Traulsen RET232LUT-FHS User Manual

Project Quantity Item #

Model Specified: CSI Section 11400

Roll-In Even-Thaw Refrigerator/

Self-Contained

Model RET232LUT-FHS

Standard Product Features

• Stainless Steel Exterior & Interior

• Special Refrigeration System/Air Flow Design Promotes

Rapid, Safe Thawing Of Frozen Food Product

• Full Length Stainless Steel Doors With Locks

• Exterior Mounted Dial Thermometer

• Self Closing Doors With Stay Open Feature at 120 Degrees

• Guaranteed For Life Cam-Lift Hinges

• Guaranteed For Life Horizontal Work Flow Door Handles

• Standard Door Hinging: Left/Right (other hingings

available)

• Automatically Activated Incandescent Lights

• Stainless Steel Breaker Caps

• Automatic Non-Electric Condensate Evaporator

• Magnetic Snap In Door Gaskets

• Gasket Protecting Metal Door Liner

• Automatic Non-Electric Condensate Evaporator

• Stainless Steel Roll-In Rack Guides & Door Threshold

Ramps

• Stainless Steel One-Piece Louver Assembly

• 9' Cord & Plug Attached

• One Year Parts and Labor Warranty

• Five Year Compressor Warranty

Two Section Roll-In Model - 32" Deep

R

SERIES

Stainless Exterior

& Interior

The Traulsen roll-in even-thaw refrigerator model is designed to thaw
frozen food product under safe, temperature controlled conditions. It can
be used to rapidly thaw both full or partial loads of frozen food product.

This model includes such high quality cabinet features as stainless steel
exterior and interior construction, self-closing doors with a stay open
feature, and is designed to accommodate two (2) 66" high roll-in racks
(supplied by others).

Roll-In Model RET232LUT-FHS

Options & Accessories

• Decorative Kool Klad Laminate Decor

• Stainless Steel Finished Back With Rear Louvers

• Two Year Service/Labor Warranty Available



R

Listed by Underwriters Laboratories Inc., to U.S.
and Canadian safety standards and classified
by Underwriters Laboratories in accordance with
ANSI/NSF7.

AW-03118

TRAULSEN
4401 BLUE MOUND RD. FT. WORTH, TX 76106
PHONE [phone] FAX-MKTG. 1 [phone]
Website: www.traulsen.com

Approval: __________________________________

SECTION

7-9

Project Quantity Item #

Model Specified: CSI Section 11400

Specifications

CONSTRUCTION, HARDWARE AND INSULATION

Cabinet exterior, including front, one piece sides, louver assembly and doors are
constructed of heavy gauge stainless steel. Cabinet interior is constructed of
stainless steel. Exterior cabinet top, back and bottom are constructed of heavy
gauge aluminized steel. The interior floor is constructed of stainless steel and
insulated with
is provided.

Doors are equipped with removable plug cylinder locks and guaranteed for life cam­lift, gravity action, self-closing metal, glide hinges with stay open feature at 120°.
Hinges include a switch to automatically activate the interior incandescent lighting.
Guaranteed for life, work flow door handle is mounted horizontally over recess in
door which limits protrusion from door face into aisleways.

Vinyl magnetic door gaskets assure tight door seal and are easily removable for
cleaning. Cabinet contains high density, non-CFC, foamed in place polyurethane
insulation.

3

⁄4" of resilient cork. A readily attachable stainless steel ramp

DIMENSIONAL DATA RET232LUT-FHS

Net Capacity cu. ft. 74.3 (2105 cu l)

Length - Overall in. 68 (172.7 cm)

Depth - Over Body in. 32 (81.3 cm)

Depth - with door open 90° 631⁄4 (160.7 cm)

Depth - Overall in. 359⁄16 (90.3 cm)

Clear Door Width in. 271⁄8 (68.8 cm)

Clear Full Door Height in. 665⁄

16

(168.4 cm)

Height - Overall in. 831⁄4 (211.5 cm)

ELECTRICAL DATA

1

Voltage 208/115/60/1

Feed Wires with Ground 4

Full Load Amperes 16.0

REFRIGERATION DATA

1

Refrigerant R-404A

BTU/HR2 (HP) 3790 (3/4 HP)

CARTON DIMENSIONS

Length - Crated in. 73 (185 cm)

Depth - Crated in. 44 (112 cm)

Height - Crated in. 921⁄2 (235 cm)

Volume - Crated cu. ft. 172 (4872 cu l)

WEIGHT DATA

Net Weight - Uncrated lbs. 700 (318 kg)

Gross Weight - Crated lbs. 865 (392 kg)

NOTE: Figures in parentheses reflect metric equivalents.
1= Wattage is determined by listed amps X listed volts X an average run time of

70% for refrigerators and 80% for freezers.

2= Based on a 90 degree F ambient and 20 degree F evaporator.

NOTES

REFRIGERATION SYSTEM

A top mounted, self-contained, balanced refrigeration system using R-404A
refrigerant is conveniently located behind the one-piece louver assembly. It features
a plenum effect blower, large, high humidity evaporator coil located outside the food
zone, coated with a plastic to retard corrosion, and a top mounted non-electric
condensate evaporator. Heaters and fans mounted in the mullion facilitate the
even-thaw process. A cord and plug is supplied standard. Standard operating
temperature is 37-41°F.

INTERIOR ARRANGEMENTS

This model is designed to accommodate two (2) roll-in racks. Readily removable,
interior mounted, stainless steel guides for racks are provided for protection.
Maximum rack size with wheels inboard of frame is 27” wide by 29” deep by 66” high.
Racks supplied by others.

WARRANTIES

Both a one year parts and labor warranty and a five year compressor warranty (self­contained models only) are provided standard. An optional 2
and labor warranty is also available.

nd

year extended parts

Elevation - RET232LUT-FHS

Plan - RET232LUT-FHS

Equipped With One NEMA L14-20P Plug

Full load amps and plug style may vary depending on
electrical options chosen and condensing unit employed.

In order to assure optimum performance, the condensing unit MUST have an adequate supply of
air for cooling purposes. Therefore, the operating location must either have a minimum of 12”
clearance overhead of the condensing unit or allow for unrestricted air flow at the back of the unit.
Clearance of at least 12” above is required in order to perform certain maintenance tasks.

NOTE: When ordering please specify: Voltage, Hinging, Door Size, Options and any
additional warranties.

Continued product development may necessitate specification changes without notice.
Part No. TR35852 (revised 1/07)

SECTION

7-9

REQUIRED CLEARANCES

TRAULSEN
4401 BLUE MOUND RD. FT. WORTH, TX 76106
PHONE [phone] FAX-MKTG. 1 [phone]
Website: www.traulsen.com

Section - RET232LUT-FHS