Swisher ZT2660, 26069 Owner’s Manual

26 HP- 60" CUT

CELEBRATINGOVER60YEARSOFINNOVATION

1945-2007

1602 CORPORATE DRIVE, P.O. BOX 67, WARRENSBURG, MISSOURI 64093

PHONE [phone] FAX [phone]

Manufacturing quality lawn care equipment since 1945

OWNER'S MANUAL

12935

Rev. 07-009

STARTING SERIAL # L507-00100!

MadeUSAInThe I

LIMITED WARRANTY

The manufacturer's warranty to the original consumer purchaser is: This product is free
from defects in materials and workmanship for a period of two (2) years from the date of

purchase by the original consumer purchaser. We will repair or replace, at our discretion,
parts found to be defective due to materials or workmanship. This warranty is subject to
the following limitations and exclusions:

1) Engine Warranty All engines utilized on our products have a separate warranty
extended to them by the individual engine manufacturer. Any

engine service difficulty is the responsibility of the engine
manufacturer and in no way is Swisher Mower Co., Inc. or its

agents responsible for the engine warranty. The Briggs &
Stratton Engine Service Hot-Line is 1-800-233-3723. The

Tecumseh Engine Service Hot-Line is 1-800-558-5402.

2) Commercial Use

This product is not intended for commercial use and

carries no commercial warranty.

3) Limitation

This warranty applies only to products which have been
properly assembled, adjusted, and operated in accordance

with the instructions contained within this manual. This
warranty does not apply to any product of Swisher Mower

Co., Inc., that has been subject to alteration, misuse,abuse,
improper assembly or installation, shipping damage, or to

normal wear of the product.

4) Exclusions Excluded from this warranty are normal wear, normal

adjustments, and normal maintenance.

In the event you have a claim under this warranty, you must return the product to an

authorized service dealer. All transportation charges, damage, or loss incurred during
transportation of parts submitted for replacement or repair under this warranty shall be
borne by the purchaser. Should you have any questions concerning this warranty, please

contact us toll-free at 1-800-222-8183. The model number, serial number, date of
purchase, and the name of the authorized Swisher dealer from whom you purchased the
mower will be needed before any warranty claim can be processed.

THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES AND ANY IMPLIED WARRANTIES ARE LIMITED TO THE SAME TIME

PERIODS STATED HEREIN FOR ALL EXPRESSED WARRANTIES. Some states do not
allow the limitation of consequential damages or limitations on how long an implied

warranty may last, so the above limitations or exclusions may not apply to you. This
warranty gives you specific legal rights and you may have other rights, which vary from

state-to-state. This is a limited warranty as defined by the Magnuson-Moss Act of 1975.

Operator Presence ............. 12 ;i i_ i_

PARTS BREAKDOWNIIIIIIIII 27

Tires ................................ 12

.............................................................................................................................................................................................................................................................!:.................................................................................................................................................................................................................................................. ...........................................

Blade Maintenance .............. 13

!: 6_R 16ENTiFi CATION::: 37

B ry.........................!# ;_

i REP LACEME NT PARTS Zii ill 38

V_be'{siiiiii iiiiiiiiiiiiiii4

_ sW_S HER H ISi O _Y ............ 40

Overall Unit C are ................ 14

......................TranspoSing Saf_iy :::::::::::: 14 ................................................................................................................................................................................................

INTRODUCTION

Congratulations

Thank you for purchasing a Swisher Zero Turn mower. This machine is built for the
greatest efficiency and rapid mowing of large areas. Conveniently located controls and

dual commercial grade hydrostatic transmissions regulated by steering levers, contribute to
the machine's performance.

This manual is a valuable document. Following the instructions for use, service,
maintenance, etc. can greatly increase the life-span of your machine.

General

In this operator's manual, left and right, backward and forward are used in relation to the normal

operators position.

NOTE:

If you have never used a Zero Turn mower before, refer

Read Before Operating

to the Operation Controls section of this manual before
attempting to operate one for the first time.

This machine is constructed only for mowing grass on lawns and other free and even
ground without obstacles. This machine is not intended for commercial use. The

manufacturer's directions concerning operation, maintenance, and repairs must be
carefully followed.

This machine must only be operated, maintained, and repaired by persons that are
familiar with the machine's special characteristics and who are well versed in safety

instructions.

Accident prevention regulations, other general safety regulations, occupational safety

rules, and traffic regulations must be followed without fail.

Unauthorized modifications to the design of the machine may absolve the manufacturer
from liability for any resulting personal injury or property damage.

Read engine manufacturer's

operating and maintenance

_Set parking brake

Be sure mower blades are turned off-

instructions.

PTO switch pushed down.

Read and observe all safety

instructions on your mower and in the
manual

Know how to stop the engine - Turn key

to off

Check engine oil.
Check fuel caps to sure that they

are in place.

Know how to stop the unit - Return

control handles to neutral

4

INTRODUCTION

Uncrating & Assembly

TOOLS REQUIRED:

,/ 2 - ½" Wrenches or ½" Socket with drive ratchet
,/ Tire pressure gauge

,/ Nail bar or claw hammer
,/ Wire snips

To Remove The Mower From The Crate

Dispose of top and side panels of the crate.
Remove loose parts and packing material

Cut any banding or strapping that may be holding the mower to the crate.

Disengage spark plug wire and place where it cannot make a connection.
Raise the mower deck to its highest position..

Disengage the parking brakes by placing the handle controls in the upright position.

Open the transmission valves at the rear of the unit by pulling the release rods and

locking them in place. SEE INSTRUCTION DECAL AT THE REAR OF THE UNIT.

Carefully push the mower off the crate to a safe and level area.
Check engine oil. All engines are filled with oil and tested at the factory. Verify oil

level and add if necessary before starting engine. SEE ENGINE OWNER'S MANUAL

Check the battery. If the battery is put into service after the "month & year" of the
date on the battery, then it may need to be charged with a 12 volt charger for a minimum
of 1 hour, but no more than 2 hours at a rate of 6 to 10 amps.

Attach battery cables to battery. Always attach the positive terminal first.

Install steering levers. Remove the bolts from the control arms on the mower. Align

the holes in the lever with the holes in the control arms and attach with the bolts provided.
Make sure both bolts on both handles are tight.

Close the transmission valves at the rear of the unit. SEE INSTRUCTION DECAL
AT THE REAR OF THE UNIT.

Reconnect spark plug wire.

Check tire pressure on all four wheels. REFER TO UNIT SPECIFICATIONS TABLE

SYMBOLS & DECALS

OD45- Warning Decal

Swisher Flag U.S.A.- OD39

Flying Debris Decal- OD43 Operator Must Be Seated Decal- OD73

Notice Do Not Alter Wiring Decal- OD74

Triangle Danger Decal- OD55 No Step Decal- OD11

SYMBOLS & DECALS cont.

Key/PTO Decal-10273

RELFL_ETOO_:_ATE

NACN!f4_ N_MALLY,

Throttle/Choke Decal- 10271

Danger/Warning Decal- 10276

Hydro Release -

10280

Decals Not Shown

10275
10281

OD9128

XZT60 Decal Small

Height Adjustment Decal

60" Deck White Decal

13072
10274

OD991 25

Replacement Parts Decal

Z-M ax Decal

Medium Swisher Decal

General Use

SAFETY INSTRUCTIONS

These instructions are for your safety. Read them carefully.

This Safety Alert Symbol indicates important messages in
this manual. When you see this symbol, carefully read the

message that follows and be alert to the possibility of

1

personal injury.

Read all instructions in this operator's manual

and on the machine before starting it. Ensure that
you understand them and then abide by them.

_Learn how to use the machine and its controls

safely and learn how to stop quickly. Also learn to
recognize the safety decals.

Only allow the machine to be used by adults

who are familiar with its use.

Make sure nobody else is in the area of the

machine when you start the engine, engage the
drive, or run the machine.

_Stop the machine if someone enters the work

area.

_Clear the area of objects such as stones, toys,

steel wire, etc. that may become caught in the
blades and thrown out.

NOTE:

If you have never used a Zero

Turn mower before, refer to the
Operation Controls section of

this manual before attempting
to operate one for the first time.

_Do Not Use this machine without the

Discharge Chute in place.

Stop the engine and disconnect the spark plug

before cleaning the discharge deck.

Never take passengers. The machine is only

intended for use by one person.

SAFETY INSTRUCTIONS

General Use Continued

_Always look around before and during reversing

maneuvers.

Slow down before turning.

Shut down the mower deck when not mowing.

Be careful when rounding fixed objects, so that

the blades do not hit them.

Only operate the machine in daylight or other

well-lit conditions.

Keep the machine a safe distance from holes

or other irregularities in the ground.

Never use the machine if you are tired, if you

have consumed alcohol, or if you are taking other
drugs or medications that can affect your vision,

judgment, or coordination.

Beware of traffic when working near or

crossing a road.

Remember

The operator is responsible
for avoiding dangers or

accidents.

WARN ING

When using the
machi ne, approved
personal protective
equipment shall be

used. Personal
protective

equipment cannot
eliminate the risk of

injury, but it will

Never leave the machine unsupervised with

the engine running. Always shut down the blades,
engage the parking brakes, stop the engine, and

remove the ignition key before leaving the
machine.

Never allow children or other persons not

trained in the use of the machine to use or service
it. Local laws may regulate the age of the user.

Make sure that you have first aid equipment

close at hand when using the machine.

Never use the machine when barefoot. Always

wear protective shoes or boots.

Always wear approved protective glasses or a

full visor when assembling or driving.

Ear Protection is recommended

Never wear loose clothing that can get caught in

moving parts.

9

reduce the degree of

injury if an accident

does occur. Ask

your retailer for help

in choosing the right

equipment.

SAFETY INSTRUCTIONS

Slope Operation

Remove obstacles such as stones, tree branches, etc.
Mow up and down, not side to side. Never drive the rider

on terrain that slopes more than 10 degrees.

Avoid starting or stopping on a slope. If the tires begin to

slip, shut down the blades and drive slowly down the slope.

Always drive evenly and slowly on slopes.

Make no sudden changes in speed or direction.

Avoid unnecessary turns on slopes, and if it proves
necessary, turn slowly and gradually downward, if possible.

Watch for holes, ruts, or bumps. On uneven terrain, the

machine can tip more easily. Long grass can hide obstacles.

Remember

The operator is
responsible for
avoiding dangers or

accidents.

Drive slowly and use small movements of the steering

controls.

Do not mow wet grass. It is slippery, and the tires can

loose their grip, so that the machine slides.

Do not try to stabilize the machine by putting a foot on the

ground.

Children

Serious accidents may occur if you fail to be on guard for
children in the area of the machine. Children are often

attracted to the machine and mowing work. Never assume that
children will stay put where you last saw them.

Keep children away from the mowing area and under close

supervision by another adult.

Shut off the machine if children enter the work area.

Never allow a child to ride with you.
Never allow children to operate the machine.

Be extra cautious near corners, bushes, trees, or other

objects that block your view.

10

SPECIFICATIONS

GASOLINE CAPACITY DUAL 2.0 GAL TANKS
AND TYPE UNLEADED REGULAR

OIL TYPE (SPI-SF-SJ): SEE ENGINE MANUAL
SPARK PLUG SEE ENGINE MANUAL

GROUND SPEED 0- 6 mph
TIRE SIZE FRONT: 4.10x3.5-5 5/8

Bearing
REAR: 20 X 10 X 8

TIRE PRESSURE FRONT: 50 psi Max

REAR: 22 psi Max

BA-I-I-ERY 12V / Heavy Duty 275 CCA

Type Ul L

HYDRO Bolt Torque 27 + - 3 ft. Ibs

BLADE BOLT TORQUE 35 ft. Ibs

CUTTING HEIGHT 1.5"- 5"

CUTTING WIDTH 60"- 3 Mulching Blade System

PARKING BRAKE Automatic - On Steering

Handles

FRONT AXLE Pivoting

SEAT Deluxe 18" Back w/Arm Rest

6" Adjustable Slide

TRANSMISSION Commercial Grade Eaton

Hydrostatic

DECK LIFT Spring Assisted
UNIT MEASUREMENTS LENGTH: 70"

WIDTH: 60 ¼ ....

Including Deck

WEIGHT: 680 Ibs

11

CUSTOMER RESPONSIBILITIES

Operator Presence Syste m

Be sure the operator presence and interlock systems are working properly. If your
mower does not function as described, repair the problem immediately.

The engine should not start unless the parking brakes (handle controls)

are engaged (rotated outward), the PTO (Blade Engagement - See
OPERATION FEATURES section of this manual) switch is disengaged
(pressed down), and the operator is on the seat.

When the engine is running, any attempt by the operator to leave the seat

without first setting the parking brake should shut off the engine.

When the engine is running and the PTO switch is engaged, any attempt
by the operator to leave the seat without first disengaging the PTO switch,
should shut off the engine.

When the engine is running and the control levers are rotated in, any
attempt by the operator to leave the seat without rotating the control levers

out, should shut off the engine.

The PTO switch should never engage without the operator on the seat.

Tires

Maintain proper air pressure in all tires ( SEE SPECIFICATIONS section)

Keep tires free of gasoline, oil, or insect control chemicals which can harm

rubber.

Avoid stumps, stones, deep ruts, sharp objects and other hazards that
may cause tire damage.

12