Page 1
Safety Data Sheet
according to 29CFR1910/1200 and GHS Rev. 3
Effective date : 03.18.20 15
Page 1
of 7
Tap
Magic EP-Xtra (Aerosol)
Product name
SECTION 1: Identification of the substance/mixture and of the supplier
SECTION 2: Hazards identification
Manufacturer/Supplier Trade name:
:
Tap Magic EP-Xtra(Aerosol)
Manufacturer/Supplier Article number: 10012EL
Recommended uses of the product and restrictions on use
Processing.
Special Notes on Product Uses
and/or corrosion.
Manufacturer Details:
The StecoCorporation
2330 Cantrell Road
Little Rock, AR 72202 USA
501-375-5644
Website: www.tapmagic.com Email: [email protected]
Emergency telephone number:
ChemTel Inc.:
Classification of the substance or mixture:
: After use of this product, clean and lubricate metal surfaces to avoid staining
(800)255-3924, +1(813)248-0585
Flammable
: Machining, Cutting, Tapping, and Metal
Compressed Gas
Flammable aerosol 1; H222
Signal word
Hazard statements:
Extremely flammable aerosol.
Pressurized container: may burst if heated. May
be fatal if swallowed and enters airways.
Precautionary statements:
If medical advice is needed, have product container or label at hand. Keep
away from heat/sparks/open flames/hot surfaces. No smoking. Wear
protective gloves/protective clothing/eye protection/face protection. Do not
spray on an open flame or other ignition source.
Pressurized container. Do not pierce or burn, even after use.
IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician.
Do NOT induce vomiting.
If on skin: Wash with soap and water.
If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do.
Continue rinsing.
Protect from sunlight. Do not expose to temperatures exceeding 50 °C/122 °F.
Dispose of contents and container as instructed in Section 13.
: Danger
Created by Global Safety Management, 1-813-435-5161 - www.GSMSDS.com
This SDS applies to part number 10012EL
Page 2
Safety Data Sheet
according to 29CFR1910/1200 and GHS Rev. 3
Effective date : 03.18.20 15
Page 2
of 7
Tap
Magic EP-Xtra (Aerosol)
Other Non-GHSClassification:
Ingredients:
CAS 64742-53-6
Hydrotreated oil
1-50%
Paraffin wax compound
1-25%
CAS 74-98-6
Propane
1-10%
CAS 106-97-8
N-Butane
1-5%
Percentages are by weight
SECTION 3: Composition/information on ingredients
SECTION 4: First aid measures
SECTION 5: Firefighting measures
CAS 63449-39-8
WHMIS
NFPA/HMIS
NFPA SCALE (0-4)
None
HMIS RATINGS (0-4)
Description of first aid measures
After inhalation:
Move exposed individual to fresh air. Loosen clothing as necessary and position individual in a comfortable
position. Seek medical advice if discomfort or irritation persists. If breathing difficult, give oxygen.
After skin contact:
Wash affected area with soap and water. Rinse/flush exposed skin gently using water for 15 -20 minutes. Seek
medical advice if discomfort or irritation persists.
After eye contact:
Protect unexposed eye. Rinse/flush exposed eye(s) gently using water for 15-20 minutes. Remove contact
lens(es) if able to do so during rinsing. Seek medical attention if irritation persists or if concerned.
After swallowing:
IF SWALLOWED: Immediately call a POISON CENTER or doctor. Do NOT induce vomiting.
Most important symptoms and effects, both acute and delayed:
Irritation. Nausea.
Indication of any immediate medical attention and special treatment needed:
If seeking medical attention provide SDS document to physician. Physician should treat symptomatically.
Created by Global Safety Management, 1-813-435-5161 - www.GSMSDS.com
This SDS applies to part number 10012EL
Page 3
Safety Data Sheet
according to 29CFR1910/1200 and GHS Rev. 3
Effective date : 03.18.20 15
Page 3
of 7
Tap
Magic EP-Xtra (Aerosol)
Created by Global Safety Management, 1-813-435-5161 -
www.GSMSDS.com
This SDS applies to part number 10012EL
Extinguishing media
SECTION 6:
Accidental
release measures
SECTION 8: Exposure controls/personal protection
Suitable extinguishing agents:
Use water, dry chemical, chemical foam, carbon dioxide, or alcohol-resistant foam.
Unsuitable extinguishing agents:
None identified.
Special hazards arising from the substance or mixture:
Thermal decomposition can lead to release of irritating gases and vapors.
Advice for firefighters:
Protective equipment:
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.
Additional information (precautions):
Avoid inhaling gases, fumes, dust, mist, vapor, and aerosols. Avoid contact with skin, eyes, and clothing.
Personal precautions, protective equipment and emergency procedures:
Ensure adequate ventilation. Ensure that air-handling systems are operational.
Environmental precautions:
Should not be released into environment.
Methods and material for containment and cleaning up:
Wear protective eyeware, gloves, and clothing. Refer to Section 8. Keep in suitable closed containers for
disposal. Refer to Section 13. Always obey local regulations.
Reference to other sections:
None
Precautions for safe handling:
Avoid contact with skin, eyes, and clothing. Follow proper disposal methods. Refer to Section 13. Do not eat,
drink, smoke, or use personal products when handling chemical substances. Use only with adequate ventilation.
Conditions for safe storage, including any incompatibilities:
Keep container tightly sealed. Store away from incompatible materials.
Control Parameters:
No applicable occupational exposure limits.
Page 4
Safety Data Sheet
according to 29CFR1910/1200 and GHS Rev. 3
Effective date : 03.18.20 15
Page 4
of 7
Tap
Magic EP-Xtra (Aerosol)
Created by Global Safety Management, 1-813-435-5161 -
www.GSMSDS.com
This SDS applies to part number 10012EL
Appropriate Engineering controls:
Appearance
(physical state,
Pressurized liquid w/
propellant, Amber
Explosion limit lower:
Explosion limit upper:
Not determined
Odor:
Mild
Vapor pressure at 20°C:
Not determined
Odor threshold:
Not determined
Vapor density:
Not determined
pH-value:
Neutral (non-aqueous)
Relative density:
Not determined
Melting/Freezing point:
Not determined
Solubilities:
insoluble in water
Boiling point/Boiling
range:
Not determined
Partition coefficient (noctanol/water):
Not determined
Flash point (closedcup):
>150 C
Auto/Selfignition
Not determined
Evaporation rate:
Not determined
Decomposition
temperature:
Not determined
Flammability (solid,
gaseous):
Not determined
Viscosity:
a.
Kinematic: 24 Cst at
40 C
b.
Dynamic:
Density at 20°C:
0.93 g/ml
SECTION 9: Physica l and
chemical
properties
SECTION 10: Stability and reactivity
Respiratory protection:
Protection of skin:
The product does not contain any relevant quantities of materials with
critical values that have to be monitored at the workplace.
Not required under normal conditions of use.
Protective gloves should be worn. The glove material has to be
impermeable and resistant to the product. Selection of the glove material
should be based on the penetration time, rates of diffusion and the
degradation of the glove material. The exact break through time has to be
determined by the manufacturer of the protective gloves.
Eye protection:
General hygienic measures:
Contact lenses should not be worn.
Avoid contact with skin, eyes, and clothing.
Reactivity:
Nonreactive under normal conditions.
Chemical stability:
Stable under normal conditions.
Possible hazardous reactions:
None under normal processing.
Conditions to avoid:
Page 5
Safety Data Sheet
according to 29CFR1910/1200 and GHS Rev. 3
Effective date : 03.18.20 15
Page 5
of 7
Tap
Magic EP-Xtra (Aerosol)
Created by Global Safety Management, 1-813-435-5161 -
www.GSMSDS.com
This SDS applies to part number 10012EL
Incompatible materials. Excess heat.
SECTION 11: Toxicological information
SECTION 12: Ecological information
SECTION 13: Disposal
considerations
SECTION 14: Transport information
Incompatible materials:
Strong oxidizing agents. Strong acids and alkali.
Hazardous decomposition products:
No data available.
Acute Toxicity
Chronic Toxicity
Corrosion Irritation
Sensitization
Numerical Measures
: No additional information.
: No additional information.
: No additional information.
: No additional information.
: No additional information.
Carcinogenicity:
IARC: 3 - Group 3: Not classifiable as to its carcinogenicity to humans (Distillates (petroleum), hydrotrated light,
kerosene - unspecified)
Mutagenicity
: No additional information.
Reproductive Toxicity
Ecotoxicity:
No additional information.
: No additional information.
Persistence and degradability:
No data available.
Bioaccumulative potential:
No data available.
Mobility in soil:
No data available.
Other adverse effects:
None identified.
Waste disposal recommendations:
Dispose of empty containers as unused product. Product or containers must not be disposed together with
household garbage. It is the responsibility of the waste generator to properly characterize all waste materials
according to applicable regulatory entities (US 40CFR262.11).
US DOT
UN Number:
ADR, ADN, DOT, IMDG, IATA
Limited Quantity Exception: 1 L
UN1950
Page 6
Safety Data Sheet
according to 29CFR1910/1200 and GHS Rev. 3
Effective date : 03.18.20 15
Page 6
of 7
Tap
Magic EP-Xtra (Aerosol)
Created by Global Safety Management, 1-813-435-5161 -
www.GSMSDS.com
This SDS applies to part number 10012EL
Bulk:
SECTION 15: Regulatory information
RQ (if applicable):
None
Proper shipping Name: flammable
Non Bulk:
RQ (if applicable):
Proper shipping Name: flammable
None
Hazard Class: 2.1
Packing Group:
Marine Pollutant (if applicable):
Comments:
None
United States (USA)
No
SARA Section 311/312 (Specific toxic chemical listings):
Hazard Class: 2.1
Packing Group:
Marine Pollutant (if applicable): No
Comments:
None
Acute, Chronic, Fire, Pressure
SARA Section 313 (Specific toxic chemical listings):
None of the ingredients are listed.
RCRA (hazardous waste code):
None of the ingredients are listed.
TSCA (Toxic Substances Control Act):
All ingredients are listed.
CERCLA (Comprehensive Environmental Response, Compensation, and Liability Act):
None of the ingredients are listed.
Proposition 65 (California):
Chemicals known to cause cancer:
None of the ingredients are listed.
Chemicals known to cause reproductive toxicity for females:
None of the ingredients are listed.
Chemicals known to cause reproductive toxicity for males:
None of the ingredients are listed.
Chemicals known to cause developmental toxicity:
None of the ingredients are listed.
Canada
Canadian Domestic Substances List (DSL):
All ingredients are listed.
Canadian NPRI Ingredient Disclosure list (limit 0.1%):
None of the ingredients are listed.
Canadian NPRI Ingredient Disclosure list (limit 1%):
None of the ingredients are listed.
Page 7
Created by Global Safety Management, 1-813-435-5161 -
www.GSMSDS.com
This SDS applies to part number 10012EL
Safety Data Sheet
according to 29CFR1910/1200 and GHS Rev. 3
Effective date : 03.18.20 15
Page 7
of 7
This product has been classified in accordance with hazard criteria of the Controlled Products Regulations and
the SDS contains all the information required by the Controlled Products Regulations. The responsibility to
provide a safe workplace remains with the user. The user should consider the health hazards and safety
information contained herein as a guide and should take those precautions required in an individual operation
to instruct employees and develop work practice procedures for a safe work environment. The information
contained herein is, to the best of our knowledge and belief, accurate. However, since the conditions of
handling and use are beyond our control, we make no guarantee of results, and assume no liability for damages
incurred by the use of this material. It is the responsibility of the user to comply with all applicable laws and
regulations applicable to this material. Note. The responsibility to provide a safe workplace remains with the
user. The user should consider the health hazards and safety information contained herein as a guide and
should take those precautions required in an individual operation to instruct employees and develop work
practice procedures for a safe work environment. The information contained herein is, to the best of our
knowledge and belief, accurate. However, since the conditions of handling and use are beyond our control, we
make no guarantee of results, and assume no liability for damages incurred by the use of this material. It is the
responsibility of the user to comply with all applicable laws and regulations applicable to this material. This
product has been classified in accordance with hazard criteria of the Controlled Products Regulations and the
SDS contains all the information required by the Controlled Products Regulations. Note.
GHS Full Text Phrases: None
Abbreviations and Acronyms:
IMDG International Maritime Code for Dangerous Goods.
PNEC Predicted No-Effect Concentration (REACH).
CFR Code of Federal Regulations (USA).
SARA Superfund Amendments and Reauthorization Act (USA).
RCRAResource Conservation and Recovery Act(USA).
TSCA Toxic Substances Control Act (USA).
NPRI National Pollutant Release Inventory (Canada).
DOT US Department of Transportation.
IATA International Air Transport Association.
GHS Globally Harmonized System of Classification and Labelling of Chemicals.
ACGIH American Conference of Governmental Industrial Hygienists.
CAS Chemical Abstracts Service (division of the American Chemical Society).
NFPANational Fire Protection Association (USA).
HMIS Hazardous Materials Identification System (USA).
WHMIS Workplace Hazardous Materials Information System (Canada).
DNEL Derived No-Effect Level (REACH).
Effective date
Last updated
: 03.18.2015
: 07.16.2015
Loading...