SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
Material name
:
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Material number
:
000000000001042705
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW
Atlanta, GA 30318
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
Liquefied gas
Colour
colourless
Odour
characteristic
Flammable aerosols
:
Category 1
Gases under pressure
:
Liquefied gas
Eye irritation
:
Category 2A
Specific target organ toxicity single exposure
:
Category 3 (Central nervous system)
Hazard pictograms
:
Signal word
:
Danger
Hazard statements
:
H222 Extremely flammable aerosol.
H280 Contains gas under pressure; may explode if heated.
H319 Causes serious eye irritation.
H336 May cause drowsiness or dizziness.
Precautionary statements
:
Prevention:
P210 Keep away from heat, hot surfaces, sparks, open flames
and other ignition sources. No smoking.
P211 Do not spray on an open flame or other ignition source.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS Label element
1 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
P251 Pressurized container: Do not pierce or burn, even after
use.
P261 Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray.
P264 Wash skin thoroughly after handling.
P271 Use only outdoors or in a well-ventilated area.
P280 Wear eye protection/ face protection.
Response:
P304 + P340 + P312 IF INHALED: Remove victim to fresh air
and keep at rest in a position comfortable for breathing. Call a
POISON CENTER or doctor/ physician if you feel unwell.
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing.
P337 + P313 If eye irritation persists: Get medical advice/
attention.
Storage:
P405 Store locked up.
P410 + P412 Protect from sunlight. Do not expose to
temperatures exceeding 50 °C/ 122 °F.
P403 + P235 Store in a well-ventilated place. Keep cool.
Disposal:
P501 Dispose of contents/container in accordance with local
regulation.
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Substance / Mixture
:
Mixture
Chemical Name
CAS-No.
Concentration [%]
acetone
67-64-1
>= 30 - < 50
2-(2-ethoxyethoxy)ethanol
111-90-0
>= 20 - < 30
propane
74-98-6
>= 20 - < 30
Naphtha (petroleum), light alkylate
64741-66-8
>= 5 - < 10
Potential Health Effects
Carcinogenicity:
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
2 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
General advice
:
Move out of dangerous area.
Show this safety data sheet to the doctor in attendance.
Do not leave the victim unattended.
If inhaled
:
Consult a physician after significant exposure.
If unconscious place in recovery position and seek medical
advice.
In case of skin contact
:
If skin irritation persists, call a physician.
Wash off immediately with plenty of water for at least 15
minutes.
If on clothes, remove clothes.
Wash contaminated clothing before re-use.
In case of eye contact
:
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
In case of contact, immediately flush eyes with plenty of water
for at least 15 minutes.
If swallowed
:
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Suitable extinguishing media
:
Alcohol-resistant foam
Carbon dioxide (CO2)
Dry chemical
Water spray jet
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
For safety reasons in case of fire, cans should be stored
separately in closed containments.
Use a water spray to cool fully closed containers.
Special protective equipment
:
Wear self-contained breathing apparatus for firefighting if
SECTION 4. FIRST AID MEASURES
SECTION 5. FIREFIGHTING MEASURES
3 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
for firefighters
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Ensure adequate ventilation.
Remove all sources of ignition.
Evacuate personnel to safe areas.
Beware of vapours accumulating to form explosive
concentrations. Vapours can accumulate in low areas.
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Sweep up or vacuum up spillage and collect in suitable
container for disposal.
Advice on safe handling
:
Avoid exposure - obtain special instructions before use.
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Take precautionary measures against static discharges.
Provide sufficient air exchange and/or exhaust in work rooms.
Dispose of rinse water in accordance with local and national
regulations.
Do not breathe vapours or spray mist.
Always replace cap after use.
Conditions for safe storage
:
BEWARE: Aerosol is pressurized. Keep away from direct sun
exposure and temperatures over 50 °C. Do not open by force
or throw into fire even after use. Do not spray on flames or
red-hot objects.
No smoking.
Keep in a dry, cool and well-ventilated place.
Observe label precautions.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
Store and keep away from, oxidizing agents and acids.
Components
CAS-No.
Value type
Control
Basis
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
4 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
(Form of
exposure)
parameters /
Permissible
concentration
acetone
67-64-1
TWA
500 ppm
ACGIH
STEL
750 ppm
ACGIH
TWA
250 ppm
590 mg/m3
NIOSH REL
TWA
1,000 ppm
2,400 mg/m3
OSHA Z-1
TWA
750 ppm
1,800 mg/m3
OSHA P0
STEL
1,000 ppm
2,400 mg/m3
OSHA P0
2-(2-ethoxyethoxy)ethanol
111-90-0
TWA
25 ppm
US WEEL
propane
74-98-6
TWA
1,000 ppm
ACGIH
TWA
1,000 ppm
1,800 mg/m3
NIOSH REL
TWA
1,000 ppm
1,800 mg/m3
OSHA Z-1
TWA
1,000 ppm
1,800 mg/m3
OSHA P0
Component
CAS-No.
Control
parameters
Biological
specimen
Sampling
time
Permissible
concentration
Basis
2-PROPANONE
67-64-1
Acetone
Urine
End of
shift (As
soon as
possible
after
exposure
ceases)
50 mg/l
ACGIH BEI
Respiratory protection
:
Use respiratory protection unless adequate local exhaust
ventilation is provided or exposure assessment demonstrates
that exposures are within recommended exposure guidelines.
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Ensure that eyewash stations and safety showers are close to
the workstation location.
Safety glasses
Skin and body protection
:
impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
Biological occupational exposure limits
Personal protective equipment
Hand protection
5 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
Appearance
:
Liquefied gas
Colour
:
colourless
Odour
:
characteristic
Odour Threshold
:
no data available
pH : not applicable
Melting point/freezing point
:
no data available
Boiling point
:
no data available
Flash point
:
< -6.6 °C
Evaporation rate
:
no data available
Flammability (solid, gas)
:
Extremely flammable aerosol.
Upper explosion limit
:
no data available
Lower explosion limit
:
no data available
Vapour pressure
:
no data available
Relative vapour density
:
no data available
Density
:
no data available
Water solubility
:
partly soluble
Partition coefficient: noctanol/water
:
no data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
no data available
Viscosity, kinematic
:
no data available
Heat of combustion
:
36.86 kJ/g
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Vapours may form explosive mixture with air.
Conditions to avoid
:
Heat, flames and sparks.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
6 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
Extremes of temperature and direct sunlight.
Incompatible materials
:
Oxidizing agents
Acids
Bases
Hazardous decomposition
products
:
Carbon monoxide
Carbon dioxide (CO2)
Remarks: May cause skin irritation and/or dermatitis.
Remarks: Eye irritation
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
no data available
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
no data available
Germ cell mutagenicity
no data available
Carcinogenicity
no data available
Reproductive toxicity
no data available
acetone:
2-(2-ethoxyethoxy)ethanol:
propane:
Naphtha (petroleum), light alkylate:
STOT - single exposure
no data available
STOT - repeated exposure
no data available
Aspiration toxicity
no data available
Further information
Product:
7 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
Remarks: Symptoms of overexposure may be headache, dizziness, tiredness, nausea
and vomiting., Concentrations substantially above the TLV value may cause narcotic
effects., Solvents may degrease the skin.
Partition coefficient: noctanol/water
:
Remarks: no data available
Partition coefficient: noctanol/water
:
Pow: 0.54
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
An environmental hazard cannot be excluded in the
event of unprofessional handling or disposal., Harmful to
aquatic life with long lasting effects.
Waste from residues
:
The product should not be allowed to enter drains, water
courses or the soil.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Dispose of in accordance with local regulations.
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
no data available
Persistence and degradability
no data available
Bioaccumulative potential
Product:
Components:
2-(2-ethoxyethoxy)ethanol :
Mobility in soil
no data available
Other adverse effects
no data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
8 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Do not burn, or use a cutting torch on, the empty drum.
Transportation Regulation: 49 CFR (USA):
This material is not classified.
Transportation Regulation: IMDG (Vessel):
This material is not classified.
Transportation Regulation: IATA (Cargo Air):
This material is not classified.
Transportation Regulation: IATA (Passenger Air):
This material is not classified.
Transportation Regulation: TDG (Canada):
This material is not classified.
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
acetone
67-64-1
5000
*
SARA 311/312 Hazards
:
Fire Hazard
Sudden Release of Pressure Hazard
Acute Health Hazard
SARA 302
:
SARA 302: No chemicals in this material are subject to the
reporting requirements of SARA Title III, Section 302.
SARA 313
:
SARA 313: This material does not contain any chemical
components with known CAS numbers that exceed the
threshold (De Minimis) reporting levels established by SARA
Title III, Section 313.
SECTION 14. TRANSPORT INFORMATION
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
*: Calculated RQ exceeds reasonably attainable upper limit.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
9 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
California Prop 65
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
TSCA
On TSCA Inventory
DSL
This product contains one or several components that are not on the
Canadian DSL nor NDSL.
AICS
Not in compliance with the inventory
NZIoC
Not in compliance with the inventory
PICCS
Not in compliance with the inventory
IECSC
Not in compliance with the inventory
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Danger:
Hazard statements
:
Extremely flammable aerosol. Contains gas under pressure; may explode if heated.
Causes serious eye irritation. May cause drowsiness or dizziness.
Precautionary statements
:
Prevention: Keep away from heat, hot surfaces, sparks, open flames and other ignition
sources. No smoking. Do not spray on an open flame or other ignition source.
Pressurized container: Do not pierce or burn, even after use. Avoid breathing dust/
fume/ gas/ mist/ vapours/ spray. Wash skin thoroughly after handling. Use only
outdoors or in a well-ventilated area. Wear eye protection/ face protection.
Response: IF INHALED: Remove victim to fresh air and keep at rest in a position
comfortable for breathing. Call a POISON CENTER or doctor/ physician if you feel
Flammability
Health
Instability
3
4
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
4
2
3
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
The components of this product are reported in the following inventories:
Inventory Acronym and Validity Area Legend:
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL
(Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TSCA (USA)
SECTION 16. OTHER INFORMATION
Further information
OSHA GHS Label Information:
10 / 11
SAFETY DATA SHEET
A07734 TM BAYBERRY 30% 12/CS 12n5.3
Version 1.0
Revision Date 02/23/2015
Print Date 02/15/2017
unwell. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact
lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical
advice/ attention.
Storage: Store locked up. Protect from sunlight. Do not expose to temperatures
exceeding 50 °C/ 122 °F. Store in a w ell-ventilated place. Keep cool.
Disposal: Dispose of contents/container in accordance with local regulation.
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Misty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, F C
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
11 / 11
Loading...