Tap Magic 90019CTC User Manual
1. Identification
www.tapmagic.com
1 / 11
SAFETY DATA SHEET
Product number
Company information
Company phone
Emergency telephone US
Emergency telephone outside
US
Version #
Recommended use
Recommended restrictions
2. Hazard(s) identification
Physical hazards
Health hazards
OSHA defined hazards
1000013157
Tap Magic Multi-Purpose Cleaner/DegreaserProduct identifier
THE STECO CORPORATION
2330 CANTRELL ROAD
LITTLE ROCK, AR 72202 United States
General Assistance 1-501-375-5644
1-800-255-3924
1-813-248-0585
01
Cleaner
None known.
Liquefied gasGases under pressure
Category 2ASerious eye damage/eye irritation
Not classified.
Label elements
Signal word
Hazard statement
Precautionary statement
Prevention
Response
Storage
Disposal
Hazard(s) not otherwise
classified (HNOC)
Supplemental information
Warning
Contains gas under pressure; may explode if heated. Causes serious eye irritation.
Wash thoroughly after handling. Wear eye protection/face protection.
If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention.
Protect from sunlight. Store in a well-ventilated place.
Dispose of waste and residues in accordance with local authority requirements.
None known.
None.
3. Composition/information on ingredients
Mixtures
CAS number %Common name and synonymsChemical name
2-Butoxyethanol
Butane
EDTA Tetrasodium Salt
Isopropyl Alcohol
N-Alkyl-N,N-Dimethyl-N-Benzylam
monium
Propane
Other components below reportable levels 80 - 90
*Designates that a specific chemical identity and/or percentage of composition has been withheld as a trade secret.
Product name: Tap Magic Multi-Purpose Cleaner/Degreaser
Product #: 1000013157 Version #: 01 Issue date: 10-07-2016
Chloride
111-76-2
106-97-8
64-02-8
67-63-0
68391-01-5
74-98-6
2.5 - 10
1 - 2.5
1 - 2.5
1 - 2.5
0.1 - 1
0.1 - 1
SDS US
4. First-aid measures
with water to prevent vapor pressure build up. For massive fire in cargo area, use unmanned hose
Avoid discharge into drains, water courses or onto the ground.
2 / 11
Inhalation
Skin contact
Eye contact
Ingestion
Most important
symptoms/effects, acute and
delayed
Indication of immediate
medical attention and special
treatment needed
General information
5. Fire-fighting measures
Suitable extinguishing media
Unsuitable extinguishing
media
Move to fresh air. Call a physician if symptoms develop or persist.
Wash off with soap and water. Get medical attention if irritation develops and persists.
Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention.
Not likely, due to the form of the product. In the unlikely event of swallowing contact a physician or
poison control center. Rinse mouth.
Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred
vision.
Provide general supportive measures and treat symptomatically. Keep victim under observation.
Symptoms may be delayed.
Ensure that medical personnel are aware of the material(s) involved, and take precautions to
protect themselves.
Water fog. Foam. Dry chemical powder. Carbon dioxide (CO2).
None known.
Specific hazards arising from
the chemical
Special protective equipment
and precautions for firefighters
Fire fighting
equipment/instructions
Specific methods
General fire hazards
During fire, gases hazardous to health may be formed.
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.
In case of fire: Stop leak if safe to do so. Do not move cargo or vehicle if cargo has been exposed
to heat. Move containers from fire area if you can do so without risk. Containers should be cooled
holder or monitor nozzles, if possible. If not, withdraw and let fire burn out.
Cool containers exposed to flames with water until well after the fire is out.
Contents under pressure. Pressurized container may explode when exposed to heat or flame.
6. Accidental release measures
Personal precautions,
protective equipment and
emergency procedures
Methods and materials for
containment and cleaning up
Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of
low areas. Many gases are heavier than air and will spread along ground and collect in low or
confined areas (sewers, basements, tanks). Wear appropriate protective equipment and clothing
during clean-up. Emergency personnel need self-contained breathing equipment. Do not touch
damaged containers or spilled material unless wearing appropriate protective clothing. Ventilate
closed spaces before entering them. Local authorities should be advised if significant spillages
cannot be contained. For personal protection, see section 8 of the SDS.
Refer to attached safety data sheets and/or instructions for use. Stop leak if you can do so without
risk. Move the cylinder to a safe and open area if the leak is irreparable. Isolate area until gas has
dispersed. Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area).
Keep combustibles (wood, paper, oil, etc.) away from spilled material. Cover with plastic sheet to
prevent spreading. Absorb in vermiculite, dry sand or earth and place into containers. Following
product recovery, flush area with water.
Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to
remove residual contamination. For waste disposal, see section 13 of the SDS.
Environmental precautions
Product name: Tap Magic Multi-Purpose Cleaner/Degreaser
Product #: 1000013157 Version #: 01 Issue date: 10-07-2016
SDS US
7. Handling and storage
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
US. ACGIH Threshold Limit Values
US. NIOSH: Pocket Guide to Chemical Hazards
3 / 11
Precautions for safe handling
Conditions for safe storage,
including any incompatibilities
Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Pressurized container: Do
not pierce or burn, even after use. Do not use if spray button is missing or defective. Do not spray
on a naked flame or any other incandescent material. Do not smoke while using or until sprayed
surface is thoroughly dry. Do not cut, weld, solder, drill, grind, or expose containers to heat, flame,
sparks, or other sources of ignition. Ground and bond containers when transferring material. Close
valve after each use and when empty. Protect cylinders from physical damage; do not drag, roll,
slide, or drop. When moving cylinders, even for short distances, use a cart (trolley, hand truck,
etc.) designed to transport cylinders. Suck back of water into the container must be prevented. Do
not allow backfeed into the container. Purge air from system before introducing gas. Use only
properly specified equipment which is suitable for this product, its supply pressure and
temperature. Contact your gas supplier if in doubt. Do not re-use empty containers. Do not get in
eyes, on skin, or on clothing. Use only in well-ventilated areas. Wear appropriate personal
protective equipment. Observe good industrial hygiene practices.
Level 1 Aerosol.
Contents under pressure. Do not expose to heat or store at temperatures above 120°F/49°C as
can may burst. Do not puncture, incinerate or crush. Do not handle or store near an open flame,
heat or other sources of ignition. Cylinders should be stored upright, with valve protection cap in
place, and firmly secured to prevent falling or being knocked over. Stored containers should be
periodically checked for general condition and leakage. Store in a well-ventilated place. Store
away from incompatible materials (see Section 10 of the SDS).
8. Exposure controls/personal protection
Occupational exposure limits
PEL 240 mg/m32-Butoxyethanol (CAS
111-76-2)
PEL 980 mg/m3Isopropyl Alcohol (CAS
67-63-0)
PEL 1800 mg/m3Propane (CAS 74-98-6)
TWA 20 ppm2-Butoxyethanol (CAS
111-76-2)
STEL 1000 ppmButane (CAS 106-97-8)
STEL 400 ppmIsopropyl Alcohol (CAS
67-63-0)
TWA 200 ppm
ValueComponents Type
50 ppm
400 ppm
1000 ppm
ValueComponents Type
TWA 24 mg/m32-Butoxyethanol (CAS
111-76-2)
TWA 1900 mg/m3Butane (CAS 106-97-8)
STEL 1225 mg/m3Isopropyl Alcohol (CAS
67-63-0)
TWA 980 mg/m3
TWA 1800 mg/m3Propane (CAS 74-98-6)
Product name: Tap Magic Multi-Purpose Cleaner/Degreaser
Product #: 1000013157 Version #: 01 Issue date: 10-07-2016
ValueComponents Type
5 ppm
800 ppm
500 ppm
400 ppm
1000 ppm
SDS US
Biological limit values
ACGIH Biological Exposure Indices
with hydrolysis
Acetone
exposure limits have not been established, maintain airborne levels to an acceptable level. Provide
Aerosol. Liquefied gas.
4 / 11
ValueComponents Determinant Specimen Sampling Time
2-Butoxyethanol (CAS
111-76-2)
Isopropyl Alcohol (CAS
200 mg/g Butoxyacetic
acid (BAA),
40 mg/l
67-63-0)
* - For sampling details, please see the source document.
Exposure guidelines
US - California OELs: Skin designation
2-Butoxyethanol (CAS 111-76-2) Can be absorbed through the skin.
US - Minnesota Haz Subs: Skin designation applies
2-Butoxyethanol (CAS 111-76-2) Skin designation applies.
US - Tennessee OELs: Skin designation
2-Butoxyethanol (CAS 111-76-2) Can be absorbed through the skin.
US NIOSH Pocket Guide to Chemical Hazards: Skin designation
2-Butoxyethanol (CAS 111-76-2) Can be absorbed through the skin.
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
2-Butoxyethanol (CAS 111-76-2) Can be absorbed through the skin.
Appropriate engineering
controls
Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates
should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation,
or other engineering controls to maintain airborne levels below recommended exposure limits. If
Creatinine in
urine
Urine
*
*
eyewash station.
Individual protection measures, such as personal protective equipment
Eye/face protection
Wear safety glasses with side shields (or goggles).
Skin protection
Hand protection
Wear appropriate chemical resistant gloves. Suitable gloves can be recommended by the glove
supplier.
Other
Respiratory protection
Wear suitable protective clothing.
If permissible levels are exceeded use NIOSH mechanical filter / organic vapor cartridge or an
air-supplied respirator.
Thermal hazards
General hygiene
considerations
Wear appropriate thermal protective clothing, when necessary.
When using do not smoke. Always observe good personal hygiene measures, such as washing
after handling the material and before eating, drinking, and/or smoking. Routinely wash work
clothing and protective equipment to remove contaminants.
9. Physical and chemical properties
Appearance
Physical state
Gas.
Form
Color
Odor
Odor threshold
pH
Melting point/freezing point
Initial boiling point and boiling
Not available.
Not available.
Not available.
Not available.
Not available.
212 °F (100 °C) estimated
range
Flash point
Evaporation rate
Flammability (solid, gas)
-156.0 °F (-104.4 °C) Propellant estimated
Not available.
Not available.
Upper/lower flammability or explosive limits
Flammability limit - lower
Not available.
(%)
Product name: Tap Magic Multi-Purpose Cleaner/Degreaser
Product #: 1000013157 Version #: 01 Issue date: 10-07-2016
SDS US
Loading...