Page 1
ACCESS FLOOR MODULE
INSTALLATION INSTRUCTIONS
CATALOG NUMBERS
AFM-2, AFM-4, AFM-6, AFM-6S2, AFM-6V, AFM-8 and AFM8-ABN
WARNING
ELECTRICAL HAZARD!
TURN POWER OFF BEFORE WORK!
USING THE AFM COVER
1) To lift the lid on the Access Floor Module (AFM), insert
screwdriver into two slots and pry upward (see Figure 2).
2) To raise Cord Door, use thumbs or ngers to press the
two inside "locking" tabs and rotate the Door open. See
note on underside of Lid (see Figure 3).
3) Close Lid. Keep Cord Door open when closing Lid. Route
electrical and data cords out through opened Cord Door
(see Figure 4).
4) When AFM is used in high trafc area, inspect the AFM
cover and gasket surface routinely to see if they are dirty.
When dirty, clean with a mild detergent and water.
Condition the gaskets after cleaning. (See Installation
Note 7 for gasket conditioning instructions.)
FIGURE 1
AFM-4
Shown
AFM Lid
OPTIONAL
Metallic 668 CST Cover
Series for use with
AFM-8 only.
INSTALLATION
AFM-2: 7-1/8" x 4-18"
AFM-4: 7-15/16" x 7-15/16"
AFM-6: 7-15/16" x 10"
AFM-6S2: 7-15/16" x 10"
AFM-8: 9-5/8" x 9-5/8"
AFM-8-ABN: 9-3/4" x 9-3/4 (maximum)
1) Cut hole in raised panel for oor box per sizes above.
2) Install AFH Bracket on raised oor panel as shown to
match the set screws used to hold the box in place. Place
bracket in center of cutout opening (see Figure 5).
3) Hold bracket tightly against the side and fold legs around
edge to engage bottom of oor panel.
4) Sealing Carpet Flange: Before lowering AFM Box into
hole on wood or tile oors, apply caulk or sealant to the
underside of Carpet Flange to block water entry
(see Figure 5).
5) Lower AFM into cut hole and attach conduit as required
to meet wiring needs and per National Electrical Code
requirements.
6) Install 1-1/8" long screws to engage bracket as shown
(see Figure 5).
7) Gasket Conditioning: At initial installation apply a light
coating of petroleum jelly to gaskets on Cord Door and
Carpet Flange to keep gaskets supple and prevent
water entry.
8) Carpet or Vinyl Tile may be cut to t top of metal plate
and secure with adhesive (see Figure 4).
Carpet
Flange
FIGURE 2
FIGURE 3
Carpet or Tile
may be cut to
t on top of
Metal Plate
FIGURE 4
Cord Door
Pry & Lift Upward
to Open
Cord Door Raised
Electrical or
Data Cord
TA02113 D Page 1 of 2
Page 2
ACTIVATION
Step 1: Open cover to access inside of box.
Step 2: Attach device(s) as required.
Step 3: Install all wiring and devices in accordance with
National Electrical code and all local codes.
Raised Floor Panel
Apply Caulk or
Sealant under
Flange on Wood
or Tile Floors
NOTE: One Duplex Panel supplied with AFM-2, AFM-4, AFM-6, two
Duplex Panels supplied with AFM-6S2. Order additional power and
Data Panels separately.
FIGURE 5
Access Floor Module
AFH Bracket Installed
with Legs bent around
Raised Floor
Set Screw Engaged
in "V" Notch
of Bracket
WARRANTY: Thomas & Betts sells this product with the understanding that the user will perform all necessary tests to determine the suitability of this product
for the user's intended application. Thomas & Betts warrants that this product will be free from defects in materials and workmanship for a period of two (2)
years following the date of purchase. Upon prompt notication of any warranted defect, Thomas & Betts will, at its option, repair or replace the defective product
or refund the purchase price. Proof of purchase is required. Misuse or unauthorized modication of the product voids all warranties.
Limitations and Exclusions: THE ABOVE WARRANTY IS THE SOLE WARRANTY CONCERNING THIS PRODUCT, AND IS IN LIEU OF ALL OTHER
WARRANTIES EXPRESS OR IMPLIED, INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE, WHICH ARE SPECIFICALLY DISCLAIMED. LIABILITY FOR BREACH OF THE ABOVE WARRANTY IS LIMITED TO COST OF
REPAIR OR REPLACEMENT OF THE PRODUCT, AND UNDER NO CIRCUMSTANCES WILL THOMAS & BETTS BE LIABLE FOR ANY INDIRECT,
SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES.
Thomas & Betts Corporation
Memphis, Tennessee 38125
© 2012 Thomas & Betts. All Rights Reserved.
www.tnb.com
TA02113 D Page 2 of 2
Loading...