Textron Bell 206A Series, BHT-206A, Bell 206B Series, BHT-206B, BHT-206B3 Maintenance Manual
BHT-206A/B-SERIES-MM-1
32672)),&(%2;)257:257+7(;$6
COPYRIGHT NOTICE
COPYRIGHT
201
BELL
®
HELICOPTER TEXTRON INC.
AND BELL HELICOPTER TEXTRON
CANADA LTD.
ALL RIGHTS RESERVED
MAINTENANCE MANUAL
GENERAL INFORMATION
The instructions set forth in this manual, as supplemented or modified by Alert Service Bulletins (ASB) or
other directions issued by Bell Helicopter Textron Inc. and Airworthiness Directives (AD) issued by the
applicable regulatory agencies, shall be strictly followed. This manual covers 206A, 206B, and 206B3
helicopters SN 4 through and including current production. TH-57/TH-67 helicopters are covered along
with the use of manual supplements. 206B1 helicopters are not covered by this manual.
FOR MODELS 206A, 206B, AND 206B3 HELICOPTERS
Export Classification C, ECCN EAR99
VOLUME 1
NOTICE
7 JANUARY 1998
REVISION 16 — 25 JUNE 2019
BHT-206A/B-SERIES-MM-1
PROPRIETARY RIGHTS NOTICE
These data are proprietary to Bell Helicopter Textron Inc. Disclosure,
reproduction, or use of these data for any purpose other than helicopter
operation or maintenance is forbidden without prior written authorization from
Bell Helicopter Textron Inc.
DESTINATION CONTROL STATEMENT
WARNING — This document contains technical data whose export is restricted
by the Arms Export Control Act (Title 22, U.S.C., Sec 2751, et. seq.) or the Export
Administration Act of 1979, as amended, Title 50, U.S.C., App. 2401 et. seq.
Violations of these export laws are subject to severe criminal penalties.
Disseminate in accordance with provisions of DoD Directive 5230.25.
Additional copies of this publication may be obtained by contacting:
PN Rev. 16 25 JUN 2019
Commercial Publication Distribution Center
Bell Helicopter Textron Inc.
P. O. Box 482
Fort Worth, Texas 76101-0482
Export Classification C, ECCN EAR99
WARNING
THIS MANUAL APPLIES ONLY TO HELICOPTERS AND COMPONENTS
MAINTAINED IN ACCORDANCE WITH BELL HELICOPTER TEXTRON
(BELL) APPROVED PROCEDURES USING BELL APPROVED PARTS.
ALL INSPECTION, REPAIR AND OVERHAUL PROCEDURES PUBLISHED
BY BELL, INCLUDING PART RETIREMENT LIFE, ARE BASED SOLELY ON
THE USE OF BELL PARTS THAT HAVE BEEN MAINTAINED USING BELL
APPROVED DATA. THE DATA PUBLISHED HEREIN OR OTHERWISE
SUPPLIED BY BELL IS NOT APPLICABLE TO NON-BELL PARTS OR
PARTS THAT HAVE BEEN REPAIRED USING DATA AND/OR PROCESSES
NOT APPROVED BY BELL.
BELL IS NOT RESPONSIBLE FOR ANY PART OTHER THAN THOSE THAT
IT HAS APPROVED.
BEFORE PERFORMING ANY PROCEDURE CONTAINED IN THIS MANUAL
YOU MUST INSPECT THE AFFECTED PARTS AND RECORDS FOR
EVIDENCE OF ANY MANUFACTURE, REPAIR, REWORK OR USE OF A
PROCESS NOT APPROVED BY BELL.
IF YOU IDENTIFY OR SUSPECT THE USE OF PARTS NOT AUTHORIZED
BY BELL, EITHER REMOVE THE AFFECTED ITEM FROM THE AIRCRAFT
OR OBTAIN INSTRUCTIONS FOR CONTINUED AIRWORTHINESS FROM
THE MANUFACTURER OR THE ORGANIZATION THAT APPROVED THE
REPAIR.
BHT-206A/B-SERIES-MM-1
Export Classification C, ECCN EAR99
25 JUN 2019 Rev. 16 W arning
BHT-206A/B-SERIES-MM-1
CUSTOMER SUPPORT AND SERVICES
Flying smart means that no matter where you are, or what time it is, you can make a call
and get additional information, clarification, or advice on a technical or operational issue
concerning your helicopter or information contained in our Technical Publications.
Product Support Engineering (PSE) is just a phone call away and may be contacted as
follows:
Model 206, 407, or 505
Phone: 450-437-2862 or 800-363-8023 ( U.S./Canada)
Fax: 450-433-0272
E-mail: productsupport@bellflight.com
Model 222, 230, 427, 429, or 430
Phone: 450-437-2077 or 800-463-3036 ( U.S./Canada)
Fax: 450-433-0272
E-mail: productsupport@bellflight.com
Model 204, 205, 212, or 412
Phone: 450-437-6201 or 800-363-8028 ( U.S./Canada)
Fax: 450-433-0272
E-mail: productsupport@bellflight.com
Model 210, HUEY II, and All Bell’s Active and
Military Medium Helicopter Models
Phone: 817-280-3548
Fax: 817-280-2635
E-mail: mts-medium@bellflight.com
Model OH-58, TH-67, TH-57, Both Active and
Military
Phone: 817-280-3548
Fax: 817-280-2635
E-mail: mts-light@bellflight.com
Surplus
Surplus
For additional information on Customer Suppo rt a nd Ser vices as well as Pr oduct Su pp ort
Engineering (PSE) and your local Customer Service Engineering (CSE) network, please
access http://www.bellhflightcom/support-and-service/support.
CSS Rev. 16 25 JUN 2019 Export Classification C, ECCN EAR99
BHT-206A/B-SERIES-MM-1
LOG OF REVISIONS
Insert latest revision pages and dispose of superseded ones.
On a revised page, the text and/or illustration affected by the latest revision is shown by a vertical line. A revised
page with only a vertical line next to the page number indicates that text has shifted or that non-technical
correction(s) were made on that page.
Original . . . .0. . . . . . 07 JAN 98
Revision. . . .1. . . . . . 21 MAY 02
Revision. . . .2. . . . . . 07 JUN 02
Revision. . . .3. . . . . . .12 JUL 04
Revision. . . .4. . . . . . 28 APR 06
Revision. . . .5. . . . . . .31 JUL 09
Page No. Rev No.
VOLUME 1
Cover . . . . . . . . . . . . . . . . . . . .16
Title . . . . . . . . . . . . . . . . . . . . .16
PN . . . . . . . . . . . . . . . . . . . . . .16
Warning . . . . . . . . . . . . . . . . . .16
CSS . . . . . . . . . . . . . . . . . . . . .16
A – D . . . . . . . . . . . . . . . . . . . .16
E/F . . . . . . . . . . . . . . . . . . . . . .16
Help . . . . . . . . . . . . . . . . . . . . .13
Customer Feedback. . . . . . . . .16
Helicopter Sales Notice . . . . . .16
Warranty. . . . . . . . . . . . . . . . . .16
BR . . . . . . . . . . . . . . . . . . . . . .16
TR . . . . . . . . . . . . . . . . . . . . . .16
i – ii. . . . . . . . . . . . . . . . . . . . . .16
Chapter 1
1/2 . . . . . . . . . . . . . . . . . . . . . . .6
3. . . . . . . . . . . . . . . . . . . . . . . .12
4 – 8. . . . . . . . . . . . . . . . . . . . . .6
9/10 . . . . . . . . . . . . . . . . . . . . . .6
Chapter 4
1 – 2. . . . . . . . . . . . . . . . . . . . .16
3/4 . . . . . . . . . . . . . . . . . . . . . .16
5– 14 . . . . . . . . . . . . . . . . . . . .16
Chapter 5
1 – 2. . . . . . . . . . . . . . . . . . . . .14
3/4 . . . . . . . . . . . . . . . . . . . . . .14
5 – 8. . . . . . . . . . . . . . . . . . . . .14
9/10 . . . . . . . . . . . . . . . . . . . . .14
11 – 16 . . . . . . . . . . . . . . . . . . .14
17/18 . . . . . . . . . . . . . . . . . . . .14
Revision . . . 6 . . . . . .07 DEC 09
Revision . . . 7 . . . . . .14 APR 10
Revision . . . 8 . . . . . . 30 JUN 10
Revision . . . 9 . . . . . . 27 SEP 10
Revision . . . 10 . . . . . 08 APR 11
Revision . . . 11 . . . . .13 OCT 11
Revision . . . 12 . . . . .01 JUN 12
Revision . . . 13 . . . . 07 NOV 13
Revision . . . 14 . . . . 30 APR 13
Revision . . . 15 . . . . .02 JUN 15
Revision . . . 16 . . . . .25 JUN 19
LOG OF PAGES
Page No. Rev No. Page No. Rev No.
19 – 34 . . . . . . . . . . . . . . . . . . 14
35/36. . . . . . . . . . . . . . . . . . . . 14
37 – 48 . . . . . . . . . . . . . . . . . . 14
49/50. . . . . . . . . . . . . . . . . . . . 14
51 – 54 . . . . . . . . . . . . . . . . . . 14
55/56. . . . . . . . . . . . . . . . . . . . 14
57 – 62 . . . . . . . . . . . . . . . . . . 14
63/64. . . . . . . . . . . . . . . . . . . . 14
65 – 70 . . . . . . . . . . . . . . . . . . 14
71/72. . . . . . . . . . . . . . . . . . . . 14
73 – 84 . . . . . . . . . . . . . . . . . . 14
85/86. . . . . . . . . . . . . . . . . . . . 15
87 – 90 . . . . . . . . . . . . . . . . . . 14
91/92. . . . . . . . . . . . . . . . . . . . 14
93/94. . . . . . . . . . . . . . . . . . . . 14
95 – 106 . . . . . . . . . . . . . . . . . 14
107/108. . . . . . . . . . . . . . . . . . 14
109 – 110 . . . . . . . . . . . . . . . . 14
111/112 . . . . . . . . . . . . . . . . . . 14
113/114. . . . . . . . . . . . . . . . . . 14
115 – 118 . . . . . . . . . . . . . . . . 14
119/120. . . . . . . . . . . . . . . . . . 14
121 – 130 . . . . . . . . . . . . . . . . 14
131/132. . . . . . . . . . . . . . . . . . 14
133 – 134 . . . . . . . . . . . . . . . . 14
135/136. . . . . . . . . . . . . . . . . . 14
137/138. . . . . . . . . . . . . . . . . . 14
139 – 146 . . . . . . . . . . . . . . . . 14
147/148. . . . . . . . . . . . . . . . . . 14
149/150. . . . . . . . . . . . . . . . . . 14
151 – 154 . . . . . . . . . . . . . . . . 14
155/156. . . . . . . . . . . . . . . . . . 14
157 – 160 . . . . . . . . . . . . . . . . 14
161/162. . . . . . . . . . . . . . . . . . 14
163 – 166 . . . . . . . . . . . . . . . . 14
167/168. . . . . . . . . . . . . . . . . . 14
169 – 170 . . . . . . . . . . . . . . . . 14
171/172. . . . . . . . . . . . . . . . . . 14
173 – 174 . . . . . . . . . . . . . . . . 14
175/176. . . . . . . . . . . . . . . . . . 14
177 – 180 . . . . . . . . . . . . . . . . 14
181/182. . . . . . . . . . . . . . . . . . 14
183 – 196 . . . . . . . . . . . . . . . . 14
197/198. . . . . . . . . . . . . . . . . . 14
199/200. . . . . . . . . . . . . . . . . . 14
201 – 204 . . . . . . . . . . . . . . . . 14
Index MM
1 – 16 (Deleted) . . . . . . . . . . . . 5
VOLUME 2
Cover . . . . . . . . . . . . . . . . . . . 14
Title . . . . . . . . . . . . . . . . . . . . . 14
PN. . . . . . . . . . . . . . . . . . . . . . 14
Chapter 6
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 6 . . . . . . . . . . . . . . . . . . . . . 0
7/8. . . . . . . . . . . . . . . . . . . . . . . 0
Chapter 7
1/2. . . . . . . . . . . . . . . . . . . . . . . 6
3 – 4 . . . . . . . . . . . . . . . . . . . . . 6
5/6. . . . . . . . . . . . . . . . . . . . . . . 6
Chapter 8
1 – 22 . . . . . . . . . . . . . . . . . . . . 3
23 . . . . . . . . . . . . . . . . . . . . . . . 9
Export Classification C, ECCN EAR99
25 JUN 2019 Rev. 16 A
BHT-206A/B-SERIES-MM-1
LOG OF PAGES (CONT)
Page No. Rev No.
24 – 32 . . . . . . . . . . . . . . . . . . . 3
33/34. . . . . . . . . . . . . . . . . . . . . 3
Chapter 9
1/2. . . . . . . . . . . . . . . . . . . . . . . 6
3 – 4 . . . . . . . . . . . . . . . . . . . . . 6
Chapter 10
1/2. . . . . . . . . . . . . . . . . . . . . . . 6
3 – 6 . . . . . . . . . . . . . . . . . . . . . 6
Chapter 11
1/2. . . . . . . . . . . . . . . . . . . . . . . 6
3 – 18 . . . . . . . . . . . . . . . . . . . . 6
19/20. . . . . . . . . . . . . . . . . . . . . 6
Chapter 12
1 . . . . . . . . . . . . . . . . . . . . . . . . 4
2 . . . . . . . . . . . . . . . . . . . . . . . 10
3/4. . . . . . . . . . . . . . . . . . . . . . . 4
5 – 6 . . . . . . . . . . . . . . . . . . . . . 4
7/8. . . . . . . . . . . . . . . . . . . . . . . 4
9 – 14 . . . . . . . . . . . . . . . . . . . . 4
15/16. . . . . . . . . . . . . . . . . . . . . 4
17 – 24 . . . . . . . . . . . . . . . . . . . 4
25 – 26 . . . . . . . . . . . . . . . . . . . 8
27/28. . . . . . . . . . . . . . . . . . . . . 4
29 – 30 . . . . . . . . . . . . . . . . . . . 4
31/32. . . . . . . . . . . . . . . . . . . . 14
33 . . . . . . . . . . . . . . . . . . . . . . 10
34 . . . . . . . . . . . . . . . . . . . . . . . 4
35 – 36 . . . . . . . . . . . . . . . . . . . 9
37 – 38 . . . . . . . . . . . . . . . . . . . 4
39/40. . . . . . . . . . . . . . . . . . . . 10
41 – 44 . . . . . . . . . . . . . . . . . . . 4
45/46. . . . . . . . . . . . . . . . . . . . . 4
VOLUME 3
Cover . . . . . . . . . . . . . . . . . . . 14
Title. . . . . . . . . . . . . . . . . . . . . 14
PN. . . . . . . . . . . . . . . . . . . . . . 14
Chapter 18
1 – 2 . . . . . . . . . . . . . . . . . . . . . 0
3/4. . . . . . . . . . . . . . . . . . . . . . . 0
5 – 24 . . . . . . . . . . . . . . . . . . . . 0
25/26. . . . . . . . . . . . . . . . . . . . . 0
27 – 34 . . . . . . . . . . . . . . . . . . . 0
35 – 36 . . . . . . . . . . . . . . . . . . . 4
Page No. Rev No. Page No. Rev No.
37 – 38 . . . . . . . . . . . . . . . . . . . 0
38A/38B . . . . . . . . . . . . . . . . . . 4
39 – 58 . . . . . . . . . . . . . . . . . . . 0
59 – 60 . . . . . . . . . . . . . . . . . . . 4
60A/60B . . . . . . . . . . . . . . . . . . 4
61 – 70 . . . . . . . . . . . . . . . . . . . 0
71 – 72 . . . . . . . . . . . . . . . . . . . 4
73 . . . . . . . . . . . . . . . . . . . . . . . 0
74 . . . . . . . . . . . . . . . . . . . . . . 14
75 – 78 . . . . . . . . . . . . . . . . . . . 0
79 – 80 . . . . . . . . . . . . . . . . . . . 4
Chapter 21
1 – 14 . . . . . . . . . . . . . . . . . . . . 6
15/16. . . . . . . . . . . . . . . . . . . . . 6
17 – 20 . . . . . . . . . . . . . . . . . . . 6
Chapter 25
1 – 8 . . . . . . . . . . . . . . . . . . . . . 6
9/10. . . . . . . . . . . . . . . . . . . . . . 6
Chapter 26
1/2. . . . . . . . . . . . . . . . . . . . . . . 6
3 – 4 . . . . . . . . . . . . . . . . . . . . . 6
5/6. . . . . . . . . . . . . . . . . . . . . . . 6
VOLUME 4
Cover . . . . . . . . . . . . . . . . . . . 13
Title . . . . . . . . . . . . . . . . . . . . . 15
PN. . . . . . . . . . . . . . . . . . . . . . 13
Chapter 28
1 – 2 . . . . . . . . . . . . . . . . . . . . 11
3 . . . . . . . . . . . . . . . . . . . . . . . . 0
4 . . . . . . . . . . . . . . . . . . . . . . . . 8
5 . . . . . . . . . . . . . . . . . . . . . . . . 0
6 . . . . . . . . . . . . . . . . . . . . . . . . 8
7 – 11 . . . . . . . . . . . . . . . . . . . . 0
12 . . . . . . . . . . . . . . . . . . . . . . 11
12A/12B . . . . . . . . . . . . . . . . . 11
13 – 15 . . . . . . . . . . . . . . . . . . . 0
16 . . . . . . . . . . . . . . . . . . . . . . 11
17 – 40 . . . . . . . . . . . . . . . . . . . 0
41/42. . . . . . . . . . . . . . . . . . . . 11
Chapter 29
1 . . . . . . . . . . . . . . . . . . . . . . . 10
2 . . . . . . . . . . . . . . . . . . . . . . . 11
3 – 8 . . . . . . . . . . . . . . . . . . . . . 0
9 – 10. . . . . . . . . . . . . . . . . . . . .5
10A/10B. . . . . . . . . . . . . . . . . .10
1 1. . . . . . . . . . . . . . . . . . . . . . . .5
12. . . . . . . . . . . . . . . . . . . . . . .10
12A/12B. . . . . . . . . . . . . . . . . .10
13. . . . . . . . . . . . . . . . . . . . . . .10
14. . . . . . . . . . . . . . . . . . . . . . . .5
14A . . . . . . . . . . . . . . . . . . . . . .5
14B . . . . . . . . . . . . . . . . . . . . . .6
14C/14D . . . . . . . . . . . . . . . . . .5
15. . . . . . . . . . . . . . . . . . . . . . .10
16 – 18. . . . . . . . . . . . . . . . . . . .5
19 – 20. . . . . . . . . . . . . . . . . . .15
20A – 20B . . . . . . . . . . . . . . . .15
21. . . . . . . . . . . . . . . . . . . . . . .13
22 – 24. . . . . . . . . . . . . . . . . . .10
24A/24B. . . . . . . . . . . . . . . . . .10
25 – 30. . . . . . . . . . . . . . . . . . . .0
31. . . . . . . . . . . . . . . . . . . . . . . .8
32. . . . . . . . . . . . . . . . . . . . . . . 11
33/34 . . . . . . . . . . . . . . . . . . . . .8
VOLUME 5
Cover. . . . . . . . . . . . . . . . . . . . .6
Title . . . . . . . . . . . . . . . . . . . . . .8
PN . . . . . . . . . . . . . . . . . . . . . . .6
Chapter 30
1/2 . . . . . . . . . . . . . . . . . . . . . . .6
3/4 . . . . . . . . . . . . . . . . . . . . . . .6
Chapter 32
1 – 3. . . . . . . . . . . . . . . . . . . . . .0
4. . . . . . . . . . . . . . . . . . . . . . . . .8
5 – 22. . . . . . . . . . . . . . . . . . . . .0
23/24 . . . . . . . . . . . . . . . . . . . . .0
25 – 26. . . . . . . . . . . . . . . . . . . .0
27/28 . . . . . . . . . . . . . . . . . . . . .0
29 – 54. . . . . . . . . . . . . . . . . . . .0
Chapter 52
1 – 2. . . . . . . . . . . . . . . . . . . . . .8
2A/2B. . . . . . . . . . . . . . . . . . . . .8
3. . . . . . . . . . . . . . . . . . . . . . . . .8
4. . . . . . . . . . . . . . . . . . . . . . . . .0
4A/4B. . . . . . . . . . . . . . . . . . . . .8
5 – 26. . . . . . . . . . . . . . . . . . . . .0
27. . . . . . . . . . . . . . . . . . . . . . . .8
28. . . . . . . . . . . . . . . . . . . . . . . .0
B Rev. 16 25 JUN 2019 Export Classification C, ECCN EAR99
LOG OF PAGES (CONT)
BHT-206A/B-SERIES-MM-1
Page No. Rev No.
29 – 30. . . . . . . . . . . . . . . . . . . .8
30A/30B. . . . . . . . . . . . . . . . . . .8
31 – 32. . . . . . . . . . . . . . . . . . . .0
33 – 34. . . . . . . . . . . . . . . . . . . .8
35 – 42. . . . . . . . . . . . . . . . . . . .0
43/44 . . . . . . . . . . . . . . . . . . . . .0
Chapter 53
1 – 10. . . . . . . . . . . . . . . . . . . . .4
11/12 . . . . . . . . . . . . . . . . . . . . .6
13 – 22. . . . . . . . . . . . . . . . . . . .4
23. . . . . . . . . . . . . . . . . . . . . . . .8
24 – 30. . . . . . . . . . . . . . . . . . . .4
31/32 . . . . . . . . . . . . . . . . . . . . .4
33 – 36. . . . . . . . . . . . . . . . . . . .4
37/38 . . . . . . . . . . . . . . . . . . . . .4
39 – 40. . . . . . . . . . . . . . . . . . . .4
VOLUME 6
Cover . . . . . . . . . . . . . . . . . . . .14
Title . . . . . . . . . . . . . . . . . . . . .14
PN . . . . . . . . . . . . . . . . . . . . . .14
Chapter 62
1 – 2. . . . . . . . . . . . . . . . . . . . .14
2A/2B. . . . . . . . . . . . . . . . . . . . .6
3. . . . . . . . . . . . . . . . . . . . . . . . .0
4. . . . . . . . . . . . . . . . . . . . . . . . .9
5. . . . . . . . . . . . . . . . . . . . . . . . .6
6. . . . . . . . . . . . . . . . . . . . . . . . .8
7 – 8. . . . . . . . . . . . . . . . . . . . . .0
9 – 10. . . . . . . . . . . . . . . . . . . . .6
11 – 12 . . . . . . . . . . . . . . . . . . . .0
13/14 . . . . . . . . . . . . . . . . . . . . .0
15 – 16. . . . . . . . . . . . . . . . . . .14
16A/16B. . . . . . . . . . . . . . . . . .14
17 – 22. . . . . . . . . . . . . . . . . . . .0
23/24 . . . . . . . . . . . . . . . . . . . . .0
25 – 30. . . . . . . . . . . . . . . . . . . .0
31/32 . . . . . . . . . . . . . . . . . . . . .0
33 – 36. . . . . . . . . . . . . . . . . . . .0
37. . . . . . . . . . . . . . . . . . . . . . .14
38. . . . . . . . . . . . . . . . . . . . . . . .6
38A/38B. . . . . . . . . . . . . . . . . . .6
39. . . . . . . . . . . . . . . . . . . . . . .14
40 – 42. . . . . . . . . . . . . . . . . . . .0
43 – 46. . . . . . . . . . . . . . . . . . .14
46A – 46B . . . . . . . . . . . . . . . .14
47 – 57. . . . . . . . . . . . . . . . . . . .0
Page No. Rev No. Page No. Rev No.
58 . . . . . . . . . . . . . . . . . . . . . . 11
58A/58B . . . . . . . . . . . . . . . . . 11
59 – 60 . . . . . . . . . . . . . . . . . . . 0
61/62. . . . . . . . . . . . . . . . . . . . . 0
Chapter 63
1 – 2 . . . . . . . . . . . . . . . . . . . . . 9
3/4. . . . . . . . . . . . . . . . . . . . . . . 9
5 – 7 . . . . . . . . . . . . . . . . . . . . . 9
8 – 15 . . . . . . . . . . . . . . . . . . . . 6
16 . . . . . . . . . . . . . . . . . . . . . . 12
17 – 30 . . . . . . . . . . . . . . . . . . . 6
31 . . . . . . . . . . . . . . . . . . . . . . 12
32 – 55 . . . . . . . . . . . . . . . . . . . 6
56 . . . . . . . . . . . . . . . . . . . . . . 10
57 – 60 . . . . . . . . . . . . . . . . . . . 6
VOLUME 7
Cover . . . . . . . . . . . . . . . . . . . . 6
Title. . . . . . . . . . . . . . . . . . . . . 10
PN. . . . . . . . . . . . . . . . . . . . . . . 6
Chapter 64
1/2. . . . . . . . . . . . . . . . . . . . . . . 6
3/4. . . . . . . . . . . . . . . . . . . . . . . 6
5 – 14 . . . . . . . . . . . . . . . . . . . . 6
15 . . . . . . . . . . . . . . . . . . . . . . . 8
16 – 22 . . . . . . . . . . . . . . . . . . . 6
23 . . . . . . . . . . . . . . . . . . . . . . . 7
24 – 25 . . . . . . . . . . . . . . . . . . . 6
26 . . . . . . . . . . . . . . . . . . . . . . . 7
27 . . . . . . . . . . . . . . . . . . . . . . . 6
28 . . . . . . . . . . . . . . . . . . . . . . . 7
29 – 30 . . . . . . . . . . . . . . . . . . . 6
31/32. . . . . . . . . . . . . . . . . . . . . 6
Chapter 65
1 – 2 . . . . . . . . . . . . . . . . . . . . 10
2A/2B . . . . . . . . . . . . . . . . . . . . 6
3 . . . . . . . . . . . . . . . . . . . . . . . . 0
4 . . . . . . . . . . . . . . . . . . . . . . . 10
5 – 12 . . . . . . . . . . . . . . . . . . . . 0
13/14. . . . . . . . . . . . . . . . . . . . . 0
15 – 18 . . . . . . . . . . . . . . . . . . . 0
18A/18B . . . . . . . . . . . . . . . . . . 6
19 – 20 . . . . . . . . . . . . . . . . . . 10
21 . . . . . . . . . . . . . . . . . . . . . . . 0
22 . . . . . . . . . . . . . . . . . . . . . . . 8
23 . . . . . . . . . . . . . . . . . . . . . . . 0
24 . . . . . . . . . . . . . . . . . . . . . . . 6
24A – 24C. . . . . . . . . . . . . . . . . 6
24D . . . . . . . . . . . . . . . . . . . . . 10
25 – 26 . . . . . . . . . . . . . . . . . . 10
26A/26B . . . . . . . . . . . . . . . . . . 8
27 – 28 . . . . . . . . . . . . . . . . . . . 6
28A – 28B. . . . . . . . . . . . . . . . . 6
28C/28D . . . . . . . . . . . . . . . . . . 6
29 . . . . . . . . . . . . . . . . . . . . . . 10
30 . . . . . . . . . . . . . . . . . . . . . . . 0
30A/30B . . . . . . . . . . . . . . . . . 10
31 . . . . . . . . . . . . . . . . . . . . . . 10
32 – 33 . . . . . . . . . . . . . . . . . . . 0
34 . . . . . . . . . . . . . . . . . . . . . . . 6
34A/34B . . . . . . . . . . . . . . . . . . 6
35 . . . . . . . . . . . . . . . . . . . . . . . 0
36 . . . . . . . . . . . . . . . . . . . . . . . 8
37 – 38 . . . . . . . . . . . . . . . . . . . 6
38A – 38B. . . . . . . . . . . . . . . . . 7
38C . . . . . . . . . . . . . . . . . . . . . . 6
38D . . . . . . . . . . . . . . . . . . . . . . 7
38E – 38I. . . . . . . . . . . . . . . . . . 6
38J . . . . . . . . . . . . . . . . . . . . . 10
38K/38L. . . . . . . . . . . . . . . . . . . 8
39 – 40 . . . . . . . . . . . . . . . . . . 10
40A/40B . . . . . . . . . . . . . . . . . 10
41 – 42 . . . . . . . . . . . . . . . . . . . 6
43 – 47 . . . . . . . . . . . . . . . . . . . 0
48 – 52 . . . . . . . . . . . . . . . . . . 10
VOLUME 8
Cover . . . . . . . . . . . . . . . . . . . . 5
Title . . . . . . . . . . . . . . . . . . . . . 11
PN. . . . . . . . . . . . . . . . . . . . . . . 5
Chapter 67
1 – 4 . . . . . . . . . . . . . . . . . . . . . 8
4A/4B . . . . . . . . . . . . . . . . . . . . 8
5 – 8 . . . . . . . . . . . . . . . . . . . . . 0
9 – 10 . . . . . . . . . . . . . . . . . . . . 5
10A/10B . . . . . . . . . . . . . . . . . . 5
1 1 – 12 . . . . . . . . . . . . . . . . . . . 0
13/14. . . . . . . . . . . . . . . . . . . . . 0
15 . . . . . . . . . . . . . . . . . . . . . . . 5
16 . . . . . . . . . . . . . . . . . . . . . . . 0
17/18. . . . . . . . . . . . . . . . . . . . . 0
19 – 22 . . . . . . . . . . . . . . . . . . . 0
23/24. . . . . . . . . . . . . . . . . . . . . 0
25 – 27 . . . . . . . . . . . . . . . . . . . 0
Export Classification C, ECCN EAR99
25 JUN 2019 Rev. 16 C
BHT-206A/B-SERIES-MM-1
LOG OF PAGES (CONT)
Page No. Rev No.
28 . . . . . . . . . . . . . . . . . . . . . . 11
28A/28B . . . . . . . . . . . . . . . . . . 5
29 . . . . . . . . . . . . . . . . . . . . . . . 5
30 – 32 . . . . . . . . . . . . . . . . . . 11
32A/32B . . . . . . . . . . . . . . . . . . 5
33 – 34 . . . . . . . . . . . . . . . . . . . 0
35 – 38 . . . . . . . . . . . . . . . . . . . 8
38A/38B . . . . . . . . . . . . . . . . . . 8
39 . . . . . . . . . . . . . . . . . . . . . . . 0
40 . . . . . . . . . . . . . . . . . . . . . . . 5
41 – 42 . . . . . . . . . . . . . . . . . . . 0
43 – 46 . . . . . . . . . . . . . . . . . . . 5
46A/46B . . . . . . . . . . . . . . . . . . 5
47 – 48 . . . . . . . . . . . . . . . . . . . 0
49 – 50 . . . . . . . . . . . . . . . . . . . 5
51 – 55 . . . . . . . . . . . . . . . . . . . 0
56 – 58 . . . . . . . . . . . . . . . . . . . 5
58A/58B . . . . . . . . . . . . . . . . . . 5
59 – 67 . . . . . . . . . . . . . . . . . . . 0
68 – 71 . . . . . . . . . . . . . . . . . . . 5
72 . . . . . . . . . . . . . . . . . . . . . . . 0
73/74. . . . . . . . . . . . . . . . . . . . . 0
75 – 78 . . . . . . . . . . . . . . . . . . . 5
79 – 84 . . . . . . . . . . . . . . . . . . . 0
85 . . . . . . . . . . . . . . . . . . . . . . . 5
86 – 90 . . . . . . . . . . . . . . . . . . . 2
91/92. . . . . . . . . . . . . . . . . . . . . 2
93 – 101 . . . . . . . . . . . . . . . . . . 2
102 – 104 . . . . . . . . . . . . . . . . . 5
105 – 107 . . . . . . . . . . . . . . . . . 2
108 . . . . . . . . . . . . . . . . . . . . . . 5
109 – 118 . . . . . . . . . . . . . . . . . 2
VOLUME 9
Cover . . . . . . . . . . . . . . . . . . . . 6
Title. . . . . . . . . . . . . . . . . . . . . 10
PN. . . . . . . . . . . . . . . . . . . . . . . 6
Chapter 71
1 – 4 . . . . . . . . . . . . . . . . . . . . . 6
4A/4B . . . . . . . . . . . . . . . . . . . . 6
5 – 12 . . . . . . . . . . . . . . . . . . . . 0
13 – 15 . . . . . . . . . . . . . . . . . . . 8
16 . . . . . . . . . . . . . . . . . . . . . . . 6
16A/16B . . . . . . . . . . . . . . . . . . 8
17 – 22 . . . . . . . . . . . . . . . . . . . 0
23/24. . . . . . . . . . . . . . . . . . . . . 0
25 – 28 . . . . . . . . . . . . . . . . . . . 0
29/30. . . . . . . . . . . . . . . . . . . . . 0
Page No. Rev No. Page No. Rev No.
31 – 40 . . . . . . . . . . . . . . . . . . . 0
41 – 43 . . . . . . . . . . . . . . . . . . . 8
44 . . . . . . . . . . . . . . . . . . . . . . . 6
44A/44B . . . . . . . . . . . . . . . . . . 6
45 – 50 . . . . . . . . . . . . . . . . . . . 0
51/52. . . . . . . . . . . . . . . . . . . . . 0
53 – 56 . . . . . . . . . . . . . . . . . . . 0
57/58. . . . . . . . . . . . . . . . . . . . . 0
59 – 70 . . . . . . . . . . . . . . . . . . . 0
71 – 74 . . . . . . . . . . . . . . . . . . 10
74A/74B . . . . . . . . . . . . . . . . . 10
75 – 84 . . . . . . . . . . . . . . . . . . . 0
85/86. . . . . . . . . . . . . . . . . . . . . 0
Chapter 75
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 6 . . . . . . . . . . . . . . . . . . . . . 0
Chapter 76
1 . . . . . . . . . . . . . . . . . . . . . . . . 7
2 . . . . . . . . . . . . . . . . . . . . . . . . 2
3/4. . . . . . . . . . . . . . . . . . . . . . . 7
5 – 8 . . . . . . . . . . . . . . . . . . . . . 2
9 . . . . . . . . . . . . . . . . . . . . . . . . 7
10 . . . . . . . . . . . . . . . . . . . . . . . 2
11 – 12 . . . . . . . . . . . . . . . . . . . 7
13 . . . . . . . . . . . . . . . . . . . . . . . 2
14 . . . . . . . . . . . . . . . . . . . . . . . 6
15 – 16 . . . . . . . . . . . . . . . . . . . 7
16A/16B . . . . . . . . . . . . . . . . . . 7
17 – 28 . . . . . . . . . . . . . . . . . . . 2
29 – 31 . . . . . . . . . . . . . . . . . . . 7
32 – 34 . . . . . . . . . . . . . . . . . . . 2
35/36. . . . . . . . . . . . . . . . . . . . . 2
37 – 42 . . . . . . . . . . . . . . . . . . . 2
43/44. . . . . . . . . . . . . . . . . . . . . 2
45/46. . . . . . . . . . . . . . . . . . . . . 2
47/48. . . . . . . . . . . . . . . . . . . . . 2
49/50. . . . . . . . . . . . . . . . . . . . . 2
51/52. . . . . . . . . . . . . . . . . . . . . 2
53/54. . . . . . . . . . . . . . . . . . . . . 2
55 – 68 . . . . . . . . . . . . . . . . . . . 2
69/70. . . . . . . . . . . . . . . . . . . . . 2
71/72. . . . . . . . . . . . . . . . . . . . . 2
73/74. . . . . . . . . . . . . . . . . . . . . 2
75/76. . . . . . . . . . . . . . . . . . . . . 7
77 – 82 . . . . . . . . . . . . . . . . . . . 2
83/84. . . . . . . . . . . . . . . . . . . . . 2
Chapter 79
1/2 . . . . . . . . . . . . . . . . . . . . . . .0
3 – 4. . . . . . . . . . . . . . . . . . . . . .0
5/6 . . . . . . . . . . . . . . . . . . . . . . .0
7 – 10. . . . . . . . . . . . . . . . . . . . .0
VOLUME 10
Cover. . . . . . . . . . . . . . . . . . . . .7
Title . . . . . . . . . . . . . . . . . . . . . 11
PN . . . . . . . . . . . . . . . . . . . . . . .7
Chapter 95
1 – 2. . . . . . . . . . . . . . . . . . . . . 11
2A/2B. . . . . . . . . . . . . . . . . . . . 11
3 – 5. . . . . . . . . . . . . . . . . . . . . .0
6. . . . . . . . . . . . . . . . . . . . . . . . .7
7 – 18. . . . . . . . . . . . . . . . . . . . .0
19/20 . . . . . . . . . . . . . . . . . . . . .7
21 – 22. . . . . . . . . . . . . . . . . . . .0
23. . . . . . . . . . . . . . . . . . . . . . . 11
24 – 28. . . . . . . . . . . . . . . . . . . .0
29 – 30. . . . . . . . . . . . . . . . . . . 11
30A/30B. . . . . . . . . . . . . . . . . . 11
31 – 32. . . . . . . . . . . . . . . . . . .10
32A/32B. . . . . . . . . . . . . . . . . .10
33 – 36. . . . . . . . . . . . . . . . . . . .0
37. . . . . . . . . . . . . . . . . . . . . . . .7
38. . . . . . . . . . . . . . . . . . . . . . . .0
39/40 . . . . . . . . . . . . . . . . . . . . .0
Chapter 96
1 – 2. . . . . . . . . . . . . . . . . . . . . .0
3 – 6. . . . . . . . . . . . . . . . . . . . .10
6A/6B. . . . . . . . . . . . . . . . . . . .10
7 – 20. . . . . . . . . . . . . . . . . . . . .0
21/22 . . . . . . . . . . . . . . . . . . . . .0
23 – 38. . . . . . . . . . . . . . . . . . . .0
39. . . . . . . . . . . . . . . . . . . . . . .10
40. . . . . . . . . . . . . . . . . . . . . . . .0
41 – 42. . . . . . . . . . . . . . . . . . .10
42A/42B. . . . . . . . . . . . . . . . . .10
43 – 50. . . . . . . . . . . . . . . . . . . .0
51/52 . . . . . . . . . . . . . . . . . . . . .0
53 – 64. . . . . . . . . . . . . . . . . . . .0
65 – 68. . . . . . . . . . . . . . . . . . . .9
69 – 78. . . . . . . . . . . . . . . . . . . .0
79/80 . . . . . . . . . . . . . . . . . . . . .0
81/82 . . . . . . . . . . . . . . . . . . . . .0
83 – 98. . . . . . . . . . . . . . . . . . . .0
D Rev. 16 25 JUN 2019 Export Classification C, ECCN EAR99
LOG OF PAGES (CONT)
BHT-206A/B-SERIES-MM-1
Page No. Rev No.
VOLUME 11
Cover . . . . . . . . . . . . . . . . . . . . .7
Title . . . . . . . . . . . . . . . . . . . . . .7
PN . . . . . . . . . . . . . . . . . . . . . . .7
Chapter 97
1 – 8. . . . . . . . . . . . . . . . . . . . . .0
9/10 . . . . . . . . . . . . . . . . . . . . . .0
11/12 . . . . . . . . . . . . . . . . . . . . .0
13/14 . . . . . . . . . . . . . . . . . . . . .0
15/16 . . . . . . . . . . . . . . . . . . . . .0
17/18 . . . . . . . . . . . . . . . . . . . . .0
19 – 32. . . . . . . . . . . . . . . . . . . .0
33/34 . . . . . . . . . . . . . . . . . . . . .0
35 – 64. . . . . . . . . . . . . . . . . . . .0
VOLUME 12
Cover . . . . . . . . . . . . . . . . . . . .15
Title . . . . . . . . . . . . . . . . . . . . .15
PN . . . . . . . . . . . . . . . . . . . . . .15
Chapter 98
1 – 8. . . . . . . . . . . . . . . . . . . . .15
9/10 . . . . . . . . . . . . . . . . . . . . .15
11 – 82 . . . . . . . . . . . . . . . . . . .15
83/84 . . . . . . . . . . . . . . . . . . . .15
Page No. Rev No. Page No. Rev No.
VOLUME 13
Cover . . . . . . . . . . . . . . . . . . . . 0
Title. . . . . . . . . . . . . . . . . . . . . . 0
PN. . . . . . . . . . . . . . . . . . . . . . . 0
Chapter 99
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
MMS-01
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 6 . . . . . . . . . . . . . . . . . . . . . 0
MMS-02
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 12 . . . . . . . . . . . . . . . . . . . . 0
MMS-03
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 6 . . . . . . . . . . . . . . . . . . . . . 0
MMS-04
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 6 . . . . . . . . . . . . . . . . . . . . . 0
MMS-05
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 4 . . . . . . . . . . . . . . . . . . . . . 0
MMS-06
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 22 . . . . . . . . . . . . . . . . . . . . 0
23/24. . . . . . . . . . . . . . . . . . . . . 0
MMS-07
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 10 . . . . . . . . . . . . . . . . . . . . 0
1 1/12 . . . . . . . . . . . . . . . . . . . . . 0
MMS-08
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 18 . . . . . . . . . . . . . . . . . . . . 0
19/20. . . . . . . . . . . . . . . . . . . . . 0
MMS-09
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 4 . . . . . . . . . . . . . . . . . . . . . 0
5/6. . . . . . . . . . . . . . . . . . . . . . . 0
MMS-10
1/2. . . . . . . . . . . . . . . . . . . . . . . 0
3 – 24 . . . . . . . . . . . . . . . . . . . . 0
Export Classification C, ECCN EAR99
25 JUN 2019 Rev. 16 E/F
CUSTOMER FEEDBACK
RETURN VIA FAX TO PRODUCT SUPPORT ENGINEERING (450) 433-0272
Manual Title: ___________________________________________________________
Manual Number (if assigned): _____________________________________________
Date of Issue: ___________________________________________________________
Date of Last Revision: ___________________________________________________
Section, Chapter, Paragraph Affected: ______________________________________
Your Feedback: ________________________________________________________
_______________________________________________________________________
_______________________________________________________________________
_______________________________________________________________________
Now Reads: ____________________________________________________________
_______________________________________________________________________
_______________________________________________________________________
_______________________________________________________________________
Should Read: ___________________________________________________________
_______________________________________________________________________
_______________________________________________________________________
_______________________________________________________________________
_______________________________________________________________________
Your Name: _____________________________________________________________
Address: _______________________________________________________________
_______________________________________________________________________
Position: __________________________ Telephone No.: _______________________
Company: _______________________________ Fax No.: _______________________
Reference No. (your initials and date): _____________________________________
(If you choose to mail this form, fold in thirds with address exposed, tape and mail.)
TAPE HERE
From
POSTAGE
NECESSARY
Product Support Engineering
12,800 rue de l’Avenir
Mirabel, Québec, Canada, J7J 1R4
FOLD ON DOTTED LINES AND TAPE
TAPE HERE
Export Classification C, ECCN EAR99
IMPORTANT
HELICOPTER SALES NOTICE
Please complete this form and return by mail, e-mail (publications@bHOOIOLJKW.com), or fax
(817-280-6466, Attention: CPDC). This will ensure that the new owners/operators receive
updates to their BellHelicopter Textron Technical Manuals and Bulletins.
Model of Helicopter Sold or Purchased ___________________________________________
Serial and Registration Number _________________________________________________
Name of New Owner (company or individual) ______________________________________
Name of New Operator _______________________________________________________
Future Publications to be mailed to this address:
Address ____________________________________________________________________
City _______________________________________________________________________
State/Province _______________________________________________________________
Zip/Postal Code _____________________________________________________________
Country ____________________________________________________________________
Fax No. ___________________________ Telephone No. ____________________________
E-mail Address ______________________________________________________________
Register for access to electronic publications at www.bellIOLJKW.FRP
Export Classification C, ECCN EAR99
TAPE HERE
From
NO POSTAGE
NECESSARY
IF MAILED
IN THE
UNITED STATES
COMMERCIAL PUBLICATION DISTRIBUTION CENTER
P.O. BOX 482
FORT WORTH, TEXAS 76101-0482
FOLD ON DOTTED LINES AND TAPE
BUSINESS REPLY MAIL
FIRST CLASS PERMIT NO. 1744 FORT WORTH, TEXAS
Export Classification C, ECCN EAR99
BHT-206A/B-SERIES-MM-1
SPARE PARTS WARRANTY
ONE YEAR/1,000 HOURS PRORATED
WARRANTY AND REMEDY: Seller warrants each new helicopter part or helicopter part reconditioned by seller to be free from defect
in material and workmanship under normal use and service and if installed on Bell model helicopters. Seller’s sole obligation under this
warranty is limited to replacement or repair of parts which are determined to Seller’s reasonable satisfaction to have been defective
with 1,000 hours of operation or one (1) year after installation, whichever occurs first and reimbursement of reasonable freight charges.
After 200 hours of use, there will be a prorated charge to the Purchaser for replacement parts (prorating the hours of total use against
the then applicable part life or 2,000 hours, whichever is the lesser). Defective parts must be reported in writing to the Seller’s Warranty
Administration within 90 days of being found defective. Replacement of parts may be with either new or reconditioned parts, at Seller’s
election. Warranty adjustment is contingent upon the Purchaser complying with the Warranty Remedies as described in the
Commercial Warranty Information brochure and the Seller’s Warranty Administration disposition instructions for defective parts. Failure
to comply with all of the terms of this paragraph may, at Seller’s sole option, void this warranty.
NOTE: Parts, components and assemblies of all new helicopters may have been restored or reworked due to mars, blemishes, dents
or other irregularities during the manufacturing process. Such restoration and/or rework is permitted under Seller’s approved
manufacturing and engineering processes and guidelines. The restoration and/or rework so completed does not render such items
defective in material or workmanship.
THIS WARRANTY IS GIVEN AND ACCEPTED IN PLACE OF (i) ALL OTHER WARRANTIES OR CONDITIONS, EXPRESS OR
IMPLIED, INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OR CONDITIONS OF MERCHANT ABILITY AND
FITNESS FOR A PARTICULAR PURPOSE AND (ii) ANY OBLIGATION, LIABILITY, RIGHT, CLAIM OR REMEDY IN CONTRACTOR
IN TORT (DELICT), INCLUDING PRODUCT LIABILITIES BASED UPON STRICT LIABILITY, NEGLIGENCE, OR IMPLIED
WARRANTY IN LAW.
This warranty is the only warranty made by Seller. The Purchaser’s sole remedy for a breach of this warranty or any defect in a part is
the repair or replacement of helicopter parts and reimbursement of reasonable freight charges as provided herein. Seller excludes
liability, whether as a result of a breach of contract or warranty, negligence or strict product liability, for incidental or consequential
damages, including without limitation, damage to the helicopter or other property, costs and expenses resulting from required changes
or modifications to helicopter components and assemblies, changes in retirement lives and overhaul periods, local customs fees and
taxes, and costs or expenses for commercial losses or lost profits due to loss of use or grounding of helicopters or otherwise.
Seller makes no warranty and disclaims all liability in contract or in tort (delict), including, without limitation, negligence and strict tort
(delictual) liability, with respect to work performed by third parties at Purchaser’s request and with respect to engines, engine
accessories, batteries, radios, and avionics, except Seller assigns each manufacturer’s warranty to Purchaser to the extent such
manufacturer’s warranty exists and is assignable.
This warranty shall not apply to any helicopter part which has been repaired or altered outside Seller ’s factory in any way so as, in
Seller’s judgment, to affect its stability, safety or reliability, or which has been subject to misuse, negligence or accident, or which has
been installed in any aircraft which has been destroyed unless that helicopter has been rebuilt by Bell. A list of destroyed aircraft is
obtainable from Bell Product Support. Repairs and alterations which use or incorporate parts and components other than genuine Bell
parts or parts approved by Bell for direct acquisition from sources other than Bell itself are not warranted by Bell, and this warranty shall
be void to the extent that such repairs and alterations, in Seller’s sole judgment, affect the stability, safety or reliability of the helicopter
or any part thereof, or damage genuine Bell or Bell-approved parts. No person, corporation or organization, including Bell Customer
Service Facilities, is authorized by Seller to assume for it any other liability in connection with the sale of its helicopters and parts.
NO STATEMENT, WHETHER WRITTEN OR ORAL, MADE BY ANY PERSON, CORPORATION OR ORGANIZATION, INCLUDING
BELL CUSTOMER SERVICE FACILITIES MAY BE TAKEN AS A WARRANTY NOR WILL IT BIND SELLER.
Seller makes no warranty and disclaims all liability with respect to components or parts damaged by, or worn due to, corrosion. Seller
makes no warranty and disclaims all liability for consumables (wear items) which are defined as items required for normal and routine
maintenance or replaced at scheduled intervals shorter than the warranty period. “Consumables” include but are not limited to engine
and hydraulic oil, oil filters, packings and o-rings, anti-corrosion and/or sealing compounds, brush plating material, nuts, bolts, washers,
screws, fluids, compounds, and standard aircraft hardware that is readily available to aircraft operators from sources other than Seller.
All legal actions based upon claims or disputes pertaining to or involving this warranty including, but not limited to, Seller’s denial of any
claim or portion thereof under this warranty, must be filed in the courts of general jurisdiction of Tarrant County, Texas or in the United
States District Court for the Northern District of Texas, Ft. Worth Division located in Ft. Worth, Tarrant County, Texas. In the event that
Purchaser files such an action in either of the court systems identified above, and a final judgment in Seller’s favor is rendered by such
court, then Purchaser shall indemnify Seller for all costs, expenses and attorneys’ fees incurred by Seller in defense of such claims. In
the event Purchaser files such a legal action in a court other than those specified, and Seller successfully obtains dismissal of that
action or transfer thereof to the above described court systems, then Purchaser shall indemnify Seller for all costs, expenses and
attorneys’ fees incurred by Seller in obtaining such dismissal or transfer.
January 2007
Export Classification C, ECCN EAR99
25 JUN 2019 Rev. 16 Warranty
TC APPROVED BHT-206A/B-SERIES-MM-1
TABLE OF CONTENTS
Paragraph Chapter/Section Page
Number Title Number Number
TABLES
Table Page
Number Title Number
Chief Engineering
Aircraft Certification
Transport Can ada
The Airworthiness Limitations Schedule is approved by the Minister and specifies the maintenance required by
any applicable airworthiness or operational rules unless an alternative program has been approved by the
Minister.
CHAPTER 4 — AIRWORTHINESS LIMITATIONS SCHEDULE
AIRWORTHINESS LIMITATIONS SCHEDULE
4-1 Airworthiness Limitations Schedule............................................... 4-00-00 3
4-1 Airworthiness Limitations Schedule.................................................................... 4
Export Classification C, ECCN EAR99
25 JUN 2019 Rev. 16 Page 1
4-00-00
BHT-206A/B-SERIES-MM-1 TC APPROVED
REVISION NO. DATE OF SIGNATURE TC SIGNATURE
Original 7 January 1998 N/A
1 21 May 2002
2N/A N/A
3N/A N/A
4N/A N/A
5N/A N/A
6 7 December 2009
7N/A N/A
8N/A N/A
9N/A N/A
10 8 April 2011
11 13 October 2011
12 1 June 2012
13 7 November 2012
4-00-00
Page 2 Rev. 16 25 JUN 2019
Export Classification C, ECCN EAR99
TC APPROVED BHT-206A/B-SERIES-MM-1
REVISION NO. DATE OF SIGNATURE TC SIGNATURE
14 N/A N/A
15 N/A N/A
16 25 JUNE 2019
Export Classification C, ECCN EAR99
4-00-00
25 JUN 2019 Rev. 16 Page 3/4
TC APPROVED BHT-206A/B-SERIES-MM-1
WARNING
WARNING
NOTE
NOTE
WARNING
AIRWORTHINESS LIMITATIONS SCHEDULE
4-1. AIRWORTHINESS LIMITATIONS
SCHEDULE
ALL REPAIR AND OVERHAUL
PROCEDURES LIVES PUBLISHED BY
BELL HELICOPTER TEXTRON,
INCLUDING COMPONENT RETIREMENT
LIFE, ARE BASED SOLELY ON THE USE
OF BELL APPROVED PARTS AND
PROCESSES. IF PARTS OR
PROCESSES DEVELOPED OR
APPROVED BY PARTIES OTHER THAN
BELL HELICOPTER ARE USED, THEN
THE DATA PUBLISHED OR OTHERWISE
SUPPLIED BY BELL HELICOPTER ARE
NOT APPLICABLE. THE USER IS
WARNED TO NOT RELY ON BELL
HELICOPTER DATA FOR PARTS AND
PROCESSES NOT APPROVED BY BELL
HELICOPTER. ALL APPLICABLE
INSPECTIONS AND REPAIR METHODS
MUST BE OBTAINED FROM THE
SUPPLIER OF THE PARTS OR
PROCESSES NOT APPROVED BY BELL
HELICOPTER. BELL HELICOPTER IS
NOT RESPONSIBLE FOR PARTS OR
PROCESSES OTHER THAN THOSE
WHICH IT HAS ITSELF DEVELOPED OR
APPROVED.
CONSPICUOUS MANNER TO PREVENT
CONTINUED USE, EVEN INADVERTENT
USE.
WHEN A REPLACEMENT PART IS
INSTALLED, THE PART NAME, PART
NUMBER, SERIAL NUMBER, AND
CURRENT OPERATING HOURS, IF
APPLICABLE, MUST BE RECORDED IN
THE HISTORICAL SERVICE RECORD
FOR THE ASSEMBLY OR HELICOPTER.
The requirements stated in Chapter 5 are to
be complied with and the appropriate
maintenance actions are to be performed.
The airworthiness life or inspection interval
for any part number contained in this
schedule applies to all the successive dash
numbers for that component unless it is
otherwise specified.
The mandatory airworthiness limitations schedule
(Table 4-1) summarizes the mandatory maximum life,
in hours, years (months) or by Retirement Index
Number (RIN) of components with a limited
airworthiness life. Parts that are not on the schedule
have an unlimited airworthiness life.
Refer to the engine manufacturer's publications for the
airworthiness limitations schedule of the engine and
components.
CONTINUED USE OF ANY TIME/
CALENDAR/RIN LIFE LIMITED
COMPONENT PAST ITS STATED LIMITS
IS NOT PERMITTED AS IT COULD
SERIOUSLY AFFECT THE
AIRWORTHINESS OF THE HELICOPTER.
THE COMPONENT MUST BE REMOVED
FROM THE HELICOPTER NOT LATER
THAN THE END OF THE LIFE LIMIT. IT
MUST EITHER BE MADE
UNSERVICEABLE OR MARKED IN A
Export Classification C, ECCN EAR99
SOME PARTS ARE INSTALLED AS
ORIGINAL EQUIPMENT ON BOTH
MILITARY AND COMMERCIAL
HELICOPTERS AND MAY HAVE A
LOWER AIRWORTHINESS LIFE AND/OR
OVERHAUL SCHEDULE WHEN USED
ON A MILITARY HELICOPTER. IN
ADDITION, CIRCUMSTANCES
4-00-00
25 JUN 2019 Rev. 16 Page 5
BHT-206A/B-SERIES-MM-1 TC APPROVED
CAUTION
NOTE
1
2
3
6
192019
SURROUNDING THEIR USE MAY CALL
FOR OPERATION OF THE MILITARY
HELICOPTER OUTSIDE OF THE
APPROVED COMMERCIAL FLIGHT
ENVELOPE. CONSEQUENTLY, PARTS
THAT HAVE BEEN USED ON MILITARY
HELICOPTERS SHOULD NOT BE USED
ON COMMERCIAL HELICOPTERS.
AIRWORTHINESS LIFE OF SOME KIT
COMPONENTS MAY NOT BE COVERED
IN THIS SCHEDULE. REFER TO
APPLICABLE SERVICE INSTRUCTION
(SI) OR MAINTENANCE MANUAL
SUPPLEMENT (MMS) FOR KIT
COMPONENTS’ SCHEDULE.
Agreement for the helicopter or the
component.
The airworthiness lives given to the components and
assemblies are determined by experience, tests and
the judgment of Bell Helicopter engineers. The
airworthiness lives and inspection intervals cannot be
changed without the approval of the Minister of
Transport Can ada.
Prior to disposing of unsalvageable helicopter parts
and materials, caution should be exercised to ensure
that the parts and materials are disposed of in a
manner that does not allow them to be returned for
service. Refer to FAA Advisory Circular 21-38 for
guidance on the disposal of unsalvageable helicopter
parts and materials.
The airworthiness life given or the failure to
give an airworthiness life to a component
does not constitute a warranty of any kin d.
The only warranty applicable to the
helicopter or any component is the
warranty included in the Purchase
Table 4-1. Airworthiness Limitations Schedule
COMPONENT
PART NUMBER
AIRWORTHINESS LIFE
MAIN ROTOR HUB AND BLADES
Main Rotor Yoke 206-010-101-001/-009/-013/
10 years
-019/-021
Main Rotor Grip 206-010-102-009/-013/-117/-121 4800 hours
Main Rotor Trunnion 206-010-104-003 2400 hours
Tension Torsion Strap 206-010-105-003/-005
Strap Retention Pin 206-010-123-001 100 hours
Strap Retention Pin 206-010-123-003 1200 hours
Strap Retention Fitting 206-010-155-007 100 hours
4-00-00
Page 6 Rev. 16 25 JUN 2019
Export Classification C, ECCN EAR99
TC APPROVED BHT-206A/B-SERIES-MM-1
1
4438273
16
43
5
7
267261722
1746422332
39
Table 4-1. Airworthiness Limitations Schedule (Cont)
COMPONENT
PART NUMBER
AIRWORTHINESS LIFE
MAIN ROTOR HUB AND BLADES (CONT)
Strap Retention Fitting 206-010-155-011/-015 1200 hours
Latch Bolt 206-010-169-001/-003
Main Rotor Blade 206-010-200-029
Main Rotor Blade 206-010-200-033/-133/-137/
5000 hours
-139/-141/-145/-149/-151/-153
Main Rotor Trunnion 206-011-113-001 2400 hours
Main Rotor Trunnion 206-011-113-103/-105 4800 hours
Latch Bolt 206-011-122-003
Strap Retention Fitting 206-011-124-001 2400 hours
Strap Retention Pin 206-011-125-001 1200 hours
Strap Retention Pin 206-011-125-105 2500 hours
Main Rotor Grip 206-011-132-009/-113 4800 hours
Strap Retention Fitting 206-011-140-001 1200 hours
Tension Torsion Strap 206-011-147-001/-003/-005/-007 1200 hours/24 months
Strap Retention Fitting 206-011-150-101/-105 2400 hours
Tension Torsion Strap 206-011-154-101/-103/-105/-107 1200 hours/24 months
Latch Bolt 206-011-260-101 1200 hours
Latch Bolt 206-011-260-103 2500 hours
Tension Torsion Strap 206-310-004-101/-103 1200 hours/48 months
SWASHPLATE AND SUPPORT
Upper Collective Tube 206-001-024-017/-027 4800 hours
Lower Collective Tube 206-001-194-001 4800 hours
Lower Cyclic Tube 206-001-194-005 Unlimited
Lower Cyclic Tube 206-001-194-101 15,000 hours
Bellcrank Support 206-001-521-005/-006
Bellcrank Support 206-001-521-013/-014
4-00-00
25 JUN 2019 Rev. 16 Page 7Export Classification C, ECCN EAR99
BHT-206A/B-SERIES-MM-1 TC APPROVED
1
23930303030333114
34
24
Table 4-1. Airworthiness Limitations Schedule (Cont)
COMPONENT
PART NUMBER
AIRWORTHINESS LIFE
SWASHPLATE AND SUPPORT (CONT)
Lower Collective Tube 206-001-524-001/-011/-015 4800 hours
Servo Actuator Support 206-001-566-001/-10 1 10,000 hours
Servo Actuator Support 206-001-566-105 5000 hours
Collective Idler Link 206-010-407-001 4800 hours
Collective Idler Link 206-010-446-107 14,400 hours
Swashplate Duplex Bearing 206-010-420-001/-003 1200 hours
Swashplate Support Assembly 206-010-452-001/-005/-109 4800 hours
Swashplate Support Assembly 206-010-452-113 Unlimited
Swashplate Sleeve Assembly 206-010-454-001/-005 4800 hours
Swashplate Sleeve Assembly 206-010-454-109/-113 14,400 hours
Collective Lever 206-010-447-109 14,400 hours
Collective Lever 206-010-467-001/-105 4800 hours
Servo Actuator 206-076-023-001/-003 875 hours
Servo Actuator 206-076-024-ALL 875 hours
Servo Actuator 41 103750/-2 875 hours
Servo Actuator 41 103650-005 875 hours
POWER TRAIN
Mast 206-010-332-001 1200 hours
Spider 206-040-041-001 500 hours
Tail Rotor Gearbox Duplex Bearing 206-040-410-003/-005/-101 3000 hours
Sun Gear 206-040-662-101
Oil Cooler Fan Impeller 206-061-432-011
Freewheel Clutch CL41742/-1 3000 hours
Freewheel Clutch CL42250-1 3000 hours
Freewheel Clutch X136028 1200 hours
Oil Cooler Fan Impeller SPL610-216 1200 hours
4-00-00
Page 8 Rev. 16 25 JUN 2019
Export Classification C, ECCN EAR99
TC APPROVED BHT-206A/B-SERIES-MM-1
1
10
11
111111
121812252828292137
213638
35
41
40
40
Table 4-1. Airworthiness Limitations Schedule (Cont)
COMPONENT
PART NUMBER
AIRWORTHINESS LIFE
TAIL ROTOR HUB AND BLADES
Tail Rotor Blade 206-010-750-003/-005/-007
Tail Rotor T runnion 206-010-776-001 2400 hours
Tail Rotor Yoke 206-010-788-001 1200 hours
Tail Rotor Yoke 206-011-802-001 1200 hours
Tail Rotor Trunnion 206-011-803-001/-005 2400 hours
Tail Rotor Yoke 206-011-811-001/-005
Tail Rotor Yoke 206-011-811-009 4800 hours
Tail Rotor Yoke 206-011-811-123/-125 1800 hours
Tail Rotor Yoke 206-011-819-101/-105/-109 5000 hours
Tail Rotor Blade 206-016-201-001/-103/-107/
2400 hours
-113/-115
Tail Rotor Blade 206-016-201-125/-127/-131/
2500 hours
-133/-135/-137
Tail Rotor Blade 206-016-501-001 200 hours
MISCELLANEOUS
Landing Gear Crosstube Assembly 206-050-107-ALL
Emergency Lightweight Flotation
206-050-107-025/-027/-119/-121
Landing Gear Crosstube Assembly
Landing Gear Crosstube Assembly 206-050-119-AL L
Emergency Flotation Landing Gear
Crosstube Assembly
Fixed Float Landing Gear
206-050-134-001/-003/-005/
-007/-011/-105
206-050-157-001/-003
Crosstube Assembly
Fixed Float Landing Gear
206-050-169-001/-003
Crosstube Assembly
Emergency Floats Cylinder 206-073-818-001 10 years
Emergency Floats Cylinder 206-073-839-103 15 years
Emergency Floats Cylinder 206-073-848-113/
15 years
-121 (1271226)
4-00-00
Export Classification C, ECCN EAR99
25 JUN 2019 Rev. 16 Page 9
BHT-206A/B-SERIES-MM-1 TC APPROVED
1
4141414140
404015
44
45131
2
3
Table 4-1. Airworthiness Limitations Schedule (Cont)
COMPONENT
PART NUMBER
AIRWORTHINESS LIFE
MISCELLANEOUS (CONT)
Emergency Floats Cylinder 206-073-919-001/-003/-005/-007 10 years
Emergency Floats Cylinder 206-073-922-101 10 years
Emergency Floats Cylinder 206-073-929-003/-101/-103 10 years
Emergency Floats Cylinder 206-073-930-101 10 years
Emergency Floats Cylinder 1269556-3/-4 15 years
Emergency Floats Cylinder 23711982 15 years
Emergency Floats Cylinder 274645 15 years
Squib, Emergency Floats 94455 15 years
Squib, Emergency Floats 29022968 15 years
Hoist Cable Cutter Assembly Y-1265-11-1
POWER PLANT
Turboshaft Engine 250-C18 Series Refer to Rolls-Royce 250-C18 Series
Operation and Maintenance Manual,
5W2
Turboshaft Engine 250-C20 Series Refer to Rolls-Royce 250-C20 Series
Operation and Maintenance Manual,
10W2
AIRFRAME
Pylon Support Link 206-031-508-005/-007
NOTES:
Airworthiness limitation for part number listed applies to all successive dash numbers for that component
unless otherwise specified.
Main rotor yokes 206-010-101-125/-129 are not listed and are conditional. All yokes listed have a 10-year
airworthiness life. Yokes in use as of 17 July 1979, with less than 5 years in service, shall be remove d after
10 years. Yokes in use as of 17 July 1979, with more than 5 years in service, will have been removed by
1 January 1984. Refer to ASB 206-79-4, dated 17 July 1979.
Main rotor trunnions 206-010-104 and 206-011-113-001 with more than 2400 hours in service, or time in
use unknown, will have been removed from service by 1 September 1981. Refer to ASB 206-80-7 Rev. B,
dated 15 October 1980.
4-00-00
Page 10 Rev. 16 25 JUN 2019
Export Classification C, ECCN EAR99
TC APPROVED BHT-206A/B-SERIES-MM-1
4
6
5
A1-00001 A1-00029 A1-00050 A1-00077 A1-00099 A1-00132
A1-00004 A1-00031 A1-00053 A1-00078 A1-00100 A1-00133
A1-00005 A1-00032 A1-00054 A1-00080 A1-00101 A1-00134
A1-00006 A1-00033 A1-00055 A1-00083 A1-00103 A1-00135
A1-00007 A1-00034 A1-00056 A1-00084 A1-00104 A1-00136
A1-00009 A1-00035 A1-00057 A1-00085 A1-00105 A1-00192
A1-00010 A1-00036 A1-00059 A1-00086 A1-00106 A1-00222
A1-00014 A1-00038 A1-00061 A1-00087 A1-001 1 1 A1-00248
A1-00016 A1-00039 A1-00062 A1-00088 A1-00113 A1-00287
A1-00017 A1-00040 A1-00064 A1-00089 A1-00115 A1-00300
A1-00019 A1-00042 A1-00066 A1-00090 A1-00116 A1-00305
A1-00021 A1-00043 A1-00067 A1-00091 A1-00118 A1-00308
A1-00022 A1-00044 A1-00068 A1-00092 A1-00119
A1-00023 A1-00046 A1-00071 A1-00093 A1-00120
A1-00024 A1-00047 A1-00073 A1-00095 A1-00124
A1-00027 A1-00048 A1-00074 A1-00096 A1-00130
A1-00028 A1-00049 A1-00075 A1-00098 A1-00131
6
7
8
Table 4-1. Airworthiness Limitations Schedule (Cont)
NOTES (CONT):
Strap retention fittings 206-010-155-011/-015 will have been removed from service no later than
1 January 1979. Refer to ASB 206-76-7, dated 13 August 1976 and note .
Main rotor grip 206-011-132-009, with serial numbers listed below, have a 1200-hour airworthiness life.
The serial numbers not listed below have a 4800-hour airworthiness life. These parts are originally
delivered on Bell 206L1, but could have found their way to the 206A/B series. Refer to ASB 206L-80-15,
dated 29 July 1980.
Tension torsion straps 206-010-105-003/-005 will have been removed from service no later than
1 January 1979. Refer to ASB 206-78-1, dated 14 April 1978 and FAA AD 78-11-02 R1, dated
15 December 1988.
Tension torsion straps 206-011-147 and 206-011-154 have airworthiness lives of 1200 hours or 24
months, whichever occurs first. The calendar life of 24 months starts when new straps ar e installed in a
main rotor hub and blade assembly, and are subjected to rotation on the helicopter. Refer to ASB
206-80-9, dated 3 June 1980.
Main rotor blade 206-010-200-029 will have been retired no later than 31 March 1976. Refer to
ASB 206-75-10, dated 13 November 1975.
Export Classification C, ECCN EAR99
25 JUN 2019 Rev. 16 Page 11
4-00-00
BHT-206A/B-SERIES-MM-1 TC APPROVED
9
101110
12
10
13
14
15
16171819202122
23
Table 4-1. Airworthiness Limitations Schedule (Cont)
NOTES (CONT):
Swashplate supports 206-010-452-001/-005/-10 9 with more than 1500 hours in service are subjected to
a visual inspection every 50 hours. The supports may remain in service until a crack is found or until a
total of 4800 hours time in service is accumulated. Refer to ASB 206-93-74 Rev. B, dated 4 April 1994.
Tail rotor blade 206-010-750 will have been retired no later than 1 July 1981. Refer to ASB 206-80-12,
dated 9 September 1980.
Tail rotor yokes 206-010-788, 206-011-802 and trunnions 206-010-776-001, 206-011-803-001 are not
authorized after 1 July 1981. Yokes are to be replaced concurrently with the replacement of tail rotor
blade 206-010-750. See also note . Refer to ASB 206-75-4, dated 15 May 1975.
Tail rotor yokes 206-011-811-001/-005 are not authorized after 1 July 19 8 1. Yokes were reidentified as
206-011-811-123/-125 concurrently with the replacement of tail rotor blade 206-010-750. Yokes that
have been reidentified have an 1800-hour airworthiness life starting with the reidentification. Refer also
to note .
Aluminum links 206-031-508-005/-007 have been removed from service. Refer to ASB 206-01-73-6,
dated 19 September 1973 and FAA AD 73-8-3, dated 18 April 1973.
Duplex bearings 206-040-410-001/-103 installed in tail rotor gearbox 206-040-400-(ALL) are
conditional. Duplex bearings 206-040-410-003/-005/-101 installed in tail rotor gearbox
206-040-402-(ALL) have a life of 3000 hours.
Part of squib assembly 30908. Retire squib no later than 15 years after date of manufacture . Dispose of
time expired squib in accordance with local regulations.
Selected serial numbers of main rotor trunnion 206-011-113-103 will have been removed from service
no later than 30 November 1994. Refer to ASB 206-94-80, dated 5 August 1994 for list of serial
numbers affected.
Latch bolts 206-011-260-101/-103 that have a serial number with the prefix “SC”, purchased as spares
will have been removed from service no later than 3 December 1992. Refer to ASB 206-92-70, dated
3 December 1992.
Selected serial numbers of tail rotor hub assemblies 206-011-810-015 and tail rotor yokes
206-011-811-009 must be removed from service. Refer to ASB 206-89-47 Rev . A, dated
29 August 1989 for list of serial numbers affected.
Strap retention pin 206-010-123-001 and fitting 206-010-155-007 have been removed from service.
Refer to FAAAD 72-19-1, dated 7 September 1972.
Refer to ASB 206(04-1)-73-1, dated 25 June 1973.
Crosstube assemblies 206-050-107-(ALL) and 206-050-119-(ALL) must be removed from service.
Refer to ASB 206-94-78, dated 11 April 1994.
Usable only with main rotor hub 206-011-100-127. Refer to TB 206-91-133 Rev. A, dated 1 July 1998.
Usable only on model 206B, S/N 5101 and subsequent. These part numbers are reserved for US Army ,
model TH-67 training helicopters. Refer to ASB 206-96-87 Rev. A, dated 22 March 1996.
4-00-00
Page 12 Rev. 16 25 JUN 2019
Export Classification C, ECCN EAR99
TC APPROVED BHT-206A/B-SERIES-MM-1
2425262728293031323334
353637
38
Table 4-1. Airworthiness Limitations Schedule (Cont)
NOTES (CONT):
Oil cooler impeller 206-061-432-011 will have been removed from service no later than 1 March 1978.
Refer to ASB 206-77-10 Rev. A, dated 21 February 1978.
Selected serial numbers of tail rotor yokes 206-011-819-101 must be removed from service. Refer to
ASB 206-88-41, dated 28 January 1988 for list of serial numbers affected.
Selected serial numbers of tension torsion straps 206-011-147-007 and 206-011-154-101/-105 must be
removed from service. Refer to ASB 206-89-46 Rev. A, dated 29 August 1989 for list of serial numbers
affected.
Selected serial numbers of main rotor blades 2 06-010-200 -033 must be removed from service. Refe r to
ASB 206-89-50 Rev. A, dated 29 November 1989 for list of serial numbers affected.
Selected serial numbers of tail rotor blades 206-016-201-113/-127 must be remove d from service. Refer
to ASB 206-90-57, dated 27 June 1990 for list of serial numbers affected.
Selected serial numbers of tail rotor blades 2 06-016-201-125/-12 7 must be removed from service. Re fer
to ASB 206-90-58 Rev. A, dated 31 October 1990 for list of serial numbers affected.
Refer to ASB 206A-12 Rev. A, dated 8 April 1970. Servo actuator 206-076-023 is equivalent to
Hydraulic Research part number 41103750 and servo actuator 206-076-024 is equivalent to Hydraulic
Research part number 41103650.
Refer to ASB 206A-14 Rev. A, dated 8 April 1970.
Cyclic control bellcrank support assembly 206-001-521-005/-006 will have been removed from service
no later than 15 July 1969. Refer to ASB 206A-11 Rev. B, dated 29 September 1969.
Masts 206-010-332-005/-009/-013/-017/-121 a re not listed and are cond itional. Selected serial numbers
of main rotor mast 206-010-332-121 will have been returned to Bell Helicopter Textron for metallurgical
evaluation no later than 31 May 1987. Affected masts inspected at BHT and found to be acceptable
have a suffix “U” added to the serial number. Refer to ASB 206-87-37, dated 23 April 1987 for list of
serial numbers affected.
Selected serial numbers of sun gear 206-040-662-101 will have been removed from service no later
than 15 January 1991. Refer to ASB 20 6-90-56 Rev. A, dated 15 January 1991 for list of serial numbers
affected.
Fixed float landing gear crosstubes 206-050-169-001/-003 must be removed from service. Refer to
ASB 206-94-81 Rev. A, dated 17 August 1994.
Emergency flotation landing gear crosstubes 206-050-134-001/-003/-005/-007/-011/-103/-105 must be
removed from service. Refer to ASB 206-94-82 Rev. A, dated 17 April 1995.
Emergency lightweight flotation landing gear crosstubes 206-050-107-025/-027/-119/-121 must be
removed from service. Refer to ASB 206-94-83, dated 6 September 1994.
Fixed float landing gear crosstubes 206-050-157-001/-003 must be removed from service. Refer to
ASB 206-96-88, dated 3 June 1996.
4-00-00
Export Classification C, ECCN EAR99
25 JUN 2019 Rev. 16 Page 13
BHT-206A/B-SERIES-MM-1 TC APPROVED
394041
42
43
444546
Table 4-1. Airworthiness Limitations Schedule (Cont)
NOTES (CONT):
Usable only on model 206A, S/N 5001 through 5040. These part numbers are reserved for US Army,
model TH-57 training helicopters.
Cylinder per DOT-3HT and DOT-E7218 specifications. Refer to IL GEN-93-52, dated 21 June 1993.
Cylinder per FAA specifications. Refer to IL GEN-93-52, dated 21 June 1993.
Upper collective tube 206-001-024-029 is not listed and is conditional.
Main rotor latch bolts 206-010-169-001/-003 and 206 -011-122-003 must be remove d from service.
Refer to ASB 206-06-109, dated 25 July 2006, and Transport Canada AD CF-2006-23, dated
6 November 2006.
Part of squib assembly 29022971 and approved alternate for squib 30908. Retire squib no later than
15 years after date of manufacture. Dispose of time expired squib in accordance with local regulations.
Storage life of cutter assembly Y-1265-11-1, in original sealed container, is set at 60 months. Service life
is 36 months from the time the cutter assembly is removed from the original sealed container. The
36-month service life must be contained within the 60 -month storag e life. Dispose of time e xpired squ ib
in accordance with local regulations.
Example 1 – Cutter assembly stored for 24 months: 60 - 24 = 36-month service life.
Example 2 – Cutter assembly stored for 48 months: 60 - 48 = 12-month service life.
Example 3 – Cutter assembly stored for 1 month: 60 - 1 = 59 months, reduced to 36 months maximum
service life.
Main rotor hub tension torsion straps 206-310-004 have an airworthiness life of 1200 hours or 48
months, whichever occurs first. The calendar life of 48 months starts when new straps are insta lled in a
main rotor hub and blade assembly, and are subjected to rotation on the helicopter.
4-00-00
Page 14 Rev. 16 25 JUN 2019 Export Classification C, ECCN EAR99
Loading...