Swissh 25PLC Installation Instructions & User Manual

GLASS/DISHWASHER

25PLC

INSTALLATION

INSTRUCTIONS &

USER MANUAL

Retain this manual for future references.

Swissh Commercial Equipment
6060 Métropolitain E.
Bureau 200
Montréal, Québec H1S 1A9

Phone:[phone]
Fax: [phone]
Toll Free: 1-888-794-7749
E-mail: [e-mail]

IMPORTANT SAFETY INSTRUCTIONS

Your Swissh Dish/Glasswasher has been designed and engineered by our
craftsmen to exacting standards of reliability and long life while still provid­ing you with outstanding performance and results.

To ensure proper use of the unit and guarantee efficiency, please take a moment to

read the installation instructions and user manual thoroughly.

WARNING: When using your dishwasher, follow basic precautions, including the following:

(a) Read all instructions before using the dishwasher.

(b) Use the dishwasher only for it’s intended function.

(c) Use only detergents or wetting agents recommended . Chlorinated products
must not be used with this unit. Using chlorinated products will void the warranty.

(d) When loading items to be washed:

(1) Load sharp knifes with the handles up to reduce the risk of cut type injuries.

(e) Do not abuse, sit on, or stand on the door or dish rack of the dishwasher.

(f) Under certain conditions, hydrogen gas may be produced in a hot water system
that has not been used for two weeks or more. HYDROGEN GAS IS EXPLOSIVE. If
the hot water system has not been used for such a period, before using dishwasher
turn on all hot water faucets and let the water flow from each for several minutes.
This will release any accumulated hydrogen gas. As the gas is flammable, do not
smoke or use an open flame during this time.

Remove the door to the washing compartment when removing an old dishwasher from
service or discarding it.

NOTE:

Before leaving the factory, every dishwasher has been thoroughly tested and adjusted to
standard conditions. Therefore, it is possible that a small quantity of water remains in the
wash tank.

DO NOT REMOVE THE OVERFLOW PIPE

1.0 GENERAL

1.1 Carefully remove unit from carton

While removing the unit from the carton, make sure that the equipment has
not been damaged during the transport and that no parts are missing.
Make sure, that machine has been delivered with following parts:

• 2 Washpipes

• Dirt filter

• Overflow pipe

• Drain reducer connector

• 1 dishrack / 1 cutlery rack

Bras de rincage /
Rinse Arms

Tuyaux de lavage /
Wash Pipes

Bras de lavage /
Wash Arm

Tuyau de renvoi /
Overflow Pipe

Activateur de porte /

Door Switch

Filtre /

Dirt Filter

DD

P

I

O

Table de bord / Display Board

Programme /
Program

Détartrage / Nettoyage
Daily Cleaning / Descaling

Sone de detergent /

Detergent Probe

Tuyau pour detergent (noir)
Detergent Hose (black)

Tuyau pour rince (clair)
Rince agent hose (clear)

Ecrou a ailettes /

Wing Nut

Sonde de remplissage /
Water level probe

ON/OFF

Cycle 1

Cycle 2

Injecteur de détergent /

Detergent injector

2.0 INSTALLATION AND PLACEMENT

To simplify the Technical Spec Sheet (see pages 6 & 7), all connections
(drain, water, electricity) have been located to the right side of the equip­ment. However, with the fact that the Swissh has flexible connections, and
by respecting the indicated measurements, some or all connections can be
either on the left or right side of the machine.

Apart from the space required for your machine, make sure, that you also provide enough
space for the placement of your detergent and rinse chemicals. Detergent and rinse pails
come in two different sizes, according to the space available. Pail sizes of 4 litres requires
405mm (16”) clearance in height and 165mm (6”) in width. The 20 litres pail sizes require
455mm (18”) in height and 305mm (12”) in width.

2.1 Drain connection

To minimise the future maintenance of your dish/glasswasher, the Swissh
25PLC has been designed to drain by gravity. Depending on the height of
the machine base, the drain height can never exceed the recommended max-
imum drain height (see technical spec sheet pages 6 & 7).

Recommended maximum drain height:

• No base (standard) max. 100mm (4”)

• 4” base (standard) max. 150mm (6”)

• 6” base (standard) max. 200mm (8”)

6 1/2"

12"

12"

18"

4 Litres

20 Litres

4"