Installation Manual
SKU# 29054 TracVan Double
SKU# 29055 TracVan Double
SKU# 29056 TracVan Triple
2 TracRac
INSTRUCTION MANUAL
TracVan installation is straightforward, and should take you
the Corner Brackets, then attach this assembly to the Gutter
TRACVAN
Tools Required
• All 1998 + Chevy Express / GMC Savanna (G-Series Vans) require the supplied Gutter
tions on page 5 for proper installation.
• All 200 0+ Ford Econoline Vans: DO NOT install the rubber strips to the Corner Brackets.
• When installing a TracVan Triple
(SKU# 29056)
to a Chevy Express / GMC Savanna
to compensate for the gutter’s curve.
TracRac
3
INSTALLATION INSTRUCTIONS
SKU# 29054, 29055 & 29056
Thread each screw approx. 1/4 in. into the J-hook’s brass
5. Now you’re ready to attach the Crossbars (see Shim
(see Fig. 2
• On 2000+ Ford 150 Econoline vans.
• If using the Gutter Spans
through the Lock Washers and then into the holes in each
(See Fig. 1)
van’s roof, making sure
that the Crossbars are
the Corner Brackets
from the driver and
Tiedown
Assembly slot
T-Bolt
TracRac
Normal Installation
9. The lower edge of each Corner Bracket fits snugly into
the top corner of the van’s rain gut ter. Place the J-Hooks
with Neoprene Strips around the outside edge of rain
• Roof Installation A: Normal Installation
the Crossbar.
you’re ready to go!
• Roof Installation B: Gutter Span Installation
Roof Installation A:
6 TracRac
Roof Installation B:
9. Slide 2 Gutter Spans under each Corner Bracket so
that they line up under the slots as shown, with the “V”
(see Fig 3B).
the top of the Gutter Span. Place the J-Hooks around the
the Crossbar.
TracRac
Recheck the bolt torques every 3000 miles.
With prolonged driving, vibrations may cause the
fasteners to loosen.
The gutters on some Vans are curved, which makes install-
the middle rack.
(Fig. 5)
flatly and evenly on all three crossbars. Complete instal-
7. Check all fasteners for proper torque.
SHIM INSTALLATION
_IM_
Loading...