Toyota Corolla 2004 Repair Manual - REAR SPOILER

76–7

–EXTERIOR/INTERIOR TRIM REAR SPOILER

REAR SPOILER

760I1–02

REPLACEMENT

HINT:
Installation is in the reverse order of the removal. But the installation is indicated only when it has a point.

1. REMOVE LUGGAGE COMPARTMENT DOOR COVER

2. REMOVE REAR SPOILER

(a) Remove the 2 screws.
(b) Disconnect the wire harness connector.
(c) Put protective tape.
(d) Using a heat light, heat the spoiler to 40 – 60C (104 –

140F).

(e) Tie both piano wire ends to a wooden block or a similar

object.

Clip

Clip

Protective Tape

Clip

B59776

B59775

(f) Scrape the spoiler protector off by pulling the piano wire

as shown in the illustration.

NOTICE:

 If reusing the rear spoiler, take care not to damage the

rear spoiler.

 Do not damage the body and wire harness.

(g) Remove the 2 clips, wire harness grommet and rear spoil-

er.

3. REMOVE CENTER STOP LAMP ASSY

(a) Remove the 2 bolts and the center stop lamp assembly.

4. INSTALL REAR SPOILER

(a) Using a heat light, heat the body mounting surface to 40

–60C (104 – 140F).

NOTICE:
Do not heat the body excessively.

(b) Remove the protective tape from the body.
(c) Wipe off the stains with cleaner.
(d) Clean the rear spoiler (if reusing the rear spoiler).

(1) Using a heat light, heat the rear spoiler to 40 –60 C

(104 – 140F).

NOTICE:
Do not heat the rear spoiler excessively.

(2) Remove the rear spoiler protector from the rear

spoiler.

(3) Wipe off the stains with cleaner.

2004 COROLLA (RM1037U)

1862Author: Date:

76–8

–EXTERIOR/INTERIOR TRIM REAR SPOILER

Rear Spoiler Protector RH

Rear Spoiler Protector LH

Rear Spoiler Side Protector RH

Rear Spoiler Side Protector LH

(4) Install 4 new rear spoiler protectors to the rear spoil-

er as shown in the illustration.

B59774

2004 COROLLA (RM1037U)

1863Author: Date: