Toyota TNS300ETA Installation Instructions Manual

INSTALLATION INSTRUCTIONS

TOYOTA MOTOR CORPORATION

PART NUMBER

Manual Ref. Nr. D3RT25/W-0-0

FOR

**

T25*R

TOYOTA NAVIGATION SYSTEM

Avensis (RHD)

MOUNTING BRACKET KIT

PZ425-T0330-60

RDS-ANTENNA KIT

PZ445-T9281-00

NAVIGATION KIT

08545-20800

ADDITIONAL PARTS

see page 7

06-03

Avensis (T25) TNS300ETA

Avensis (RHD) - 2

PRECAUTIONS

• Do not pinch the rear wiring or har­ness in the tightened part.

PLEASE READ THOROUGHLY THESE PRECAUTIONS BEFORE THE INSTALLATION

• Be sure to disconnect the negative
(-) lead from the battery terminals.

• When passing the wires through the
dashboard or other panels, use a
grommet to ensure waterproofing.

• Protect the wiring with tape when it is
passed through a hole.

• When disconnecting the connectors,
be sure to grip the connector body.
Do not tug on the wiring.

• Do not forcibly pull any car wiring harness.
Rough tugging may result in opened con­nections, or a broken wire or harness.

•

Confirm that lamps, horn, wiper and
other car accessories operate normally.

• Protect your car with fender covers, seat
and so on.

• Use the correct tool when tightening
bolts or nuts.

• Before drilling a hole, check that the rear of
the mounting wall is clear.

• Be sure to firmly tighten connectors
and terminals.

• Before connecting the power wiring to
the battery, check the wiring con­nections, harness, etc. to see that they
are properly secured.

• Check body and trim near area of installation to be certain no
dirt or scratches resulted from the installation.

waterproof - O.K. !!

Taping

Grommet

Insert

completely

Stop it !

1. Precautions ............................................................................................................................................................ 2

2. Table of contents .................................................................................................................................................... 3

3. Application chart .................................................................................................................................................... 4

4. Navigation kit ......................................................................................................................................................... 5

5. Mounting bracket kit .............................................................................................................................................. 5

6. RDS-antenna kit ..................................................................................................................................................... 6

7. Required parts ....................................................................................................................................................... 6

8. Additional parts ...................................................................................................................................................... 7

9. Wiring connection .................................................................................................................................................. 8

10. Installation overview .............................................................................................................................................. 9

11. Vehicle disassembly ............................................................................................................................................... 10

12. Installation of the GPS antenna .............................................................................................................................. 16

13. Wire harness installation ........................................................................................................................................ 18

14. Installation of the RDS antenna wire ...................................................................................................................... 19

15. Installation of the RDS antenna ............................................................................................................................ 21

16. Installation of the TNS computer + ETA ................................................................................................................. 23

17. Installation of the navigation disc .......................................................................................................................... 26

18. Post-Installation inspection .................................................................................................................................... 27

19. Reassembling ......................................................................................................................................................... 27

06-03

Avensis (T25) TNS300ETA

Avensis (RHD) - 3

TABLE OF CONTENTS

+ ADD-ON UNIT

(

S

)

Hide Awa

y

CD-Chan

g

er TM0461

(

08601-00911

)

Navi

g

ation S

y

stem TNS300

(

08545-20800

)

1

Radio/Cassette/CD (Lo) (only) MOP-unit or

-

W53900 (08600-05821)

-

2

Radio/Cassette/CD (Hi) (only) MOP-unit or

-

W53901 (08600-05822)

-

3

Radio/Cassette/CD (Lo) + Hide Away CD-Changer MOP-unit or

(2) Wire (08695-00370)

W53900 (08600-05821)

(2) Wire (08695-00370)

4

Radio/Cassette/CD (Lo) + In-Dash CD-Changer MOP-unit or

(1) Wire (08695-00370) + F/K (08695-05801)

W53900 (08600-05821)

(1) Wire (08695-00370) + F/K (08695-05801)

5

Radio/Cassette/CD (Lo) + Navigation (TBT) MOP-unit or

(3) Wire (08695-00370) + F/K (PZ425-T0330-60)

W53900 (08600-05821)

(3) Wire (08695-00370) + F/K (PZ425-T0330-60)

6

Radio/Cassette/CD (Lo) + Hide Away CD-Changer + Navigation (TBT) MOP-unit or

(2) (3) Wire (08695-00370) + F/K (PZ425-T0330-60)

W53900 (08600-05821)

(2) (3) Wire (08695-00370) + F/K (PZ425-T0330-60)

7

Radio/Cassette/CD (Lo) + In-Dash CD-Changer + Navigation (TBT) MOP-Unit or

(1) (3) Wire (08695-00370) + F/K (08695-05801) + F/K (PZ425-T0330-60)

W53900 (08600-05821)

(1) (3) Wire (08695-00370) + F/K (08695-05801) + F/K (PZ425-T0330-60)

8

Radio/Cassette/CD (Hi) + Hide Away CD-Changer MOP-unit or

(2) Wire (08695-00370)

W53901 (08600-05822)

(2) Wire (08695-00370)

9

Radio/Cassette/CD (Hi) + In-Dash CD-Changer MOP-Unit or

(1) Wire (08695-00370) + F/K (08695-05801)

W53901 (08600-05822)

(1) Wire (08695-00370) + F/K (08695-05801)

10

Radio/Cassette/CD (Hi) + Navigation (TBT) MOP-unit or

(3) Wire (08695-00370) + F/K (PZ425-T0330-60)

W53901 (08600-05822)

(3) Wire (08695-00370) + F/K (PZ425-T0330-60)

11

Radio/Cassette/CD (Hi) + Hide Away CD-Changer + Navigation (TBT) MOP-Unit or

(2) (3) Wire (08695-00370) + F/K (PZ425-T0330-60)

W53901

(

08600-05822

)

(

2

)

(

3

)

Wire

(

08695-00370

)

+ F/K

(

PZ425-T0330-60

)

12

Radio/Cassette/CD (Hi) + In-Dash CD-Changer + Navigation (TBT) MOP-Unit or

(1) (3) Wire (08695-00370) + F/K (08695-05801) + F/K (PZ425-T0330-60)

W53901 (08600-05822)

(1) (3) Wire (08695-00370) + F/K (08695-05801) + F/K (PZ425-T0330-60)

Unique Design Audio

HEAD UNITCOMBINATION REQUIRED ADDITIONAL PARTS

In-Dash CD-Chan

g

er TM0561

(

08601-00907

)

AUDIO & NAVIGATION APPLICATION CHART

TMME-CA Division Dev. Dept. II - August 21st, 2003

Avensis **T25*R

(RHD)

p. 1/1

MOP: Factory installed option

(1): Glove box application (2): Located under the RH-seat (3): Located under the LH-seat

Avensis (RHD) - 5

NAVIGATION KIT 08545-20800

Avensis (T25) TNS300ETA

06-03

No. Part name Part No. Quantity

Navigation ECU 08662-00850 1
Bolt (M5x8) 4
Butyl tape 1

C

B

A

A

B

C

(a)

(b)

(c)

(d)

(e)

No. Part name Part No. Quantity

(a) ECU Bracket L 1
(b) ECU Bracket R 1
(c) Bolt (M5x8) 2
(d) Foam tape 1
(e) Bolt (M8x15) 1

i

MOUNTING BRACKET KIT PZ425-T0330-60

i

Avensis (T25) TNS300ETA

Avensis (RHD) - 606-03

NAVIGATION DISC

To be ordered separately.
Please refer to the list of available DVD-ROM for TNS300 Navigation Systems (Access to accessories).

OWNER’S MANUAL

To be ordered separately.

REQUIRED PARTS

(1): For vehicles without pre-wired RDS-antenna.

RDS-ANTENNA KIT PZ445-T9281-00

(1)

(1)

IIIIII

IV

No. Part name Part No. Quantity

Antenna strip PZ445-E9281-01 1

(1)

RDS antenna wire PZ445-T9281-01 1

(1)

Ground bolt 1
Fakra connector PZ445-E9330-01 1

IV

IIIIII

Avensis (T25) TNS300ETA

Avensis (RHD) - 7 06-03

No. Part name Part No. Quantity

Bracket cover 86804-32010 1
RDS-Tuner PZ445-E9330-02 1
Subwire harness PZ445-E9330-03 1

(3)

Extension wire PZ445-T0210-60 1

(2)

GPS antenna 08663-00811 1

(2)

Earth plate 08674-00810 1
Wire tie 12

12

11

9

8

5

4

2

2

4

5

8

12

11

9

ADDITIONAL PARTS

(2): For vehicles without pre-wired GPS-antenna.
(3): For vehicles without pre-wired connector.

(2)

(2)

(3)

Avensis (T25) TNS300ETA

Avensis (RHD) - 806-03

WIRING CONNECTION

Connection Method:

Vehicle Wire harness

4

8

9

No. Part name

RDS-TUNER
SUBWIRE HARNESS
EXTENSION WIRE
GPS ANTENNA

NAVIGATION ECU
RDS ANTENNA WIRE

II

A

9

8

5

4

1P

8P

13P

A

5

GPS antenna

II

Avensis (T25) TNS300ETA

Avensis (RHD) - 9 06-03

INSTALLATION OVERVIEW

9

4

8

A

EXTENSION WIRE
GPS ANTENNA WIRE
RDS ANTENNA WIRE
RDS-TUNER
ANTENNA STRIP
NAVIGATION ECU

A

I

4

II

9

8

II

I