Town & Country Fireplaces TC30 User Manual
USER MANUAL
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
WARNING: If the information in these
instructions is not followed exactly, a re or
explosion may result causing property damage,
personal injury or death.
FOR YOUR SAFETY
Installation and service must be performed
by a qualied installer, service agency or the
gas supplier.
WHAT TO DO IF YOU SMELL GAS
• Donottrytolightanyappliance.
• Donottouchanyelectricalswitch.
•Donotuseanyphoneinyourbuilding.
• Immediatelycallyourgassupplierfrom
a neighbour’s phone. Follow the gas
supplier’s instructions.
• Ifyoucannotreachyourgassuppliercall
the re department.
TC30
USER MANUAL
Do not store or use gasoline or other ammable
vapours and liquids in the vicinity of this or
any other appliance.
This appliance may be installed in an aftermarket
permanently located, manufactured home (USA only)
or mobile home, where not prohibited by local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is
not convertible for use with other gases, unless a
certied kit is used.
This appliance is suitable for installation in a
bedroom or bed sitting room.
MODEL TC30
SERIES D - Version 2
MODULAR DIRECT VENT
FIREPLACE
Visit www. townandcountryfireplaces.net for the most recent version of this manual
100817-16 TC30_D.Ver 2 5056.430D
DANGER
Table of Contents
Caution .....................................................................3
Safety .......................................................................3
Lighting Instructions .................................................4
First Fire ....................................................................5
Special Operator Note ..............................................5
Remote Control Operation .......................................5
Fireplace Description ...........................................7
Transmitter (Remote Control with LCD Display) ..7
IFC Module ..........................................................7
Operating Procedure ...........................................7
Using the Remote Control Transmitter ................8
Temperature indication Display ...........................8
Turn on the Fireplace ...........................................8
Turn off the Fireplace ...........................................8
Manual Bypass of the Remote Fireplace.............8
Instructions for enabling the
Thermostat function for Canadian users ..................9
Remote Flame Control ........................................9
Smart Thermostat (Transmitter Operation)
if enabled .............................................................9
Room Thermostat (Transmitter Operation) ..........9
Remote dimmer control (Light) ..........................10
Continuous Pilot/Intermittent Pilot
(CPI/IPI) selection ..............................................10
Key Lock ............................................................10
Low Battery Power Detection ............................10
Transmitter .........................................................10
Receiver .............................................................10
®
Linking Remote Handset and Apple
to Fireplace .............................................................11
Step 1: Procedure for linking / pairing
wall switch to replace ......................................11
Step 2: Procedure for linking / pairing the wall
switch to remote handset ..................................12
Step 3: Optional procedure for linking / pairing
a BlueTooth
to the replace (iOS only). .................................12
Using the TC Fire app ........................................13
Maintenance ...........................................................14
Glass Panel: .......................................................14
Annual Inspection: .............................................14
Periodically: .......................................................14
Warranty ...................................................................15
®
enabled apple mobile device
Device
!
A barrier designed to reduce the risk of burns from the
hot viewing glass is provided with the appliance and
shall be installed for the protection of children and
other at-risk individuals.
5056.430D
HOT GLASS WILL CAUSE
BURNS.
DO NOT TOUCH GLASS UNTIL
COOLED.
NEVER ALLOW CHILDREN TO
TOUCH GLASS.
2
TC30-D ver2_100817-16
Caution
FOR YOUR SAFETY - Do not install or operate your Town & Country
replace without rst reading and understanding this manual. Any
installation or operational deviation from the following instructions voids
the Town & Country Fireplaces Warranty and may prove hazardous.
This appliance and its individual shut off valve must be disconnected
from gas supply piping system during any pressure testing of that system at test pressures in excess of 1/2 psig (3.5 kPa).
This appliance must be isolated from the gas supply piping system by
closing its individual manual shut off valve during any pressure testing of
the gas supply piping system at test pressures equal to or less than 1/2
psig (3.5 kPa).
Note: When lit for the rst time, the appliance will emit a slight odour
for a couple of hours. This is due to the curing of paints, sealants
and lubricants used in the manufacturing process. This condition is
temporary. Open doors and windows to ventilate area. Smoke and
fumes caused by the curing process may cause discomfort to some
individuals.
We recommend that our gas
hearth products be installed and
serviced by professionals who are
certied in the United States by the
National Fireplace Institute® (NFI)
as NFI Gas Specialists
Do not use the replace if any part has been under water. Immediately
call a qualied service technician to inspect the replace and to replace
any part of the control system and any gas control which has been
under water.
Safety
Due to high temperatures, this gas appliance should be located out of trafc and away from furniture and
draperies.
Children and adults should be alerted to the hazards of high surface temperatures and should stay away to
avoid burns or clothing ignition.
Young children should be carefully supervised when they are in the same room as the appliance. Toddlers,
young children, and others may be susceptible to accidental contact burns. A physical barrier is recommended if there are at-risk individuals in the house. To restrict access to a replace or stove, install an adjustable safety gate to keep toddlers, young children, and other at-risk individuals out of the room and away from
hot surfaces. Clothing or other ammable material should not be placed on or near the appliance.
Any grill, panel or door removed for servicing the unit must be replaced prior to operating. Failure to do so
may create a hazardous condition.
Installation and repair should be done by a qualied service person. The appliance should be inspected
before use and at least annually by a professional service person. More frequent cleaning may be required
due to excessive lint from carpeting, bedding material, etc. It is imperative that control compartments, burners
and circulating air passageways of the appliance be kept clean.
It is our policy that no responsibility is assumed by the Company or by any of its employees or representatives for any damages caused by an inoperable, inadequate, or unsafe condition which is the result, either
directly or indirectly, of any improper operation or installation procedures.
This appliance must not be connected to a chimney ue serving a separate solid fuel burning appliance.
TC30-D ver2_100817-16
3
5056.430D
FOR YOUR SAFETY READ BEFORE LIGHTING
WARNING:
A. This appliance is equipped with an ignition device which
building.
- Immediately call your gas supplier from a neighbour's phone. Follow
1. STOP! Read the safety information above on this label.
"On/ Off" switch for the fireplace to OFF, turn off all electric power
to the fireplace and call your service technician or gas supplier.
6. Set fireplace to desired setting by using hand held remote.
1.
2. Turn off all electric power to the appliance and remove backup
Due to high surface temperatures, keep children, clothing and furniture away. Keep burner and control compartment clean. See installation and
CAUTION:
090713
5051.185
GBWY
Lighting Instructions
fire or explosion may result causing property damage,
personal injury or loss of life.
If you do not follow these instructions exactly, a
automatically lights the pilot. Do not try to light the pilot by hand.
B. BEFORE LIGHTING smell all around the appliance area for gas. Be
sure to smell next to the floor because some gas is heavier than
air and will settle on the floor.
WHAT TO DO IF YOU SMELL GAS:
- Do not try to light any appliance.
- Do not touch any electric switch; do not use any phone in your
LIGHTING INSTRUCTIONS
2. This appliance is equipped with an ignition device which
automatically lights the pilot. Do not try to light the pilot by hand.
3. Push the "On/ Off" switch to turn the fireplace ON.
- If the burner does light go to step 6.
- If the burner does not light, complete steps 4 through 5.
- If the burner will not light or stay lit after several tries, push the
TO TURN OFF GAS APPLIANCE
Push the "on/ off" switch to the "Off" position.
the gas supplier's instructions.
- If you cannot reach your gas supplier, call the fire department.
C. Use only your hand to push in or turn the gas control knob. Never use
tools. If the knob will not push in or turn by hand, don't try to repair it,
call a qualified service technician. Force or attempted repair may
result in a fire or explosion.
D. Do not use this appliance if any part has been under water.
Immediately call a qualified service technician to inspect the
appliance & to replace any part of the control s
control which has been under water.
ystem & any ga
s
Note: Sufficient time must be allowed for air to escape from lines if
the unit is being lit for the first time.
4. Push the "On/ Off" switch to the fireplace Off.
5. Allow sufficient length of time (minimum 5 minutes) for any gas in the
combustion chamber to escape. If you still smell gas, STOP! Follow
"B" in the safety information above on this label. If you don't smell
gas, go to step 3.
batteries if service is to be performed or for extended shutdown.
operating instructions accompanying the appliance.
A cause de la temperature elevee des parios, tenir eloignes les enfants, les vetements et les meubles. Maintenir propres le bruleur et le
compartiment de commande. Voir les instructions relatives a l'installation et au fonctionnement qui accompagnent l'appareil.
Hot while in operation. Do not touch. Severe burns may result. Keep children,
clothing, furniture, gasoline and other liquids having flammable vapours away. Keep burner and control
compartment clean. See installation and operating instructions accompanying the appliance.
ATTENTION:L'appareil est chaud lorsqu'il fonctionne. Ne pas toucher l'appareil. Risque de
brûlures graves. Serveiller les enfants. Garder les vêtements, le meubles, l'essence ou autres liquides
produisant des vapeurs infl ammables loin de l'appareil. S'assurer que le brûleur et le compa
commandes sont propres. Voir les instructions d'installation et d'utilisation qui accompagnent l'appareil.
rtiment des
5056.430D
4
TC30-D ver2_100817-16
First Fire
When lit for the rst time, the replace will emit a slight odor for a couple of hours. This is due to the curing of paints, sealants and lubricants used in the manufacturing process. This condition is temporary. Open
doors and windows to ventilate area. Odors caused by the curing process may cause discomfort to some
individuals.
It is normal for replaces fabricated of steel to give off some expansion and/or contraction noises during the
start up or cool down cycle. Similar noises are found with your furnace heat exchanger or cook stove oven.
Special Operator Note
NOTE: Fireplace may
take up to 30 seconds
to ignite each time the
“ON” button has been
selected.
Remote Control Operation
Blue back lit LCD display
ON/OFF Key
THERMOSTAT Key
UP/DOWN Arrow Key
MODE Key
Figure 1: Proame 2 handset.
TC30-D ver2_100817-16
5
5056.430D
Loading...