Page 1
SERVICE MANUAL
FILE NO. 050-200126
21T01F2, 21R01F2
21T01B2, 14R01F2
14T01B2, 14R01B2
21T01N2, 21T01I2
21T01D2, 14T01N2
14T01I2, 14T01D2
PRINTED IN U. K
COLOUR TELEVISION
Page 2
1. Precautions
1-1 Safety Precautions
1. Be sure that all of the built-in protective
devices are replaced. Restore any missing
protective shields.
2. When reinstalling the chassis and its
assemblies, be sure to restore all protective
devices, including: nonmetallic control knobs
and compartment covers.
3. Make sure that there are no cabinet openings
through which people—particularly
children—might insert fingers and contact
dangerous voltages. Such openings include
the spacing between the picture tube and the
cabinet mask, excessively wide cabinet
ventilation slots, and improperly fitted back
covers.
If the measured resistance is less than 1.0
megohm or greater than 5.2 megohms, an
abnormality exists that must be corrected
before the unit is returned to the customer.
4. Leakage Current Hot Check (Figure 1-1):
Warning: Do not use an isolation
transformer during this test. Use a leakagecurrent tester or a metering system that
complies with American National Standards
Institute (ANIS C101.1, Leakage Current for
Appliances), and Underwriters Laboratories
(UL Publication UL1410, 59.7).
5. With the unit completely reassembled, plug
the AC line cord directly into the power
outlet. With the unit’s AC switch first in the
ON position and then OFF, measure the
current between a known earth ground (metal
water pipe, conduit, etc.) and all exposed
metal parts, including: antennas, handle
brackets, metal cabinets, screwheads and
control shafts. The current measured should
not exceed 0.5 milliamp. Reverse the powerplug prongs in the AC outlet and repeat the
test.
Fig. 1-1 AC Leakage Test
6. Antenna Cold Check:
With the unit’s AC plug disconnected from the
AC source, connect an electrical jumper across
the two AC prongs. Connect one lead of the
ohmmeter to an AC prong. Connect the other
lead to the coaxial connector.
7. X-ray Limits:
The picture tube is especially designed to prohibit X-ray emissions. To ensure continued
X-ray protection, replace the picture tube only
with one that is the same type as the original.
Carefully reinstall the picture tube shields and
mounting hardware; these also provide X-ray
protection.
8. High Voltage Limits:
High voltage must be measured each time servicing is done on the B+, horizontal deflection
or high voltage circuits. Correct operation of
the X-ray protection circuits must be
reconfirmed whenever they are serviced.
(X-ray protection circuits also may be called
“horizontal disable” or “hold-down”.)
Heed the high voltage limits. These include
the X–ray Protection Specifications Label, and
the Product Safety and X-ray Warning Note on
the service data schematic.
Precautions
1-1
LEAKAGE
CURRENT
TESTER
DEVICE
UNDER
TEST
TEST ALL
EXPOSED METAL
SURFACES
2-WIRE CORD
ALSO TEST WITH
PLUG REVERSED
(USING AC ADAPTER
PLUG AS REQUIRED)
EARTH
GROUND
(READING SHOULD
NOT BE ABOVE
0.5mA)
Follow these safety, servicing and ESD precautions to prevent damage and protect against potential
hazards such as electrical shock and X-rays.
Page 3
1-1 Safety Precautions (Continued)
9. High voltage is maintained within specified
limits by close-tolerance, safety-related
components and adjustments. If the high
voltage exceeds the specified limits, check
each of the special components.
10. Design Alteration Warning:
Never alter or add to the mechanical or
electrical design of this unit. Example: Do not
add auxiliary audio or video connectors. Such
alterations might create a safety hazard. Also,
any design changes or additions will void the
manufacturer’s warranty.
11. Hot Chassis Warning:
Some TV receiver chassis are electrically
connected directly to one conductor of the AC
power cord. If an isolation transformer is not
used, these units may be safely serviced only
if the AC power plug is inserted so that the
chassis is connected to the ground side of the
AC source.
To confirm that the AC power plug is inserted
correctly, do the following: Using an AC
voltmeter, measure the voltage between the
chassis and a known earth ground. If the
reading is greater than 1.0V, remove the AC
power plug, reverse its polarity and reinsert.
Re-measure the voltage between the chassis
and ground.
12. Some TV chassis are designed to operate with
85 volts AC between chassis and ground,
regardless of the AC plug polarity. These units
can be safely serviced only if an isolation
transformer inserted between the receiver and
the power source.
13. Some TV chassis have a secondary ground
system in addition to the main chassis ground.
This secondary ground system is not
isolated from the AC power line. The two
ground systems are electrically separated by
insulating material that must not be defeated
or altered.
14. Components, parts and wiring that appear to
have overheated or that are otherwise
damaged should be replaced with parts that
meet the original specifications. Always
determine the cause of damage or overheating, and correct any potential hazards.
15. Observe the original lead dress, especially
near the following areas: Antenna wiring,
sharp edges, and especially the AC and high
voltage power supplies. Always inspect for
pinched, out-of-place, or frayed wiring. Do
not change the spacing between components
and the printed circuit board. Check the AC
power cord for damage. Make sure that leads
and components do not touch thermally hot
parts.
16. Picture Tube Implosion Warning:
The picture tube in this receiver employs
“integral implosion” protection. To ensure
continued implosion protection, make sure
that the replacement picture tube is the same
as the original.
17. Do not remove, install or handle the picture
tube without first putting on shatterproof
goggles equipped with side shields. Never
handle the picture tube by its neck. Some
“in-line” picture tubes are equipped with a
permanently attached deflection yoke; do not
try to remove such “permanently attached”
yokes from the picture tube.
18. Product Safety Notice:
Some electrical and mechanical parts have
special safety-related characteristics which
might not be obvious from visual inspection.
These safety features and the protection they
give might be lost if the replacement component differs from the original—even if the
replacement is rated for higher voltage,
wattage, etc.
Components that are critical for safety are
indicated in the circuit diagram by shading,
( ) or ( ).
Use replacement components that have the
same ratings, especially for flame resistance
and dielectric strength specifications.
A replacement part that does not have the
same safety characteristics as the original
might create shock, fire or other hazards.
Precautions
1-2
!
Page 4
1-2 Servicing Precautions
1. Servicing precautions are printed on the
cabinet. Follow them.
2. Always unplug the unit’s AC power cord from
the AC power source before attempting to: (a)
Remove or reinstall any component or
assembly, (b) Disconnect an electrical plug or
connector, (c) Connect a test component in
parallel with an electrolytic capacitor.
3. Some components are raised above the printed
circuit board for safety. An insulation tube or
tape is sometimes used. The internal wiring is
sometimes clamped to prevent contact with
thermally hot components. Reinstall all such
elements to their original position.
4. After servicing, always check that the screws,
components and wiring have been correctly
reinstalled. Make sure that the portion around
the serviced part has not been damaged.
5. Check the insulation between the blades of the
AC plug and accessible conductive parts
(examples: metal panels, input terminals and
earphone jacks).
6. Insulation Checking Procedure: Disconnect the
power cord from the AC source and turn the
power switch ON. Connect an insulation
resistance meter (500V) to the blades of the AC
plug.
The insulation resistance between each blade
of the AC plug and accessible conductive parts
(see above) should be greater than 1 megohm.
7. Never defeat any of the B+ voltage interlocks.
Do not apply AC power to the unit (or any of
its assemblies) unless all solid-state heat sinks
are correctly installed.
8. Always connect a test instrument’s ground
lead to the instrument chassis ground before
connecting the positive lead; always remove
the instrument’s ground lead last.
Precautions
1-3
Warning1: First read the “Safety Precautions” section of this manual. If some unforeseen circumstance creates a conflict between
the servicing and safety precautions, always follow the safety precautions.
Warning2: An electrolytic capacitor installed with the wrong polarity might explode.
Page 5
1. Some semiconductor (“solid state”) devices
are easily damaged by static electricity. Such
components are called Electrostatically
Sensitive Devices (ESDs); examples include
integrated circuits and some field-effect
transistors. The following techniques will
reduce the occurrence of component damage
caused by static electricity.
2. Immediately before handling any semicon
ductor components or assemblies, drain the
electrostatic charge from your body by
touching a known earth ground. Alternatively,
wear a discharging wrist-strap device. (Be
sure to remove it prior to applying power—
this is an electric shock precaution.)
3. After removing an ESD-equipped assembly,
place it on a conductive surface such as
aluminum foil to prevent accumulation of
electrostatic charge.
4. Do not use freon-propelled chemicals. These
can generate electrical charges that damage
ESDs.
5. Use only a grounded-tip soldering iron when
soldering or unsoldering ESDs.
6. Use only an anti-static solder removal device.
Many solder removal devices are not rated as
“anti-static”; these can accumulate sufficient
electrical charge to damage ESDs.
7. Do not remove a replacement ESD from its
protective package until you are ready to
install it. Most replacement ESDs are
packaged with leads that are electrically
shorted together by conductive foam,
aluminum foil or other conductive materials.
8. Immediately before removing the protective
material from the leads of a replacement ESD,
touch the protective material to the chassis or
circuit assembly into which the device will be
installed.
9. Minimize body motions when handling
unpackaged replacement ESDs. Motions such
as brushing clothes together, or lifting a foot
from a carpeted floor can generate enough
static electricity to damage an ESD.
Precautions
1-4
1-3 Precautions for Electrostatically Sensitive Devices (ESDs)
Page 6
2-1
Specifications and IC Data
2. Specifications and IC Data
2-1 Specifications
Television System:
Channels:
Intermediate Frequencies (MHz) :
MODEL
CB
CI
CF
CZ
System
Band
VHF
UHF
SYSTEM
IF Carrier Frequency
SYSTEM
PAL-B/G
PAL-I (VHF/UHF)
PAL-B/G, SECAM-L,L'
PAL-B/G, D/K, I, SECAM-B/G, D/K, NT4.43
PAL/SECAM-
B/G,I
2 - 12
21 - 69
PAL/
SECAM- B/G
PAL,
SECAM- D/K
1 - 13
21 - 69
PAL/SECAM-D/K,
SECAM-K1
SECAM-K1,
PAL-D
2 - 9
13 - 57
PAL - I
Power Requirements:
Antenna Input Impedance:
Speaker Impedance:
Picture IF Carrier
Sound IF Carrier
Color Sub Carrier
AC 230V, 50Hz
VHF, UHF : Telescopic dipole antenna (75 ohm unbalanced type )
16 ohm, 3W (Monitor Type & Dual Type)
38.90
33.40
34.47
38.90
32.40
34.47
38.90
32.90
34.47
Page 7
2-2
2-2 IC Line Up
Specifications and IC Data
Table 2-1 IC Line-Up
Loc. No Specification Description Remark
HIC01 PAP103 IF PRE-AMP
LPM-802EE
LPM-802EW
IC201S
LPM-802EEW
LPM-802EWN
IC301
IC501 TDA6107Q RGB DRIVE AMP
IC602
IC801S
IC802 KA7632
IC902 24C08/KS28C040 EEPROM
LA7840
TDA8943SF
KA5Q0765R
TTX ( LPM-802EE : East Europe )
( LPM-802EW : West Europe )
W/O TTX ( LPM-802EEN : East Europe )
( LPM-802EWN : West Europe )
VERTICAL OUTPUT
SOUND-AMP (3W x 1CH or 3W x 2CH)
POWER IC (STR)
CUSTOM REGULATOR (5V, 8V, 3.3V)
Philips
Sanyo
Philips
Philips
Page 8
2-3 Semiconductor Base Diagrams
Specifications and IC Data
2-3
Fig. 2-1 Semiconductor Base Diagrams
ELECTROLYTICCONDENSER
DIODE
IC
LPM-802XXX(Pin 64)
LPM-802XX(Pin 64)
X24CO8P(Pin 8)
KS24C080(Pin 8)
TRANSISTOR
B
C
E
IC
2SD1651
2SD1650
2SD2499
KSA614
TRANSISTOR
E B C
LA7840
TDA6107Q
KA7632
KSC815-Y
KSA539-Y
BC548
KTC9014
IC
UPC574J
or
KA33V
TRANSISTOR
SAW-FILTER
1
1
1
KSR1012
KSR1010
KSR2010
KTD863-Y
KSC2331-Y
K2971M
G1963M
E C B
Page 9
2-4
MEMO
Page 10
3-1
Disassembly and reassembly
3. Disassembly and Reassembly
3-1 Back Cover Removal
1. After removing the screws, press the tension rib and pull the cabinet backwards.
2. To reassemble, press the tension rib (see diagram).
Page 11
3-2
3-2 Main Board Removal
Disassembly and reassembly
1. Separate the socket board from the CRT neck.
2. Remove the Anode Cap from the CRT.
3. Remove the main board by pulling it with both hands.
Warning: The FBT is charged with high voltage.
Before removing the Anode Cap, discharge the voltage
through one of the heat sinks on the main board.
Page 12
3-3 Speaker Removal
Disassembly and reassembly
3-3
1. Remove the speaker by
pressing the tension rib.
1. Remove the screws.
2. Remove the speaker by
pressing the tension rib.
Page 13
3-4
Disassembly and reassembly
3-4 CRT Removal
1. Spread a soft mat on the floor. Place the TV set face
down.
2. Remove the 4 nuts mounting the CRT to the front cabinet. Lift the CRT.
3. Caution: Because of the high vacuum and large surface
area of the picture tube, be careful while handling it: (1)
Always lift the picture tube by grasping it firmly around
the faceplate, (2) Never lift the tube by its neck. (3) Do
not scratch the picture tube or apply excessive pressure.
Fractures of the glass may cause an implosion.
Page 14
Alignment and Adjustments
4-1
4. Alignment and Adjustments
4-1 Preadjustment
4-1-1 Factory Mode
1. Do not attempt these adjustments in the Video
Mode.
2. The Factory Mode adjustments are necessary
when either the EEPROM (IC902) or the CRT
is replaced.
3. Do not tamper with the “Adjustment” screen
of the Factory Mode menu. This screen is
intended only for factory use.
4-1-2 When EEPROM (IC902) Is Replaced
1. When IC902 is replaced all adjustment data
revert to initial values. It is necessary to
re-program this data.
2. After IC902 is replaced, warm up the TV for
10 seconds.
4-1-3 When CRT Is Replaced
1. Make the following adjustments AFTER setting up after setting up purity and convergence :
White Balance
Sub-Brightness
Vertical Center
Vertical Size
Horizontal Size
Fail Safe (This adjustment must be the last
step).
2. If the EEPROM or CRT is replaced, set PVA to
40 (factory mode) and set SC as follows.
14 inch : 18
21 inch : 24
4-2 Factory/Service Mode
4-2-1 Procedure for the “Adjustment” Mode
1. This mode uses the standard remote control.
The Service Mode is activated by entering the
following remote-control sequence :
(1) DISPLAY→FACTORY.
(2) STAND-BY→ DISPLAY→ MENU→ MUTE
→POWER ON.
2. The “SERVICE (FACTORY)” message will be
displayed. The Service Mode has three components: ADJUST, OPTION and Reset.
3. Access the Adjustment Mode by pressing the
“VOLUME” keys ( Up or Down). The adjustment parameters are listed in the accompanying table, and selected by pressing the CHANNEL keys (▲ ,▼).
4. Selection sequences for the all system:
DOWN or UP key:
AGC>SCT>SBT>BLR>BLB>RG>GG>BG>
VSL>VS>VA>HS>SC>CDL>STT>AKB>
PDL>NDL>PSR>NSR>VOL>LCO>TXP>
MVOL>FMWS>AGCS>OMD>SCL>PWL>
AGN>PEK>ACL>FCO>SCBT>TSC
5. The VOLUME keys increase or decrease the
adjustment values (stored in the
non-volatile memory) when Adjustment Mode
is cancelled.
6. Cancel the Adjustment Mode by re-pressing
the “FACTORY” or “Power OFF” keys.
Page 15
4-2-2 Main Adjustment Parameter
NOTE : PVS,PVA, PHS, parameters must be aligned using the 50Hz vertical-field rates.
Alignment and Adjustments
4-2
OSD FUNCTION RANGE INITIAL DATA REMARK
AGC
SCT
SBT
BLR
BLB
RG
GG
BG
VSL
VS
VA
HS
SC
CDL
STT
AKB
PDL
NDL
PSR
NSR
VOL
LCD
TXP
MVOL
FMWS
AGCS
OMD
SCL
PWL
AGN
PEK
ACL
FCO
SCBT
TSC
Automatic Gain Control
Sub Contrast
Sub Brightness
Black Level offset Red
Black Level offset Blue
Red Gain
Green Gain
Blue Gain
Vertical Slope
Vertical Shift
Vertical Amplitude
Horizontal Shift
S-Correction
Cathode Drive Level
Sub Tint
Black Current Stabilisation
PAL Delay
NTSC Delay
PAL Sub Color
NTSC Sub color
Volume pre setting
SECAM-L Vision IF
TTX Position
Melody Volume Levle
Window Selection of Narrow SoundPLL
IF AGC Speed
Off-set IF Demodulator
Soft Clipping Levle
Peak White Limiting
Gain FM Demodulator
Peaking Centre Frequency
Automatic Color Limiting
Forced Color On
Screen Adjust Bright Value
TTX Mix Mode Sub Contrast
0 ~ 63
0 ~ 23
0 ~ 23
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 7
0 ~ 1
0 ~ 15
0 ~ 15
0 ~ 23
0 ~ 23
0 ~ 63
0 ~ 1
0 ~ 15
0 ~ 50
0 ~ 1
0 ~ 3
0 ~ 63
0 ~ 3
0 ~ 15
0 ~ 1
0 ~ 3
0 ~ 1
0 ~ 1
0 ~ 63
0 ~ 63
33
13
9
9
7
32
25(Fix)
32
19
38
40(Fix)
30
Option
Option
3(Fix)
0(Fix)
1(Fix)
10(Fix)
10(Fix)
5(Fix)
10(Fix)
Option
9(Fix)
10(Fix)
0(Fix)
Option
26(Fix)
3(Fix)
12(Fix)
1(Fix)
2(Fix)
1(Fix)
0(Fix)
45(Fix)
20(Fix)
14inch : 18, 21inch : 24
14inch : 1, 21inch : 3
CF MODEL : 1, others : 0
CF MODEL : 0, others : 1
TTX Option
Page 16
Alignment and Adjustments
4-3
4-2-3 Option Bytes
In the Service Mode, various can be selected via the Option Table. Example:
OPTION TALBE : LPM-802EW/EWN, LPM-802EE/EEN
LPM-802EW/EWN REMARK LPM-802EE/EEN REMARK
1
LNA
--
OFF
10
11
12
13
14
15
16
2
3
4
5
6
7
8
9
SYSTEM
AUDIO
JACK
ZOOM
AUTO POWER
SBL
2ND SIF
HOTEL MODE
BKS
HIGH DEVIA
HELP MENU
NICAM
LIST/FLOF
TIME
V-GUARD
MONO
SCART
NOR/ZOOM/16"9
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
FLOF
OFF
OFF
CZ
MONO
SCART
NOR/ZOOM/16"9
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF
TTX OPTION TTX OPTION
FLOF
OFF
OFF
Page 17
Alignment and Adjustments
4-4
4-3 Other Adjustments
4-3-1 General
1. Usually, a color TV needs only slight touchup adjustment upon installation. Check the
basic characteristics such as height, horizontal
and vertical sync and focus.
2. The picture should have good black and white
details. There should be no objectionable
color shading; if color shading is present, perform the purity and convergence adjustments
described below.
3. Use the specified test equipment or its equivalent.
4. Correct impedance matching is essential.
5. Avoid overload. Excessive signal from a sweep
generator might overload the front-end of the
TV. When inserting signal markers, do not
allow the marker generator to distort test
results.
6. Connect the TV only to an AC power source
with voltage and frequency as specified on the
backcover nameplate.
7. Do not attempt to connect or disconnect any
wires while the TV is turned on. Make sure
that the power cord is disconnected before
replacing any parts.
8. To protect against shock hazard, use an isolation transformer.
4-3-2 Automatic Degaussing
A degaussing coil is mounted around the picture tube, so that external degaussing after
moving the TV should be unnecessary. But
the receiver must be properly degaussed upon
installation.
The degaussing coil operates for about 1 second after the power is switched ON. If the set
has been moved or turned in a different direction, disconnect its AC power for at least 30
minutes.
If the chassis or parts of the cabinet become
magnetized, poor color purity will result. If
this happens, use an external degaussing coil.
Slowly move the degaussing coil around the
faceplate of the picture tube and the sides and
front of the receiver. Slowly withdraw the coil
to a distance of about 6 feet before removing
power.
4-2-4 RESET
The Reset Mode is used during factory inspection.
Function Reset:
1. Picture Custom
2. Auto Volume Off
3. Color System Auto (option)
4. Blue Screen Off
5. Volume 10
6. CH. Skip Erased
7. CH. Lock Off
Page 18
Alignment and Adjustments
4-5
4-3-3 High Voltage Check
CAUTION: There is no high voltage adjustment on this chassis.
The B+ power supply must be set to +125 volts (Full color bar input
and normal picture level).
1. Connect a digital voltmeter to the second
anode of the picture tube.
2. Turn on the TV. Set the Brightness and
Contrast controls to minimum (zero beam current).
3. The high voltage should not exceed 27.5KV.
4. Adjust the Brightness and contrast controls to
both extremes. Ensure that the high voltage
does not exceed 27.5KV under any conditions.
4-3-4 FOCUS Adjustment
1. Input a black and white signal.
2. Adjust the tuning control for the clearest pic-
ture.
3. Adjust the FOCUS control for well defined
scanning lines in the center area of the screen.
4-3-5 Cathode Voltage Adjustment
(Screen Adjustment)
1. Enter the FACTORY mode.
2. Select the G2-ADJUST.
3. Adjust the screen VR(on the FBT)
so that ‘SCREEN ADJUST : NG(Red or Blue)’
becomes ‘SCREEN ADJUST : OK’.
When the color of ‘SCREEN ADJUST’ is
red, the cathode voltage is low and when blue,
it is high.
4-3-6 Purity Adjustment
1. Warm up the receiver for at least 20 minutes.
2. Plug in the CRT deflection yoke and tighten
the clamp screw.
3. Plug the convergence yoke into the CRT and
set in as shown in Fig. 4-1.
4. Input a black and white signal.
5. Fully demagnetize the receiver by applying an
external degaussing coil.
6. Turn the CONTRAST and BRIGHTNESS controls to maximum.
7. Loosen the clamp screw holding the yoke.
Slide the yoke backward or forward to provide vertical green belt. (Fig. 4-2).
8. Tighten the convergence yoke.
9. Slowly move the deflection yoke forward,
and adjust for the best overall green screen.
10. Temporarily tighten the deflection yoke.
11. Produce blue and red rasters by adjusting the
low-light controls. Check for good purity in
each field.
12. Tighten the deflection yoke.
Page 19
Alignment and Adjustments
4-6
4-3-7 White Balance Adjustment
Fig. 4-1 Convergence Magnet Assembly
Fig. 4-2 Center Convergence Adjustment
Fig. 4-3
(a) Set up
1. Warm up the TV for at least 30 minutes in the
Aging Mode (OSD White). This mode is
entered by entering the following sequence:
(Displaying AGING on the screen)
DISPLAY
→FACTORY → FACTORY
2. Input a Toshiba pattern.
(b) Low-Light Adjustment
1. Set SBT to 3.5 ± 0.5 fL in the Factory Service
Mode with using CA100. See Fig. 4-3
➁.
(14inch : 2.5 ± 0.5fL, 21inch : 1.5 ± 0.5fL)
2. Adjust RG,BG so that the levels are suitable to
each local area.
(c) High-Light Adjustment
1. Set SCT to 35 FL (20”. 21”), 60 FL(14”) in the
Factory Service Mode with using CA100. See
Fig. 4-3
①.
6 Pole Magnet
Clamper
Screw
4 Pole Magnet
2 Pole Magnet
2 POLE
PURITY
YOKE
CLAMP
SCREW
6 POLE
CONVERGENCE
4 POLE
CONVERGENCE
ADJUST THE ANGLE
(VERTICAL LINES)
31m/m
1
Vertical Green Belt
2
Page 20
Alignment and Adjustments
4-7
4-3-8 Center Convergence Adjustment
1. Warm up the receiver for at least 20 minutes.
2. Adjust the two tabs of the 4 pole magnets to
change the angle between them. Superimpose
the red and blue vertical lines in the center
area of the screen.
3. Adjust the Brightness and Contrast controls
for a well defined picture.
4. Adjust the two-tab pairs of the 4 pole magnets, and change the angle between them.
Superimpose the red and the blue vertical
lines in the center area of the screen.
5. Turn the both tabs at the same time, keeping
the angle constant, and superimpose the red
and blue horizontal line in the center of the
screen.
6. Adjust the two-tab pairs of the 6-pole magnets
to superimpose the red and blue line onto the
green. (Changing the angle affects the vertical
lines, and rotating both magnets affects the
horizontal lines.)
7. Repeat adjustments 2~6, if necessary.
8. Since the 4-pole magnets and 6-pole magnets
interact, the dot movement is complex
(Fig. 4-4).
Fig. 4-4 Center Convergence Adjustment
BLUE
BLUE
RED
RED
RED/BLUE
RED/BLUE
GREEN
GREEN
4-Pole Magnet Movement
6-Pole Magnet Movement
Page 21
4-3-9 RF AGC Adjustment
Set the AGC data to 33 (Factory Mode).
4-3-10 Sub-Color Adjustment
Set data to (Factory Mode).
4-3-11 Geometry Adjustment
SC →VS→VSL→HS
1. Input a lion head pattern (in the PAL channel).
2. Set the SC (S-Correction) as follows : 24 (21”),
24 (20”), 18 (14”) and VA 40 so that the lion
head circle becomes oval.
3. Adjust with VSL (Vertical-Slope) so that the
bottom margin of the picture is 4.
Fig. 4-5
4. Adjust with VS (Vertical shift) so that the top
margin of the picture is 4.
Fig. 4-6
5. Adjust with HS (Horizontal Shift) so that the
lion-head pattern and CRT centers are aligned.
Fig. 4-7
6. Adjust HS (using the width coil) so that the
left and right margins of the picture are 5.
Alignment and Adjustments
4-8
4
5
5
4
PSR
NSR
10
5
Page 22
Troubleshooting
5-1
5. Troubleshooting
5-1 No Video (Raster On, No Sound)
Open the IF Pin of Tuner
Measure the
Voltage of Each Pin
of TU01S
Yes
Check IC201S
Pins 2,3
Yes
Check IC201S
Pins 40,49,50
No
No
No
Check/Replace
TU01S
Check/Replace
IC201S
See "No Sound"
(Video OK)
Check/Replace
IC501, IC201S
See "No Video"
(Sound OK)
See "No Sound"
(Video OK)
Page 23
5-2
5-2 No Power
Troubleshooting
Check the 125V,
13.0V B+ Lines
Yes
Check IC802
Pin 8 (8V)
Pin 9 (9V)
Pin 10 (5V)
Check IC201S
Pin 1 (3.3V)
Yes
Check IC201S
Pin 1 : Stand-by : 0V
Normal : 3.3V
No
No
No
No
Check/Replace
IC801S, D801S, D802S,
D803S,D804S,FP801S
Check/Replace
IC802 (KA7632)
Check/Replace
IC201S
Check/Replace
IC201S, (µ-com).
Check IC201S,
Pin 33 (H-out)
No
Check/Replace
IC201S, Q401, Q402.
Page 24
5-3 No Video (Sound OK)
Troubleshooting
5-3
Check IC201S
Pin 40 (CVBS)
Yes
Check IC201S
Pins 38/R214, R215
Check IC201S
Pin 49 (V-GUARD)
Pin 50 (Cut-off)
Pin 51~53 (R,G,B-out)
Yes
No
No
No
Check/Replace
IC201S
Check/Replace
IC201S
Check IC501
on the CRT PCB
Check/Replace
R421, R505 (HEATER 6.3Vrms)
D503 (CRT G1 pin)
CRT, V999S
No
Check/Replace
IC501
Page 25
5-4
Troubleshooting
5-4 No Sound (Video OK)
5-5 No TTX
Check IC201S
Pin 44 (Sound Out)
Yes
Check IC601
Pins 6 (0V)
No
Check IC601
Pin 3,13 (B+ 10-12.5V)
Yes
Check IC601
No
Yes
No
No
Check/Replace
IC201S
Check/Replace
Q904, IC201S
Check/Replace
R814, R815
Check/Replace
IC601
Yes
Check/Replace
A/V Front assembly.
Check IC201S
Yes
See No Video
No
Check/Replace
IC201S
Page 26
6. Exploded View & Parts List
6-1 CF14R01F2GXTSB
Exploded View & Parts List
6-1
No. Code No. Replacement No. Description;Specification Q’ty Remark
1 HA91-00225A AZ760047 ASSY-CABINET,FRONT;-,14R01,-,-,-,- 1
HA64-00568A AZ760012 CABINET-FRONT;-,14R01,-,HIPS,HB,DARK-GRA 1
1-1 HA64-00418B AZ760015 KNOB-POWER;14R01,HIPS,HB,BLK,D/GRAY 1
1-2 AA61-60003J AZ760018 SPRING-CS;-,SUS304,-,-,OD6,N7,OD6,-,-,-, 1
1-3 HA61-00109B AZ760013 BOSS-CABINET;SPACE 2
1-4 AA96-10142A AZ660086 ASSY-SPEAKER;-,16OHM2.5W,000275,AA392050 1
1-5 HA61-40010A AZ760094 BOSS-WING;-,HIPS,HB,NTR,-,- 2
1-6 AA64-00420B AZ760020 INDICATOR-LED;-,14R01,-,ACRYL,HB,CLR,- 1
1-7 AA64-00419B AZ760013 WINDOW-REMOCON;-,14R01,-,PC,V0,VIOLET,- 1
1-8 HA60-020003 AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S 1 CF+WR
1-9 HA64-00427B AZ760014 KNOB-CONTROL;14R01,HIPS,HB,BLK,D/GRAY 1
1-10 HA60-020003 AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S 1 CF+KC
2 HA94-500012 AZ660081 ASSY-CRT;A34EAC01X06,+400MG,14,PHIL,ITC 1
2-1 AA65-30106A AZ760010 CLAMP-D,COIL;14 INCH,NYLON 66,V2,-,NTR,- 2
2-2 HA60-020010 AZ760058 SCREW-ASSY;WC,HH,+,M5,L26.5,SWRCH18A,ZPC 4 CRT+CF
2-3 3704-001089 AZ664047 SOCKET-CRT;7P,22.5PI,12PI,SN,- 1 V999S
3 HA90-00165A AZ760099 ASSY-CABINET(COM);-,14R01 1
HA64-00571A AZ760001 CABINET-BACK;-,14R01,-,HIPS,V0,BLK,-,- 1
3-1 HA60-020003 AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S 4 CB+CF
3-2 AA42-00003A AZ664166 ANT-ROD;-,3S,720mm,ABS,UL/CSA,- 1
3-3 AA96-20122A AZ664124 ASSY-POWER,CORD;-,CP2/NO(4.0),H/C250,KKJ 1
Page 27
Exploded View & Parts List
6-2
6-2 CF21T01F2GXTSB
No. Code No. Replacement No. Description;Specification Q’ty Remark
1 HA91-100032 AZ760091 ASSY-CABINET,FRONT;-,21T01,-,-,-,- 1
HA64-300072 AZ760082 CABINET-FRONT;-,21T01,-,HIPS,HB,DARK-GRA 1
1-1 HA64-00423B AZ760030 KNOB-POWER;21R01,HIPS,HB,BLK,D/GRAY 1
1-2 AA61-60003J AZ760018 SPRING-CS;-,SUS304,-,-,OD6,N7,OD6,-,-,-, 1
1-3 AA61-40007A AZ760032 STOPPER-PCB;5038.5368,HIPS HB,-,-,-,NTR, 1
1-4 AA65-30105A AZ760035 CLAMP-WIRE;ALL MODEL,NYLON 66,V2,-,NTR,1 1
1-5 AA64-00430B AZ760034 INDICATOR-LED;-,21R01,-,ACRYL,HB,CLR,- 1
1-6 AA64-00428B AZ760033 WINDOW-REMOCON;-,21R01,-,PC,V0,VIOLET,- 1
1-7 HA60-020003 AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S 1 CF+WR
1-8 HA64-00426B AZ760029 KNOB-CONTROL;21R01,HIPS,HB,BLK,D/GRAY 1
1-9 HA60-020003 AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S 1 CF+KC
1-10 HA96-00254A AZ660066 ASSY-SPEAKER;-,16OHM,3W,-,3001-001039,70 1
1-11 HA60-020003 AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S 2 CF+SPK
2 HA94-50012A AZ660063 ASSY-CRT;A51EER31X,+400MG,-,-,-,21 1
2-1 AA65-30107A AZ760026 CLAMP-D,COIL;20~22 INCH,NYLON 66,V2,-,NT 4
2-2 HA60-020010 AZ760058 SCREW-ASSY;WC,HH,+,M5,L26.5,SWRCH18A,ZPC 4 CRT+CF
2-3 3704-001105 AZ664016 SOCKET-CRT;11P,20PI,26.5PI,NI,- 1 V999S
3 HA90-00166A AZ760089 ASSY-CABINET(COM);-,21R01 1
HA64-00572A AZ760022 CABINET-BACK;-,21R01,-,HIPS,V0,BLK,-,- 1
3-1 HA60-020003 AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S 4 CB+CF
3-2 AA96-20122A AZ664124 ASSY-POWER,CORD;-,CP2/NO(4.0),H/C250,KKJ 1
Page 28
Electric Parts List
7-1
ASSY-PCB,MAIN(OPT)
* AZ660089 ASSY-PCB,MAIN(OPT);CF,21T0,TSB,KS1A HA94-100850 1
PCB(AC AZ660090 ASSY-PCB,MAIN(ACI);CF,21R0-T0,TSB,KS1A HA99-100786 1
D201 AZ462001 DIODE-SWITCHING;1N4148,100V,200mA,DO-35, 0401-000005 1
D811 AZ462001 DIODE-SWITCHING;1N4148,100V,200mA,DO-35, 0401-000005 1
D102 AZ462001 DIODE-SWITCHING;1N4148,100V,200mA,DO-35, 0401-000005 1
D501 AZ462009 DIODE-RECTIFIER;RGP10J,600V,1A,DO-41,TP 0402-000254 1
D803 AZ462009 DIODE-RECTIFIER;RGP10J,600V,1A,DO-41,TP 0402-000254 1
D807 AZ462010 DIODE-RECTIFIER;1R5GU41,400V,1.5A,DO-15L 0402-000493 1
D301 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D304 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D401 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D502 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D503 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D504 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D812 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D801S AZ462019 DIODE-RECTIFIER;1N5397GP,600V,1.5A,DO-20 0402-001111 1
D802S AZ462019 DIODE-RECTIFIER;1N5397GP,600V,1.5A,DO-20 0402-001111 1
D803S AZ462019 DIODE-RECTIFIER;1N5397GP,600V,1.5A,DO-20 0402-001111 1
D804S AZ462019 DIODE-RECTIFIER;1N5397GP,600V,1.5A,DO-20 0402-001111 1
D303 AZ462034 DIODE-RECTIFIER;1A4G,400,1A,R-1,TP 0402-001321 1
D809 AZ462034 DIODE-RECTIFIER;1A4G,400,1A,R-1,TP 0402-001321 1
D302 AZ462035 DIODE-RECTIFIER;GUF15G-20A,400V,1.5A,DO- 0402-001352 1
DZ402 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ807 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ810 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ903 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ904 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ905 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ901 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ101 AZ461013 DIODE-ZENER;TZP33A,33V,31-35V,1W,DO-41,T 0403-000700 1
DZ303 AZ461013 DIODE-ZENER;TZP33A,33V,31-35V,1W,DO-41,T 0403-000700 1
DZ803 AZ461013 DIODE-ZENER;TZP33A,33V,31-35V,1W,DO-41,T 0403-000700 1
DZ201 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ204 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ205 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ207 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ501 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ502 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ503 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ504 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ704 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ808 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ306 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ307 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ701 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ702 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ703 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ801 AZ462042 DIODE-ZENER;RD10ESAB-T4,10V,9.19-10.30V, 0403-001140 1
DZ302 AZ462028 DIODE-ZENER;UZ39BSB,35.36-37.19V,500MW,D 0403-001221 1
DZ806 AZ462036 DIODE-ZENER;MTZJ3.0B,3.01-3.22V,500mW,DO 0403-001317 1
DZ802 AZ462037 DIODE-ZENER;MTZJ4.3B,4.17-4.43V,500mW,DO 0403-001318 1
DZ203 AZ462030 DIODE-ZENER;MTZJ8.2B,7.78-8.19V,500mW,DO 0403-001322 1
DZ805 AZ462038 DIODE-ZENER;MTZJ18A,16.22-17.06V,500mW,D 0403-001327 1
DZ301 AZ462039 DIODE-ZENER;MTZJ22A,20.15-21.20V,500mW,D 0403-001328 1
DZ305 AZ462039 DIODE-ZENER;MTZJ22A,20.15-21.20V,500mW,D 0403-001328 1
Q201 AZ561001 TR-SMALL SIGNAL;KSA539,PNP,400MW,TO-92,T 0501-000283 1
Q901 AZ561001 TR-SMALL SIGNAL;KSA539,PNP,400MW,TO-92,T 0501-000283 1
Q402 AZ561002 TR-SMALL SIGNAL;KSC2331-Y,NPN,1W,TO-92L, 0501-000369 1
Q202 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q205 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q903 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q905 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q704 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q701 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-1 CF21T01F2GXTSB
7. Electric Parts List
!!!!!
!!!
!
!
Page 29
VX801S AZ664040 VARISTOR;750V,1250A,12.5x7mm,TP 1405-000187 1
R207 AZ261391 R-CARBON;390OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000005 1
R905 AZ261391 R-CARBON;390OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000005 1
R906 AZ261391 R-CARBON;390OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000005 1
R218 AZ261153 R-CARBON;15KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000008 1
R602 AZ261153 R-CARBON;15KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000008 1
R205 AZ268005 R-CARBON;75Kohm,5%,1/8W,AA,TP,1.8x3.2mm 2001-000011 1
R301 AZ262010 R-CARBON(S);1OHM,5%,1/2W,AA,TP,2.4x6.4MM 2001-000016 1
J125 AZ262010 R-CARBON(S);1OHM,5%,1/2W,AA,TP,2.4x6.4MM 2001-000016 1
R843 AZ262100 R-CARBON(S);10OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-000019 1
R618 AZ262100 R-CARBON(S);10OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-000019 1
R409 AZ262330 R-CARBON(S);33OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-000022 1
R823 AZ262331 R-CARBON(S);330OHM,5%,1/2W,AA,TP,2.4X6.4 2001-000037 1
R902 AZ261152 R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000241 1
R904 AZ261152 R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000241 1
R211 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R215 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R223 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R501 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R502 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R506 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R510 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R511 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R512 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R909 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R911 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R912 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R913 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R914 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
J137 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R213 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R718 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R933 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R934 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R224 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R828 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R910 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R919 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R920 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R921 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R922 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R709 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R230 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R225 AZ268006 R-CARBON;91ohm,5%,1/8W,AA,TP,1.8x3.2mm 2001-001035 1
R918 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R926 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R210 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R723 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R721 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R916 AZ261222 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 1
R917 AZ261222 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 1
R220 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R901 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R903 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R907 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R908 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R214 AZ261201 R-CARBON;200OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000490 1
R206 AZ261273 R-CARBON;27KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000563 1
R829 AZ261273 R-CARBON;27KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000563 1
R929 AZ261273 R-CARBON;27KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000563 1
R208 AZ261332 R-CARBON;3.3KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000591 1
R108 AZ261332 R-CARBON;3.3KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000591 1
R202 AZ268007 R-CARBON;390KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000689 1
R925 AZ261472 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000734 1
R841 AZ261472 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000734 1
R601 AZ261472 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000734 1
R227 AZ268008 R-CARBON;4.7MOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000739 1
R228 AZ268008 R-CARBON;4.7MOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000739 1
R109 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R724 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R725 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R726 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R727 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R209 AZ261470 R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000793 1
R927 AZ261470 R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000793 1
R203 AZ261561 R-CARBON;560OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000857 1
R204 AZ261561 R-CARBON;560OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000857 1
Electric Parts List
7-2
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
Page 30
Electric Parts List
7-3
R713 AZ261561 R-CARBON;560OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000857 1
R715 AZ261561 R-CARBON;560OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000857 1
R110 AZ261681 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000924 1
R915 AZ261681 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000924 1
R722 AZ261681 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000924 1
R222 AZ261918 R-CARBON;7.5KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000947 1
R702 AZ261750 R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000969 1
R719 AZ261750 R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000969 1
R720 AZ261750 R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000969 1
R408 AZ262398 R-CARBON(S);0.39OHM,5%,1/2W,AA,TP,2.4X6. 2001-001037 1
R504 AZ262106 R-CARBON(S);10MOHM,5%,1/2W,AA,TP,2.4X6.4 2001-001062 1
R414 AZ268009 R-CARBON(S);15KOHM,5%,1/2W,AA,TP,2.4X6.4 2001-001078 1
R806 AZ268010 R-CARBON(S);22KOHM,5%,1/2W,AA,TP,2.4X6.4 2001-001108 1
R411 AZ262271 R-CARBON(S);270OHM,5%,1/2W,AA,TP,2.4X6.4 2001-001114 1
R809 AZ262474 R-CARBON(S);470KOHM,5%,1/2W,AA,TP,2.4X6. 2001-001150 1
R810 AZ262474 R-CARBON(S);470KOHM,5%,1/2W,AA,TP,2.4X6. 2001-001150 1
R501H AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
R502H AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
R503 AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
RX801S AZ263005 R-COMPOSITION;3.3MOHM,10%,1/2W,AA,TP,3.7 2002-001011 1
RY801S AZ268011 R-COMPOSITION;8.2MOHM,10%,1/2W,AA,TP,3.7 2002-001012 1
R827 AZ263068 R-METAL OXIDE(S);330OHM,5%,2W,AF,TP,4X12 2003-000652 1
R316 AZ263068 R-METAL OXIDE(S);330OHM,5%,2W,AF,TP,4X12 2003-000652 1
R315 AZ263068 R-METAL OXIDE(S);330OHM,5%,2W,AF,TP,4X12 2003-000652 1
R403 AZ263014 R-METAL OXIDE(S);7.5KOHM,5%,2W,AF,TP,4X1 2003-000784 1
R834 AZ263021 R-METAL OXIDE(S);47Kohm,5%,2W,AF,TP,3.9x 2003-001040 1
R303 AZ268012 R-FUSIBLE(S);0.75ohm,5%,2W,AF,TP,3.9x10m 2008-001133 1
R801 AZ268013 R-METAL OXIDE(S);150ohm,5%,2W,AG,TP,3.9x 2003-002171 1
R402 AZ268014 R-METAL OXIDE(S);1Kohm,5%,2W,AG,TP,3.9x1 2003-002178 1
R407 AZ268015 R-METAL OXIDE(S);47Kohm,5%,2W,AG,TP,3.9X 2003-002209 1
R423 AZ268016 R-METAL(S);100KOHM,1%,1/2W,AA,TP,2.4X6.4 2004-001373 1
R424 AZ264004 R-METAL(S);6.8KOHM,1%,1/2W,AA,TP,2.4X6.4 2004-001402 1
R219 AZ263032 R-METAL;39KOHM,2%,1/8W,AA,TP,1.8X3.5MM 2004-001914 1
R817 AZ263037 R-METAL;123KOHM,1%,1/2W,AA,TP,2.5X6.5M 2004-004089 1
R304 AZ268017 R-FUSIBLE(S);0.47ohm,5%,1W,AF,TP,3.9x10m 2008-000253 1
R305 AZ268017 R-FUSIBLE(S);0.47ohm,5%,1W,AF,TP,3.9x10m 2008-000253 1
R825 AZ263044 R-FUSIBLE(S);1OHM,5%,2W,AF,TP,3.9X10MM 2008-000266 1
R824 AZ263047 R-FUSIBLE(S);33ohm,5%,2W,AF,TP,3.9x10mm 2008-000294 1
R420 AZ268018 R-FUSIBLE(S);68ohm,5%,2W,AG,TP,3.9X12mm 2008-001110 1
C904 AZ163029 C-CERAMIC,DISC;10NF,10%,50V,Y5V,TP,6.5*3 2201-000180 1
C501 AZ163002 C-CERAMIC,DISC;0.01nF,0.25pF,500V,NP0,TP 2201-000192 1
C302 AZ163030 C-CERAMIC,DISC;0.18nF,10%,500V,Y5P,TP,5. 2201-000259 1
C303 AZ163011 C-CERAMIC,DISC;0.47nF,10%,500V,Y5P,TP,5. 2201-000556 1
C305 AZ163011 C-CERAMIC,DISC;0.47nF,10%,500V,Y5P,TP,5. 2201-000556 1
C908 AZ163031 C-CERAMIC,DISC;82pF,5%,50V,CH,8x5mm,5mm, 2201-000872 1
C909 AZ163031 C-CERAMIC,DISC;82pF,5%,50V,CH,8x5mm,5mm, 2201-000872 1
C408 AZ163013 C-CERAMIC,DISC;0.56nF,10%,500V,Y5P,TP,5. 2201-000599 1
CR404S AZ163032 C-CERAMIC,DISC;0.68nF,10%,2kV,Y5P,TP,9x5 2201-000639 1
C503 AZ163033 C-CERAMIC,DISC;4.7nF,20%,3KV,Y5U,TP,16x5 2201-000723 1
C811 AZ163018 C-CERAMIC,DISC;0.56nF,10%,2kV,Y5P,TP,7.5 2201-000991 1
C814 AZ163018 C-CERAMIC,DISC;0.56nF,10%,2kV,Y5P,TP,7.5 2201-000991 1
C704 AZ161101 C-CERAMIC,MLC-AXIAL;100pF,10%,50V,Y5P,TP 2202-000121 1
C703 AZ161101 C-CERAMIC,MLC-AXIAL;100pF,10%,50V,Y5P,TP 2202-000121 1
C106 AZ161103 C-CERAMIC,MLC-AXIAL;10nF,+80-20%,25V,Y5V 2202-000127 1
C111 AZ161103 C-CERAMIC,MLC-AXIAL;10nF,+80-20%,25V,Y5V 2202-000127 1
C105 AZ161103 C-CERAMIC,MLC-AXIAL;10nF,+80-20%,25V,Y5V 2202-000127 1
C702 AZ161271 C-CERAMIC,MLC-AXIAL;270PF,10%,50V,Y5P,TP 2202-000210 1
C115 AZ161703 C-CERAMIC,MLC-AXIAL;100nF,20%,50V,Z5U,TP 2202-000632 1
C211 AZ161703 C-CERAMIC,MLC-AXIAL;100nF,20%,50V,Z5U,TP 2202-000632 1
C911 AZ161703 C-CERAMIC,MLC-AXIAL;100nF,20%,50V,Z5U,TP 2202-000632 1
C223 AZ161102 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3 2202-000796 1
C224 AZ161102 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3 2202-000796 1
C906 AZ161102 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3 2202-000796 1
C505 AZ161681 C-CERAMIC,MLC-AXIAL;680pF,10%,50V,Y5P,TP 2202-000825 1
C226 AZ161704 C-CERAMIC,MLC-AXIAL;820pF,10%,50V,Y5P,3. 2202-000829 1
C707 AZ162004 C-FILM,PEF;2.7nF,5%,50V,TP,7.4x3.9x13mm, 2301-000204 1
C502 AZ162005 C-FILM,PEF;220nF,5%,250V,TP,21.5x11,7.5 2301-000213 1
C109 AZ162006 C-FILM,PEF;22nF,5%,50V,TP,7.4x3.9x13mm 2301-000224 1
C804 AZ162006 C-FILM,PEF;22nF,5%,50V,TP,7.4x3.9x13mm 2301-000224 1
C805 AZ162015 C-FILM,PEF;3.9nF,5%,50V,TP,6.5x3.0x5.5mm 2301-000235 1
C309 AZ162008 C-FILM,PEF;39nF,5%,50V,TP,7.5x3.5x6.5mm, 2301-000254 1
C606 AZ162016 C-FILM,PEF;1.8nF,5%,50V,TP,6.5x3.0x5.5mm 2301-000111 1
C217 AZ162031 C-FILM,PEF;2.2nF,5%,50V,TP,7.4x3.9x13mm, 2301-000342 1
C234 AZ162031 C-FILM,PEF;2.2nF,5%,50V,TP,7.4x3.9x13mm, 2301-000342 1
C407 AZ162012 C-FILM,PEF;10nF,5%,50V,TP,6x7x3.2mm,5mm 2301-000383 1
C227 AZ162013 C-FILM,PEF;4.7nF,5%,50V,TP,5.5x7x3mm,5mm 2301-000445 1
C248 AZ162013 C-FILM,PEF;4.7nF,5%,50V,TP,5.5x7x3mm,5mm 2301-000445 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!!!
Page 31
C420 AZ162014 C-FILM,MPPF;47nF,5%,630V,TP,19x15.5x7,7. 2301-001065 1
C806 AZ162017 C-FILM,PPF;1.5nF,5%,1.2kV,TP,15x8x12.5mm 2301-001435 1
C301 AZ162020 C-FILM,MPEF;220nF,5%,100V,TP,20x18x11.5 2305-000285 1
C215 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
C216 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
C233 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
C613 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
C611 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
CR405S AZ162023 C-FILM,MPEF;4.7NF,5%,400V,TP,-,5MM 2305-000382 1
C207 AZ162025 C-FILM,MPEF;470nF,5%,63V,TP,-,5mm 2305-000412 1
C901 AZ162025 C-FILM,MPEF;470nF,5%,63V,TP,-,5mm 2305-000412 1
C103 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C208 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C210 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C218 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C230 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C803 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C819 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C913 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C204 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C205 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C231 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C618 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C225 AZ162030 C-FILM,PE-PPF;100nF,5%,50V,TP,20x16x8.5, 2309-000138 1
C812 AZ165001 C-AL;100uF,20%,160V,HR,TP,16x25,7.5 2401-000262 1
C817 AZ164005 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2401-000302 1
C821 AZ164005 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2401-000302 1
C823 AZ164005 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2401-000302 1
C915 AZ164005 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2401-000302 1
C307 AZ164006 C-AL;100uF,20%,50V,GP,TP,8x11.5,5 2401-000360 1
C308 AZ164006 C-AL;100uF,20%,50V,GP,TP,8x11.5,5 2401-000360 1
C506 AZ165004 C-AL;10UF,20%,250V,GP,TP,10X16MM,5M 2401-000430 1
C820 AZ164009 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-000480 1
C612 AZ164009 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-000480 1
C604 AZ164009 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-000480 1
C403 AZ165006 C-AL;1uF,20%,160V,GP,TP,6.3x11,5 2401-000560 1
C219 AZ164011 C-AL;1uF,20%,50V,GP,TP,5x11,5 2401-000603 1
C212 AZ164013 C-AL;2.2uF,20%,50V,GP,TP,5x11,5 2401-000660 1
C221 AZ164013 C-AL;2.2uF,20%,50V,GP,TP,5x11,5 2401-000660 1
C605 AZ164013 C-AL;2.2uF,20%,50V,GP,TP,5x11,5 2401-000660 1
C222 AZ165015 C-AL;220NF,20%,50V,GP,TP,5X11MM,5MM 2401-000758 1
C827 AZ165008 C-AL;22UF,20%,250V,GP,TP,13X20MM,5M 2401-000927 1
C101 AZ165016 C-AL;330uF,20%,16V,GP,TP,8x11.5,5 2401-001101 1
C802 AZ165017 C-AL;33uF,20%,50V,GP,TP,6.3x11,5 2401-001192 1
C504 AZ165009 C-AL;4.7uF,20%,250V,GP,TP,10x12.5,5 2401-001232 1
C209 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C213 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C229 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C903 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C910 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C110 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C705 AZ165018 C-AL;4.7uF,20%,50V,BP,TP,5x11,5 2401-001989 1
C706 AZ165018 C-AL;4.7uF,20%,50V,BP,TP,5x11,5 2401-001989 1
C710 AZ165018 C-AL;4.7uF,20%,50V,BP,TP,5x11,5 2401-001989 1
C711 AZ165018 C-AL;4.7uF,20%,50V,BP,TP,5x11,5 2401-001989 1
C601 AZ164029 C-AL;1000UF,20%,25V,GP,TP,10X20,5MM 2401-001998 1
C206 AZ164031 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM 2401-002235 1
C220 AZ164031 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM 2401-002235 1
C709 AZ164031 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM 2401-002235 1
C304 AZ165019 C-AL;470uF,20%,25V,WT,TP,10x20,5 2401-002288 1
C306 AZ165019 C-AL;470uF,20%,25V,WT,TP,10x20,5 2401-002288 1
C813 AZ165012 C-AL;47uF,20%,160V,GP,TP,13x20,5 2401-002290 1
C406 AZ164037 C-AL;47uF,20%,25V,GP,TP,5x11,5 2401-002619 1
C214 AZ165020 C-AL;100uF,20%,10V,GP,TP,5x11,5 2401-003102 1
L103 AZ361001 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 1
L202 AZ361001 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 1
L301 AZ361004 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2701-000142 1
L302 AZ361004 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2701-000142 1
L404 AZ361004 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2701-000142 1
L903 AZ361006 INDUCTOR-AXIAL;22uH,10%,2.5x3.4mm 2701-000158 1
L102 AZ361007 INDUCTOR-AXIAL;22UH,10%,4.2X9.8MM 2701-000159 1
L201 AZ361007 INDUCTOR-AXIAL;22UH,10%,4.2X9.8MM 2701-000159 1
L205 AZ361007 INDUCTOR-AXIAL;22UH,10%,4.2X9.8MM 2701-000159 1
L405 AZ361007 INDUCTOR-AXIAL;22UH,10%,4.2X9.8MM 2701-000159 1
L104 AZ361008 INDUCTOR-AXIAL;3.3 UH 5% 2.5X3.4 MM 2701-000168 1
L204 AZ361008 INDUCTOR-AXIAL;3.3 UH 5% 2.5X3.4 MM 2701-000168 1
L902 AZ361009 INDUCTOR-AXIAL;33UH,5%,2.5X3.4MM 2701-000180 1
Electric Parts List
7-4
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
Page 32
Electric Parts List
7-5
L904 AZ361009 INDUCTOR-AXIAL;33UH,5%,2.5X3.4MM 2701-000180 1
L702 AZ361010 INDUCTOR-AXIAL;4.7UH,10%,2.5X3.4MM 2701-000184 1
L703 AZ361010 INDUCTOR-AXIAL;4.7UH,10%,2.5X3.4MM 2701-000184 1
L704 AZ361010 INDUCTOR-AXIAL;4.7UH,10%,2.5X3.4MM 2701-000184 1
L706 AZ361010 INDUCTOR-AXIAL;4.7UH,10%,2.5X3.4MM 2701-000184 1
X901 AZ663009 CRYSTAL-UNIT;12MHz,25ppm,28-AAM,30pF,30o 2801-003937 1
L403 AZ362001 FILTER-EMI ON BOARD;-,3A,-,-,3.5X5,TP,- 2901-000297 1
L806 AZ362001 FILTER-EMI ON BOARD;-,3A,-,-,3.5X5,TP,- 2901-000297 1
L808 AZ362001 FILTER-EMI ON BOARD;-,3A,-,-,3.5X5,TP,- 2901-000297 1
Z202 AZ664004 FILTER-CERAMIC;TR,5.5/6.0/6.5MHz,-,1dB,- 2903-001040 1
J910 AZ362003 CORE-FERRITE BEAD;AA,3.5x1.0x6.0mm,1500, 3301-000287 1
L802 AZ362003 CORE-FERRITE BEAD;AA,3.5x1.0x6.0mm,1500, 3301-000287 1
L803 AZ362003 CORE-FERRITE BEAD;AA,3.5x1.0x6.0mm,1500, 3301-000287 1
SW901 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
SW902 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
SW903 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
SW904 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
SW905 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
FD801S AZ664146 FUSE-AXIAL LEAD;125V,7A,-,EPOXY,2.4X7.1M 3601-001163 1
F801A AZ664014 FUSE-HOLDER;-,-,30MOHM 3602-000114 1
F801B AZ664014 FUSE-HOLDER;-,-,30MOHM 3602-000114 1
F401A AZ664014 FUSE-HOLDER;-,-,30MOHM 3602-000114 1
F401B AZ664014 FUSE-HOLDER;-,-,30MOHM 3602-000114 1
C107 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
C507 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
C508 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
C912 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
D202 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J102 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J103 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J104 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J105 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J106 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J107 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J108 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J110 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J111 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J113 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J114 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J120 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J121 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J122 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J124 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J126 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J127 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J128 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J129 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J131 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J132 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J133 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J134 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J135 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J136 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J138 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J139 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J140 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J142 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J143 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J145 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J146 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J147 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J148 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J150 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J151 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J152 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J154 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J155 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J156 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J157 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J158 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J159 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J160 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J163 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J167 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J168 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J170 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J171 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
Page 33
J173 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J175 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J176 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J182 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J183 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J184 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J185 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J186 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J187 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J189 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J190 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J192 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J193 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J195 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J196 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J198 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J209 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J211 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J212 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J803 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J807 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J812 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J902 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
NT801S AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R309 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R406 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R422S AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R507 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R508 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R509 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R717 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J153 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J174 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J204 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J177 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J199 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J112 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J913 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J169 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R701 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
L910 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J200 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J117 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
D802 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R805 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R850 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R229 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J179 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J180 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J601 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J603 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J814 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R101 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R102 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R708 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J207 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
JK04 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J162 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
PCB AZ660069 PCB-MAIN;G,KS1A,FR-1,1L,C,1.6T,245 AA41-00131G 1
EY401 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY402 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY403 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY404 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY405 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY406 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY407 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY408 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY409 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY410 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY411 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY412 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY414 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY415 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY416 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY417 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY419 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY420 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
Electric Parts List
7-6
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
!
!
Page 34
Electric Parts List
7-7
EY421 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY422 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY423 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY501 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY801 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY802 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY803 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY807 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY808 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY809 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY810 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY813 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY818 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY819 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY821 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY822 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY823 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY824 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY825 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY827 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY828 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY829 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY833 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY850 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY851 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY852 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY853 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY860 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY861 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY101 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY830 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EL301 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL302 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL403 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL404 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL407 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL408 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL501 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL502 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL801 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL802 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL804 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL603 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL604 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
GT101 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT301 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT302 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT401 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT402 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT502 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT801 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT802 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT803 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT804 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT805 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT806 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT501 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT807 AZ664172 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
R505 AZ263049 R-FUSIBLE(S);0.18ohm,10%,2W,AF,TP,3.9x10 2008-001011 1
L101 AZ361033 INDUCTOR-AXIAL;330NH,10%,2.5X3.4MM 2701-000171 1
HIC01 AZ661025 IC-HYBRID;-,PAP103T,SIP,6P,PRE-AMP,TP AA13-20004W 1
RW701 AZ263058 R-NETWORK;33K/24K/75x3,5%,1/8W,X,SIP,6P, 2011-001133 1
R107 AZ261123 R-CARBON;12KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000331 1
R421 AZ263061 R-FUSIBLE(S);1.2ohm,5%,2W,AF,TP,3.9x10mm 2008-001013 1
Z203 AZ664001 FILTER-CERAMIC;TR,5.5MHz,-,-,-,TP,TPS5.5 2903-000181 1
J101 AZ261392 R-CARBON;3.9KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000613 1
L807 AZ361034 INDUCTOR-AXIAL;43uH,10%,5x14mm 2701-001030 1
L804 AZ361034 INDUCTOR-AXIAL;43uH,10%,5x14mm 2701-001030 1
C615 AZ161472 C-CERAMIC,MLC-AXIAL;4.7nF,20%,16V,Y5R,TP 2202-000253 1
C822 AZ165021 C-AL;2200uF,20%,25V,GP,TP,16x25,7.5 2401-000711 1
FP801S AZ664011 FUSE-CARTRIDGE;250V,4A,TIME-LAG,GLASS,5. 3601-000281 1
R302 AZ268019 R-METAL(S);1.1Kohm,1%,1/2W,AA,TP,2.4x6.4 2004-004969 1
R413 AZ263010 R-METAL OXIDE(S);18ohm,5%,2W,AF,TP,4x12m 2003-000532 1
R808 AZ268020 R-CARBON(S);390OHM,5%,1/2W,AA,TP,2.4X6.4 2001-001138 1
R831 AZ261921 R-CARBON(S);1KOHM,5%,1/2W,AA,TP,2.4X6.4M 2001-001088 1
D804 AZ462040 DIODE-SWITCHING BAV21,250V,250mA,DO-35,T 0401-000006 1
D805 AZ462041 DIODE-RECTIFIER;EGP20K,800V,1.5A,DO-204A 0402-001443 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
!
!
Page 35
R405 AZ261928 R-CARBON(S);27OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-001116 1
C203 AZ165022 C-AL;33uF,20%,16V,GP,TP,5x11,5 2401-002462 1
R306 AZ263031 R-METAL(S);1KOHM,2%,1/2W,AA,TP,2.4X6.4MM 2004-001390 1
R811 AZ263075 R-METAL OXIDE(S);100KOHM,5%,2W,AF,TP,3.9 2003-002239 1
R812 AZ263075 R-METAL OXIDE(S);100KOHM,5%,2W,AF,TP,3.9 2003-002239 1
R840 AZ268021 R-CARBON(S);3.9KOHM,5%,1/2W,AA,TP,2.4X6. 2001-001122 1
C818 AZ164038 C-AL;100uF,20%,25V,WT,TP,6.3x11,5 2401-003028 1
R728 AZ261104 R-CARBON;100KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000273 1
R923 AZ261104 R-CARBON;100KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000273 1
C603 AZ162007 C-FILM,PEF;33nF,5%,50V,TP,8.1x4.5x13mm,5 2301-000247 1
AZ760062 TAPE-PAPER;#53131,T0.15,W6.0,L200000,YEL 0203-001123 6.01
C102 AZ161470 C-CERAMIC,MLC-AXIAL;47pF,5%,50V,SL,TP,3. 2202-000279 1
FD401S AZ664012 FUSE;250V,630mA,SLOW-BLOW,GLASS,5.2x20mm 3601-001057 1
DZ401 AZ461016 DIODE-ZENER;MTZJ4.7C,4.68-4.93V,500mW,DO 0403-001319 1
DZ906 AZ461016 DIODE-ZENER;MTZJ4.7C,4.68-4.93V,500mW,DO 0403-001319 1
DZ907 AZ461016 DIODE-ZENER;MTZJ4.7C,4.68-4.93V,500mW,DO 0403-001319 1
DZ908 AZ461016 DIODE-ZENER;MTZJ4.7C,4.68-4.93V,500mW,DO 0403-001319 1
R814 AZ263077 R-FUSIBLE(S);2.4ohm,5%,2W,AG,TP,3.9x12mm 2008-001112 1
R815 AZ263077 R-FUSIBLE(S);2.4ohm,5%,2W,AG,TP,3.9x12mm 2008-001112 1
NT802S AZ664112 THERMISTOR-NTC;4.7OHM,15%,2900K,35.0MW,T 1404-001045 1
P803S AZ664113 THERMISTOR-PTC;9OHM,+30%/-20%,220VRMS,27 1404-001156 1
CX801S AZ166013 C-FILM,MPPF;220nF,20%,250V,TP,-,22.5mm 2306-000318 1
SF101S AZ664008 FILTER-SAW AV;38.9MHz,SIP5K,TP,14.5dB,PA 2904-001070 1
T401 AZ363005 TRANS-HORIZ.DRIVE;-,-,-,7.1mH,-,-,102uH, AA26-50001B 1
LX801S AZ664150 FILTER-LINE NOISE;SQ1913,-,6.0MH,0.8A,- AA29-30001D 1
TU01S AZ664151 TUNER;TECC0949PG35A(S),PAL,181CH,38.9MHZ AA40-00076A 1
LD901 AZ664152 ASSY LED GUIDE;-,-,UEX-LD-030,GREEN AA96-00555A 1
IC501 AZ660070 ASSY-H/S;-,VIDEO,AA62-30175D,TDA6107Q,- HA96-50311A 1
IC501 AZ661044 IC-VIDEO AMP;6107,ZSIP,9P,-,SINGLE,-,PLA 1201-001541 1
SCR501 AZ760079 SCREW-TAPTITE;RH,+,2S,M3,L6,ZPC(YE),SWR HA60-020004 1
H/S501 AZ664157 HEAT SINK-PS;-,SECC,T1.0,-,33X15X30 FT-2 AA62-30175D 1
V999S AZ664016 SOCKET-CRT;11P,20PI,26.5PI,NI,- 3704-001105 1
RM901 AZ664153 MODULE REMOCON;-,ORC-195VF,38KHZ,940nm,M AA32-00001A 1
IC801S AZ660071 ASSY-H/S;-,-,AA62-30186B,KA5Q0765R,- HA96-00242A 1
IC801 AZ661045 IC-PWM CONTROLLER;5Q0765,TO-220F,5P,185M 1203-001932 1
SCR801 AZ760080 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YELYEL) HA60-020007 1
H/S801 AZ664158 HEAT SINK-ES;-,-,-,SILVER,171J + COVER-H AA62-30186B 1
AZ760066 LABEL-WARNING;A/P(90G),W33,H18,WHT HA68-500033 1
AZ760065 GREASE-SILICON;SC102,JAPAN 0205-000129 0.00005
IC802 AZ660072 ASSY-H/S;-,POWER,AA62-00055A,KA7632,- HA96-00245A 1
IC802 AZ661046 IC-POSI.FIXED REG.;7632,SIP,10P,-,PLASTI 1203-001939 1
H/S802 AZ664159 HEAT SINK-PS;-,-,T1.0,-,35*15*25,D1,-,-, AA62-00055A 1
SCR802 AZ760079 SCREW-TAPTITE;RH,+,2S,M3,L6,ZPC(YE),SWR HA60-020004 1
IC902 AZ661047 IC-EEPROM;C81DC,1028x8Bit,DIP,8P,300MIL, 1103-001106 1
SW801S AZ662001 SWITCH-PUSH;250V,5A,DPST,-,JPW-2104B 3403-000179 1
Q401 AZ561017 TR-POWER;2SD2499,NPN,50000mW,TO-3P,BK,8- 0502-001160 1
JS701 AZ664028 JACK-SCART;21P,4mm,SN,BLK,NO 3722-000183 1
TOP AZ660002 LEAD CONNECTOR-ASSY;,1P,YFH800-01,S,400, AA39-20010D 1
TOP AZ660002 LEAD CONNECTOR-ASSY;,1P,YFH800-01,S,400, AA39-20010D 1
CN501 AZ664155 LEAD-CONNECTOR,ASSY;,9P,YBNH250-09,S,500 AA39-20620C 1
IC301 AZ660073 ASSY-H/S;-,-,AA62-00046A,LA7840,- HA96-00244A 1
AZ661048 IC-VERTICAL PROCESSO;LA7840,SIP,7P,708MI 1204-001483 1
AZ664160 HEAT SINK-PS;DP,-,-,-,AA62-00046A,-,-,-, AA62-00064A 1
AZ760067 SCREW-TAPTITE;RH,+,2S,M3,L8,ZPC(YEL),SL) 6003-000335 1
AZ760065 GREASE-SILICON;SC102,JAPAN 0205-000129 0.00005
C801 AZ165023 C-AL;220uF,20%,400V,GP,ST,25x40,10 2401-002219 1
CR402S AZ166016 C-FILM,MPPF;270nF,5%,400V,BK,26.5x19mm,2 2306-000172 1
T444S AZ363058 TRANS FBT;FSV-14A004H(S),CT15A8,3.24MH,1 AA26-00116A 1
SUB AZ660074 ASSY-SUB,PART;KS1A,MAIN(OPT),PAL,- AA98-00079A 1
AZ760060 SOLDER-WIRE;S63S-W3.0,S63S,D3,SN63/PB37 0202-000008 0.02567
AZ760061 SOLDER-WIRE FLUX;-,RS60S,D1.2,63SN/37PB 0202-000187 0.00028
AZ760063 SOLVENT;1M-1000,C3H70H,96,- 0204-000442 0.00863
AZ760064 FLUX;DF-98TVS,-,20%,- 0204-001024 0.00562
LR401S AZ362005 COIL-LINEARLITY;-,195uH,QIC1010,PI0.4,4. AA27-30001B 1
CR410S AZ162686 C-FILM,PPF;5.5nF,5%,1.6kV,TP,29x9.5x17,2 2303-001015 1
IC602 AZ660075 ASSY-H/S;-,SOUND,AA62-30175D,TDA8943,- HA96-00245B 1
SCR602 AZ760079 SCREW-TAPTITE;RH,+,2S,M3,L6,ZPC(YE),SWR HA60-020004 1
H/S602 AZ664157 HEAT SINK-PS;-,SECC,T1.0,-,33X15X30 FT-2 AA62-30175D 1
IC602 AZ661049 IC-AUDIO AMP;TDA8943,SIL,9P,850MIL,SINGL 1201-001740 1
CN706A AZ660091 ASSY-PCB,SECAM-L;-,KS1A,PAL/SEC-L,-,- HA95-900048 1
ICL01 AZ661052 IC-IF CIRCUIT;U4468B,DIP,16P,-,PLASTIC,5 1204-001583 1
SFS01 AZ664173 FILTER-SAW AV;38.9MHz,SIP5K,ST,15.7dB,L/ 2904-001225 1
CN706 AZ664174 CONNECTOR-HEADER;NOWALL,3P,1R,2.5MM,ANGL 3711-002701 1
CN705 AZ664175 CONNECTOR-HEADER;NOWALL,10P,1R,2.5MM,ANG 3711-002708 1
AZ660092 ASSY-PCB,SECAM-L(ACI);-,KS1A,PAL/SEC-L,- HA99-200075 1
CL01 AZ161102 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3 2202-000796 1
CL02 AZ164001 C-AL;4.7uF,20%,50V,GP,TP,5x11,5 2401-000027 1
Electric Parts List
7-8
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!!!!!!!!!!!!!!!
!!!
Page 36
Electric Parts List
7-9
CL03 AZ164001 C-AL;4.7uF,20%,50V,GP,TP,5x11,5 2401-000027 1
CL04 AZ164031 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM 2401-002235 1
CL05 AZ164025 C-AL;47uF,20%,16V,GP,TP,5x11,5 2401-001495 1
CL06 AZ164025 C-AL;47uF,20%,16V,GP,TP,5x11,5 2401-001495 1
CL07 AZ162019 C-FILM,MPEF;150NF,5%,63V,TP,-,5MM 2305-000196 1
CL08 AZ162019 C-FILM,MPEF;150NF,5%,63V,TP,-,5MM 2305-000196 1
DL01 AZ462043 DIODE-SWITCHING;BAW76,50V,300mA,DO-35,TP 0401-001088 1
LL01 AZ361003 INDUCTOR-AXIAL;10uH,10%,4.2x9.8mm 2701-000116 1
QL01 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
QL02 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
QL03 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
QL04 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
RL07 AZ261222 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 1
RL03 AZ261222 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 1
RL02 AZ261915 R-CARBON;360OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000674 1
RL05 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
RL13 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
RL11 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
RL06 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
RL10 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
RL12 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
RL15 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
RL14 AZ261203 R-CARBON;20KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000009 1
PCB AZ660093 PCB-SECAM,L D1;CF2139,FR-1,1L,A,1.6T,245 AA41-00468A 1
RL08 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
AZ760062 TAPE-PAPER;#53131,T0.15,W6.0,L200000,YEL 0203-001123 0.44
CN703 AZ664021 CONNECTOR-HEADER;BOX,9P,1R,2.5MM,STRAIGH 3711-002648 1
CN601 AZ664017 CONNECTOR-HEADER;BOX,3P,1R,2.5MM,STRAIGH 3711-002642 1
LW01 AZ362012 COIL-HORIZ.WIDTH;-,180/480uH,SB-5S6202.6 AA27-40001M 1
CY801S AZ163009 C-CERAMIC,DISC;3.3nF,20%,400V,Y5U,TP,18x 2201-000446 1
IC201S AZ661050 IC-MOC;TDA9351PS/N2H6,OPM-802EW,64K,DIP, AA09-00194A 1
T801S AZ363059 TRANS-SWITCHING;,CS21S5T,160V~260V,PM2 P AA26-00134A 1
ASSY-CRT
* AZ660063 ASSY-CRT;A51EER31X,+400MG,-,-,-,21 HA94-50012A 1
AZ664137 CRT COLOR;A51EER33X,+380MG,2.07MH,21.0MH AA03-00279A 1
AZ362004 COIL-DEGAUSSING;-,21,13.5ohm,25T,L2380,E AA27-20003Z 1
AZ760068 BAND-TIE;-,NYLON66 V2,-,-,L100,NTR,-,- AA63-10002A 1
AZ660064 ASSY-TBC,WIRE(P);DP,21,AA98-70014C,1P,TV AA98-70030A 1
AZ760026 CLAMP-D,COIL;20~22 INCH,NYLON 66,V2,-,NT AA65-30107A 4
ASSY ACCESSORY
* AZ664170 ASSY ACCESSORY;FRA,TXT,KS1A,TSB AA94-05176A 1
AZ664123 BATTERY-MN;1.5V,-,AA,14.5X50MM,- 4301-000120 2
AZ760074 TAPE-ACETATE;-,TO0.1,W20,L200MM HA02-030003 0.07
AZ760088 VINYL-BAG;HDPE,T0.025,L400,W240,-,W/O LO HA69-00276A 1
AZ664167 MANUAL USERS;,TSB,FRA,A/P 70(G),36P,145M HA68-01709A 1
AZ664171 MANUAL USERS;,TSB,DUT,A/P 70(G),36P,145M HA68-01711A 1
AZ664164 MANUAL USERS;,TSB,GER,A/P 70(G),36P,145M HA68-01705A 1
AZ664161 MANUAL USERS;,TSB,ITA,A/P 70(G),36P,145M HA68-01710A 1
ASSY-CABINET,FRONT
* AZ760091 ASSY-CABINET,FRONT;-,21T01,-,-,-,- HA91-100032 1
AZ760032 STOPPER-PCB;5038.5368,HIPS HB,-,-,-,NTR, AA61-40007A 1
AZ760018 SPRING-CS;-,SUS304,-,-,OD6,N7,OD6,-,-,-, AA61-60003J 1
AZ760030 KNOB-POWER;21R01,HIPS,HB,BLK,D/GRAY HA64-00423B 1
AZ760059 RESIN-HIPS;HR-1360,BLK,476L,HB 0103-000287 0.0048
AZ760078 MARKING-PAINT;-,DARK GRAY,411/010007 HA02-060008 0.001
AZ760077 MARKING-PAINT;-,TPC180,WHITE HA02-060005 0.00001
AZ760071 RESIN;M.BATCH,WILSON 902-BK-60,BLK HA01-030001 0.00015
AZ760029 KNOB-CONTROL;21R01,HIPS,HB,BLK,D/GRAY HA64-00426B 1
AZ760059 RESIN-HIPS;HR-1360,BLK,476L,HB 0103-000287 0.0213
AZ760078 MARKING-PAINT;-,DARK GRAY,411/010007 HA02-060008 0.001
AZ760071 RESIN;M.BATCH,WILSON 902-BK-60,BLK HA01-030001 0.0005
AZ760033 WINDOW-REMOCON;-,21R01,-,PC,V0,VIOLET,- AA64-00428B 1
AZ760034 INDICATOR-LED;-,21R01,-,ACRYL,HB,CLR,- AA64-00430B 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!!!
Page 37
AZ760035 CLAMP-WIRE;ALL MODEL,NYLON 66,V2,-,NTR,1 AA65-30105A 1
AZ760082 CABINET-FRONT;-,21T01,-,HIPS,HB,DARK-GRA HA64-300072 1
AZ760081 CABINET-FRONT;-,21R01,6007-GY60,HIPS,HB, HA64-00566A 1
AZ760059 RESIN-HIPS;HR-1360,BLK,476L,HB 0103-000287 1.36906
AZ760071 RESIN;M.BATCH,WILSON 902-BK-60,BLK HA01-030001 0.02794
AZ760077 MARKING-PAINT;-,TPC180,WHITE HA02-060005 0.000012
AZ760078 MARKING-PAINT;-,DARK GRAY,411/010007 HA02-060008 0.091
CF+SPK AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S HA60-020003 2
CF+WR AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S HA60-020003 1
CF+KC AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S HA60-020003 1
AZ660066 ASSY-SPEAKER;-,16OHM,3W,-,3001-001039,70 HA96-00254A 1
AZ664037 SPEAKER;3W,16ohm,90dB,180Hz 3001-001039 1
AZ664110 LEAD CONNECTOR-ASSY;,3(2),67096-003,REC, AA39-20500C 1
ASSY-CABINET(COM)
* AZ760089 ASSY-CABINET(COM);-,21R01 HA90-00166A 1
CB+CF AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S HA60-020003 4
PA+CF AZ760057 SCREW-TAPTITE;RWH,+,B,M4,L12,ZPC(YEL),SW HA60-020008 2
CRT+CF AZ760058 SCREW-ASSY;WC,HH,+,M5,L26.5,SWRCH18A,ZPC HA60-020010 4
AZ760009 CLAMP-CORD;PE,HB,BLK,-,-,- AA65-30008A 1
AZ760022 CABINET-BACK;-,21R01,-,HIPS,V0,BLK,-,- HA64-00572A 1
AZ760073 RESIN-HIPS;V0,BASF ES8550,BLK HA01-030018 1.52284
AZ760070 CLAMP-FBT;ABS,V0,BLK,-,-,- AA65-30009A 1
AZ760069 CLAMP-FBT;NYLON-66,V0,BLK,-,-,- AA65-30002A 2
AZ760050 CLAMP-WIRE;DONG-A,NYLON-66,-,-,-,DATL-60 AA65-30018A 5
AZ760075 TAPE-INK;WIDTH 55 MM HA02-030005 0.06
AZ760083 LABEL-QMS;-,T0.1,L135,W35,WHT,-,- HA68-500021 1
AZ760076 TAPE-INK; WIDTH 105 MM HA02-030006 0.23
ASSY-PACKING
* AZ760090 ASSY-PACKING;21R01,- HA90-00175A 1
AZ760008 PIN-STAPLE;-,-,H18,33X17.8X2.4,-,AUTO AA60-40006A 12
AZ760087 PACKING-CASE;21R01,TSB,CB D-1,YEL,-,-,-, HA69-00209B 1
AZ760027 BAG-SHEET;HDPE+PE FOAM,-,W1050,H950,-,-, AA69-30032C 1
AZ760086 CUSHION-SET;21R01,PS,C=0.02,-,-,-,- HA69-00205B 1
AZ760072 RESIN-EPS;CHEIL SF-301V,WHT HA01-030006 0.155
AZ760085 LABEL-BOX;A/P (120G),T0.2,TSB,-,STANDARD HA68-500040 1
AZ760076 TAPE-INK; WIDTH 105 MM HA02-030006 0.23
AZ760084 LABEL-BOX;A/P (120G),T0.2,-,-,STANDARD HA68-500026 1
ASSY-POWER,CORD
* AZ664124 ASSY-POWER,CORD;-,CP2/NO(4.0),H/C250,KKJ AA96-20122A 1
ASSY-PCB,A/V FRONT
* AZ660076 ASSY-PCB,A/V FRONT;KS1A,(..73,..H1) HA95-900053 1
CN702 AZ664057 LEAD CONNECTOR-ASSY;,9P,YBNH025-09,67096 AA39-20112E 1
AZ760060 SOLDER-WIRE;S63S-W3.0,S63S,D3,SN63/PB37 0202-000008 0.00185
AZ760061 SOLDER-WIRE FLUX;-,RS60S,D1.2,63SN/37PB 0202-000187 0.0001
AZ760064 FLUX;DF-98TVS,-,20%,- 0204-001024 0.00014
AZ760063 SOLVENT;1M-1000,C3H70H,96,- 0204-000442 0.00018
JE601 AZ664027 JACK-PHONE;1P(VER),3.4mm,AG,BLK,NO 3722-000143 1
JA702 AZ664030 JACK-RCA;2P,3.6MM,-,AG 3722-000506 1
AZ660077 ASSY-PCB,A/V FRONT(ACI);KS1A,(..73,..H1) HA99-200080 1
RE04 AZ361001 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 1
RE01 AZ262470 R-CARBON(S);47OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-001153 1
RE02 AZ262470 R-CARBON(S);47OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-001153 1
CE07 AZ161332 C-CERAMIC,MLC-AXIAL;3.3nF,20%,16V,Y5P,TP 2202-000222 1
CE06 AZ161101 C-CERAMIC,MLC-AXIAL;100pF,10%,50V,Y5P,TP 2202-000121 1
CE01 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
JE01 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
JE02 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
JE04 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
RE05 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
Electric Parts List
7-10
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
Page 38
Electric Parts List
7-11
JE03 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
PCB AZ660078 PCB-A/V FRONT;S15A,1L,FR-1,245x245x1.6T, AA41-10903B 1
AZ760062 TAPE-PAPER;#53131,T0.15,W6.0,L200000,YEL 0203-001123 0.44
LE01 AZ361006 INDUCTOR-AXIAL;22uH,10%,2.5x3.4mm 2701-000158 1
ASSY-SPEAKER
* AZ660066 ASSY-SPEAKER;-,16OHM,3W,-,3001-001039,70 HA96-00254A 1
AZ664037 SPEAKER;3W,16ohm,90dB,180Hz 3001-001039 1
AZ664110 LEAD CONNECTOR-ASSY;,3(2),67096-003,REC, AA39-20500C 1
REMOCON
* AZ664156 REMOCON;,TM59,OZM521TO,29,TOSHIBA,G6671B AA59-00082D 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
ASSY-CABINET,FRONT
* AZ760048 ASSY-CABINET,FRONT;-,21R01,-,-,- HA91-00226A 1
AZ760028 CABINET-FRONT;-,21R01,-,HIPS,HB,DARK-GRA HA64-00569A 1
ASSY-PCB,MAIN(OPT)
* AZ660095 ASSY-PCB,MAIN(OPT);CF,21R0,TSB,KS1A HA94-100847 1
REMOCON
* AZ664169 REMOCON;,TM59,OZM521TO,25,TOSHIBA,KS1A, AA59-00082C 1
ASSY ACCESSORY
* AZ660094 ASSY ACCESSORY;FRA,KS1A,TSB AA94-05175A 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-2 CF21R01F2GXTSB (CF21T01F2GXTSB and CF21R01F2GXTSB Dissimilar Parts)
Page 39
Electric Parts List
7-12
ASSY-PCB,MAIN(OPT)
* AZ660097 ASSY-PCB,MAIN(OPT);CI,21T0,TSB,KS1A HA94-100849 1
PCB(AC AZ660098 ASSY-PCB,MAIN(ACI);CI,21R0-T0,TSB,KS1A HA99-100785 1
SF101S AZ664077 FILTER-SAW AV;38.9MHz,SIP5K,TP,17dB,PAL- 2904-001063 1
ASSY ACCESSORY
* AZ660096 ASSY ACCESSORY;ENG,KS1A,TSB AA94-05174A 1
AZ664142 MANUAL USERS;,TSB,ENG,A/P 70(G),36P,145M HA68-01704A 1
AZ664176 CARD-WARRANTY;-,A/P 80(G),A5,-,TOSHIBA,U HA68-00601A 1
AZ664049 TRANS-MATCHING;-,300ohm/75ohm,PAL,40-890 AA26-90001C 1
AZ664166 ANT-ROD;-,3S,720mm,ABS,UL/CSA,- AA42-00003A 1
ASSY-POWER,CORD
* AZ664128 ASSY-POWER,CORD;-,EP3/YES,H/C250MM,U.K, HA96-700003 1
AZ664079 POWER-CORD;DP,CP3,-,2.4M,BLK,AC250V,10A HA39-010001 1
AZ664044 HOLDER;-,P-CORD,PP,VO,BLK,KE-002 AA61-20284A 1
AZ664080 CAP-CORD;-,PP,-,RED,CI HB61-200001 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-3 CI21T01B2GXTSB (CF21T01F2GXTSB and CI21T01B2GXTSB Dissimilar Parts)
!
!
Page 40
Electric Parts List
7-13
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-4 CF14R01F2GXTSB (CF21T01F2GXTSB and CF14R01F2GXTSB Dissimilar Parts)
ASSY-PCB,MAIN(OPT)
* AZ660099 ASSY-PCB,MAIN(OPT);CF,14R0,TSB,KS1A HA94-100844 1
PCB(AC AZ660100 ASSY-PCB,MAIN(ACI);CF,14R0-T0,TSB,KS1A HA99-100784 1
R501M AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
R502M AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
R814 AZ263052 R-FUSIBLE(S);3.3ohm,5%,2W,AG,TP,3.9x12mm 2008-001086 1
R815 AZ263052 R-FUSIBLE(S);3.3ohm,5%,2W,AG,TP,3.9x12mm 2008-001086 1
R421 AZ263078 R-FUSIBLE(S);1.5ohm,5%,2W,AG,TP,3.9x12mm 2008-001114 1
R406 AZ262220 R-CARBON(S);22OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-000020 1
R302 AZ268022 R-METAL(S);1.2Kohm,1%,1/2W,AA,TP,2.4x6.4 2004-001369 1
R316 AZ268023 R-METAL OXIDE(S);220OHM,5%,2W,AF,TP,3.9X 2003-001018 1
R505 AZ268002 R-FUSIBLE(S);0.1OHM,10%,2W,AF,TP,3.9X10M 2008-000284 1
R601 AZ261562 R-CARBON;5.6KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000812 1
V999S AZ664047 SOCKET-CRT;7P,22.5PI,12PI,SN,- 3704-001089 1
LR401S AZ362019 COIL-LINEARLITY;-,193uH,DR10X10 C:4.35,7 AA27-00053A 1
CR410 AZ162686 C-FILM,PPF;5.5nF,5%,1.6kV,TP,29x9.5x17,2 2303-001015 1
IC601 AZ660075 ASSY-H/S;-,SOUND,AA62-30175D,TDA8943,- HA96-00245B 1
IC201S AZ661051 IC-MOC;TDA9381PS/N2H6,OPM-802EWN,64K,DIP AA09-00195A 1
LW01 AZ362020 COIL-HORIZ.WIDTH;480UH,480UH,6X20,0.12X1 AA27-00184A 1
ASSY-CRT
* AZ660081 ASSY-CRT;A34EAC01X06,+400MG,14,PHIL,ITC HA94-500012 1
AZ362008 COIL-DEGAUSSING;-,14,16.4ohm,75T,890mm,D AA27-20003U 1
AZ660082 ASSY-TBC,WIRE(P);DP,14,AA98-70014A,1P,TV AA98-70032A 1
AZ664048 CRT-COLOR;A34EAC01X06,-,14inch,-,-,-,1.0 AA03-10023X 1
AZ664062 LEAD CONNECTOR-ASSY;,6(4)P,YFH806-06,350 AA39-20518A 1
ASSY ACCESSORY
* AZ660101 ASSY ACCESSORY;FRA,KS1A,TSB AA94-05060A 1
AZ664049 TRANS-MATCHING;-,300ohm/75ohm,PAL,40-890 AA26-90001C 1
AZ664166 ANT-ROD;-,3S,720mm,ABS,UL/CSA,- AA42-00003A 1
ASSY-CABINET,FRONT
* AZ760047 ASSY-CABINET,FRONT;-,14R01,-,-,-,- HA91-00225A 1
AZ760015 KNOB-POWER;14R01,HIPS,HB,BLK,D/GRAY HA64-00418B 1
AZ760014 KNOB-CONTROL;14R01,HIPS,HB,BLK,D/GRAY HA64-00427B 1
AZ760013 WINDOW-REMOCON;-,14R01,-,PC,V0,VIOLET,- AA64-00419B 1
AZ760020 INDICATOR-LED;-,14R01,-,ACRYL,HB,CLR,- AA64-00420B 1
AZ760012 CABINET-FRONT;-,14R01,-,HIPS,HB,DARK-GRA HA64-00568A 1
AZ760095 CABINET-FRONT;-,14R01,902-BK-60,BLK HA64-00565A 1
AZ760094 BOSS-WING;-,HIPS,HB,NTR,-,- HA61-40010A 2
AZ760093 ADHESIVE-GEL;BLACK SOLVENT HA02-010005 0.00064
AZ760013 BOSS-CABINET;SPACE HA61-00109B 2
AZ760092 SPACER-COVER;PVC SHEET,T2.0,94V0,-,14R01 AA60-00022C 1
ASSY-CABINET(COM)
* AZ760099 ASSY-CABINET(COM);-,14R01 HA90-00165A 1
AZ760001 CABINET-BACK;-,14R01,-,HIPS,V0,BLK,-,- HA64-00571A 1
AZ760010 CLAMP-D,COIL;14 INCH,NYLON 66,V2,-,NTR,- AA65-30106A 2
ASSY-PACKING
* AZ760100 ASSY-PACKING;14R01,- HA90-00174A 1
!!!
Page 41
Electric Parts List
7-14
ASSY-PCB,MAIN(OPT)
* AZ660102 ASSY-PCB,MAIN(OPT);CI,14T0,TSB,KS1A HA94-100846 1
PCB(AC AZ660103 ASSY-PCB,MAIN(ACI);CI,14R0-T0,TSB,KS1A HA99-100783 1
R213 AZ261680 R-CARBON;68ohm,5%,1/8W,AA,TP,1.8x3.2mm 2001-000938 1
C110 AZ164017 AL;22uF,20%,50V,GP,TP,5x11,5 2401-000962 1
R413 AZ263076 R-METAL OXIDE(S);27ohm,5%,2W,AF,TP,3.9x1 2003-001035 1
SF101S AZ664077 FILTER-SAW AV;38.9MHz,SIP5K,TP,17dB,PAL- 2904-001063 1
IC201S AZ661050 IC-MOC;TDA9351PS/N2H6,OPM-802EW,64K,DIP, AA09-00194A 1
ASSY ACCESSORY
* AZ660096 ASSY ACCESSORY;ENG,KS1A,TSB AA94-05174A 1
AZ664142 MANUAL USERS;,TSB,ENG,A/P 70(G),36P,145M HA68-01704A 1
AZ664176 CARD-WARRANTY;-,A/P 80(G),A5,-,TOSHIBA,U HA68-00601A 1
ASSY-CABINET,FRONT
* AZ760101 ASSY-CABINET,FRONT;-,14T01,-,-,-,- HA91-100031 1
AZ760096 CABINET-FRONT;-,14T01,-,HIPS,HB,DARK-GRA HA64-300071 1
ASSY-POWER,CORD
* AZ664128 ASSY-POWER,CORD;-,EP3/YES,H/C250MM,U.K, HA96-700003 1
AZ664079 POWER-CORD;DP,CP3,-,2.4M,BLK,AC250V,10A HA39-010001 1
AZ664044 HOLDER;-,P-CORD,PP,VO,BLK,KE-002 AA61-20284A 1
AZ664080 CAP-CORD;-,PP,-,RED,CI HB61-200001 1
REMOCON
* AZ664156 REMOCON;,TM59,OZM521TO,29,TOSHIBA,G6671B AA59-00082D 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-5 CI14T01B2GXTSB (CF14R01F2GXTSB and CI14T01B2GXTSB Dissimilar Parts)
AZ760011 BAG-SHEET;HDPE+PE FOAM,-,W800,H750,-,-,- AA69-30032A 1
AZ760098 PACKING-CASE;14R01,TSB,CB S-1,YEL,-, HA69-00212B 1
AZ760097 CUSHION-SET;14R01,PS,C=0.02,-,-,-,- HA69-00206B 1
ASSY-SPEAKER
* AZ660086 ASSY-SPEAKER;-,16OHM2.5W,000275,AA392050 AA96-10142A 1
AZ660061 LEAD CONNECTOR-ASSY;,3(2),67096-003,REC, AA39-20501A 1
AZ664068 SPEAKER;2.5W,16ohm,90dB,105Hz 3001-000275 1
REMOCON
* AZ664169 REMOCON;,TM59,OZM521TO,25,TOSHIBA,KS1A, AA59-00082C 1
!
!
!
Page 42
Electric Parts List
7-15
ASSY-PCB,MAIN(OPT)
* AZ660104 ASSY-PCB,MAIN(OPT);CI,14R0,TSB,KS1A HA94-100843 1
PCB(AC AZ660103 ASSY-PCB,MAIN(ACI);CI,14R0-T0,TSB,KS1A HA99-100783 1
R213 AZ261680 R-CARBON;68ohm,5%,1/8W,AA,TP,1.8x3.2mm 2001-000938 1
C110 AZ164017 AL;22uF,20%,50V,GP,TP,5x11,5 2401-000962 1
R413 AZ263076 R-METAL OXIDE(S);27ohm,5%,2W,AF,TP,3.9x1 2003-001035 1
SF101S AZ664077 FILTER-SAW AV;38.9MHz,SIP5K,TP,17dB,PAL- 2904-001063 1
ASSY ACCESSORY
* AZ660105 ASSY ACCESSORY;ENG,KS1A,TSB AA94-05059A 1
AZ664142 MANUAL USERS;,TSB,ENG,A/P 70(G),36P,145M HA68-01704A 1
AZ664176 CARD-WARRANTY;-,A/P 80(G),A5,-,TOSHIBA,U HA68-00601A 1
ASSY-POWER,CORD
* AZ664128 ASSY-POWER,CORD;-,EP3/YES,H/C250MM,U.K, HA96-700003 1
AZ664079 POWER-CORD;DP,CP3,-,2.4M,BLK,AC250V,10A HA39-010001 1
AZ664044 HOLDER;-,P-CORD,PP,VO,BLK,KE-002 AA61-20284A 1
AZ664080 CAP-CORD;-,PP,-,RED,CI HB61-200001 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-6 CI14R01B2GXTSB (CF14R01F2GXTSB and CI14R01B2GXTSB Dissimilar Parts)
!
!
Page 43
ASSY-PCB,MAIN(OPT)
* AZ660067 ASSY-PCB,MAIN(OPT);CB,21T0,TSB,KS1A HA94-100848 1
PCB(AC AZ660068 ASSY-PCB,MAIN(ACI);CB,21R0-T0,TSB,KS1A HA99-100803 1
D201 AZ462001 DIODE-SWITCHING;1N4148,100V,200mA,DO-35, 0401-000005 1
D811 AZ462001 DIODE-SWITCHING;1N4148,100V,200mA,DO-35, 0401-000005 1
D501 AZ462009 DIODE-RECTIFIER;RGP10J,600V,1A,DO-41,TP 0402-000254 1
D803 AZ462009 DIODE-RECTIFIER;RGP10J,600V,1A,DO-41,TP 0402-000254 1
D807 AZ462010 DIODE-RECTIFIER;1R5GU41,400V,1.5A,DO-15L 0402-000493 1
D301 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D304 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D401 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D502 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D503 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D504 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D812 AZ462014 DIODE-RECTIFIER;ERB43-04SV1,400V,1.0A,-, 0402-001105 1
D801S AZ462019 DIODE-RECTIFIER;1N5397GP,600V,1.5A,DO-20 0402-001111 1
D802S AZ462019 DIODE-RECTIFIER;1N5397GP,600V,1.5A,DO-20 0402-001111 1
D803S AZ462019 DIODE-RECTIFIER;1N5397GP,600V,1.5A,DO-20 0402-001111 1
D804S AZ462019 DIODE-RECTIFIER;1N5397GP,600V,1.5A,DO-20 0402-001111 1
D303 AZ462034 DIODE-RECTIFIER;1A4G,400,1A,R-1,TP 0402-001321 1
D809 AZ462034 DIODE-RECTIFIER;1A4G,400,1A,R-1,TP 0402-001321 1
D302 AZ462035 DIODE-RECTIFIER;GUF15G-20A,400V,1.5A,DO- 0402-001352 1
DZ402 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ807 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ810 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ903 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ904 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ905 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ901 AZ462022 DIODE-ZENER;MTZJ5.6B,5.6V,5.45-5.73V,500 0403-000508 1
DZ101 AZ461013 DIODE-ZENER;TZP33A,33V,31-35V,1W,DO-41,T 0403-000700 1
DZ303 AZ461013 DIODE-ZENER;TZP33A,33V,31-35V,1W,DO-41,T 0403-000700 1
DZ803 AZ461013 DIODE-ZENER;TZP33A,33V,31-35V,1W,DO-41,T 0403-000700 1
DZ201 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ204 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ205 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ207 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ501 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ502 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ503 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ504 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ704 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ808 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ306 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ307 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ701 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ702 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ703 AZ462025 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500 0403-000720 1
DZ801 AZ462042 DIODE-ZENER;RD10ESAB-T4,10V,9.19-10.30V, 0403-001140 1
DZ302 AZ462028 DIODE-ZENER;UZ39BSB,35.36-37.19V,500MW,D 0403-001221 1
DZ806 AZ462036 DIODE-ZENER;MTZJ3.0B,3.01-3.22V,500mW,DO 0403-001317 1
DZ802 AZ462037 DIODE-ZENER;MTZJ4.3B,4.17-4.43V,500mW,DO 0403-001318 1
DZ203 AZ462030 DIODE-ZENER;MTZJ8.2B,7.78-8.19V,500mW,DO 0403-001322 1
DZ805 AZ462038 DIODE-ZENER;MTZJ18A,16.22-17.06V,500mW,D 0403-001327 1
DZ301 AZ462039 DIODE-ZENER;MTZJ22A,20.15-21.20V,500mW,D 0403-001328 1
DZ305 AZ462039 DIODE-ZENER;MTZJ22A,20.15-21.20V,500mW,D 0403-001328 1
Q201 AZ561001 TR-SMALL SIGNAL;KSA539,PNP,400MW,TO-92,T 0501-000283 1
Q901 AZ561001 TR-SMALL SIGNAL;KSA539,PNP,400MW,TO-92,T 0501-000283 1
Q402 AZ561002 TR-SMALL SIGNAL;KSC2331-Y,NPN,1W,TO-92L, 0501-000369 1
Q202 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q205 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q903 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q905 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q704 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
Q701 AZ561003 TR-SMALL SIGNAL;KSC815,NPN,400MW,TO-92,T 0501-000389 1
VX801S AZ664040 VARISTOR;750V,1250A,12.5x7mm,TP 1405-000187 1
R207 AZ261391 R-CARBON;390OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000005 1
R905 AZ261391 R-CARBON;390OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000005 1
R906 AZ261391 R-CARBON;390OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000005 1
R218 AZ261153 R-CARBON;15KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000008 1
R602 AZ261153 R-CARBON;15KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000008 1
Electric Parts List
7-16
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-7 CB21T01N2GXTSB
!
!
!
!
!
!
!!!!!
Page 44
Electric Parts List
7-17
R205 AZ268005 R-CARBON;75Kohm,5%,1/8W,AA,TP,1.8x3.2mm 2001-000011 1
R301 AZ262010 R-CARBON(S);1OHM,5%,1/2W,AA,TP,2.4x6.4MM 2001-000016 1
J125 AZ262010 R-CARBON(S);1OHM,5%,1/2W,AA,TP,2.4x6.4MM 2001-000016 1
R843 AZ262100 R-CARBON(S);10OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-000019 1
R618 AZ262100 R-CARBON(S);10OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-000019 1
R409 AZ262330 R-CARBON(S);33OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-000022 1
R823 AZ262331 R-CARBON(S);330OHM,5%,1/2W,AA,TP,2.4X6.4 2001-000037 1
R902 AZ261152 R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000241 1
R904 AZ261152 R-CARBON;1.5KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000241 1
R211 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R215 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R223 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R501 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R502 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R506 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R510 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R511 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R512 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R909 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R911 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R912 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R913 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R914 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
J137 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R718 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R213 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R224 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R828 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R910 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R919 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R920 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R921 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R922 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R709 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R230 AZ261103 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000290 1
R225 AZ268006 R-CARBON;91ohm,5%,1/8W,AA,TP,1.8x3.2mm 2001-001035 1
R918 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R926 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R210 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R723 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R721 AZ261102 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000429 1
R916 AZ261222 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 1
R917 AZ261222 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000449 1
R220 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R901 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R903 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R907 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R908 AZ261272 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000472 1
R214 AZ261201 R-CARBON;200OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000490 1
R206 AZ261273 R-CARBON;27KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000563 1
R829 AZ261273 R-CARBON;27KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000563 1
R929 AZ261273 R-CARBON;27KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000563 1
R208 AZ261332 R-CARBON;3.3KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000591 1
R933 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R934 AZ261101 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000281 1
R202 AZ268007 R-CARBON;390KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000689 1
R925 AZ261472 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000734 1
R841 AZ261472 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000734 1
R601 AZ261472 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000734 1
R227 AZ268008 R-CARBON;4.7MOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000739 1
R228 AZ268008 R-CARBON;4.7MOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000739 1
R109 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R724 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R725 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R726 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R727 AZ261473 R-CARBON;47KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000786 1
R209 AZ261470 R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000793 1
R927 AZ261470 R-CARBON;47OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000793 1
R203 AZ261561 R-CARBON;560OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000857 1
R204 AZ261561 R-CARBON;560OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000857 1
R713 AZ261561 R-CARBON;560OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000857 1
R715 AZ261561 R-CARBON;560OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000857 1
R110 AZ261681 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000924 1
R915 AZ261681 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000924 1
R722 AZ261681 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000924 1
R108 AZ261918 R-CARBON;7.5KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000947 1
R222 AZ261918 R-CARBON;7.5KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000947 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
Page 45
R702 AZ261750 R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000969 1
R719 AZ261750 R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000969 1
R720 AZ261750 R-CARBON;75OHM,5%,1/8W,AA,TP,1.8X3.2MM 2001-000969 1
R408 AZ262398 R-CARBON(S);0.39OHM,5%,1/2W,AA,TP,2.4X6. 2001-001037 1
R504 AZ262106 R-CARBON(S);10MOHM,5%,1/2W,AA,TP,2.4X6.4 2001-001062 1
R414 AZ268009 R-CARBON(S);15KOHM,5%,1/2W,AA,TP,2.4X6.4 2001-001078 1
R806 AZ268010 R-CARBON(S);22KOHM,5%,1/2W,AA,TP,2.4X6.4 2001-001108 1
R411 AZ262271 R-CARBON(S);270OHM,5%,1/2W,AA,TP,2.4X6.4 2001-001114 1
R809 AZ262474 R-CARBON(S);470KOHM,5%,1/2W,AA,TP,2.4X6. 2001-001150 1
R810 AZ262474 R-CARBON(S);470KOHM,5%,1/2W,AA,TP,2.4X6. 2001-001150 1
R501H AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
R502H AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
R503 AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
RX801S AZ263005 R-COMPOSITION;3.3MOHM,10%,1/2W,AA,TP,3.7 2002-001011 1
RY801S AZ268011 R-COMPOSITION;8.2MOHM,10%,1/2W,AA,TP,3.7 2002-001012 1
R827 AZ263068 R-METAL OXIDE(S);330OHM,5%,2W,AF,TP,4X12 2003-000652 1
R316 AZ263068 R-METAL OXIDE(S);330OHM,5%,2W,AF,TP,4X12 2003-000652 1
R315 AZ263068 R-METAL OXIDE(S);330OHM,5%,2W,AF,TP,4X12 2003-000652 1
R403 AZ263014 R-METAL OXIDE(S);7.5KOHM,5%,2W,AF,TP,4X1 2003-000784 1
R834 AZ263021 R-METAL OXIDE(S);47Kohm,5%,2W,AF,TP,3.9x 2003-001040 1
R303 AZ268012 R-FUSIBLE(S);0.75ohm,5%,2W,AF,TP,3.9x10m 2008-001133 1
R801 AZ268013 R-METAL OXIDE(S);150ohm,5%,2W,AG,TP,3.9x 2003-002171 1
R402 AZ268014 R-METAL OXIDE(S);1Kohm,5%,2W,AG,TP,3.9x1 2003-002178 1
R407 AZ268015 R-METAL OXIDE(S);47Kohm,5%,2W,AG,TP,3.9X 2003-002209 1
R423 AZ268016 R-METAL(S);100KOHM,1%,1/2W,AA,TP,2.4X6.4 2004-001373 1
R424 AZ264004 R-METAL(S);6.8KOHM,1%,1/2W,AA,TP,2.4X6.4 2004-001402 1
R219 AZ263032 R-METAL;39KOHM,2%,1/8W,AA,TP,1.8X3.5MM 2004-001914 1
R817 AZ263037 R-METAL;123KOHM,1%,1/2W,AA,TP,2.5X6.5M 2004-004089 1
R304 AZ268017 R-FUSIBLE(S);0.47ohm,5%,1W,AF,TP,3.9x10m 2008-000253 1
R305 AZ268017 R-FUSIBLE(S);0.47ohm,5%,1W,AF,TP,3.9x10m 2008-000253 1
R825 AZ263044 R-FUSIBLE(S);1OHM,5%,2W,AF,TP,3.9X10MM 2008-000266 1
R824 AZ263047 R-FUSIBLE(S);33ohm,5%,2W,AF,TP,3.9x10mm 2008-000294 1
R420 AZ268018 R-FUSIBLE(S);68ohm,5%,2W,AG,TP,3.9X12mm 2008-001110 1
C904 AZ163029 C-CERAMIC,DISC;10NF,10%,50V,Y5V,TP,6.5*3 2201-000180 1
C501 AZ163002 C-CERAMIC,DISC;0.01nF,0.25pF,500V,NP0,TP 2201-000192 1
C302 AZ163030 C-CERAMIC,DISC;0.18nF,10%,500V,Y5P,TP,5. 2201-000259 1
C303 AZ163011 C-CERAMIC,DISC;0.47nF,10%,500V,Y5P,TP,5. 2201-000556 1
C305 AZ163011 C-CERAMIC,DISC;0.47nF,10%,500V,Y5P,TP,5. 2201-000556 1
C908 AZ163031 C-CERAMIC,DISC;82pF,5%,50V,CH,8x5mm,5mm, 2201-000872 1
C909 AZ163031 C-CERAMIC,DISC;82pF,5%,50V,CH,8x5mm,5mm, 2201-000872 1
C408 AZ163013 C-CERAMIC,DISC;0.56nF,10%,500V,Y5P,TP,5. 2201-000599 1
CR404S AZ163032 C-CERAMIC,DISC;0.68nF,10%,2kV,Y5P,TP,9x5 2201-000639 1
C503 AZ163033 C-CERAMIC,DISC;4.7nF,20%,3KV,Y5U,TP,16x5 2201-000723 1
C811 AZ163018 C-CERAMIC,DISC;0.56nF,10%,2kV,Y5P,TP,7.5 2201-000991 1
C814 AZ163018 C-CERAMIC,DISC;0.56nF,10%,2kV,Y5P,TP,7.5 2201-000991 1
C704 AZ161101 C-CERAMIC,MLC-AXIAL;100pF,10%,50V,Y5P,TP 2202-000121 1
C703 AZ161101 C-CERAMIC,MLC-AXIAL;100pF,10%,50V,Y5P,TP 2202-000121 1
C106 AZ161103 C-CERAMIC,MLC-AXIAL;10nF,+80-20%,25V,Y5V 2202-000127 1
C111 AZ161103 C-CERAMIC,MLC-AXIAL;10nF,+80-20%,25V,Y5V 2202-000127 1
C105 AZ161103 C-CERAMIC,MLC-AXIAL;10nF,+80-20%,25V,Y5V 2202-000127 1
C702 AZ161271 C-CERAMIC,MLC-AXIAL;270PF,10%,50V,Y5P,TP 2202-000210 1
C115 AZ161703 C-CERAMIC,MLC-AXIAL;100nF,20%,50V,Z5U,TP 2202-000632 1
C211 AZ161703 C-CERAMIC,MLC-AXIAL;100nF,20%,50V,Z5U,TP 2202-000632 1
C911 AZ161703 C-CERAMIC,MLC-AXIAL;100nF,20%,50V,Z5U,TP 2202-000632 1
C223 AZ161102 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3 2202-000796 1
C224 AZ161102 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3 2202-000796 1
C906 AZ161102 C-CERAMIC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3 2202-000796 1
C505 AZ161681 C-CERAMIC,MLC-AXIAL;680pF,10%,50V,Y5P,TP 2202-000825 1
C226 AZ161704 C-CERAMIC,MLC-AXIAL;820pF,10%,50V,Y5P,3. 2202-000829 1
C707 AZ162004 C-FILM,PEF;2.7nF,5%,50V,TP,7.4x3.9x13mm, 2301-000204 1
C502 AZ162005 C-FILM,PEF;220nF,5%,250V,TP,21.5x11,7.5 2301-000213 1
C109 AZ162006 C-FILM,PEF;22nF,5%,50V,TP,7.4x3.9x13mm 2301-000224 1
C804 AZ162006 C-FILM,PEF;22nF,5%,50V,TP,7.4x3.9x13mm 2301-000224 1
C805 AZ162015 C-FILM,PEF;3.9nF,5%,50V,TP,6.5x3.0x5.5mm 2301-000235 1
C309 AZ162008 C-FILM,PEF;39nF,5%,50V,TP,7.5x3.5x6.5mm, 2301-000254 1
C606 AZ162016 C-FILM,PEF;1.8nF,5%,50V,TP,6.5x3.0x5.5mm 2301-000111 1
C217 AZ162031 C-FILM,PEF;2.2nF,5%,50V,TP,7.4x3.9x13mm, 2301-000342 1
C234 AZ162031 C-FILM,PEF;2.2nF,5%,50V,TP,7.4x3.9x13mm, 2301-000342 1
C407 AZ162012 C-FILM,PEF;10nF,5%,50V,TP,6x7x3.2mm,5mm 2301-000383 1
C227 AZ162013 C-FILM,PEF;4.7nF,5%,50V,TP,5.5x7x3mm,5mm 2301-000445 1
C248 AZ162013 C-FILM,PEF;4.7nF,5%,50V,TP,5.5x7x3mm,5mm 2301-000445 1
C420 AZ162014 C-FILM,MPPF;47nF,5%,630V,TP,19x15.5x7,7. 2301-001065 1
C806 AZ162017 C-FILM,PPF;1.5nF,5%,1.2kV,TP,15x8x12.5mm 2301-001435 1
C301 AZ162020 C-FILM,MPEF;220nF,5%,100V,TP,20x18x11.5 2305-000285 1
C215 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
C216 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
C233 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
Electric Parts List
7-18
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
!
!
Page 46
Electric Parts List
7-19
C613 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
C611 AZ162021 C-FILM,MPEF;220nF,5%,63V,TP,-,5mm 2305-000289 1
CR405S AZ162023 C-FILM,MPEF;4.7NF,5%,400V,TP,-,5MM 2305-000382 1
C207 AZ162025 C-FILM,MPEF;470nF,5%,63V,TP,-,5mm 2305-000412 1
C901 AZ162025 C-FILM,MPEF;470nF,5%,63V,TP,-,5mm 2305-000412 1
C103 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C208 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C210 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C218 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C230 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C803 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C819 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C913 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C204 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C205 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C231 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C618 AZ162027 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m 2305-000665 1
C225 AZ162030 C-FILM,PE-PPF;100nF,5%,50V,TP,20x16x8.5, 2309-000138 1
C812 AZ165001 C-AL;100uF,20%,160V,HR,TP,16x25,7.5 2401-000262 1
C817 AZ164005 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2401-000302 1
C821 AZ164005 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2401-000302 1
C823 AZ164005 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2401-000302 1
C915 AZ164005 C-AL;100uF,20%,25V,GP,TP,6.3x11,5 2401-000302 1
C307 AZ164006 C-AL;100uF,20%,50V,GP,TP,8x11.5,5 2401-000360 1
C308 AZ164006 C-AL;100uF,20%,50V,GP,TP,8x11.5,5 2401-000360 1
C506 AZ165004 C-AL;10UF,20%,250V,GP,TP,10X16MM,5M 2401-000430 1
C820 AZ164009 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-000480 1
C612 AZ164009 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-000480 1
C604 AZ164009 C-AL;10uF,20%,50V,GP,TP,5x11,5 2401-000480 1
C403 AZ165006 C-AL;1uF,20%,160V,GP,TP,6.3x11,5 2401-000560 1
C219 AZ164011 C-AL;1uF,20%,50V,GP,TP,5x11,5 2401-000603 1
C212 AZ164013 C-AL;2.2uF,20%,50V,GP,TP,5x11,5 2401-000660 1
C221 AZ164013 C-AL;2.2uF,20%,50V,GP,TP,5x11,5 2401-000660 1
C605 AZ164013 C-AL;2.2uF,20%,50V,GP,TP,5x11,5 2401-000660 1
C222 AZ165015 C-AL;220NF,20%,50V,GP,TP,5X11MM,5MM 2401-000758 1
C827 AZ165008 C-AL;22UF,20%,250V,GP,TP,13X20MM,5M 2401-000927 1
C101 AZ165016 C-AL;330uF,20%,16V,GP,TP,8x11.5,5 2401-001101 1
C802 AZ165017 C-AL;33uF,20%,50V,GP,TP,6.3x11,5 2401-001192 1
C504 AZ165009 C-AL;4.7uF,20%,250V,GP,TP,10x12.5,5 2401-001232 1
C209 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C213 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C229 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C903 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C910 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
C705 AZ165018 C-AL;4.7uF,20%,50V,BP,TP,5x11,5 2401-001989 1
C706 AZ165018 C-AL;4.7uF,20%,50V,BP,TP,5x11,5 2401-001989 1
C710 AZ165018 C-AL;4.7uF,20%,50V,BP,TP,5x11,5 2401-001989 1
C711 AZ165018 C-AL;4.7uF,20%,50V,BP,TP,5x11,5 2401-001989 1
C601 AZ164029 C-AL;1000UF,20%,25V,GP,TP,10X20,5MM 2401-001998 1
C206 AZ164031 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM 2401-002235 1
C220 AZ164031 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM 2401-002235 1
C709 AZ164031 C-AL;10UF,20%,16V,GP,TP,5X11MM,5MM 2401-002235 1
C306 AZ165019 C-AL;470uF,20%,25V,WT,TP,10x20,5 2401-002288 1
C304 AZ165019 C-AL;470uF,20%,25V,WT,TP,10x20,5 2401-002288 1
C813 AZ165012 C-AL;47uF,20%,160V,GP,TP,13x20,5 2401-002290 1
C406 AZ164037 C-AL;47uF,20%,25V,GP,TP,5x11,5 2401-002619 1
C214 AZ165020 C-AL;100uF,20%,10V,GP,TP,5x11,5 2401-003102 1
L103 AZ361001 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 1
L202 AZ361001 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 1
L301 AZ361004 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2701-000142 1
L302 AZ361004 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2701-000142 1
L404 AZ361004 INDUCTOR-AXIAL;1UH,10%,2.5X3.4MM 2701-000142 1
L903 AZ361006 INDUCTOR-AXIAL;22uH,10%,2.5x3.4mm 2701-000158 1
L102 AZ361007 INDUCTOR-AXIAL;22UH,10%,4.2X9.8MM 2701-000159 1
L201 AZ361007 INDUCTOR-AXIAL;22UH,10%,4.2X9.8MM 2701-000159 1
L205 AZ361007 INDUCTOR-AXIAL;22UH,10%,4.2X9.8MM 2701-000159 1
L405 AZ361007 INDUCTOR-AXIAL;22UH,10%,4.2X9.8MM 2701-000159 1
L104 AZ361008 INDUCTOR-AXIAL;3.3 UH 5% 2.5X3.4 MM 2701-000168 1
L204 AZ361008 INDUCTOR-AXIAL;3.3 UH 5% 2.5X3.4 MM 2701-000168 1
L902 AZ361009 INDUCTOR-AXIAL;33UH,5%,2.5X3.4MM 2701-000180 1
L904 AZ361009 INDUCTOR-AXIAL;33UH,5%,2.5X3.4MM 2701-000180 1
L702 AZ361010 INDUCTOR-AXIAL;4.7UH,10%,2.5X3.4MM 2701-000184 1
L703 AZ361010 INDUCTOR-AXIAL;4.7UH,10%,2.5X3.4MM 2701-000184 1
L704 AZ361010 INDUCTOR-AXIAL;4.7UH,10%,2.5X3.4MM 2701-000184 1
L706 AZ361010 INDUCTOR-AXIAL;4.7UH,10%,2.5X3.4MM 2701-000184 1
X901 AZ663009 CRYSTAL-UNIT;12MHz,25ppm,28-AAM,30pF,30o 2801-003937 1
L403 AZ362001 FILTER-EMI ON BOARD;-,3A,-,-,3.5X5,TP,- 2901-000297 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
!
Page 47
L806 AZ362001 FILTER-EMI ON BOARD;-,3A,-,-,3.5X5,TP,- 2901-000297 1
L808 AZ362001 FILTER-EMI ON BOARD;-,3A,-,-,3.5X5,TP,- 2901-000297 1
Z202 AZ664004 FILTER-CERAMIC;TR,5.5/6.0/6.5MHz,-,1dB,- 2903-001040 1
J910 AZ362003 CORE-FERRITE BEAD;AA,3.5x1.0x6.0mm,1500, 3301-000287 1
L802 AZ362003 CORE-FERRITE BEAD;AA,3.5x1.0x6.0mm,1500, 3301-000287 1
L803 AZ362003 CORE-FERRITE BEAD;AA,3.5x1.0x6.0mm,1500, 3301-000287 1
SW901 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
SW902 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
SW903 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
SW904 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
SW905 AZ662002 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SP 3404-000244 1
FD801S AZ664146 FUSE-AXIAL LEAD;125V,7A,-,EPOXY,2.4X7.1M 3601-001163 1
F801A AZ664014 FUSE-HOLDER;-,-,30MOHM 3602-000114 1
F801B AZ664014 FUSE-HOLDER;-,-,30MOHM 3602-000114 1
F401A AZ664014 FUSE-HOLDER;-,-,30MOHM 3602-000114 1
F401B AZ664014 FUSE-HOLDER;-,-,30MOHM 3602-000114 1
C107 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
C507 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
C508 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
C912 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
D202 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J102 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J103 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J104 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J105 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J106 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J107 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J108 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J110 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J111 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J113 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J114 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J120 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J121 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J122 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J124 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J126 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J127 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J128 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J129 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J131 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J132 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J133 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J134 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J135 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J136 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J138 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J139 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J140 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J142 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J143 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J145 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J146 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J147 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J148 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J150 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J151 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J152 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J154 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J155 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J156 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J157 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J158 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J159 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J160 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J163 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J167 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J168 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J170 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J171 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J173 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J175 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J176 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J182 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J183 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J184 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J185 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
Electric Parts List
7-20
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
Page 48
Electric Parts List
7-21
J186 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J187 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J189 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J190 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J192 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J193 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J195 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J196 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J198 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J209 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J211 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J212 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J803 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J807 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J812 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J902 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
NT801S AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R309 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R406 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R422S AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R507 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R508 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R509 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R717 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J153 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J174 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J204 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J177 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J199 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J112 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J913 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J169 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R701 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
L910 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J200 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J117 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
D802 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R805 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R850 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R229 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R107 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J179 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J180 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J601 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J603 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J814 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R101 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R102 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
R708 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J207 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
JK04 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
J162 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
PCB AZ660069 PCB-MAIN;G,KS1A,FR-1,1L,C,1.6T,245 AA41-00131G 1
EY401 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY402 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY403 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY404 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY405 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY406 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY407 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY408 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY409 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY410 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY411 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY412 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY414 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY415 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY416 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY417 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY419 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY420 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY421 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY422 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY423 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY501 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY801 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY802 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!!!
Page 49
EY803 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY807 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY808 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY809 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY810 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY813 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY818 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY819 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY821 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY822 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY823 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY824 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY825 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY827 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY828 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY829 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY833 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY850 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY851 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY852 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY853 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY860 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY861 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY101 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EY830 AZ664148 EYELET;ID2.0,OD2.8,-,-,BST,- AA60-40011A 1
EL301 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL302 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL403 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL404 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL407 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL408 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL501 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL502 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL801 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL802 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL804 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL603 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
EL604 AZ664149 EYELET;ID2.2,OD3.2,-,-,BSP,- AA60-40011B 1
GT101 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT301 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT302 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT401 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT402 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT502 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT801 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT802 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT803 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT804 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT805 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT806 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT501 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
GT807 AZ664149 PIN-GT,ASSY;1P,-,-,AUTO AA60-40014A 1
R505 AZ263049 R-FUSIBLE(S);0.18ohm,10%,2W,AF,TP,3.9x10 2008-001011 1
L101 AZ361033 INDUCTOR-AXIAL;330NH,10%,2.5X3.4MM 2701-000171 1
HIC01 AZ661025 IC-HYBRID;-,PAP103T,SIP,6P,PRE-AMP,TP AA13-20004W 1
RW701 AZ263058 R-NETWORK;33K/24K/75x3,5%,1/8W,X,SIP,6P, 2011-001133 1
R421 AZ263061 R-FUSIBLE(S);1.2ohm,5%,2W,AF,TP,3.9x10mm 2008-001013 1
J101 AZ261392 R-CARBON;3.9KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000613 1
L807 AZ361034 INDUCTOR-AXIAL;43uH,10%,5x14mm 2701-001030 1
L804 AZ361034 INDUCTOR-AXIAL;43uH,10%,5x14mm 2701-001030 1
C615 AZ161472 C-CERAMIC,MLC-AXIAL;4.7nF,20%,16V,Y5R,TP 2202-000253 1
C822 AZ165021 C-AL;2200uF,20%,25V,GP,TP,16x25,7.5 2401-000711 1
FP801S AZ664011 FUSE-CARTRIDGE;250V,4A,TIME-LAG,GLASS,5. 3601-000281 1
R302 AZ268019 R-METAL(S);1.1Kohm,1%,1/2W,AA,TP,2.4x6.4 2004-004969 1
R808 AZ268020 R-CARBON(S);390OHM,5%,1/2W,AA,TP,2.4X6.4 2001-001138 1
R831 AZ261921 R-CARBON(S);1KOHM,5%,1/2W,AA,TP,2.4X6.4M 2001-001088 1
D804 AZ462040 DIODE-SWITCHING BAV21,250V,250mA,DO-35,T 0401-000006 1
D805 AZ462041 DIODE-RECTIFIER;EGP20K,800V,1.5A,DO-204A 0402-001443 1
R405 AZ261928 R-CARBON(S);27OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-001116 1
C203 AZ165022 C-AL;33uF,20%,16V,GP,TP,5x11,5 2401-002462 1
R306 AZ263031 R-METAL(S);1KOHM,2%,1/2W,AA,TP,2.4X6.4MM 2004-001390 1
R811 AZ263075 R-METAL OXIDE(S);100KOHM,5%,2W,AF,TP,3.9 2003-002239 1
R812 AZ263075 R-METAL OXIDE(S);100KOHM,5%,2W,AF,TP,3.9 2003-002239 1
R413 AZ263076 R-METAL OXIDE(S);27ohm,5%,2W,AF,TP,3.9x1 2003-001035 1
C110 AZ164017 AL;22uF,20%,50V,GP,TP,5x11,5 2401-000962 1
R840 AZ268021 R-CARBON(S);3.9KOHM,5%,1/2W,AA,TP,2.4X6. 2001-001122 1
C818 AZ164038 C-AL;100uF,20%,25V,WT,TP,6.3x11,5 2401-003028 1
Electric Parts List
7-22
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!!!
Page 50
Electric Parts List
7-23
R728 AZ261104 R-CARBON;100KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000273 1
R923 AZ261104 R-CARBON;100KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000273 1
C603 AZ162007 C-FILM,PEF;33nF,5%,50V,TP,8.1x4.5x13mm,5 2301-000247 1
AZ760062 TAPE-PAPER;#53131,T0.15,W6.0,L200000,YEL 0203-001123 6.01
C102 AZ161470 C-CERAMIC,MLC-AXIAL;47pF,5%,50V,SL,TP,3. 2202-000279 1
FD401S AZ664012 FUSE;250V,630mA,SLOW-BLOW,GLASS,5.2x20mm 3601-001057 1
DZ401 AZ461016 DIODE-ZENER;MTZJ4.7C,4.68-4.93V,500mW,DO 0403-001319 1
DZ906 AZ461016 DIODE-ZENER;MTZJ4.7C,4.68-4.93V,500mW,DO 0403-001319 1
DZ907 AZ461016 DIODE-ZENER;MTZJ4.7C,4.68-4.93V,500mW,DO 0403-001319 1
DZ908 AZ461016 DIODE-ZENER;MTZJ4.7C,4.68-4.93V,500mW,DO 0403-001319 1
R814 AZ263077 R-FUSIBLE(S);2.4ohm,5%,2W,AG,TP,3.9x12mm 2008-001112 1
R815 AZ263077 R-FUSIBLE(S);2.4ohm,5%,2W,AG,TP,3.9x12mm 2008-001112 1
NT802S AZ664112 THERMISTOR-NTC;4.7OHM,15%,2900K,35.0MW,T 1404-001045 1
P803S AZ664113 THERMISTOR-PTC;9OHM,+30%/-20%,220VRMS,27 1404-001156 1
CX801S AZ166013 C-FILM,MPPF;220nF,20%,250V,TP,-,22.5mm 2306-000318 1
SF101S AZ664008 FILTER-SAW AV;38.9MHz,SIP5K,TP,14.5dB,PA 2904-001070 1
T401 AZ363005 TRANS-HORIZ.DRIVE;-,-,-,7.1mH,-,-,102uH, AA26-50001B 1
LX801S AZ664150 FILTER-LINE NOISE;SQ1913,-,6.0MH,0.8A,- AA29-30001D 1
TU01S AZ664151 TUNER;TECC0949PG35A(S),PAL,181CH,38.9MHZ AA40-00076A 1
LD901 AZ664152 ASSY LED GUIDE;-,-,UEX-LD-030,GREEN AA96-00555A 1
IC501 AZ660070 ASSY-H/S;-,VIDEO,AA62-30175D,TDA6107Q,- HA96-50311A 1
IC501 AZ661044 IC-VIDEO AMP;6107,ZSIP,9P,-,SINGLE,-,PLA 1201-001541 1
SCR501 AZ760079 SCREW-TAPTITE;RH,+,2S,M3,L6,ZPC(YE),SWR HA60-020004 1
H/S501 AZ664157 HEAT SINK-PS;-,SECC,T1.0,-,33X15X30 FT-2 AA62-30175D 1
V999S AZ664016 SOCKET-CRT;11P,20PI,26.5PI,NI,- 3704-001105 1
RM901 AZ664153 MODULE REMOCON;-,ORC-195VF,38KHZ,940nm,M AA32-00001A 1
IC801S AZ660071 ASSY-H/S;-,-,AA62-30186B,KA5Q0765R,- HA96-00242A 1
IC801 AZ661045 IC-PWM CONTROLLER;5Q0765,TO-220F,5P,185M 1203-001932 1
SCR801 AZ760080 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YELYEL) HA60-020007 1
H/S801 AZ664158 HEAT SINK-ES;-,-,-,SILVER,171J + COVER-H AA62-30186B 1
AZ664154 LABEL-WARNING;A/P(90G),W33,H18,WHT HA68-500033 1
AZ760065 GREASE-SILICON;SC102,JAPAN 0205-000129 0.00005
IC802 AZ660072 ASSY-H/S;-,POWER,AA62-00055A,KA7632,- HA96-00245A 1
IC802 AZ661046 IC-POSI.FIXED REG.;7632,SIP,10P,-,PLASTI 1203-001939 1
H/S802 AZ664159 HEAT SINK-PS;-,-,T1.0,-,35*15*25,D1,-,-, AA62-00055A 1
SCR802 AZ760079 SCREW-TAPTITE;RH,+,2S,M3,L6,ZPC(YE),SWR HA60-020004 1
IC902 AZ661047 IC-EEPROM;C81DC,1028x8Bit,DIP,8P,300MIL, 1103-001106 1
SW801S AZ662001 SWITCH-PUSH;250V,5A,DPST,-,JPW-2104B 3403-000179 1
Q401 AZ561017 TR-POWER;2SD2499,NPN,50000mW,TO-3P,BK,8- 0502-001160 1
JS701 AZ664028 JACK-SCART;21P,4mm,SN,BLK,NO 3722-000183 1
TOP AZ660002 LEAD CONNECTOR-ASSY;,1P,YFH800-01,S,400, AA39-20010D 1
TOP AZ660002 LEAD CONNECTOR-ASSY;,1P,YFH800-01,S,400, AA39-20010D 1
CN501 AZ664155 LEAD-CONNECTOR,ASSY;,9P,YBNH250-09,S,500 AA39-20620C 1
IC301 AZ660073 ASSY-H/S;-,-,AA62-00046A,LA7840,- HA96-00244A 1
AZ661048 IC-VERTICAL PROCESSO;LA7840,SIP,7P,708MI 1204-001483 1
AZ664160 HEAT SINK-PS;DP,-,-,-,AA62-00046A,-,-,-, AA62-00064A 1
AZ760067 SCREW-TAPTITE;RH,+,2S,M3,L8,ZPC(YEL),SL) 6003-000335 1
AZ760065 GREASE-SILICON;SC102,JAPAN 0205-000129 0.00005
C801 AZ165023 C-AL;220uF,20%,400V,GP,ST,25x40,10 2401-002219 1
CR402S AZ166016 C-FILM,MPPF;270nF,5%,400V,BK,26.5x19mm,2 2306-000172 1
T444S AZ363058 TRANS FBT;FSV-14A004H(S),CT15A8,3.24MH,1 AA26-00116A 1
SUB AZ660074 ASSY-SUB,PART;KS1A,MAIN(OPT),PAL,- AA98-00079A 1
AZ760060 SOLDER-WIRE;S63S-W3.0,S63S,D3,SN63/PB37 0202-000008 0.02567
AZ760061 SOLDER-WIRE FLUX;-,RS60S,D1.2,63SN/37PB 0202-000187 0.00028
AZ760063 SOLVENT;1M-1000,C3H70H,96,- 0204-000442 0.00863
AZ760064 FLUX;DF-98TVS,-,20%,- 0204-001024 0.00562
LR401S AZ362005 COIL-LINEARLITY;-,195uH,QIC1010,PI0.4,4. AA27-30001B 1
CR410S AZ162686 C-FILM,PPF;5.5nF,5%,1.6kV,TP,29x9.5x17,2 2303-001015 1
IC602 AZ660075 ASSY-H/S;-,SOUND,AA62-30175D,TDA8943,- HA96-00245B 1
SCR602 AZ760079 SCREW-TAPTITE;RH,+,2S,M3,L6,ZPC(YE),SWR HA60-020004 1
H/S602 AZ664157 HEAT SINK-PS;-,SECC,T1.0,-,33X15X30 FT-2 AA62-30175D 1
IC602 AZ661049 IC-AUDIO AMP;TDA8943,SIL,9P,850MIL,SINGL 1201-001740 1
CN703 AZ664021 CONNECTOR-HEADER;BOX,9P,1R,2.5MM,STRAIGH 3711-002648 1
CN601 AZ664017 CONNECTOR-HEADER;BOX,3P,1R,2.5MM,STRAIGH 3711-002642 1
LW01 AZ362012 COIL-HORIZ.WIDTH;-,180/480uH,SB-5S6202.6 AA27-40001M 1
CY801S AZ163009 C-CERAMIC,DISC;3.3nF,20%,400V,Y5U,TP,18x 2201-000446 1
IC201S AZ661050 IC-MOC;TDA9351PS/N2H6,OPM-802EW,64K,DIP, AA09-00194A 1
T801S AZ363059 TRANS-SWITCHING;,CS21S5T,160V~260V,PM2 P AA26-00134A 1
ASSY-CRT
* AZ660063 ASSY-CRT;A51EER31X,+400MG,-,-,-,21 HA94-50012A 1
AZ664137 CRT COLOR;A51EER33X,+380MG,2.07MH,21.0MH AA03-00279A 1
AZ362004 COIL-DEGAUSSING;-,21,13.5ohm,25T,L2380,E AA27-20003Z 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
!!!!!
!
!
!
!
!
!
!
!
!
!
!
!!!
!
Page 51
AZ760068 BAND-TIE;-,NYLON66 V2,-,-,L100,NTR,-,- AA63-10002A 1
AZ660064 ASSY-TBC,WIRE(P);DP,21,AA98-70014C,1P,TV AA98-70030A 1
AZ760026 CLAMP-D,COIL;20~22 INCH,NYLON 66,V2,-,NT AA65-30107A 4
ASSY ACCESSORY
* AZ660065 ASSY ACCESSORY;SPA,KS1A,TSB AA94-05179A 1
AZ664123 BATTERY-MN;1.5V,-,AA,14.5X50MM,- 4301-000120 2
AZ760074 TAPE-ACETATE;-,TO0.1,W20,L200MM HA02-030003 0.07
AZ760088 VINYL-BAG;HDPE,T0.025,L400,W240,-,W/O LO HA69-00276A 1
AZ664141 MANUAL USERS;,TSB,SPA,A/P 70(G),36P,145M HA68-01706A 1
AZ664142 MANUAL USERS;,TSB,ENG,A/P 70(G),36P,145M HA68-01704A 1
AZ664143 MANUAL USERS;,TSB,POR,A/P 70(G),36P,145M HA68-01708A 1
ASSY-CABINET,FRONT
* AZ760091 ASSY-CABINET,FRONT;-,21T01,-,-,-,- HA91-100032 1
AZ760032 STOPPER-PCB;5038.5368,HIPS HB,-,-,-,NTR, AA61-40007A 1
AZ760018 SPRING-CS;-,SUS304,-,-,OD6,N7,OD6,-,-,-, AA61-60003J 1
AZ760030 KNOB-POWER;21R01,HIPS,HB,BLK,D/GRAY HA64-00423B 1
AZ760059 RESIN-HIPS;HR-1360,BLK,476L,HB 0103-000287 0.0048
AZ760078 MARKING-PAINT;-,DARK GRAY,411/010007 HA02-060008 0.001
AZ760077 MARKING-PAINT;-,TPC180,WHITE HA02-060005 0.00001
AZ760071 RESIN;M.BATCH,WILSON 902-BK-60,BLK HA01-030001 0.00015
AZ760029 KNOB-CONTROL;21R01,HIPS,HB,BLK,D/GRAY HA64-00426B 1
AZ760059 RESIN-HIPS;HR-1360,BLK,476L,HB 0103-000287 0.0213
AZ760078 MARKING-PAINT;-,DARK GRAY,411/010007 HA02-060008 0.001
AZ760071 RESIN;M.BATCH,WILSON 902-BK-60,BLK HA01-030001 0.0005
AZ760033 WINDOW-REMOCON;-,21R01,-,PC,V0,VIOLET,- AA64-00428B 1
AZ760034 INDICATOR-LED;-,21R01,-,ACRYL,HB,CLR,- AA64-00430B 1
AZ760035 CLAMP-WIRE;ALL MODEL,NYLON 66,V2,-,NTR,1 AA65-30105A 1
AZ760082 CABINET-FRONT;-,21T01,-,HIPS,HB,DARK-GRA HA64-300072 1
AZ760081 CABINET-FRONT;-,21R01,6007-GY60,HIPS,HB, HA64-00566A 1
AZ760059 RESIN-HIPS;HR-1360,BLK,476L,HB 0103-000287 1.36906
AZ760071 RESIN;M.BATCH,WILSON 902-BK-60,BLK HA01-030001 0.02794
AZ760077 MARKING-PAINT;-,TPC180,WHITE HA02-060005 0.000012
AZ760078 MARKING-PAINT;-,DARK GRAY,411/010007 HA02-060008 0.091
CF+SPK AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S HA60-020003 2
CF+WR AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S HA60-020003 1
CF+KC AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S HA60-020003 1
AZ660066 ASSY-SPEAKER;-,16OHM,3W,-,3001-001039,70 HA96-00254A 1
AZ664037 SPEAKER;3W,16ohm,90dB,180Hz 3001-001039 1
AZ664110 LEAD CONNECTOR-ASSY;,3(2),67096-003,REC, AA39-20500C 1
ASSY-CABINET(COM)
* AZ760089 ASSY-CABINET(COM);-,21R01 HA90-00166A 1
CB+CF AZ760052 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK)K),S HA60-020003 4
PA+CF AZ760057 SCREW-TAPTITE;RWH,+,B,M4,L12,ZPC(YEL),SW HA60-020008 2
CRT+CF AZ760058 SCREW-ASSY;WC,HH,+,M5,L26.5,SWRCH18A,ZPC HA60-020010 4
AZ760009 CLAMP-CORD;PE,HB,BLK,-,-,- AA65-30008A 1
AZ760022 CABINET-BACK;-,21R01,-,HIPS,V0,BLK,-,- HA64-00572A 1
AZ760073 RESIN-HIPS;V0,BASF ES8550,BLK HA01-030018 1.52284
AZ760070 CLAMP-FBT;ABS,V0,BLK,-,-,- AA65-30009A 1
AZ760069 CLAMP-FBT;NYLON-66,V0,BLK,-,-,- AA65-30002A 2
AZ760050 CLAMP-WIRE;DONG-A,NYLON-66,-,-,-,DATL-60 AA65-30018A 5
AZ664145 LABEL-RATING;A/P 90G,T0.2,L55,W55,STANDA HA68-500025 1
AZ760075 TAPE-INK;WIDTH 55 MM HA02-030005 0.06
AZ760083 LABEL-QMS;-,T0.1,L135,W35,WHT,-,- HA68-500021 1
AZ760076 TAPE-INK; WIDTH 105 MM HA02-030006 0.23
ASSY-PCB,A/V FRONT
* AZ660076 ASSY-PCB,A/V FRONT;KS1A,(..73,..H1) HA95-900053 1
CN702 AZ664057 LEAD CONNECTOR-ASSY;,9P,YBNH025-09,67096 AA39-20112E 1
AZ760060 SOLDER-WIRE;S63S-W3.0,S63S,D3,SN63/PB37 0202-000008 0.00185
Electric Parts List
7-24
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
Page 52
Electric Parts List
7-25
AZ760061 SOLDER-WIRE FLUX;-,RS60S,D1.2,63SN/37PB 0202-000187 0.0001
AZ760064 FLUX;DF-98TVS,-,20%,- 0204-001024 0.00014
AZ760063 SOLVENT;1M-1000,C3H70H,96,- 0204-000442 0.00018
JE601 AZ664027 JACK-PHONE;1P(VER),3.4mm,AG,BLK,NO 3722-000143 1
JA702 AZ664030 JACK-RCA;2P,3.6MM,-,AG 3722-000506 1
AZ660077 ASSY-PCB,A/V FRONT(ACI);KS1A,(..73,..H1) HA99-200080 1
RE04 AZ361001 INDUCTOR-AXIAL;10UH,10%,2.5X3.4MM 2701-000114 1
RE01 AZ262470 R-CARBON(S);47OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-001153 1
RE02 AZ262470 R-CARBON(S);47OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-001153 1
CE07 AZ161332 C-CERAMIC,MLC-AXIAL;3.3nF,20%,16V,Y5P,TP 2202-000222 1
CE06 AZ161101 C-CERAMIC,MLC-AXIAL;100pF,10%,50V,Y5P,TP 2202-000121 1
CE01 AZ164027 C-AL;100uF,20%,16V,GP,TP,6.3x11,5 2401-001840 1
JE01 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
JE02 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
JE04 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
RE05 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
JE03 AZ664147 WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING) 3812-000219 1
PCB AZ660078 PCB-A/V FRONT;S15A,1L,FR-1,245x245x1.6T, AA41-10903B 1
AZ760062 TAPE-PAPER;#53131,T0.15,W6.0,L200000,YEL 0203-001123 0.44
LE01 AZ361006 INDUCTOR-AXIAL;22uH,10%,2.5x3.4mm 2701-000158 1
ASSY-PACKING
* AZ760090 ASSY-PACKING;21R01,- HA90-00175A 1
AZ760008 PIN-STAPLE;-,-,H18,33X17.8X2.4,-,AUTO AA60-40006A 12
AZ760087 PACKING-CASE;21R01,TSB,CB D-1,YEL,-,-,-, HA69-00209B 1
AZ760027 BAG-SHEET;HDPE+PE FOAM,-,W1050,H950,-,-, AA69-30032C 1
AZ760086 CUSHION-SET;21R01,PS,C=0.02,-,-,-,- HA69-00205B 1
AZ760072 RESIN-EPS;CHEIL SF-301V,WHT HA01-030006 0.155
AZ760085 LABEL-BOX;A/P (120G),T0.2,TSB,-,STANDARD HA68-500040 1
AZ760076 TAPE-INK; WIDTH 105 MM HA02-030006 0.23
AZ760084 LABEL-BOX;A/P (120G),T0.2,-,-,STANDARD HA68-500026 1
ASSY-SPEAKER
* AZ660066 ASSY-SPEAKER;-,16OHM,3W,-,3001-001039,70 HA96-00254A 1
AZ664037 SPEAKER;3W,16ohm,90dB,180Hz 3001-001039 1
AZ664110 LEAD CONNECTOR-ASSY;,3(2),67096-003,REC, AA39-20500C 1
ASSY-POWER,CORD
* AZ664124 ASSY-POWER,CORD;-,CP2/NO(4.0),H/C250,KKJ AA96-20122A 1
REMOCON
* AZ664156 REMOCON;,TM59,OZM521TO,29,TOSHIBA,G6671B AA59-00082D 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
!
Page 53
Electric Parts List
7-26
ASSY ACCESSORY
* AZ660080 ASSY ACCESSORY;GER,TXT,KS1A,TSB AA94-05178A 1
AZ664164 MANUAL USERS;,TSB,GER,A/P 70(G),36P,145M HA68-01705A 1
AZ664165 LABEL-XRAY;A/P 120(G),20,SCT11D,SCT13B HA68-500001 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-9 CB21T01D2GXTSB (CB21T01N2GXTSB and CB21T01D2GXTSB Dissimilar Parts)
ASSY-PCB,MAIN(OPT)
* AZ660083 ASSY-PCB,MAIN(OPT);CB,14T0,TSB,KS1A HA94-100845 1
PCB(AC AZ660084 ASSY-PCB,MAIN(ACI);CB,14R0-T0,TSB,KS1A HA99-100802 1
R501M AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
R502M AZ263001 R-COMPOSITION;1.8KOHM,5%,1/2W,AA,TP,3.7X 2002-001008 1
R814 AZ263052 R-FUSIBLE(S);3.3ohm,5%,2W,AG,TP,3.9x12mm 2008-001086 1
R815 AZ263052 R-FUSIBLE(S);3.3ohm,5%,2W,AG,TP,3.9x12mm 2008-001086 1
R421 AZ263078 R-FUSIBLE(S);1.5ohm,5%,2W,AG,TP,3.9x12mm 2008-001114 1
R406 AZ262220 R-CARBON(S);22OHM,5%,1/2W,AA,TP,2.4X6.4M 2001-000020 1
R302 AZ268022 R-METAL(S);1.2Kohm,1%,1/2W,AA,TP,2.4x6.4 2004-001369 1
R316 AZ268023 R-METAL OXIDE(S);220OHM,5%,2W,AF,TP,3.9X 2003-001018 1
R505 AZ268002 R-FUSIBLE(S);0.1OHM,10%,2W,AF,TP,3.9X10M 2008-000284 1
R601 AZ261562 R-CARBON;5.6KOHM,5%,1/8W,AA,TP,1.8X3.2M 2001-000812 1
V999S AZ664047 SOCKET-CRT;7P,22.5PI,12PI,SN,- 3704-001089 1
LR401S AZ362019 COIL-LINEARLITY;-,193uH,DR10X10 C:4.35,7 AA27-00053A 1
LW01 AZ362020 COIL-HORIZ.WIDTH;480UH,480UH,6X20,0.12X1 AA27-00184A 1
ASSY-CRT
* AZ660081 ASSY-CRT;A34EAC01X06,+400MG,14,PHIL,ITC HA94-500012 1
AZ664048 CRT-COLOR;A34EAC01X06,-,14inch,-,-,-,1.0 AA03-10023X 1
AZ664062 LEAD CONNECTOR-ASSY;,6(4)P,YFH806-06,350 AA39-20518A 1
AZ362008 COIL-DEGAUSSING;-,14,16.4ohm,75T,890mm,D AA27-20003U 1
AZ760068 BAND-TIE;-,NYLON66 V2,-,-,L100,NTR,-,- AA63-10002A 1
AZ660082 ASSY-TBC,WIRE(P);DP,14,AA98-70014A,1P,TV AA98-70032A 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-10 CB14T01N2GXTSB (CB21T01N2GXTSB and CB14T01N2GXTSB Dissimilar Parts)
ASSY ACCESSORY
* AZ660079 ASSY ACCESSORY;ITA,KS1A,TSB AA94-05181A 1
AZ664161 MANUAL USERS;,TSB,ITA,A/P 70(G),36P,145M HA68-01710A 1
AZ664162 DIAGRAM CIRCUIT;KS1A,A/P 70(G),16P,296MM HA68-01718A 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-8 CB21T01I2GXTSB (CB21T01N2GXTSB and CB21T01I2GXTSB Dissimilar Parts)
!
Page 54
Electric Parts List
7-27
ASSY-CABINET,FRONT
* AZ760101 ASSY-CABINET,FRONT;-,14T01,-,-,-,- HA91-100031 1
AZ760015 KNOB-POWER;14R01,HIPS,HB,BLK,D/GRAY HA64-00418B 1
AZ760014 KNOB-CONTROL;14R01,HIPS,HB,BLK,D/GRAY HA64-00427B 1
AZ760013 WINDOW-REMOCON;-,14R01,-,PC,V0,VIOLET,- AA64-00419B 1
AZ760020 INDICATOR-LED;-,14R01,-,ACRYL,HB,CLR,- AA64-00420B 1
AZ760096 CABINET-FRONT;-,14T01,-,HIPS,HB,DARK-GRA HA64-300071 1
AZ760095 CABINET-FRONT;-,14R01,902-BK-60,BLK HA64-00565A 1
AZ760094 BOSS-WING;-,HIPS,HB,NTR,-,- HA61-40010A 2
AZ760093 ADHESIVE-GEL;BLACK SOLVENT HA02-010005 0.00064
AZ760013 BOSS-CABINET;SPACE HA61-00109B 2
AZ760092 SPACER-COVER;PVC SHEET,T2.0,94V0,-,14R01 AA60-00022C 1
ASSY-CABINET(COM)
* AZ760099 ASSY-CABINET(COM);-,14R01 HA90-00165A 1
AZ760001 CABINET-BACK;-,14R01,-,HIPS,V0,BLK,-,- HA64-00571A 1
AZ760010 CLAMP-D,COIL;14 INCH,NYLON 66,V2,-,NTR,- AA65-30106A 2
ASSY-PACKING
* AZ760100 ASSY-PACKING;14R01,- HA90-00174A 1
AZ760011 BAG-SHEET;HDPE+PE FOAM,-,W800,H750,-,-,- AA69-30032A 1
AZ760098 PACKING-CASE;14R01,TSB,CB S-1,YEL,-, HA69-00212B 1
AZ760097 CUSHION-SET;14R01,PS,C=0.02,-,-,-,- HA69-00206B 1
ASSY-SPEAKER
* AZ660086 ASSY-SPEAKER;-,16OHM2.5W,000275,AA392050 AA96-10142A 1
AZ660061 LEAD CONNECTOR-ASSY;,3(2),67096-003,REC, AA39-20501A 1
AZ664068 SPEAKER;2.5W,16ohm,90dB,105Hz 3001-000275 1
AZ760060 SOLDER-WIRE;S63S-W3.0,S63S,D3,SN63/PB37 0202-000008 0.00185
AZ760061 SOLDER-WIRE FLUX;-,RS60S,D1.2,63SN/37PB 0202-000187 0.0001
AZ760064 FLUX;DF-98TVS,-,20%,- 0204-001024 0.00014
AZ760063 SOLVENT;1M-1000,C3H70H,96,- 0204-000442 0.00018
ASSY ACCESSORY
* AZ660085 ASSY ACCESSORY;SPAIN,TXT,KS1A,TSB AA94-05118A 1
AZ664049 TRANS-MATCHING;-,300ohm/75ohm,PAL,40-890 AA26-90001C 1
AZ664166 ANT-ROD;-,3S,720mm,ABS,UL/CSA,- AA42-00003A 1
AZ664164 MANUAL USERS;,TSB,GER,A/P 70(G),36P,145M HA68-01705A 1
AZ664167 MANUAL USERS;,TSB,FRA,A/P 70(G),36P,145M HA68-01709A 1
AZ664161 MANUAL USERS;,TSB,ITA,A/P 70(G),36P,145M HA68-01710A 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
Page 55
ASSY ACCESSORY
* AZ660087 ASSY ACCESSORY;ITA,KS1A,TSB AA94-05119A 1
AZ664162 DIAGRAM CIRCUIT;KS1A,A/P 70(G),16P,296MM HA68-01718A 1
Electric Parts List
7-28
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-11 CB14T01I2GXTSB (CB14T01N2GXTSB and CB14T01I2GXTSB Dissimilar Parts)
ASSY-PCB,MAIN(OPT)
* AZ660088 ASSY-PCB,MAIN(OPT);CB,14R0,TSB,KS1A HA94-100842 1
IC201S AZ661051 IC-MOC;TDA9381PS/N2H6,OPM-802EWN,64K,DIP AA09-00195A 1
ASSY ACCESSORY
* AZ664168 ASSY ACCESSORY;GER,KS1A,TSB AA94-05062A 1
AZ664165 LABEL-XRAY;A/P 120(G),20,SCT11D,SCT13B HA68-500001 1
ASSY-CABINET,FRONT
* AZ760047 ASSY-CABINET,FRONT;-,14R01,-,-,-,- HA91-00225A 1
AZ760012 CABINET-FRONT;-,14R01,-,HIPS,HB,DARK-GRA HA64-00568A 1
REMOCON
* AZ664169 REMOCON;,TM59,OZM521TO,25,TOSHIBA,KS1A, AA59-00082C 1
LOC NO PARTS NO Description & Specification REPLACEMENT NO Q’ty REMARKS
7-12 CB14T01D2GXTSB (CB14T01N2GXTSB and CB14T01D2GXTSB Dissimilar Parts)
!
Page 56
8. Block Diagram
8-1 KS1A
Block Diagram
8-1
TUNER -F/S
TECC-0949PG35A or
TEDE9-022A
I2C
Pre-AMP
PAP103T
2-3
I2C
E2PROM
24C08
VIF SAW
G1963M
K2971M
SYSTEM OPTION
S/W 1
23 24
11
IC -MCU
L PM -802X X X
33
45 -48
38
28
42
AUDIO
35
21/22
50-53
AUDIO
VIDEO
44
VERTICAL
AMP
L A7840
RGB AMP
TDA6107
Q
AUDIO A M P
AV INPUT
TDA8943/44
C
R
T
8R
2EA
*
16R 2E A
*
16R 1E A
*
8R 1E A
*
AC
H-OUT
TR
2SD 2499
CHIP ON CHIP
KA5Q0765R
VIDEO
S/W
AV OUT
R/G/B/FB
F BT ( 14",20",21")
FSV -14 A004H (S)
MULTI
REGULATOR
KA7632
180V TO CRT
±
16.5V TO Ver.
Heat TO CRT
3.3V TO MCU
5V TO TUN ER
8V TO MCU
13V TO SOUND
AMP
Page 57
9. Wiring Diagram
9-1 KS1A
Block Diagram
9-1
POWER
CORD
CRT PCB
1
R-OUT
CN602(4P)
CN603(3P)
L+ OUT
L- OUT
R+ OUT
R- OUT
CN501
34
2
B-OUT
G-OUT
GND
1
2
3
4
6
5
HEAT
GND
CUT OFF
9
78
180V
NC
CN701
SOUND L OUT
SOUND L IN
SOUND R OUT
SOUND R IN
FRONT AUDIO IN
GND
21 PIN AUDIO IN
GND
21 PIN VIDEO IN
GND
FRONT VIDEO IN
1
2
3
4
5
6
7
8
9
10
11
Page 58
Schematic Diagrams
10-1
10. Schematic Diagrams
10-1 ONECHIP & MICOM
TP11 TP12
TP09 TP10
TP03 TP04
TP01 TP02
TP07 TP08
TP05 TP06
TP13
Page 59
Schematic Diagrams
10-2
10-2 SOUND, EXT-A/V (SCART)
TP14
TP15
TP14
TP15
Page 60
Schematic Diagrams
10-3
10-3 POWER / CRT / VERTICAL / HORIZONTAL
TP21
TP20
TP17
TP16
TP19
TP18
Page 61
1-1, SHIBAURA 1-CHOME, MINATO-KU, TOKYO 105-8001, JAPAN
TOSHIBA CORPORATION
Loading...