Toshiba 57H84, 51H84, 46H84 User Manual
FILE NO. 020-200404
DOCUMENT CREATED IN JAPAN, July, 2004
CIRCUIT DIAGRAMS
Projection Television
N4PSP Chassis
46H84
51H84
57H84
SCHEMATIC DIAGRAM
MODEL : 46H84/51H84/57H84
WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "X-RAY RADIATION PRECAUTION", "SAFETY
PRECAUTION" AND "PRODUCT SAFETY NOTICE" ON THE MANUAL FOR THIS MODEL.
CAUTION: The international hazard symbols " " in the schematic diagram and the parts list designate components
which have special characteristics important for safety and should be replaced only with types identical to those in the
original circuit or specified in the parts list. The mounting position of replacements is to be identical with originals.
Before replacing any of these components, read carefully the PRODUCT SAFETY NOTICE on the MANUAL for this
model. Do not degrade the safety of the receiver through improper servicing.
NOTE:
1. RESISTOR Resistance is shown in ohm [K = 1.000, M = 1.000.000]. All resistors are 1/6W and 5% tolerance
carbon resistor, unless otherwise noted as the following marks.
1/2R = Metal or Metal oxide of 1/2 watt 1/2S = Carbon compsistion of 1/2 watt
1RF = Fuse resistor of 1 watt 10W = Cement of 10 watt
±
10% G = ±2% F = ±1%
K =
2. CAPACITOR Unless otherwise noted in schematic, all capacitor values less than 1 are expressed in
the values more than 1 in pF.
All capacitors are ceramic 50V, unless otherwise noted as the following marks.
Electolytic capacitor
Mylar capacitor
µ
F, and
3. The parts indicated with "
4. Voltages read with DIGITAL MULTI-METER from point indicated to chassing ground, using a color bar signal with
all controls at normal, line voltage at 220 volts.
5. Waveforms are taken receiving color bar signal with enough sensitivity.
6. Voltage reading shown are nominal values and may vary
" have special characteristics, and should be replaced with identical parts only.
±
20% except H.V.
SCHEMATIC DIAGRAM STRUCTURE:
DEF POWER Circuit
BACK/AV Circuit
CONV/IF/AUDIO (1/3) [ SHEET - 1/3] ............. 5/60
CONVER OUT Circuit
FRONT IN/CONT/REMOVE Circuit
CRT-D Circuit (1/2) [ SHEET - 1/2] ............ 10/60
AV Circuit (1/10) [ SHEET - 1/10] ..........12/60
HYPER SIGNAL
................................................................................................................................. 4/60
......................................................................................................................... 8/60
MICOM Circuit
G-HYPER Circuit (1/3) [ SHEET - 1/3] ............32/60
AD-CONVERTER Circuit (A) [ SHEET - 1/3] ............35/60
GC-TC90A92A Circuit (1/3) [ SHEET - 1/3] ............38/60
GC-REG Circuit ......................................................................................... 41/60
GNESIS Circuit (1/3) [ SHEET - 1/3] ............42/60
SDRAM Circuit .......................................................................................... 45/60
GNESIS OUT Circuit ................................................................................. 46/60
GNESIS REG Circuit ................................................................................. 47/60
CPU Circuit ................................................................................................ 48/60
DIGITAL CONVER Circuit (1/8) [ SHEET - 1/8] ............49/60
CONVER-REG Circuit (1/4) [ SHEET - 1/4] ............57/60
(1/3) [ SHEET - 1/3] .............
(2/3) [ SHEET - 2/3] .............
(3/3) [ SHEET - 3/3] .............
(2/3) [ SHEET - 2/3] .............
(3/3) [ SHEET - 3/3] .............
.................................................................................................... 9/60
(2/2) [ SHEET - 2/2] ............
(2/10) [ SHEET - 2/10] ..........13/60
(3/10) [ SHEET - 3/10] ..........14/60
(4/10) [ SHEET - 4/10] ..........15/60
(5/10) [ SHEET - 5/10] ..........16/60
(6/10) [ SHEET - 6/10] ..........17/60
(7/10) [ SHEET - 7/10] ..........18/60
(8/10) [ SHEET - 8/10] ..........19/60
(9/10) [ SHEET - 9/10] ..........20/60
(10/10) [ SHEET - 10/10] ........21/60
(1/10) [ SHEET - 1/10] ..........22/60
(2/10) [ SHEET - 2/10] ..........23/60
(3/10) [ SHEET - 3/10] ..........24/60
(4/10) [ SHEET - 4/10] ..........25/60
(5/10) [ SHEET - 5/10] ..........26/60
(6/10) [ SHEET - 6/10] ..........27/60
(7/10) [ SHEET - 7/10] ..........28/60
(8/10) [ SHEET - 8/10] ..........29/60
(9/10) [ SHEET - 9/10] ..........30/60
(10/10) [ SHEET - 10/10] ....... 31/60
(2/3) [ SHEET - 2/3] ............33/60
(3/3) [ SHEET - 3/3] ............34/60
(B) [ SHEET - 2/3] ............36/60
(C) [ SHEET - 3/3] ............37/60
(2/3) [ SHEET - 2/3] ............39/60
(3/3) [ SHEET - 3/3] ............40/60
(2/3) [ SHEET - 2/3] ............43/60
(3/3) [ SHEET - 3/3] ............44/60
(2/8) [ SHEET - 2/8] ............50/60
(3/8) [ SHEET - 3/8] ............51/60
(4/8) [ SHEET - 4/8] ............52/60
(5/8) [ SHEET - 5/8] ............53/60
(6/8) [ SHEET - 6/8] ............54/60
(7/8) [ SHEET - 7/8] ............55/60
(8/8) [ SHEET - 8/8] ............56/60
(2/4) [ SHEET - 2/4] ............58/60
(3/4) [ SHEET - 3/4] ............59/60
(4/4) [ SHEET - 4/4] ............60/60
1/60
2/60
3/60
6/60
7/60
11/60
CIRCUIT BLOCK DIAGRAM
TO HYPER/SIGNAL
H_OUT
H_OUT_GND
ABL_SW
H_CONV
POWER
BLK_UP
H_PHA_COM
SDA1
SCL1
V_STOP_BLK
VP_Q510
+4.5V
+5V-1
GND
H.Vcc
+9V-1
GND
+11V
PF01A
16FE-BT-VK-N
AFC
ABL
GND
ACP
GND
10P_2.5mm_1.5A_Beige
GND
+7V
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
P831A
1
2
3
4
5
6
7
8
9
10
H_OUT
ABL_SW
AFC
ABL
H_CONV
ACP
POWER
H_PHA_COM
SDA1
SCL1
V_STOP_BLK
VP_Q510
4.5V
5V1
7V
HVCC
9V1
11V
2-E1
2-C1
2-D1
2-C1
2-E1
3-E7
3-E7
2-B1
2-B8
2-B8
2-C1
2-A1
3-A7
3-E7
3-A7
2-D1
2-C1
3-B7
Lock 2P_11.88mm_S
CMC042P(23372209)
or VM0284(23372184)
P800
POWER CORD
3-B7
11V
+11V
8
7
AFC
-21V
-16V2
16V2
21V
32V
11V
GND
6
CONV_ABL
5
GND
4
H_CONV
AFC
3
V_DF
2
V_BLK
1
BB21
8P 2.5PJ-P
CONVER-21V
8
GND
7
-16V
6
5
GND
+16V
4
3
PROTECT
2
GND
CONVER+21V
1
BB11
8P 2.5PJ-P
TUNER32V
8
Audio Vcc
7
6
Audio Vcc
5
Audio Vcc
4
Audio GND
3
Audio GND
2
Audio GND
+11V
1
P880A
8P_2.5mm_1.5A_Beige
TUNER GND
P805B
1P
TO CONVER
TO IF/AUDIO
2-C1
CONV_ABL
2-E1
H_CONV
2-D1
2-C1
V_DF1
2-B1
V_BLK
3-B7
2-B7
2-B7
3-C7
PROTECT
3-B7
DEF/POWER
3-C7
3-C7
AVCC
3-C7
AGND
3-B7
2-B8
(H)
2-D8
H_RET
342
2-C8
V_NF
V_OUT2
TDY707AS(R)
(V)
P403
6P_5mm_5A
1
L464
21546354213 6
2-D8
3-F1
3-F1
AC_N
AC_L1
12
P801
3-E1
AC_L2
1
243
AC_L2
TO SUB POWER
3-C7
3-D1
AC_N2
P802
OPEN
NC
NC
AC_N2
2-D8
DF_V
DF_V
GND
213
GND
NC
P405
B03B-DVS-L
TO FOCUS PACK
H_DY
2-B8
V_OUT1
2214335641
P402
6P_5mm_5A
1
342
L463
TDY707AS(R)
(H)
(V)
2-B8
3-F2
V_OUT
3-C7
GND
GND
P810
1P
P401
6P_5mm_5A
1
342
L462
TDY707AS(R)
(V)
(H)
+120V
3-C7
120V
NC
2-C8
HV_DET
GND_DEF
HV_DET
TO CRT DRIVE
GND_DEF
HEATER
TGND
2-C8
2-C8
220V
HEATER
98765
HEATER
NC
220V
P404
9P_2.5mm_1.5A_Beige
TO SVM
46H84/51H84/57H84
DEF POWER (1/3)
SHEET-1/3
(1/60)
GR30
igger
MEM1
CH1/2
MEM2
GND
5ms/div
5V/div
DEF/CONVER
(DEF)
igger
igger
MEM1
CH1/2
MEM2
10us/div
5V/div
DEF/CONVER
GND
(DEF)
MEM1
CH1/2
MEM2
GND
10us/div
H_DRIVE
1V/div
DEF/CONVER
(DEF)
(DEF)
DEF/CONVER
200V/div
MEM2
igger
CH1/2
MEM1
50V/div
10us/div
GND
GND
10us/div
(DEF)
DEF/CONVER
MEM1
igger
CH1/2
MEM2
5ms/div
200V/div
GND
MEM1
igger
CH1/2
DEF/CONVER
MEM2
(DEF)
uto
:500
:Simple
:500
uto
:Simple
Length
Length
Sampling
CH1
CH2
W2
W1
igger
ype
oint
Mode
igger
15.0
1k
1k
5V/div
20ksps
Nor
mal
1V/div
5ms/div
5ms/div
3.0
ype
Mode
oint
Length
CH1/2:1k
Length
CH1/2:1k
:64%
:Rise
:CH1
Source
Edge
el
Record
:-22%
:CH1
:Rise
el
Source
Edge
Record
:Simple
uto
:500
Length
Length
Sampling
W1
CH2
CH1
W2
Nor
mal
10Msps
1k
1V/div
10us/div
5V/div
1k
10us/div
3.0
10.0
Length
Length
Sampling
Mar
er
Mar
er
CH1
W1
CH2
W2
igger
0.0us
0.0us
0.0us
3.04
0.00
3.04
ype
Mode
oint
1k
1k
Nor
mal
10Msps
10us/div
1V/div
10us/div
2V/div
3.0
3.0
Length
CH1/2:1k
:-34%
:CH1
:Rise
el
Source
Edge
Record
Record
3.0
CH2
oint
Mode
ype
1V/div
Nor
mal
1k
1k
10us/div
10us/div
10Msps
Sampling
Length
Length
W2
W1
igger
:Rise
:500
Edge
Source
uto
:Simple
:CH1
:-22%
50V/div
CH1
100
3.0
CH2
igger
Length
CH1/2:1k
Length
Length
10us/div
Nor
mal
10Msps
1V/div
10us/div
W2
Sampling
W1
1k
1k
:Rise
:500
oint
Edge
:Simple
ype
Mode:A:A
utoLeLe
el
Source
:CH1
:-10%
Length
Record
CH1/2:1k
200V/div
CH1
400
CH2
3.0
Length
Length
Sampling
W2
W1
1V/div
5ms/div
Nor
mal
5ms/div
20ksps
1k
1k
oint
:500
Edge
uto
:Simple
igger
Mode
ype
Source
el
:Rise
CH1/2:1k
Length
Record
:CH1
:-10%
CH1
400
200V/div
OPEN
1-B2
VP_Q510
1-B2
H_PHA_COM
1-B8
V_BLK
1-B2
V_STOP_BLK
1-B8
V_DF1
1-B2
ABL
1-B2
ABL_SW
1-B8
CONV_ABL
1-D2
9V1
1-B8
AFC
3-C7
X-RAY
D450
Q4430
2SC2236-Y
10.2 14.1
+
10.9
D4431
MA8110-L
R4431
1/6P1k
1N4004A
R4430
1/2R15
3-C7
120V
1-D2
HVCC
D4430
1N4004A
C4430
16V10
1-B2
H_OUT
1
1-B8
H_CONV
46H84/51H84/57H84
DEF POWER (2/3)
SHEET-2/3
H_PHA_COM
OPEN
L310
+
C318
100u
HV_DET_OUT
1P
R
C490
16V47
Q404A
500V390p
1/2R330
1/6P27k_G
Q404
2SC5859
C402
+
R490
R243
1R6.8k
OPEN
R406
R404
1.8k
C440
Q428
KTC4075Y
C330
16V10
R348
1/6P18kG
R240
1/6P15kG
1800VH1000p
TEM2011AA
EW_DRIVE
47k
R242
L403
+
FR105-FL
5
FMQ-3GU
D461
R448
1/6P5.6k
R469
100
R342
OPEN
1/6P 18kG
D402
MA8180-M
R241
D426
C432
50V0.033u
R471
1/6P220k
R347
OPEN
0.1uF
R338
15k
63V0.10
C467
M
C327
C515
Q341
OPEN
R345
SHORT
1/6P100
M
L401
56u
R405
1/6P100
D404
ERC06-15L
C468
PP_630V5.6n_J
R446
R449
R409
3R22
G
R513
R515
1/6P10k
D505
1SS133
C444
1800VH3600p
PP_630V6.8n_J
10k
1/6P1.5k
R410
3R22
Q425
FET 2SK2920
SD
63V0.10
L406
GR31
D308
OPEN
R466
M
C405
C464
TLN3351AD
+
C310
25V100
R363
10k
C362
B25V0.047
R361
100k
R369
1/6P10k
R368
OPEN
Q306
TA75902P(J)
R343
1k
16V47
+
C340
R350
R246
1/6P4.7k
63V0.10
Q409
KTC4075Y
D491
1SS355-TE17
R499
1k
R415
1k
R7930
R7932
OPEN
R7931
SHORT
0.6
Q798
6.8k
R365
47k
R362
R360
5.6k
1357642
R341
18k
12k
R249
1/6P470k
M
C221
R498
10k
25V1000
Q410
KTC4075Y
MA8100-M
16V10
C450
C361
0.1uF
B1000p
R349
3.9k
R245
1/6P4.7k
D492
C491
KTC4075Y
10k
16.1 1.4
C309
+
+
KTA2014Y
2
R440
R439
Q241
2SC2482
Q406
Q405
10k
12k
R312
D303
MTZJ15C
R314
47k
C311
B25V0.01
7.2
8914 101213 11
9.12.2
D301
MA8075-H
R313
1k
R477
D411
R492
1k
R493
390
R417
1/6P2.2k
D401
AG01
TLN1080AH
2
1
2SK2962
330
R494
470
10
R497
1P
X
TE481TE482
T401
43
6
C401
500V3300p
Q402
R403
1R100
L490
33
R436
1/6P47k
D418
MTZJ33C
R418
10k
R419
R437
22k
10k
R315
680
R244
1/6P120k
R248
OPEN
R496
Q408
10k
KTA2014Y
NP
33k
C497
R495
16V100
D490
MA8062-M
R416
2R150
R414
1/4RF27
+
C416
100V22u
R413
1/6P100
MA8180-M
C419
R438
330p
1k
D419
1SS355
Q411
KTC4075Y
0
43k
C443
250V3.3u
L408
TEM2014
C483
47p
R483
SHORT
1800VH4700p
C449
500V220p
D425
EU2A
GR32
0
D309
OPEN
R322
100
D327
RD11ESAB1
R475
1/6P100
R467
220
C463
B6800p
R447
1R47k
6
4
L402
TLN3534AH
MA8075-H
R484
OPEN
R420
1/6P10k
R364
330
D365
1SS133
R325
4.7k
D420
3
+
R321
4.7k
1/4R10KF
C316
R330
1/4R10KF
R407
1/2R10
1
2
3
L407
TEM2014
C460
200V22u
R366
1/6P2.2k
R367
3.9k
50V1.0
R331
+
C315
OPEN
10V1000
R480
RD11ESAB1
47k
D333
RD11ESAB1
R482
Q420
2SC2482
D421
FR105-FL
R421
1/6P22k
R422
22k
C446
250V33
4
C302
M
+
D334
C481
0.33
10k
25V8200P
R444
1R0.39
+
C314
63V0.047
C312
B3300p
C482
+
TLN2222AH
4.9
3.6
42378691112 10 5 1
8.8
R491
2.2k
R481
1/6P10k
L441
R441
RSF14A3D330
Q302
TA1317AN
VRef
CENT DAC
EHT
VDrive
VDCRef
V NF
CENT OUT
Vcc
V DF OUT
EW PWM
ANA GND
H DF OUT
EW fb
EW Filter
FBP in
B301
205
+
C448
160V33u
VCH1
100
50V/div
3.0
VCH2
1V/div
10us/div
W1
1k
Length
10us/div
W2
1k
Length
Sampling
Nor
mal
10Msps
Trigger
BLK OUT
DIG GND
V RAMP
2R15k
AGC
V in
LVP
SCL
SDA
R412
T.C
D406
FR105-FL
Trigger
Type
Mode
Point
C301
63V1.0
M
C303
63V1.0
2313 17 1815 16 21 2219 2014 24
50V0.022u
C308
MM
8.2k
R306
R302
D378
1/6P100
OPEN
R379
OPEN
R311
1/6P56k
R340
1/6P10k
R307
100
R308
100
D337
MA8056-M
D336
MA8056-M
V_STOP_BLK
10
9
4
OPEN
DEF/CONVER
50V/div
10us/div
7
6
5
119
2
3
R411
2R2.2
C412
200V0.12u
CH1
400
V
200V/div
(DEF)
3.0
CH2
V
1V/div
10us/div
W1
Length
1k
10us/div
W2
Length
1k
Sampling
Nor
mal
10Msps
Trigger
R910
1R0.56
GJ406
R443
1/2R1
D415
FR105-FL
C417
250V1.5u
C425
400V0.27u
C423
400V0.30u
D414
FR105-FL
MEM2
CH1/2
MEM1
4 5
GND
Record
Source
:Simple
:CH1
Length
LeLevelel:A:Auto
:-22%
CH1/2:1k
:Rise
:500
Edge
KTA2014Y
Q305
C320
50V100
C321
50V100
R378
10k
D370
1SS355-TE17
Q372
KTC4075Y
R247
1/6P1k
TFB3094AD
T461
HV
D7
D6
D5
D4
Eo
D3
D2
D1
81
T400
TLN2220AH
R425
1/2P100K
R423
R424
1/2P100K
1/2S1k
C415
2kV1500p
R427
100
C422
B1000p
MEM1
Trigger
CH1/2
MEM2
DEF/CONVER
200V/div
10us/div
GND
:Simple
Type
Source
:CH1
Length
Record
Mode
uto
vel
:-10%
CH1/2:1k
:Rise
:500
Point
Edge
+
+
1/6P3.3k
(DEF)
R336
R435
1k
R334
1k
M
KTA2014Y
CH1
W1
W2
Sampling
P499
Length
Length
C324
63V1.0
Q371
R375
15k
R376
33k
1P
1/2P270K
200V/div
5ms/div
5ms/div
C323
0.047
R335
1k
7
R434
Q400
2SC4686A
400
V
VCH2
3.0
1V/div
1k
1k
Nor
mal
20ksps
Q301A
R337
1/2W 1R2J
D302
FR105-FL
TP-V
TP-G
R373
82k
C371
0.1uF
R433R428
1/2P270K1P220k
R426
1/6P100
M
C420
63V0.10
Trigger
Trigger
100V2200p
D304
SC570ALFE2
P1N
1P
P1N
1P
R374
100k
C445
200V47n
CH1/2
:Simple
Type
:A:Auto
Mode
Point
:500
-16.3
C328
M
C325
0.22
Q370
KTC4075Y
R432
1/2P270K
Source
LeLevel
Edge
2467531
M
TEM2011AA
GJ42
GJ43
MEM1
:CH1
:-10%
:Rise
L304
6
MEM2
Record
+
R442
OPEN
L442
OPEN
C426
2kV2200p
CH1/2:1k
R355
1/6P10k
C338
16V10u
R371
82k
R372
3.3k
D412
PR-1H
Length
Q301
LA7833S
16.2
C334
B470p
1R390
C331
R346
OPEN
D305
1N4004A-FL
C332
50V100
+
M
C333
100V0.047u
R305
1R1.0
R370
1/6P1k
+
C370
2.2u
R344
1R150
L305
TEM2014
SG99B3EN
1N4004A-FL
D306
L302
TLN3299D
8
R380
D371
OPEN
OPEN
R381
OPEN
V_OUT
L303
TLN3299D
-16V2
16V2
16V1
-16V1
R429
1/2S1k
R390
1R560
1-B8
1-C8
3-B7
R392 R391
1R560 1R560
3-B7
HEATER
1-D3
DF_V
V_OUT
V_OUT1
V_OUT2
V_NF
HV_DET
220V
SCL1
SDA1
1-B2
1-B2
1-D6
1-D6
1-D5
1-D5
1-D4
1-D4
1-D4
Z401
3-C7
GND
1-C5
H_DY
1-C5
H_RET
0.6
0.6
Trigger
MEM1
CH1/2
MEM2
3.0
V
CH1
2V/div
CH2
V
3.0
7
DEF/CONVER
5V/div
10us/div
(Vertical)
10V/div
5ms/div
1V/div
W1
10us/div
Length
1k
W2
10us/div
1k
Length
Sampling
Nor
mal
10Msps
Mar
ker
1
0.0us
T
V
V
3.04
Mar
ker
2
0.0us
T
3.04
V
V
T
0.0us
V
V
0.00
:Simple
Trigger
Type
:A:Auto
Mode
:500
Point
Trigger
CH1
V15.0
5V/div
(DEF)
CH2
V
3.0
1V/div
W1
5ms/div
1k
Length
W2
5ms/div
Length
1k
Sampling
Nor
mal
20ksps
:Simple
Trigger
Type
:A:Auto
Mode
:500
Point
-8.0 VCH1
2V/div
CH2
V
3.0
1V/div
W1
5ms/div
Length
1k
W2
5ms/div
Length
1k
Sampling
Normal
20ksps
:Simple
Type
:Auto
Mode
:500
Point
D413
PR-1H
R431
2R1k
V
CH1
10.0
5V/div
CH2
V
3.0
1V/div
W1
10us/div
Length
1k
W2
10us/div
Length
1k
Sampling
Nor
mal
10Msps
DEF/CONVER
CH1
20 V
10V/div
(DEF)
CH2
3.0 V
1V/div
5ms/div
W1
6
Length
1k
5ms/div
W2
200V/div
Length
1k
Sampling
5ms/div
GND
Normal
20ksps
Trigger
MEM1
CH1/2
MEM2
2
GND
:Simple
Trigger
Type
Mode
Point
Trigger MEM1CH1/2 MEM2 MEM1Trigger CH1/2 MEM2
Type
Mode
Point
Length
:CH1
Source
Record
:A:Auto
CH1/2:1k
:-22%
LeLevel
:500
:Rise
Edge
DEF/CONVER
GND
:SimpleTrigger
Length
Source :CH1
Record
:Auto
:-34%
Level
CH1/2:1k
:500
:Rise
Edge
DEF/CONVER
(DEF)
1
H_DRIVE
1V/div
10us/div
GND
Length
:CH1
Source
Record
CH1/2:1k
:-34%
LeLevel
:Rise
Edge
MEM1
CH1/2
MEM2
DEF/CONVER
(DEF)
3
5V/div
5ms/div
GND
Length
:CH1
Source
Record
CH1/2:1k
:64%
LeLevel
:Rise
Edge
DEF/CONVER
(Vertical)
GND
8
2V/div
5ms/div
Length
Record
:CH1Trigger
Source
CH1/2:1k
-68%
Level
:Rise
Edge
(2/60)
3
D892
FMX-12S(023
T865
TLN2229AH
6
5
7
4
8
3
9
Q801
STR-Z4479
1
VB
OUT
COM
RC
0C
DRIVCC
VCC
DT
CD
CSS
5
200V2.2
+
R872
OPEN
8
6
7
R867
1/6P22k
M
C876
D876
MTZJ36C
63V0.47
R866
1/6P4.7k
10
11
9
C879
1000
D873
MTZJ27C
M
M
C873
63V0.22
50V4700p
C867
R868
1/2R47
C862
2kV470p
R865
1/2R39
R874
1/6P15
R870
C874
1/2R150
2kV220p
D864
+
C868
50V47
FR105-FL
or35V47
14
15
1312
D862
R862
FR105-FL
1/2R6.8
C863
63V0.22
2kV680p
2kV820p
TEM2011AA
M
D875
MTZJ9.1C
L862
TEM2011AA
C871
C877
C870
800V0.1u
R871
1W 680J
L864
R873
1/2R10
T862
TPW3549AS
4
5
2
1
Q862
PS2581L(D)
6.6 15.8
41
LIVE AREA
D801
D5SB60
+-
1
D801B
Q801C
1
Q801B
1
CONT
GND
VIN
Q801A
1
323 21 8
L861
C805
250V4700pF
C809A
D801A
1
C810A
1
TEM2011AA
F860
AC125V 4.0A
+
C809
200V1000u
C860
10000
+
C810
200V1000u
4
2
3
D879
D878
M
MTZJ27C
MTZJ9.1A
C869
63V1.0
C866
R864
1/2R1k
R860
2R47k
0
C811
250V2200pF
C802
OPEN
R810
125V0.2A
RW923H1R8K
1SS355-TE17
F840
2
R840
1/2R5.6k
578
Q840
MIP280
T802
OPEN
GJ04
GJ03
GJ02
GJ01
SHORT
SHORT
1-D3
AC_N2
1-D3
AC_L2
T801
TRF3197AH
C801
AC275V0.47u
D899
TNR10V431K352
F801A
1
F801
125V8.0A
F801B
1
AC_L1
1-D2
SHORT
SHORT
R842
AA01
3.5mm GAP
R899
1/2P3.9M
AC_N
1-D3
TGND
1-D8
LN1WBA60
D840
1/2P56k
R843
1/2P56k
+
C840
250V22
3412
M
C842
63V0.10
C812
250V2200pF
SR82
G5PA-1-M
SR81
DLS5D1-0 M 0.25W
Q841
PS2581L(D)
D848
23
T840
TPW3425AH
3
1.0 5.2
41
C843
2kV100
Q842
PS2581L(D)
0 4.2
C814
250V470pF
2
10
17
4
F892
125V2.0A
15
13
YG801C04RF119
12
11
125V4.0A
9
125V4.0A
7
10
6
8
16
L886
TEM2011AA
14
L887
TEM2011AA
D881
1SS355-TE17
23
14.8
1SS355-TE17
KTC4075Y
D845
1SS355-TE17
0.1
Q843
KTC4075Y
0
TEM2011AA
D891A
D891B
1
D891
F850
125V3.0A
L851
TEM2011AA
F851
D4SBL20U
F852
L852
TEM2011AA
C880
2kV330p
L880
TEM2011AA
RL2/LF-C1
L881
TEM2011AA
C881
2kV330p
D895
D894
MA8062-M
R893
4.7k
0.1
Q894
0.7
R894
10k
0
R818
RM73B1H471JD
0.8
R819
10k
41
5
R844
10k
D843
61
54
R841
23
FR105-FL
L841
TEM2011AA
1k
+
C845
50V2.2
MA8056-H
MA8047-L
+
C841
10V2200
D841
D842
L891
R854
1/2R15
RL2/LF-C1
R883
1/2R1k
R885
1/6P470
D851
D851B
D883
D885
D4SBS4
5.1
2.4
FMX-12S(023
D884
D885B
1
L840
33u
D893
TEM2011AA
D885A
Q844
KTC4075Y
D846
RD3.0ESAB2
D847
RD3.0ESAB2
L850
1
3.0
+
D892A
D892B
1
D893A
D893B
1
TEM2011AA
125V5A
C846
OPEN
125V4A
R845
1/6P1k
TEM2011AA
TEM2011AA
F891
L854
D851A
+
F885
35V1000
L892
L893
C884
160V330u
C885
+
C892
16V1000
C893
10V1000
+
+
D854
FR105-FL
D852
RL2Z LF-C1
D853
RL2Z LF-C1
+
C850
35V560
+
C851
35V560
+
14.4 116
M
C888
63V0.22
R881
1k
D844
MA8056-M
L895
TLN3499AH
L896
TLN3499AH
C891
16V1000
L894
TLN3499AH
+
C854
25V47
+
C852
25V470
+
C853
25V470
F470
L885
TLN3299D
L888
TLN3462AH
C898
0.1uF
D880
MTZJ4.3B
BC
G
Q881
SE116N
0
AC125V 2.0A
C499
16V22
R470
1R0.47
R488
1/2R150
119.8
R474
1/2P39k
+
R487
C496
1/2R270
63V0.47
M
Q470
119.4
2SA1320
0
D470
R472
MA8120-L
100
R473
22k
R101
1W 223J
Conect to P810
R849
100
Q473
KTA2014Y
5.10
R486
4.7k
5.1
Q471
KTC4075Y
0
R478
C473
1k
0.1uF
3.0
0
Q472
KTC4075Y
R476
470
0
R489
1k
R485
680
+
C849
16V100
7V
4.5V
11V
16V1
-16V1
21V
-21V
120V
32V
GND
X-RAY
AVCC
AGND
PROTECT
POWER
5V1
ACP
1-D2
1-C2
1-D8
2-B7
2-C7
1-C8
1-B8
2-D1
1-C8
2-D8
2-D1
1-C7
1-C7
1-A2
1-C2
1-C2
1-C2
46H84/51H84/57H84
DEF POWER (3/3)
SHEET-3/3
(3/60)
46H84/51H84/57H84
BACK/AV
(4/60)
46H84/51H84/57H84
CONV/IF/AUDIO (1/3)
SHEET-1/3
(5/60)
6.3 6.3 6.2 0
12.7
16.2 7.8 0 7.7 5.2 0 0 0 0 7.7 0 7.8
6.3 6.3 6.2
46H84/51H84/57H84
CONV/IF/AUDIO (2/3)
SHEET-2/3
(6/60)
5.0
4.8 4.8
2~4
32.0
2~4
5.0 4.8 4.8 32.05.0
1.0V(p-p)(H)
9.00 2~4 5.0 04.6 4.65.0 0
9.0
46H84/51H84/57H84
CONV/IF/AUDIO (3/3)
SHEET-3/3
(7/60)
46H84/51H84/57H84
CONVER OUT
(8/60)
TO HYPER/SIGNAL
P112
TO HYPER/SIGNAL
PA03A
REMOTE
RB15
1/6P470
DB31
KETSU
DB30
KETSU
KB01 DB03
PIC-37043TE2 SIR-56SB3F
5V-1
3241 645 7213
RB19
1/6P47
+
CB01
16V47u
321
Vcc
GND
VOUT
PB22
DB05
KETSU
DB03A
390
DB01
RB01
4P_2.5mm
RMT-OUT
GND
RMT-IN
QB01
2SC1740S
or 2SC1685-Q
or 2SC1815Y
RESET
S701
TO SIGNAL
3
21
GND
LED
5V-1
RB05
SLR_56VC3FPQ
DB01A
1/6P1k
1/6P390
RB04
1/6P47k
P701
3P_2.5mm_1.5A_Beige
PV05
JACK 1S3P
GND
KEY-2
OPEN
KEY-1
1/6P8.2k
FRONT VIDEO3 INPUT
LR
R
PB11
PLUG 7P
SA03 SA04
SA02SA01
CH DNCH UP
VOL UP
VL/MONORS
RV20
1/6P75
L
RV23
1/6P100
FRONT-CONTROL
VOL DN
1/6P27k1/6P15k
LV20
SW
V
1/6P8.2k
YC
RV22
1/6P75
CV14
0.01
RV21
A
1/6P75
56
C
Y
RA76RA73 RA71RA72
SA06SA05 SA09SA08SA07
MENUPOW EXITTFOCUSVIDEO
RA78
RA77
1/6P27k
1/6P15K
TO HYPER/SIGNAL
PB60
GND
R
L
R
RA79
1/6P82k
PV60
GND
S_SW
10P
SW
C
GND
L
GND
CVY
546213810 9 7
Y
V
FRONT-IN
46H84/51H84/57H84
FRONT IN/CONT/REMOTE
(9/60)
210
210
2
11.0
10.3
3.2
2.5
1
11.0
10.3
3.2
2.5
3
120
4
119
118.3
60
46H84/51H84/57H84
CRT-D (1/2)
SHEET-1/2
60
1.7
1.0
1
2
3
4
(10/60)
TO
POWER/DEF
P915A
TO
GREEN
P916A
+210V
HEATER
HEATER
GND_DEF
HV_DET
GND_DEF
+120V 1
+210V 9
HEATER
GND_DEF
Vref
GND
+120V
9P±2.5mm±1.5A±Beige
+9V 4
TO
B-OUT
SIGNAL
4P_2.5mm_1.5A_Beige
9
NC
8
7
6
5
3
NC42
P917
9P±2.5mm±1.5A±Beige
NC 8
7
6
5
49V
3
NC
2
1
P916B
3
GND 2
SVM 1
P918
GJ903
OPEN
R900
1RF1.2
R900Z
2RF2.2
L7201
OPEN
Q7202
OPEN
R7204
OPEN
R7205
OPEN
R7210
OPEN
R7211
OPEN
CRT-D SVM/B
R9607
100
B16V1.0u
R7208
OPEN
Q7204
OPEN
R7207
OPEN
R7206
OPEN
+
C7203
OPEN
R7213
Q7203
OPEN
OPEN
R7212
OPEN
R7214
OPEN
R7209
OPEN
R7215
OPEN
210
11.0
C922
16V100
R9608
R9609
1.2k
1.2k
Q973
KTA1504Y
C954
C7214
OPEN
R7217
OPEN
C7205
OPEN
Q7205
OPEN
R7218
OPEN
R7216
OPEN
C925
R951
250V22
+
7W 2.7k
B903
CRT HOLDER
L925
R920
1/6P2.2k
Q921
2SC3942
C924
0.01
D921
+
1SS133
Q921C
1
GREASE
R924
1
Q921B
KETSU
SCREW
C953
KETSU
A
L927
2.2
3.2
R921
1/6P330
D944
1SS133
R929
R925
27
27
Q921A
1/6P2.2k
L924
HEAT SINK
R988
1SS133
1SS133
2SC3950E
Q924
2SC3790E
1/6P56
1/6P56
R926
270
Q925B
SCREW
D926
1SS244
2
D927
1SS244
R953
R930
1/6P2.2k
R923
68
Q925A
HEAT SINK
R9028
1/2R100
1/2R 100
1.5u
L923
D928
1SS244
D929
1SS244
V903A
CRT SOCKET
G954
1
C923
470P B
R928
6.8u
G924
G925
GJ18
0.6
12u
Q925
2SA1480E
G921
KETSU
10.3
D945
1SS133
Q922
2.5
C9200
KETSU
R9620
KETSU
1
R7227
OPEN
Q7206
OPEN
R7219
R7220
OPEN
R7221
OPEN
R7223
OPEN
OPEN
R7222
R7225
OPEN
OPEN
Q7207
OPEN
Q7209
OPEN
+
C7207
OPEN
+
C7206
OPEN
Q7208
OPEN
R7240
OPEN
R7224
OPEN
R7226
OPEN
R7241
OPEN
R7235
OPEN
D7201
OPEN
R7229
OPEN
R7228
OPEN
Q721
OPEN
C7208
OPEN
R7230
OPEN
R7234
OPEN
R7231
OPEN
Q722
C7209
OPEN
OPEN
R7233
R7232
OPEN
OPEN
R7237
OPEN
D7202
OPEN
+
C7210
OPEN
R7236
OPEN
Q721A
1
Q721B
L7202
L7204
OPEN
OPEN
L7203
OPEN
Q722B
1
Q722A
R7238
OPEN
+
C7211
OPEN
V902
C921
1000
FOCUS
GND
C7212
OPEN
3P_5mm
32
3
2
C936
10000
1
1
P903
PLUG 3P
P905
1P
P910
1P
4321
NC
FROM
GND
CR BLOOK
HV_DET
GND
P920
GJ21
OPEN
+
C7213
OPEN
4P_5mm
P704
OPEN
1
R7239
2
OPEN
3
1
2
D936
1S1834
C926
100
1/6P15
R958
L911
22u
R7201
OPEN
+
C7201
OPEN
R7202
OPEN
Q7201
OPEN
C7204
OPEN
C7202
R7203
OPEN
OPEN
46H84/51H84/57H84
CRT-D (2/2)
SHEET-2/2
(11/60)
46H84/51H84/57H84
AV (1/10)
SHEET-1/10
SH. NO.
1
(12/60)
46H84/51H84/57H84
AV (2/10)
SHEET-2/10
SH. NO.
3
(13/60)
46H84/51H84/57H84
AV (3/10)
SHEET-3/10
SH. NO.
5
(14/60)
46H84/51H84/57H84
AV (4/10)
SHEET-4/10
SH. NO.
7
(15/60)
2.37
5.5
9.0
2.6
5.5
5.5
1.9
9.0
3.6
2.9
1.67
0
1.9
0
5.0
5.0
2.6
3.6
0
46H84/51H84/57H84
AV (5/10)
SHEET-5/10
SH. NO.
10
(16/60)