Thermador CGBD36RX, CGBD48RSBX, CGBD48RX Installation Instructions
Installation Instructions
for
Thermador Char Glo® Outdoor Barbecues
Models:
CGBD30RX • CGBD36RX
CGBD48RSBX • CGBD48RX
!
▲
CGBD30RX
Installer: Please leave these instructions with the unit for the owner.
Owner: Please retain these instructions for future reference.
WARNING: If the information in this manual is not followed exactly, a fire or
explosion may result causing property damage, personal injury or death.
CGBD36RX
CGBD48RSBX
!
▲
AVERTISSEMENT: Si l’information dans ce manuel n’est pas suivie exactement,
une incendie ou une explosion peut résulter, entrainant des dégats matériels, des
blessures ou la mort.
Inside Front Cover – Blank
Contents
SECTION 1: Safety Information ................................................................. 2
SECTION 2: Gas Requirements................................................................... 3
Natural Gas Requirements .......................................................................... 3
Propane Gas Requirements ......................................................................... 3
Gas Consumption .......................................................................................... 3
Propane Hook-up .......................................................................................... 3
SECTION 3: Site Preparation...................................................................... 5
Built-In Installations ....................................................................................... 5
Cabinet Preparation ...................................................................................... 5
SECTION 4: Electrical Cautions .................................................................. 7
Electrical Requirements ................................................................................ 7
Grounding Instructions................................................................................. 7
SECTION 5: Unpacking, Moving and Placing the Unit ....................8 - 10
Locating your Char Glo® Barbecue ........................................................... 8
Liquid Propane to Natural Gas Conversion .......................................... 10
Gas and Electrical Hook-up ....................................................................... 11
Side Panel Installation.................................................................................. 11
SECTION 6: Test and Adjustment.............................................................. 12
Checking for Leaks ......................................................................................12
Burner Air Adjustment ................................................................................ 12
Installer Checklist......................................................................................... 12
Installation...................................................................................................... 12
Gas Supply ..................................................................................................... 12
Electrical .........................................................................................................12
Page1
SECTION 1: SAFETY INFORMATION
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, immediately call your gas
supplier or your fire department.
FOR YOUR SAFETY
1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of
this or any other appliance.
2. An LP cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliance.
AVERTISSEMENT
S’il y a une odeur de gaz:
1. Coupez l’admission de gaz de l’appariel.
2. Ènteindre toute flamme nue.
3. Ouvrir le couvercle.
4. Si l’odeur peraiste, appeler immediatement
votre compagnie de gaz ou votre departement
des incendies.
AVERTISSEMENT
1. Ne pas entreposer ni utiliser de l‘essence ni
d’autres vapeurs ou liquides inflammables dans
le voisinage de l’appareil, ni de tout autre
appareil.
2. Une bouteille de propane qui n’est pas
raccordée en vue de son utilisation, ne doit
pas etre entreposée dans le voisinage de cet
appareil ou de tout autre appareil.
Installation and service must be performed by a qualified installer,
service agency or the gas supplier.
TESTED IN ACCORDANCE WITH ANSI Z21.58 – 1995, ANSI Z21.58a – 1998 STANDARD FOR
OUTDOOR COOKING GAS APPLIANCES, AND CAN/CGA 1.6 – M95, CGA 1.6a – M98,
STANDARD FOR OUTDOOR COOKING GAS APPLIANCES.
This unit is for outdoor use only in a well-ventilated area. Not to be
used in a building, garage or any other enclosed area.
Check your local building codes for the proper method of installation. In the absence of local codes this
unit should be installed in accordance with the National Fuel Gas Code No. Z223.1 Current Issue and
National Electrical Code ANSI/NFPA No. 70 Current Issue or the CAN/CGA – B149.1 Natural Gas
Installation Code or CAN/CGA - B149.2 Propane Installation Code and C22.1 Canadian Electrical Code
Part1.
Page 2
SECTION 2: GAS REQUIREMENTS
NATURAL GAS REQUIREMENTS -
Inlet Connection: 1/2" NP with 3/8" NPT reducer adapter.
Supply Pressure: 6" to 14" W.C.
Manifold Pressure: 5" W.C.
PROPANE GAS REQUIREMENTS -
Inlet Connection: 1/2" NP with 3/8" NPT reducer adapter.
Supply Pressure: 11" to 14" W.C.
Manifold Pressure: 10" W.C.
IMPORTANT: A manual gas shut off valve must be installed external to the appliance, in
!
▲
!
▲
a location accessible with the unit installed in the enclosure. Make sure the valve is turned
off prior to connecting the appliance.
IMPORTANT: Un robinet manuel d'isolement doit étre installé à l’extérieur de l’appareil, dans
un emplacement accessible avec l’unité installée dans la module. Assurez-vous que le robinet est
fermé avant de brancher l’appareil.
FIGURE 1 – PROPANE HOOK-UP
➞
➚
Coupling 1/2" NPT fitting
threading compound on
these threads must be
resistant to LP gas
CGBD30RX Shown CGBD30RX Shown
L.P. Regulator hose
assembly 10" W.C.
➚
L.P. Tank
(Type 1)
Type 1 Regulator
➞
➞
Bottom of
unit
Regulator Adapter
➞
Main
➞
Valve
FIGURE 2 – NATURAL GAS HOOK-UP
Regulator 5.0" W.C.
➞
➚
Threading compound must
be resistant to L.P. gas
1/2" NPT
Close Nipple
➞
➞
Adapter 1/2" NPT
to 3/8" flare fitting
Installer supplied
shut-off Valve must
be easily accessible
GAS CONSUMPTION
The total gas consumption of the Thermador® Char Glo® barbecues with all burners on "HI" is as follows:
CGBD30RX = 52,000 BTU/HR
CGBD36RX = 77,000 BTU/HR
CGBD48RSBX = 107,000 BTU/HR
CGBD48RX = 109,000 BTU/HR
Page 3
Loading...