READ TH IS M ANUAL BEF ORE USI NG T HE OUTBOARD MOTOR . FAILUR E TO FOLLOW T HE
!
INS TRUC TIO NS AND SA FET Y P REC AUTIO NS IN TH IS MANUAL CAN RE SULT IN SER IOU S
INJURY OR DEATH. KEEP THIS MANUAL IN A SAFE LOCATION FOR FUTURE REFERENCE.
Upon purchasing this product, be sure that the WARRANTY CARD is correctly and
completely filled out and mailed to the addressee noted there on. This WARRANTY
CARD identifies you as the legal owner of the product and serves as your warranty
registration.
TO
THE EXTENT PERMITTED BY APPLICABLE LAW, YOUR OUTBOARD MOTOR
WILL NOT BE COVERED BY THE APPLICABLE LIMITED WARRANTY, IF THIS
PROCEDURE IS NOT FOLLOWED.
PRE-DELIVERY CHECK
Be sure that the product has been checked by an authorized TOHATSU dealer before
you take delivery.
Limited Warranty
Please refer to the TOHATSU outboard motor Limited warranty provided to you with
this product, the terms and conditions of which, as amended from time to time, are
incorporated by reference into the manual.
Serial Number
In the space below, please record the outboard motor's serial number (indicated both
on the bottom cowl and on the cylinder block). The serial number will be needed in the
event of theft or to quickly identifying the outboard motor type.
Serial Number :
To You, Our Customer
Thank you for selecting a TOHATSU outboard motor. You are now the proud owner of
an excellent outboard motor that will service you for many years to come.
Th
is manual should be read in its entirety and the inspection and maintenance
procedures described later in this manual should be followed carefully. Should a
problem arise with the outboard motor, please follow the troubleshooting procedures
listed at the end of this manual. If the problem persists, contact an authorized
TOHATSU service shop or dealer.
We
hope
adventures.
you will enjoy your outboard motor and wish you good luck in your boating
Before installing, operating or otherwise handling your outboard motor, be sure
to thoroughly read and understand this Owner's Manual and carefully follow all of
the instructions. Of particular importance is information preceded by the words
"DANGER," "WARNING," "CAUTION," and "Note." Always pay special attention to
such information to ensure safe operation of the outboard motor at all times.
Failure to observe will result in severe personal injury or death, and possibly property damage.
Failure to observe could result in severe personal injury or death, or property damage.
Failure to observe could result in personal injury or property damage.
Note
This instruction provides special information to facilitate the use or maintenance of the
outboard motor or to clarify important points.
EMERGENCY STOP SWITCH
The Emergency Stop Switch will stall the outboard motor when the stop switch tether
is pulled off. This stop switch tether can be attached to the operator of the outboard
motor to minimize or prevent injuries from the propeller in case the operator falls
overboard.
We highly recommend use of the Emergency Stop Switch tether.
Accidental activation of the Emergency Stop Switch (such as the tether being pulled out
in heavy seas) could cause passengers to lose their balance and even fall overboard,
or it could result in loss of power in heavy seas, strong currents, or high winds. Loss of
control while mooring is another potential hazard.
To minimize accidental activation of the Emergency Stop Switch, the 500 mm (20 inch.)
stop switch tether is coiled and can extended to a full 1,300 mm (51 inch.).
!
SAFE OPERATION OF BOAT
As the operator/driver of the boat, you are responsible for the safety of those aboard
and those in other boat around yours, and for following local boating regulations. You
should be thoroughly knowledgeable on how to correctly operate the boat, outboard
motor, and accessories. To learn about the correct operation and maintenance of the
outboard motor, please read through this manual carefully.
I
t
is very difficult for a person standing or floating in the water to take evasive action
should he or she see a power boat heading in his /her direction, even at a slow speed.
Therefore, when your boat is in the immediate vicinity of people in the water, the
outboard motor should be shifted to neutral and shut off.
SERIOUS INJURY IS LIKELY IF A PERSON IN THE WATER MAKES CONTACT WITH
A MOVING BOAT, GEAR HOUSING, PROPELLER, OR ANY SOLID DEVICE RIGIDLY
ATTACHED TO A BOAT OR GEAR HOUSING.
SERVICING, REPLACEMENT PARTS & LUBRICANTS
We recommend that only an authorized service shop perform service or maintenance
on this outboard motor. Be sure to use genuine parts, genuine lubricants, or
recommended lubricants.
9
MAINTENANCE
As the owner of this outboard motor, you should be acquainted with correct
maintenance procedures. It is the operator's responsibility to perform all safety checks
and to ensure that all lubrication and maintenance instructions are complied with
for safe operation. Please comply with all instructions concerning lubrication and
maintenance. You should take the engine to an authorized dealer or service shop for
periodic inspection at the prescribed intervals.
Correct
chance of problems and limit overall operating expenses.
MOUNTING
Outboard motor mounting must be performed by trained service person(s) using lift or
hoist with sufficient capacity.
periodic
maintenance and proper care of this outboard motor will reduce the
Gear OilGenuine Gear Oil or API GL5, SAE #80 to #90, approx. 320mL
Fuel Tank Capacity
L (US gal)
Gear Reduction Ratio2.08 (13 : 27)
S mm (in)996 (39.2)
L mm (in)1,123 (44.2)
UL mm (in))1,250 (49.2)
S mm (in)435 (17.2)
L mm (in)562 (22.2)
UL mm (in))689 (27.1)
S kg (lb)26 (57)29 (64)28.5 (63)26 (57)29 (64)28.5 (63)
L kg (lb)27 (60)30 (66)29.5 (65)27 (60)30 (66)29.5 (65)
UL kg (lb)28 (62)31 (68)30.5 (67)28 (62)31 (68)30.5 (67)
Forward Gear rpm750
Neutral Gear rpm950
6B MF 8B MF8B EF8B EP 9.8B MF 9.8B EF 9.8B EP
793 (31.2)505 (19.9)793 (31.2)505 (19.9)
320 (12.6)275 (10.8)320 (12.6)275 (10.8)
rpm4,500 – 5,5005,000 – 6,000
169 (10.3)
Electric starter motor* Manual Electric starter motor*
12 (3.17)
* : with manual
Specifications subject to change without notice.
Remark :
NAMES OF PARTS
6
1
2
3
4
5
7
8
9
0
q
w
e
r
t
y
u
i
o
p
a
s
f
d
g
h
j
k
6B MF, 8B MF, 9.8B MF
NAMES OF PARTS
11
2
1
Tilt Handle
2
Top Cowl
3
Bottom Cowl
4
Cooling Water Check Port
5
Tilt Stopper
6
Drive Shaft Housing
7
Water Plug
8
Anti Ventilation Plate
9
Anode / Trim Tab
0
Propeller
q
Starter Handle
w
Shift Lever
e
Throttle Grip
r
Clamp Screw
t
Clamp Bracket
y
Thrust Rod
u
Oil Plug (Upper)
i
Water Inlet
o
Oil Plug (Lower)
p
Stop Switch
a
Choke Knob
s
Fuel Connector
d
Primer Bulb
f
Fuel Tank
g
Fuel Tank Cap
h
Air Vent Screw
j
Fuel Connector
k
Fuel Pick up Elbow
2
6
1
2
3
4
5
7
8
9
0
q
w
e
r
t
y
u
i
o
a
sp
d
f
h
g
j
k
l
;
NAMES OF PARTS
12
8B EF, 9.8B EF
1
Tilt Handle
2
Top Cowl
3
Bottom Cowl
4
Cooling Water Check Port
5
Tilt Stopper
6
Drive Shaft Housing
7
Water Plug
8
Anti Ventilation Plate
9
Anode / Trim Tab
0
Propeller
q
Starter Handle
w
Shift Lever
e
Throttle Grip
r
Clamp Screw
t
Clamp Bracket
y
Thrust Rod
u
Oil Plug (Upper)
i
Water Inlet
o
Oil Plug (Lower)
p
Choke Knob
a
Stop Switch
s
Main Switch
d
Fuel Connector
f
Battery Cord
g
Primer Bulb
h
Fuel Tank
j
Fuel Tank Cap
k
Air Vent Screw
l
Fuel Connector
;
Fuel Pick up Elbow
8B EP, 9.8B EP
k
l
;
z
6
1
2
3
4
5
7
8
9
0
q
w
e
r
t
y
u
i
o
p
a
d
s
f
g
h
j
NAMES OF PARTS
13
2
1
Tilt Handle
2
Top Cowl
3
Bottom Cowl
4
Cooling Water Check Port
5
Tilt Stopper
6
Drive Shaft Housing
7
Water Plug
8
Anti Ventilation Plate
9
Anode / Trim Tab
0
Propeller
q
Starter Handle
w
Shift Lever
e
Clamp Screw
r
Clamp Bracket
t
Thrust Rod
y
Oil Plug (Upper)
u
Water Inlet
i
Oil Plug (Lower)
o
Choke Knob
p
Fuel Connector
a
Battery Cord
s
Primer Bulb
d
Fuel Tank
f
Fuel Tank Cap
g
Air Vent Screw
h
Fuel Connector
j
Fuel Pick up Elbow
k
Remote Control
l
Main Switch
;
Stop Switch
z
Cord Assembly
!
Boat Transom
Center of Boat
Bottom of hull
Anti Ventilation Plate
30-50 mm
(1.2-2 in)
Clamp screw
14
INSTALLATION
3
1.
Mounting the outboard motor on boat
Most boats are rated and certified
in terms of their maximum allowable
horsepower, as shown on the boat’
s certification plate. Do not equip your
boat with an outboard motor that
exceeds this limit. If in doubt, contact
your dealer.
Do not operate the outboard motor until
it has been securely mounted on the
boat in accordance with the instructions
below.
Installation
Single-engine Installation
■
Set engine at center of boat.
Transom matching
1
Be sure that the anti ventilation plate
of the outboard motor is 30-50mm
(1.2-2 in) below the bottom of hull.
f the above condition cannot be
I
met due to the shape of the bottom
of your boat, please consult your
authorized dealer.
2
To
boat, tighten the clamp screws by
turning their handles.
ls o , us e the bo lt s t o se c ur e
A
the outboard motor brackets on
transom board.
ecure the outboard motor with a
S
rope to prevent loss overboard.
the outboard motor to the
attach
Note
A rope is not included in the standard
accessories.
INSTALLATION
!
!
!
15
• Before beginning the running test,
check that the boat with maximum
capacity loading floats on the
water in a proper attitude. Check
the position of water surface on
the driveshaft housing. If the water
surface is near the bottom cowling,
in high waves, water may enter the
engine cylinders.
• Incorrect outboard motor mounting
height or existence of under water
object (s), such as hull bottom
design, bottom surface conditions
or underwater accessories,
can cause water spray possibly
reaching the engine through an
opening of the bottom cowling
during cruising. Exposing the
engine to such conditions for
extended periods can lead to
severe engine damage.
Mounting bolts should be installed with
the bolt head at inside surface of the
transom. Mounting bolts installed with
the threaded end at the inside surface
of the transom can cause personal
injury.
•
Mounting the outboard motor without
following this manual can lead to
unsafe conditions such as poor
maneuverability, lack of control or
fire.
•
Loose clamp screws and/or mounting
bolts can lead to the release or
displacement of the outboard motor,
possibly resulting in lost of control and/
or serious personal injury. Be sure that
fasteners are tightened to the specified
torque (30 Nm (3.0kgf) 13ft·lb). Check
the fasteners for tightness from time to
time.
•
Be sure to use outboard mounting
fasteners included in the outboard
motor package or their equivalents
in terms of size, material, quality and
strength.
Tighten fasteners to the specified
torque (30 Nm (3.0kgf) 13ft·lb). Test
cruise to check if fasteners are
tightened securely.
•
Outboard motor mounting must
be performed by trained service
person(s) using lift or hoist with
sufficient capacity.
3
Notes
1. Apply sealing agent, such as
silicone sealed between the bolts
and the transom board holes before
tightening the bolts.
2. Be sure to tighten the mounting bolt
nuts to the specified torque.
(30 Nm (3.0kgf)13ft · lb)
3
Ball
holder
Holder
cap
Spring
Washer
Nut
Cable outer
groove
Throttle cable
Spring
Nut
Cable outer
groove
Shift cableSpring pin
Lock pin
Sleeve B guide
INSTALLATION
16
2.
Installing the remote control devices
It is recommended that you consult
wi t h yo u r au t h o r i z e d de a l er fo r
installation adjustment of the remote
control device.
Installation of the Remote Control
■
Cables (Box side) :
F
oll o w th e inst r u ct i o n ma n ua l
provided with the remote control.
Installation of the Remote Control
■
on your boat :
F
oll o w th e inst r u ct i o n ma n ua l
provided with the remote control.
Installation of the Remote Control
■
Cable (engine side) and the Cord
Assembly (Wiring Harness) :
1
F
tting of holder cap and sleeve B
i
guide
Th
rottle side......Fit the holder cap
to the end of the cable and fix it
by the nut.
Shift
side......Fit the sleeve B guide
to the end of the cable and fix it
by the nut.
2
tting of Remote Control Cable to
Fi
Engine
Th
rot tl e si de ......Set the throttle
cable to the cable clip and then
connect the holder cap to the ball
joint of throttle lever.
S
h
ift side......Set the shift cable to
the cable clip and then insert the
lock pin at the shift lever fitting
hole and turn it 90° to lock it.
INSTALLATION
Shlft Lever
Sleeve B gulde:
fit it to remove
control cable and
flt it to shift lever
Holder Cap:
fit it to remove
control cable and
flt it to ball joint
Cable
clip
Shlft cable
To C.D. unlt
Connect it
to lead wlre
of remote
controf box
Cable outer groove
Steerfng
Hook plate
Remote control stop cord
(excluded from fining pans)
Throttle lever
!
17
3
Put the control lever in the Neutral
position and the free accel lever in the
fully closed position.
Length of Remote Control Cable
depends on a size of a boat.
Be careful not to loop remote control
cables to diameter of 406 mm (16
inches) or less.
Note
Note
Confirm whether the engine side shift
is in gear when shifting the control
lever of the remote control to its first
position in Forward or Reverse (about
32°) and whether the throttle of the
carburetor is fully open when shifting
the lever further.
Confirm whether the carburetor’s
throttle is fully closed when the control
lever is shifted to the Neutral position.
If it is not, adjust the position of the ball
holder.
Note
3
Choke
solenoid
Starter
solenoid
Clamp
Clamp
Clamp
Rectifier
Single remote
Control box
(RC 5C)
Cord assembly
Air silencer
Battery Cord
Fuse wire
Blue
Blue
G
G
G
R
R
B
B
B
!
INSTALLATION
18
3
Connecting the Cord Assembly (Wiring Harness)
P
ass the cord assembly from the remote control through the hole in the bottom
cowl and connect the electric terminals and then clamp the cord assembly
according to the drawing below.
Do not disconnect the cord assembly
when the outboard motor is in
operation or you will lose control of the
outboard motor.
3. Installing the battery
!
!
!
!
INSTALLATION
19
1
Place the battery box in a convenient
position away from possible water
spray. Securely fasten both the box
and the battery so they do not shake
loose.
Note
Minimum recommended battery :
12V, 40AH (465 Marine Cranking
Amps (MCA) or 350 Cold Cranking
Amps (CCA)) Specifications and
features of batteries vary among
the manufacturers. Consult the
manufacturer for details.
Batter y electrolyte contains sulfuric
acid and thus is hazardous, causing
a burn if it comes in contact with your
skin, or poisonous if swallowed.
KEEP BATTERY AND ELECTROLYTE
AWAY FROM REACH OF CHILDREN
When handling the battery, be sure to:
• Read all warnings shown on the
batter y case
• Prevent electroly te from coming in
contact with any part of your body.
Contact can cause serious burn or,
if it comes in contact with your eye,
loss of sight. Use safety glasses
and rubber gloves.
In case battery electrolyte comes in
contact with:
• Skin, flush thoroughly with water.
• Eye, flush thoroughly with water,
and then seek immediate medical
treatment.
In case battery electrolyte is
swallowed:
• Seek immediate medical treatment.
Batter y generates explosive hydrogen
gas. Be sure to:
• Charge the battery in a wellventilated place.
• Place the battery away from any
source of fire, sparks and open
flames such as burners or welding
equipment.
• Do not smoke when handling the
batter y.
• Do not smoke near the battery when
the battery is charging.
• Make sure that the battery cords do
not get stuck between the outboard
motor and boat when turning, etc.
• The star ter motor may fail to
operate if the cords are incorrectly
connected.
• Be sure to correctly connect the (+)
and (−) cords. If not, the charging
system will be damaged.
• Do not disconnect the battery
cords from battery while the engine
is operating, the electrical par ts
could be damaged.
• Always use a fully charged battery.
Do not use a battery that is not
recommended. Use of a battery
not recommended can lead to poor
performance of, and/or damage to, the
electrical system.
3
3
Battery cable
(black)
Battery cable
(red)
INSTALLATION
20
2
Connect the positive lead (+) to the
positive terminal (+) of the battery,
and then connect the negative lead
(−). When disconnecting the battery
always remove the negative lead (−)
first. After connecting the positive
terminal (+), securely place a cap on
it to prevent short circuits.
Loading...
+ 44 hidden pages
You need points to download manuals.
1 point = 1 manual.
You can buy points or you can get point for every manual you upload.