TP Toys TP880 Nagano, TP877 Himalayan, TP883 Woburn Instructions For Assembly, Maintenance And Safe Use

TP880 Nagano
TP877 Himalayan
TP883 Woburn

Instructions for assembly, maintenance and safe use.
Please retain for future reference.

Robovision Ltd t/a TP Toys

Unit 11, Enterprise Way, Flitwick, Bedfordshire, MK45 5BX England

www.tptoys.com

THIS PRODUCT CONTAINS SMALL PARTS AND IS NOT SUITABLE FOR CHILDREN UNDER 36 MONTHS.
CONTAINS SMALL PARTS. CHOKING HAZARD.

ONLY FOR DOMESTIC USE. FOR OUTDOOR USE.
TOY MUST BE ASSEMBLED BY AN ADULT BEFORE USE.
ADULT SUPERVISION IS REQUIRED
CHILDREN MUST NOT USE THE EQUIPMENT UNTIL PROPERLY INSTALLED.
REMOVE ALL PACKAGING BEFORE GIVING TO YOUR CHILDREN.
THIS PRODUCT IS INTENDED FOR USE BY CHILDREN FROM AGES 3 TO 12 YEARS.
ANCHORS THAT ARE SUPPLIED WITH THIS PRODUCT MUST BE FITTED BEFORE USE.
MAXIMUM COMBINED USER WEIGHT FOR SWING FRAMES 200KGS

TP880 NAGANO SINGLE SEAT USER WEIGHT - 60KGS GLIDE RIDE USER WEIGHT - 35KGS PER SEAT

TP877 HIMALAYAN NEST SWING USER WEIGHT - 120KGS

TP883 WOBURN SINGLE SEAT USER WEIGHT - 60KGS GLIDE RIDE USER WEIGHT - 35KGS PER SEAT

WARNING!

x2

TP880 Nagano TP877 Himalayan TP883 Woburn

Build Time

2 Hrs

TP880 TP883 TP877 Roundwood Swings New In8001-A 23.02.18.indd 1 23/02/2018 12:18

TP880 TP877 & TP883

2

Important advice for assembly, maintenance and safe use

1. Toys must be assembled by an adult before use exactly in accordance with the instructions.

2. Check all parts are present before you start to assemble the product.

3. Place small parts on a tray or similar, to ensure they are not lost.

4. If any parts are missing do not use the product until the replacement parts are fitted.

5. Remove all packaging before giving to your children or allowing them to play with this product.

6. Ensure your product is sited on level ground. Failure to do this may put additional stress on connections and joints
and in time could cause them to fail.

7. Ensure your product is located on a soft impact surface like grass. Never locate your product on hard surfaces like
concrete or asphalt.

8. Children must not use this product until properly installed.

9. Adult supervision is required at all times to ensure children play safely. Ensure children’s clothing is appropriate for
the play activity.

10. Equipment should be checked by an adult at the beginning of each season and at regular intervals during the
usage season to ensure it is safe.

11. Pay special attention to all connections and fastenings.

12. Parts may need to be replaced if they show signs of wear and tear. Replace any defective parts in accordance
with these instructions.

13. Any changes to this toy, e.g. changing or adding an accessory, must be done in accordance with our instructions.
Failure to do this will render your guarantee null and void and may make your product unsafe.

14. The age recommendation for this product is clearly stated on the packaging and these instructions. Please adhere
to it at all times.

15. When you dispose of this equipment please do so responsibly.

Safe play free space area

The safe play area refers to the zone extending 200cm
around the toys on all sides and 250cm above the toy.
The safe play area must be free from all obstacles.

Dimensions

2m

2m

2m

2m

TP880
TP877
TP883

276cm

240cm

300cm 300cm 375cm

TP880 Nagano TP877 Himayalan TP883 Woburn

TP880 TP883 TP877 Roundwood Swings New In8001-A 23.02.18.indd 2 23/02/2018 12:18

TP880 TP877 & TP883

3

Know Your TP Round Wood.

Timber is a very popular choice for active outdoor toys. For reasons of affordability and the environment, all wood playset
manufacturers use softwood rather than hardwood. Each piece of timber is unique, bearing its own knots, cracks and
variations in colour.

Round timbers tend to come from younger smaller trees and are complete tree poles, stripped of any bark and other
rough materials but subject to no further processing apart from the application of a suitable environmentally friendly
preservative.

Our round wood frames are rustic in appearance. The heartwood that they are made from naturally has cracks and
splits. Theses cracks will change over time due to atmospheric conditions. When wet, the wood will take in water, swell
and the cracks will close up (not disappear), when dry the wood contracts and the cracks will open up.

Whilst this can sometimes seem alarming, the round timber frames are designed and dimensioned to ensure these
natural characteristics do not have an impact upon the structural integrity of the frame. All of our wooden play frames
are rigorously tested by an independent test house and fully comply with the relevant toy safety regulations.

Because of the natural characteristics of such wood products, it is vital that parents check their play frame regularly to
identify any splintering or lifting of the surface layers of the wood or any exposure of rough wood due to changes in
cracks and splits. Affected areas must be rubbed down using coarse sandpaper to restore a smooth. Safe surface.

Very occasionally these characteristics can develop to a point where replacing the pole may be required. This can be if a
crack is in a particular position or if a crack exceeds certain parameters. Examples of this are:

• Where cracks open up in excess of 5mm in width.

• Where cracks of a significant width extend over half the total length of the timber.

• Where cracks run through fixing points.

TP880 TP883 TP877 Roundwood Swings New In8001-A 23.02.18.indd 3 23/02/2018 12:18

4

TP880 TP877 & TP883

TP880 TP877 TP883

Contents - Please check

5mm

Drill Bit

Step Ladder Spirit LevelTape MeasureMallet

Combi Drill

Pozi #2
Pozi #3

Screwdriver WrenchSockets

10 & 13mm

Spanner

10 & 13mm

MW0200 2700mm x2

801

Not Supplied

MW0202 900mm x2

PR9598

TP880 x2

TP877 x2

TP883 x4

M8 x25mm

FA8440

x16

70mm FA8439

x16

PR5069

x4

40mm FA8380

x6

4 x 16mm FA4527

x2

Fixings - SP0075

Shovel

802 - 1

Please note: There may be some fixings left over after the assembly build.

FB6038

x2

PM1007
Flag x1

MW0203 2250mm x1

803 - 1

MW0201 3000mm x1

Swing Accessories

Swing Seats supplied vary depending on product purchased.

See page 10 for details.

TP928

Lime Seat

TP940

Glide Ride

TP932

Nest Swing

MW0200 2700mm x2

MW0200 2700mm x2

PM1968

x1

880- 2 Nagano / 877-2 Himalayan / 883-2 Woburn

880-1 Nagano / 877-1 Himalayan

883- 1 Woburn

880-3 / 887-3 / 883-3 880- 3 Nagano / 877-3 Himalayan / 883-3 Woburn

Also

Required:

Tools - You will need:

TP880 TP883 TP877 Roundwood Swings New In8001-A 23.02.18.indd 4 23/02/2018 12:18