damaged and that you do not damage it during
unwinding.
Mounting on a wall
When mounting the device to a wall, observe the minimum
distances from walls and other objects as specified in the
Technical data chapter.
• Do not install the device directly behind a door.
• Never install the device in a way that it radiates directly
onto walls or other objects.
• Only install the device in a horizontal position.
4. Remove the template from the wall.
5 EN
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
5. Insert suitable dowels into the bore holes.
6. Insert the screws into the dowels and fasten the screws.
ð The screws should protrude approx. 0.5 cm from the
dowels.
7. Hang the device in.
For assembling the feet, please proceed as follows:
ü Work together with another person who helps you to lift the
device during assembly of the feet.
1. Hold the feet available.
2. Lift the device with the help of another person.
3. Place the device on the feet.
4. The second person keeps on holding the device.
5. Screw down the feet.
Assembling the feet (optional)
The feet can optionally be attached to the device in order to be
able to position the device in the room.
The accessories for the feet are not included in the scope of
delivery.
When positioning the device, observe the minimum distance
from walls or other objects as described in the Technical data
chapter.
EN 6
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
6. Check whether the device is standing in a stable and
upright position.
Start-up
Info
Odours might arise upon initial start-up or after a
longer period of non-use.
• Do not create tripping hazards when laying the power
cable or other electric cables, especially when positioning
the device in the middle of the room. Use cable bridges.
• Check whether the power cable is intact. If the power
cable is damaged, it must be replaced by the
manufacturer, his customer service or similarly qualified
personnel.
• Make sure that extension cables are completely unrolled.
• Make sure that there are no curtains or similar in the
immediate vicinity.
Operation
Info
Avoid open doors and windows.
Switching the device on
Once you have completely installed or positioned the device as
described in the Start-up chapter, you can switch it on.
1. Plug the mains plug into a sufficiently fused mains socket.
Make sure that the power cable is guided along the back
of the device. Never guide the power cable along the front
of the device!
ð The operating control lamp(2) is illuminated.
Shutdown
Warning of electrical voltage
Do not touch the mains plug with wet or damp hands.
1. Hold onto the mains plug while pulling the power cable out
of the mains socket.
ð The operating control lamp(2) goes off.
2. Allow the device to cool down completely.
3. Clean the device according to the Maintenance chapter.
4. Store the device according to the Storage chapter.
Errors and faults
The device has been checked for proper functioning several
times during production. If malfunctions occur nonetheless,
check the device according to the following list.
The device does not start:
• Check the power connection.
• Check the mains plug for damages.
• Wait for 10minutes before restarting the device. If the
device is not starting, have the electrics checked by a
specialist electrical company or by Trotec.
The surface of the device bulges outward:
• The material expands due to heating. This is a normal
process. No measures are required.
The surface of the device only heats up slightly:
• The mains voltage does not meet the requirements. Check
the mains voltage.
• The ambient temperature is low. This is a normal process.
No measures are required.
The device makes noises after switch-on:
• The material expands due to heating. The insulation
expands as well and generates the noises. This is a normal
process. No measures are required.
Info
Wait for at least 3 minutes after maintenance and
repair work. Only then switch the device back on.
Your device still does not operate correctly after these
checks?
Please contact the customer service. If necessary, bring the
device to a specialist company for cooling and air-conditioning
or to Trotec for repair.
Available accessories
Accessories Article number
Set of 2 feet 1.410.003.001
Assembly support fastening
clamps
Socket thermostat BN30 6.100.007.009
7 EN
1.410.003.004
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Maintenance
Activities required before starting maintenance
Warning of electrical voltage
Do not touch the mains plug with wet or damp hands.
• Hold onto the mains plug while pulling the power cable out
of the mains socket.
• Allow the device to cool down completely.
Warning of electrical voltage
Tasks which require the housing to be opened
must only be carried out by authorised specialist
companies or by Trotec.
Cleaning the device
Warning of electrical voltage
Never immerse the device in water!
Clean the device with a soft, damp and lint-free cloth. Ensure
that no moisture enters the housing. Protect electrical
components from moisture. Do not use any aggressive cleaning
agents such as cleaning sprays, solvents, alcohol-based or
abrasive cleaners to dampen the cloth.
Wipe the housing dry after cleaning.
EN 8
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Technical annex
Technical data
Parameter Value
Model
TIH 300 S TIH 400 S TIH 500 S
Article number 1.410.003.008 1.410.003.010 1.410.003.012
Heating capacity 300 W ± 5 % 450 W ± 5 % 580 W ± 5 %
Mains connection 1/N/PE ~ 230 V / 50 Hz 1/N/PE ~ 230 V / 50 Hz 1/N/PE ~ 230 V / 50 Hz
Nominal current 1.3 A 2.0 A 2.6 A
Connection type CEE 7/7 (SchuKo) CEE 7/7 (SchuKo) CEE 7/7 (SchuKo)
Cable length 1.9 m 1.9 m 1.9 m
Efficiency 98 % 98 % 98 %
Surface temperature 70-90 °C 70-90 °C 70-90 °C
Type of protection IP 54 IP 54 IP 54
Weight 2.5 kg 3.5 kg 5 kg
Dimensions
605 x 505 x 22 (mm) 705 x 605 x 22 (mm) 905 x 605 x 22 (mm)
(width x height x depth)
Minimum distances
front
rear
left
right
top
30 cm
6 cm
10 cm
10 cm
50 cm
30 cm
6 cm
10 cm
10 cm
50 cm
30 cm
6 cm
10 cm
10 cm
50 cm
Parameter Value
Model
TIH 700 S TIH 900 S TIH 1100 S
Article number 1.410.003.014 1.410.003.016 1.410.003.018
Heating capacity 700 W ± 5 % 900 W ± 5 % 1100 W ± 5 %
Mains connection 1/N/PE ~ 230 V / 50 Hz 1/N/PE ~ 230 V / 50 Hz 1/N/PE ~ 230 V / 50 Hz
Nominal current 3.2 A 3.9 A 4.8 A
Connection type CEE 7/7 (SchuKo) CEE 7/7 (SchuKo) CEE 7/7 (SchuKo)
Cable length 1.9 m 1.9 m 1.9 m
Efficiency 98 % 98 % 98 %
Surface temperature 70-90 °C 70-90 °C 70-90 °C
Type of protection IP 54 IP 54 IP 54
Weight 6.5 kg 8 kg 9 kg
Dimensions
1,205 x 605 x 22 (mm) 1,205 x 755 x 22 (mm) 1,205 x 905 x 25 (mm)
(width x height x depth)
Minimum distances
front
rear
left
right
top
30 cm
6 cm
10 cm
10 cm
50 cm
30 cm
6 cm
10 cm
10 cm
50 cm
30 cm
6 cm
10 cm
10 cm
50 cm
9 EN
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Information requirements for electrical local space heaters
Parameter Value/item
Model
TIH 300 S TIH 400 S TIH 500 S
Heat output
Nominal heat output P
nom
Minimum heat output (indicative) P
Maximum continuous heat output P
min
max,c
0.3 kW 0.4 kW 0.5 kW
NA NA NA
0.3 kW 0.4 kW 0.5 kW
Auxiliary electricity consumption
At nominal heat output el
At minimum heat output el
In standby mode el
sb
max
min
0.312 kW 0.418 kW 0.566 kW
NA NA NA
NA NA NA
Type of heat input
Manual heat charge control, with integrated thermostat NA NA NA
Manual heat charge control with room and/or outdoor temperature
NA NA NA
feedback
Electronic heat charge control with room and/or outdoor temperature
NA NA NA
feedback
Fan assisted heat output NA NA NA
Type of heat output/room temperature control
Single stage heat output, no room temperature control NO NO NO
Two or more manual stages, no room temperature control NO NO NO
With mechanic thermostat room temperature control NO NO NO
With electronic room temperature control NO NO NO
With electronic room temperature control plus day timer NO NO NO
With electronic room temperature control plus week timer YES YES YES
Other control options
Room temperature control, with presence detection NO NO NO
Room temperature control, with open window detection NO NO NO
With distance control option NO NO NO
With adaptive start control YES YES YES
With working time limitation NO NO NO
With black bulb sensor NO NO NO
Contact details TrotecGmbH&Co.KG
Grebbener Straße 7
D-52525 Heinsberg
NA = not applicable
EN 10
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Information requirements for electrical local space heaters
Parameter Value/item
Model
TIH 700 S TIH 900 S TIH 1100 S
Heat output
Nominal heat output P
nom
Minimum heat output (indicative) P
Maximum continuous heat output P
min
max,c
0.7 kW 0.9 kW 1.1 kW
NA NA NA
0.7 kW 0.9 kW 1.1 kW
Auxiliary electricity consumption
At nominal heat output el
At minimum heat output el
In standby mode el
sb
max
min
0.732 kW 0.942 kW 1.150 kW
NA NA NA
NA NA NA
Type of heat input
Manual heat charge control, with integrated thermostat NA NA NA
Manual heat charge control with room and/or outdoor temperature
NA NA NA
feedback
Electronic heat charge control with room and/or outdoor temperature
NA NA NA
feedback
Fan assisted heat output NA NA NA
Type of heat output/room temperature control
Single stage heat output, no room temperature control NO NO NO
Two or more manual stages, no room temperature control NO NO NO
With mechanic thermostat room temperature control NO NO NO
With electronic room temperature control NO NO NO
With electronic room temperature control plus day timer NO NO NO
With electronic room temperature control plus week timer YES YES YES
Other control options
Room temperature control, with presence detection NO NO NO
Room temperature control, with open window detection NO NO NO
With distance control option NO NO NO
With adaptive start control YES YES YES
With working time limitation NO NO NO
With black bulb sensor NO NO NO
Contact details TrotecGmbH&Co.KG
Grebbener Straße 7
D-52525 Heinsberg
NA = not applicable
11 EN
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Disposal
The icon with the crossed-out waste bin on waste
electrical or electronic equipment stipulates that this equipment
must not be disposed of with the household waste at the end of
its life. You will find collection points for free return of waste
electrical and electronic equipment in your vicinity. The
addresses can be obtained from your municipality or local
administration. For further return options provided by us please
refer to our website www.trotec24.com.
The separate collection of waste electrical and electronic
equipment aims to enable the re-use, recycling and other forms
of recovery of waste equipment as well as to prevent negative
effects for the environment and human health caused by the
disposal of hazardous substances potentially contained in the
equipment.
EN 12
Operating manual – infrared heating panel TIH 300 S / TIH 400 S / TIH 500 S / TIH700 S / TIH 900 S / TIH 1100 S
Trotec GmbH & Co. KG
Grebbener Str. 7
D-52525 Heinsberg
+49 2452 962-400
+49 2452 962-200
info@trotec.com
www.trotec.com
Loading...