Tailgate tools W-2100, W-2200 Owner's Manual

Cordless

Air Compressor

Shinn Fu Company of America, Inc. © 2003
10939 N. Pomona Ave.
Kansas City, MO 64153
Phone [phone], fax [phone]

Model Number

W-2100
W-2200

Rated Capacity

250 psi
250 psi

Printed in China
OIPM#CAC-03

90 DAYS LIMITED WARRANTY

For a period of ninety (90) days from date of purchase, Shinn Fu Co. of

America, Inc. will repair or replace, at its option, without charge, any of its products

which fails due to a defect in material or workmanship, or which fails to conform to any
implied warranty not excluded hereby.

Performance of any obligation under this warranty may be obtained by return-

ing the warranted product, freight prepaid, to Shinn Fu Co. of America, Inc. Warranty
Service Department, 10939 N. Pomona Ave., Kansas City, MO 64153.

Except where such limitations and exclusions are specifically prohibited by
applicable law, (1) the CONSUMER'S SOLE AND EXCLUSIVE REMEDY SHALL BE
THE REPAIR OR REPLACEMENT OF DEFECTIVE PRODUCTS AS DESCRIBED
ABOVE, and (2) Shinn Fu Co. of America, Inc. SHALL NOT BE LIABLE FOR ANY
CONSEQUENTIAL OR INCIDENTAL DAMAGE OR LOSS WHATSOEVER, and (3) THE
DURATION OF ANY AND ALL EXPRESSED AND IMPLIED WARRANTIES, INCLUDING
WITHOUT LIMITATION, ANY WARRANTIES OF MERCHANTABILITY AND FITNESS FOR
A PARTICULAR PURPOSE, IS LIMITED TO A PERIOD OF NINETY (90) DAYS FROM
DATE OF PURCHASE.

Some states do not allow limitations on how long an implied warranty lasts,
so the above limitation may not apply to you. Some states do not allow the exclusion
or limitation of incidental or consequential damages, so the above limitation or exclu­sion may not apply to you. This warranty gives you specific legal rights, and you may
also have other rights which vary from state to state.

Owner’s Manual

Contains Sealed Lead Acid Battery. Bat­tery must be recycled. Lead is known to
cause birth defects and reproductive
harm. Wash hands thoroughly after han­dling battery. Keep this product out of
the reach of children.

SPECIFICATIONS

Power Output: 12V DC 15A
Maximum PSI: 250 PSI blocked head

pressure

Duty Cycle: (minutes) 15/30 (ON/OFF)
Maximum Amperage Draw: 12 amps @

13.5 V DC

Maximum Air Flow: 0.7 CFM
Hose Length: 30”
Built-in Battery: 7AH Sealed Lead-acid

battery (dispose of properly)

AC Adapter: 120V/15A AC/DC adapter
Fuse: 15A

W-2100 shown

6

3

Save these instructions for future use.
Read, understand and follow the instruc­tions provided with and on this device. The
owner and operator of this compressor
shall have an understanding of the prod­uct and safe operating procedures before
attempting to use. If any doubt exists as to
the safe and proper use of this compres­sor, remove from service immediately. In­structions and safety materials shall be
conveyed in the operators native language
before use of this product is authorized.
Inspect before each use. Do not use if
bent, broken, melted, burnt or otherwise
damaged components are noted. A com­pressor that is damaged in any way or op­erates abnormally shall be removed from
service immediately. This unit is designed
for intermittent use only. Operation beyond
its duty cycle may result in compressor and/
or vehicle damage. NEVER exceed rated
pressure of the item being inflated. If rated
pressure is exceeded, the item being in­flated may burst.

PRODUCT DESCRIPTION

Tailgate Tools Cordless Air Compressors
are installed with a built-in 12V lead acid
battery to provide a power source to the
compressor and the DC 12V power sup­ply. Its intended use is to inflate automo­tive and light truck tires to manufacturers
recommended pressures, and to inflate
low pressure inflatables such as rafts,
cushions, and sports balls. Refer to vehi­cle owner’s manual or inflatable product
operator’s manual for proper inflation pro­cedure.

SAFETY PRECAUTIONS

A. Care and maintenance of battery

1. The battery of this compressor is not
fully charged at the time of purchase.
Before initial use, it must be charged
for 15 hours using the AC charger en­closed.

2. Recharge the battery every 3 to 6
months if the battery has not been
used. If the battery is totally drained and
without proper recharging; the battery
may not be rechargeable.

3. Recharge when DC voltmeter reads
anywhere in the “recharge” area.

B. 120V AC charger adapter

1. Use only the charging adapter enclosed.

2. Do not operate the unit when charging
with the charging adapter.

C. Air Compressor

1. Check the battery voltage via the volt­meter on the front panel before use. If
the voltage drops below the green por­tion, recharge the unit before use.

2. Do not continue to operate the compres­sor when the voltage drops below the
green portion on the voltmeter.

3. Do not let the air compressor overheat.
Let the air compressor cool for 30 min­utes after every 15 minutes of opera­tion.

4. Only replace a fuse with one of the same
amperage, 15 A in this case.

5. Never operate or store the unit near fire,
flammable gas or liquid.

OPERATING INSTRUCTIONS (see

page 2 illustration)

1. Turn on the unit by pushing the power
switch to ‘Power’.

2. Check the voltage of the battery on the
voltmeter every time you use this unit.

3. If the voltage pointer points below the
‘good’ condition, recharge the battery
according to the following steps:

AC 120V recharging (see page 2 illus­tration)

1. Push the power switch to “Recharge”.

2. Insert the power jack of the 120V AC
charger adapter into the AC charger
inlet.

3. Plug the charger adapter into a 120V
AC electrical outlet to start charging.

4. Push the power switch to ‘Power’ to
check the voltage level of the battery, if
necessary, push the switch back to ‘Re­charge’ to resume the charging pro­cess.

5. Charge the unit for about 15 hour be­fore initial use and for normal recharge.

Note: The unit must be charged before
initial use.

Fig. 1

Fig. 2

2

work light

flashing light

15A fuse

air hose

12V DC outlet

AC charger

adapter

flashing light on/off switch
power switch

work light on/off switch

compressor on/off switch

DC voltmeter

inflatable adapters

digital pressure gauge

(W-2200 only)

quick

connector

! SAFETY MESSAGE !

Do not operate this device near flam­mable materials. This device contains
a DC motor and components which may
arc during normal operation. This arc­ing may ignite flammable gases. No
alterations shall be made to this de­vice. Only attachments and/or adapters
supplied by the manufacturer shall be
used. Never operate this device using
a battery charger. If vehicle fuse is
blown, ONLY replace with fuse of iden­tical rating.

Read, understand and follow all printed
materials provided with and on this de­vice. Do not exceed rated pressure of
the item being inflated! Never attempt
to start the car engine when the unit is
connected to the lighter socket of the
car. Do not leave device operating and
unattended. Keep out of the reach of
children. Failure to heed this marking
may result in personal injury and/or
property damage.

ATENCIÓN

!

• Leer, comprender, y seguir las
instrucciónes antes de utilizar el
aparato.

• El manual de instrucciónes y la
información de seguridad deben estar
comunicado en lengua del operador
antes del uso.

• No seguir estas indicaciónes puede
causar daños personales o materiales.

AC charger inlet

WARNING

!