Wall-Hung Carrier System
INSTALLATION INSTRUCTIONS
Residential Concealed In-Wall Toilet Tank
Carrier System for Wall-Hung Toilet
SM-WC424
S
wiss
M
adison
®
@SwissMadison
#WellMadeForever
www.swissmadison.com | 1-434-623-4766 | info@swissmadison.com
WALL-HUNG CARRIER SYSTEM INSTALLATION INSTRUCTIONS
PRIOR TO INSTALLATION:
· Inspect carrier to ensure no damages have occurred while in shipping.
· Observe all plumbing and building codes in accordance with your state and local requirements.
· All dimensions are nominal! Be sure to measure your toilet prior to installation.
· The step-by-step guidelines in the installation instructions are a general reference. Should there be
any discrepancies, Swiss Madison cannot be held liable. It is recommended to install all Swiss
Madison products by hiring a licensed professional.
· Read installation and maintenance instructions thoroughly before installing. Be sure to use proper
tools and always wear proper personal safety accessories for your protection.
· Be sure to properly bleed all air from the piping system, trapped air can cause damage to the flushing
system and toilet bowl.
· Avoid outside wall installations to avoid possible freezing.
If you have any questions or concerns please contact us:
1-434-623-4766
info@swissmadison.com
SUGGESTED TOOLS & MATERIALS:
Safety
Glasses
Plumbers
Grease
Wrench
Hacksaw
Level
Flat File
Tape
Measure
Drill
— 1 —
ScissorsPlumbers Tape
Coupler
not included
WALL-HUNG CARRIER SYSTEM INSTALLATION INSTRUCTIONS
1
35
36
37
38
22
39
32
23
40
33
41
2
24
34
42
3
4
5
6
7
8
9
10
11
12
13
14
15
18
25
26
27
28
16
17
29
30
31
19
20
21
1. 2.
A：
B：
19¹9⁄64”
²5⁄64
OR
1
OR
2
44¹9⁄64”
3
4
0
OR
²5⁄64
OR
13²5⁄32”
· Before fastening sides, you must first attach legs to framing. At this
point it is possible to readjust your bowl rim to your desired height.
· L-shaped mounting brackets are for masonry applications.
· Fasten your frame into studs/framing using four mounting holes in
the carrier frame (two on each side). It is recommended for framing
installations to use 2 ¹⁄2” screws and 1 ¹⁄4” fender washers (needing
four of each total).
· Be sure to screw carrier to wood framing flush across the front.
A
A
D
B
B
C
D
C
— 2 —
WALL-HUNG CARRIER SYSTEM INSTALLATION INSTRUCTIONS
3.
4.
5.
· When connecting to a 3” sewer line it is advised
to drill a 3 5⁄8” hole before connecting the
discharge pipe to the frame.
· It is possible to offset the discharge pipe left
or right. If offsetting is required, you must
move the top bracket holding the discharge
pipe to the back holes in the frame. This
allows you to miss the carrier frame when
connecting the necessary plumbing.
· For a vertical discharge, leave bracket as
shown above.
· Use this mounting position for an offset
installation.
— 3 —
WALL-HUNG CARRIER SYSTEM INSTALLATION INSTRUCTIONS
6. 7. 8.
Depending
on your
installation
it will either
be a 4” x 3”
or a 3” x 3”
mechanical
coupling.
*coupler not included, please
consult your local plumber.
· Cover installation bolts with protective slip, do not
remove slip until after toilet is in place. It is
important to keep threads clean for later
adjustment.
9. 10. 11.
· Ensure template is plumb.
· Install dry wall over carrier system
in intended location.
· Find cutout template that was included with
your carrier.
· Cut out the small marked holes (1) to align
cutout with the threaded bolts.
— 4 —
· Align template up on your wall so the threaded
bolts fit through the precut holes.
· Cut around the marked lines (2) to reveal
pipe/actuator locations behind the drywall.
WALL-HUNG CARRIER SYSTEM INSTALLATION INSTRUCTIONS
12.
13.
· Install mud guards into
proper holes to ensure no
debris enters pipes after
sheetrock has been cut.
14.
· Cut drywall to reveal where to install flush plate
and attach plumbing.
NOTE: Swiss Madison is not responsible for any
damage done to wall or carrier system.
15. 16.
— 5 —
WALL-HUNG CARRIER SYSTEM INSTALLATION INSTRUCTIONS
17. 18.
· Install the locknut as
shown.
· Hold the shutoff valve
stationary while tightening your
water connection.
19. 20.
· Once the water connection is made to the water shutoff valve, undo the
other side of the hose. Next, turn valve on to flush out any debris before
reinstalling to the actuator.
21. 22.
— 6 —
WALL-HUNG CARRIER SYSTEM INSTALLATION INSTRUCTIONS
23. 24.
25. 26.
27. 28.
· Ensure roughing box is secure to keep debris
from entering the tank.
— 7 —
WALL-HUNG CARRIER SYSTEM INSTALLATION INSTRUCTIONS
Installing the Toilet.
1. 2. 3.
· Install pipes. Be sure to seal them thoroughly.
· With a ruler, against finished wall, on top of
pipe, mark as shown.
4. 5. 6.
L1
L2
· With a ruler, against the back of the bowl, on
top of pipe, mark as shown.
· Measure distance between both lines on
pipes. Take measured distance, deduct from
bald end of pipe and cut.
7. 8. 9.
· Remove pipes from wall and install into back
of bowl. Make sure pipes are sealed
thoroughly.
L2
L1+15/16”
L1
L2+1/8”
· After cutting, take file and remove all burrs.
Try and bevel edge.
10.
· Before mounting bowl, measure thickness of
china and mounting hardware to get
approximate depth of threaded rods.
depth + 1”
depth
· Use slotted end of thread bolt to adjust in or
out. Do not damage the thread.
— 8 —
· With grease, sponge thoroughly to
lubricate all ends.
12.11.
· Install with mounting hardware and ensure
toilet bowl is level.
®
Swiss Madison
1-434-MADISON
(623-4766)
19 Stults Road
Dayton, NJ 08810
ONE YEAR LIMITED WARRANTY
Swiss Madison® products are made with quality materials and excellent craftsmanship to provide our
customers with beautiful, durable, long-lasting products. Should there be any defects in materials or
craftsmanship under regular use that are discovered within the first year of installation, Swiss Madison®
will provide replacement parts at no charge, or at its discretion, replace any product or part of the product
that is deemed defective, under normal installation, use, service or maintenance. This warranty applies
only to the original purchaser. Proof of purchase will be required in the instance of a claim.
Swiss Madison® recommends all installations of Swiss Madison® products to be conducted by a
licensed, professional plumber or contractor. Swiss Madison® will not be held responsible for any
damage or product failure due to improper installation, misuse, or failure to utilize a licensed professional
for installation. Swiss Madison® is not responsible for any installation or removal costs.
This One Year Limited Warranty Will Be Voided If:
• The installation recommendations were not followed by the installer
• The product has been moved from its initial place of installation
• The product has in any way been modified from its packaged state
• The product has been subjected to improper maintenance, abuse, misuse, excessive use of
chemicals, accidents, or other damages, etc.
www.swissmadison.com
Swiss Madison® makes no implication that its products comply with any local building or plumbing
codes. It is the consumer’s responsibility and obligation to determine local code compliance prior to and
during installation. This warranty extends only to the original purchaser and first consumer.
Swiss Madison® is not responsible for any special, incidental or consequential damages associated with
the installation, replacement, return or use of the original purchaser’s product. This includes, but is not
limited to: freight costs, labor, travel time, lost profit, home damages and other contingent liabilities and
costs (including, without limitation, costs associated with ‘professionals’ or ‘experts’, investigations,
audits, analyses, attorneys and any other professional/hired services).
The Swiss Madison® warranty is a comprehensive and explicit limit of liability. All items not disclosed
within the warranty are not addressable within the responsibility of Swiss Madison®. Certain states have
variances regarding implied warranties; in those situations, we remain fully compliant.
If you have any questions or concerns, please contact us directly at
1-434-MADISON (623-4766)
WARNING: Contents of your order may contain sharp and possibly other harmful pieces and may
cause hazard to children and adults. Swiss Madison® is not responsible in any way for personal damages.
Loading...