Page 1
46cm Kettle Charcoal BBQ
Assembly instructions
www.tesco.com
Ref No.: RSH - 245585
Catalogue No.: 186-6220
Product size assembled :
W545 X D535 x H960 mm
Please retain this manual
for future reference
Front.pdf 12/11/11 15:11:56
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
Page 2
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
www.tesco.com
P2. pdf 15/ 11/ 11 09: 13: 24
Warnings
Before you start
REMEMBER - DO NOT USE INDOORS! FOR OUTDOOR USE ONLY.
Great care has been taken during production to remove sharp
edges but you should handle all components with care to avoid
possible injury.
• Keep a fire extinguisher handy.
• Hot fat may drip out at the bottom of the fire bowl so keep your
feet clear.
• If fire flares up due to dripping fat, douse flames lightly with
fine water spray.
• D O NO T
touch metal parts of the BBQ until it has completely
cooled to avoid burns. BBQ handles will be hot and unsafe to
touch during use, unless you are wearing protective gear
(pot holders, gloves, BBQ mittens, hot pad etc).
• Never handle charcoal after lighting.
• Ensure the coals have completely burnt before removing the
ash.
• Not to be installed in or on recreational vehicles and/or boats.
• Store away ONLY when barbecue is completely extinguished
and cool.
• In construction of this BBQ use all and only the components
provided.
• C
AUTION! Do not use spirit or petrol for lighting or relighting!
Use only firelighters complying to EN1860-3.
• C
AUTION! Keep well away from heat sensitive materials and
objects.
• After use, extinguish and allow cooling.
• Only store away when thoroughly cool and extinguished.
• C
AUTION! To avoid damage to property, ALWAYS place this
appliance on a surface which is suitably heat resistant as this
appliance will get extremely hot during operation.
• C
AUTION! To avoid injury be aware that the resting surface
directly underneath this appliance will get very hot during
operation and will remain very hot for sometime afterwards -
keep feet, other limbs and all property/item well away from
this area.
• Attention! This barbecue will become very hot do not move
it during operation.
• Warning: Keep children and pets away.
• C
AUTION! This is a squat barbecue, place where it will be
visible and will not present a trip hazard.
Do’s
Stand your barbecue on a safe, level surface, well away from
flammable items such as wooden fences or over-hanging
tree branches.
Keep children and pets away.
An adult should always be in charge of the BBQ. NEVER leave a
hot barbecue unattended.
Be careful of sharp edges during assembly.
Dont’s
CAUTION! Do not use spirit or petrol for lighting or re-lighting!
Use only firelighters complying to EN1860-3.
A
TTENTION! Once lit DO NOT move your BBQ or leave it
unattended.
Always make sure the barbecue is fully extinguished and
completely cool before applying any covers (not included) OR
storing away – remember coals can remain hot for sometime and
could re-ignite under certain conditions UNLESS fully damped
down and/or extinguished.
C
AUTION! NEVER STORE a barbecue indoors unless ALL coals and
ash have been thoroughly removed and thrown away outdoors
and all barbecue surfaces have been cleaned and are cool, as
otherwise this could lead to fire and/or emissions of poisonous
gases which could cause death.
Number of people required to assemble
One person to assemble rectangular BBQ
Time to assemble
30 minutes
Tradesman’s tips
“Hi, look out for me throughout this manual. Wherever you see
my picture I will have a handy tip to help you with the assembly of
your product”.
My first tip is: “Before you start get a cup of tea, sit down and
read through these instructions carefully”.
And for good measure my second tip is that you will need the
following tools to assemble this product, so gather them to hand
before you start
Tools required (not included)
2
46cm Kettle Charcoal BBQ
Assembly instructions
Page 3
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
www.tesco.com
P3. pdf 14/ 11/ 11 14: 50: 23
Instructions for use
Barbecue should be heated up and the fuel kept red hot for at least
30 min prior to the first cooking on the barbecue.
Method 1 - Charcoal & Lighting Fluid/Gel Follow Charcoal & Lighting
Fluid/Gel product instructions and warnings (not included)
• Set up your barbecue in a safe place with sufficient space and
make sure the barbecue is installed on a secure level base.
Place enough charcoal in the bowl to a depth of 3-5 cm.
• C
AUTION: Carefully apply lighting fluid/gel in small amounts over
the charcoal. Over application can be dangerous.
• DO N
OT spill any lighting fluid/gel onto your hands or clothes.
• Wait for 30 seconds to allow the liquid to soak into the charcoal
before lighting.
• DO N
OT light the charcoal if you have spilt fluid or gel onto your
clothes. Light the charcoal using a long taper or safety lighter.
• DO N
OT squirt liquid onto burning charcoal.
Method 2 - Lighting Blocks Follow lighting block product
instructions and warnings (not included)
• Place three or four Lighting Blocks in the centre of the barbecue
fire bowl and light with a match.
• Place pieces of charcoal around each burning block. Add more
charcoal as required, in a pyramid formation.
• When burning is established, spread the fuel out evenly. The fire
should be ready for cooking when even white ash or an even red
glow is visible.
• DO NOT cook before the fuel has a coating of ash.
• Ensure that the cooking grill is fully located into the grill supports.
Further help
Care Instructions
Follow these instructions to maintain the appearance and life of
this BBQ.
• It is not advisable to completely fill the fire bowl as the barbecue
may become far too hot to cook successfully.
• Line the fire bowl with aluminum cooking foil, shiny side up, to
make it easier to clean your barbecue after use.
Leave ventilation holes clear by piercing the foil where necessary.
This process will lengthen the life of your barbecue and reflect the
heat more efficiently on to the food.
• To clean your grill, soak the cooking grill and tools in hot soapy
water when the barbecue is completely cool as soon as possible
after use.
• When you have finished cooking, never pour cold water directly on
the coals to extinguish them as this may damage your grill. Use old
cinders, sand or a fine water spray.
• Store in a cool dry place. Ensure it is clean and dry thoroughly cool
and thoroughly cleaned of all ash and unused fuel/coals before
storage. (See Warnings)
Our Promise:
We are happy to refund or replace any Tesco product which falls
below the high standard you expect. Just ask any memeber of staff.
This does not affect your statutory rights.
We are here to help:
Tesco Stores LTD., Cheshunt EN8 9SL., U.K.
Freephone: 0844 809 4401
To view our full range of BBQ’s and covers please visit
http://direct.tesco.com
C
AUTION! To help avoid injury or damage to property, it is vitally
important that you clean and maintain your barbecue after every
Please note that you should inspect your barbecue before every use the barbecue should be clean and in good working order.
Please note that this appliance will not last forever and will begin to
degrade with use over time. It is very important that you replace your
barbecue as and when it begins to show signs of fatigue, corrosion or
damage. Please note: Continuing to use an appliance which is
damaged could cause injury or damage to property.
• Protect from severe weather conditions.
We recommend you use a BBQ cover to protect this item when not
in use. BBQ must be cooled before cover is added.
Covers must be removed periodically to minimize moisture build up
and damage to the BBQ, as most covers are not breathable.
• Some components are held at our customer service centre please
contact 0844 809 4401 if you are missing parts.
3
46cm Kettle Charcoal BBQ
Assembly instructions
Page 4
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
46cm Kettle Charcoal BBQ
Assembly instructions
www.tesco.com
Fr ont . pdf 12/ 11/ 11 15: 11: 56
Ref
Components supplied (not actual size)
Qty
VisualDescription
1
2
3
4
8
1
1
1
1
3
1
3
2
9
Fire bowl handle
Lid
Lid handle
Lid air damper
Cooking grid
5
2
1
Cooking grid handle
Gird support
6 Charcoal pan
1
7 Fire bowl
10
11
Leg support
Short leg
1
12
Long leg
Ref
Components supplied (not actual size)
Qty
VisualDescription
13
15
16
2
1
1
Hook
Wheels
14
1
Mesh base
Plate
Fixtures
4
Page 5
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
46cm Kettle Charcoal BBQ
Assembly instructions
www.tesco.com
P5.pdf 12/11/11 15:14:37
Fittings
Fittings supplied (actual size)
Visual
Description
B 1
3
Ref Qty
M5x10
A M6x45
C 6
M6x12
Fittings supplied (actual size)
Visual
Description
10
Ref Qty
F
2
E
M8
M6
D
10
1
M5
H
M6
3
G
M6
(Pre-
Assembled for user)
10
0
mm
20
30
40
50
60
70
80
90
100
110
120
130
140
150
160
170
180
190
200
210
220
230
240
250
260
270
280
(Pre-
Assembled for user)
5
Page 6
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
46cm Kettle Charcoal BBQ
Assembly instructions
www.tesco.com
P6.pdf 12/11/11 15:15:00
Getting to know your product
1
16
4
2
3
5
6
7
9
8
15
10
11
13
14
12
6
Page 7
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
46cm Kettle Charcoal BBQ
Assembly instructions
www.tesco.com
P7. pdf 14/ 11/ 11 14: 49: 55
7
11
12
1
2
C x6
6x12
F x6
6
D x6
6
A x3
6x45
G x3
6
8
10
7
F
C
D
G
A
7
Page 8
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
46cm Kettle Charcoal BBQ
Assembly instructions
www.tesco.com
P7.pdf 14/11/11 14:49:55
9
7
14
13
11
12
3
4
E x2
8
F x2
6
D x2
6
E
F
D
8
Page 9
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
46cm Kettle Charcoal BBQ
Assembly instructions
www.tesco.com
P7.pdf 14/11/11 14:49:55
1
3
2
3
16
5
6
B x1
5
H x1
5
F x2
6
D x2
6
F
B
H
D
9
Page 10
Produced in China for TESCO Stores Ltd.
©
Tesco 2013
46cm Kettle Charcoal BBQ
Assembly instructions
www.tesco.com
P7.pdf 14/11/11 14:49:55
4
6
15
5
7
8
10
Loading...