INSTRUCTION MANUAL
37202
BX-Armored
Cable Dispenser/
BX-Armored
Cable Dispenser
37218
Transporter
Read and understand all of the instructions and
safety information in this manual before operating
or servicing this tool.
99905302 © 2009 Greenlee Textron Inc. IM 1131 REV 5 3/09
37202 and 37218 BX-Armored Cable Dispensers
IMPORTANT SAFETY
INFORMATION
SAFETY
ALERT
SYMBOL
This symbol is used to call your attention to hazards
or unsafe practices which could result in an injury or
property damage. The signal word, dened below,
indicates the severity of the hazard. The message
after the signal word provides information for pre-
venting or avoiding the hazard.
Immediate hazards which, if not avoided, WILL result
in severe injury or death.
Hazards which, if not avoided, COULD result in
severe injury or death.
Hazards or unsafe practices which, if not avoided,
MAY result in injury or property damage.
Specifications
37202 BX-Armored Cable Dispenser/Transporter
Size: 1143 mm H x 724 mm W x 736 mm D
(45" x 28-1/2" x 29")
Capacity:
Dispense: One 76.2 m (250') coil of 14/2, 14/3,
12/2, or 12/3 armored cable or ROMEX® nonmetallic
electrical wire
Transport: Three coils, maximum capacity 113 kg
(250 lb)
Weight: 20.4 kg (45 lb)
37218 BX-Armored Cable Dispenser
Size: 342.9 mm H x 660.4 mm diameter (13-1/2" x 26")
Capacity: One 76.2 m (250') coil of 14/2, 14/3, 12/2, or
12/3 armored cable or ROMEX® nonmetallic electrical
wire
Weight: 14.1 kg (31 lb)
Features
Can transport three (3) 250' coils, but dispense only •
one coil at a time (37202)
Large wheels for easy mobility (37202)•
Fits through 32" doorway•
Rotates freely for smooth feeding•
Feeding eye rotates fully for pulling in any direction•
The 37202 includes long handle for extra balance •
when transporting
All metal construction for durability•
Do not stand on unit. Dispenser will
spin or tip. Failure to observe this
precaution may result in injury or
property damage.
Do not overload units. Maxium weight to be trans-•
ported is 250 lb.
Remove cable before transporting or moving the •
37218 dispenser.
Use proper lifting techniques to load cable onto •
dispensers.
Keep clear of rotating dispenser.•
Do not exceed the design capacity of the dis penser.•
Use to transport rated materials only. Transporting •
other materials may damage dispenser.
Failure to observe these precautions may result in
injury or property damage.
Instructions for Use
1. Place coil on plate over center guides. Remove coil
straps or wires. For ROMEX® wire, remove from box
before placing on unit.
2. Find free end of cable on outside of coil, and then
feed through guide.
3. Adjust feeding resistance by turning hex nut located
at the center of the plate to desired drag.
Other Greenlee Products for Use
with Armored Cable
1940 BX-Cutter•
916 Cable Reel Transporter•
All specications are nominal and may change as design
improvements occur. Greenlee Textron Inc. shall not be liable for
damages resulting from misapplication or misuse of its products.
ROMEX is a registered trademark of Southwire Company.
KEEP THIS MANUAL
Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070
2
37202 and 37218 BX-Armored Cable Dispensers
13
1
5
6
7
8
9
14
4
15
10
11
12
2
3
17
16
16
8
9
4
13
18
7
6
11
14
15
10
12
19
17
Illustrations and Parts Lists
37202 BX-Armored Cable
Dispenser/Transporter
Item Part No. Description Qty
1 50372033 Frame weldment ...................................1
2A 90515099 Wheel (axle stub 2.36)...........................2
2B 52033343 Wheel (axle stub 3.11)........................... 2
3 90552989 Ring, rue–3/4 reg. .................................2
4 50372106 Plate, turntable......................................1
5 50372114 Bracket, center .....................................2
6 90541340 Bolt, 5/16–18 x .875 carriage ................5
7 90516028 Washer, 5/16 lock .................................5
8 90547675 Nut, 1–8 hex ..........................................1
9 50342720 Spring, compression .............................1
10 50372122 Support wlmt., plate .............................1
11 50372130 Guide weldment ....................................1
12 90525981 Washer, thrust .......................................1
13 90506383 Nut, 5/16–18 hex .................................. 5
14 90525701 Washer, 1 x 1-1/2 x .041 at .................1
15 90541359 Washer, 1 x 1-1/2 x .041 nylon .............1
16 90517407 Washer, at ...........................................4
17 90541367 Cap, tubing ...........................................2
37218 BX-Armored Cable Dispenser
Item Part No. Description Qty
4 50372106 Plate, turntable......................................1
6 90541340 Bolt, 5/16–18 x .875 carriage ................5
7 90516028 Washer, 5/16 lock .................................5
8 90531914 Nut, 1–14 hex ........................................1
9 50342720 Spring, compression .............................1
10 50372122 Support wlmt., plate .............................1
11 50372130 Guide weldment ....................................1
12 90525981 Washer, thrust .......................................1
13 90506383 Nut, 5/16–18 hex .................................. 5
14 90525701 Washer, 1 x 1-1/3 x .041 at .................1
15 90541359 Washer, 1 x 1-1/2 x .041 nylon .............1
17 90541367 Cap, tubing ...........................................4
18 50372114 Bracket, center .....................................2
19 50372190 Frame weldment ................................... 1
Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070
3
USA 800-435-0786 Fax: 800-451-2632
815-397-7070 Fax: 815-397-1865
Canada 800-435-0786 Fax: 800-524-2853
International +1-815-397-7070 Fax: +1-815-397-9247
4455 Boeing Drive • Rockford, IL 61109-2988 • USA • 815-397-7070
An ISO 9001 Company • Greenlee Textron Inc. is a subsidiary of Textron Inc.
www.greenlee.com
Loading...