Page 1
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Revision: February 9, 2016
SE CTION 1: Identification of the substance/mixture and of the company/
undertaking
·
1.1 Product identifier
·
Trade name: Super Lube® Grommet Lube
·
Article number:
·
1.2 Relevant identified uses of the substance or mixture and uses advised against
No further relevant information available.
·
Application of the substance / the mixture
·
1.3 Details of the supplier of the Safety Data Sheet
·
Manufacturer/Supplier:
Synco Chemical Corporation
24 DaVinci Dr., P.O. Box 405
Bohemia, NY 11716
Telephone: 631-567-5300
Email: info@super-lube.com
·
1.4 Emergency telephone number:
CHEMTREC
1-800-424-9300 (US/Canada)
+01 703-527-3887 (International)
No other identifiers.
Lubricant
Page 1/9
SECTION 2: Hazards identification
·
2.1 Classification of the substance or mixture
·
Classification according to Regulation (EU) No 2015/830
The product is not classified as hazardous according to OSHA GHS regulations within the United States.
The product is not classified as hazardous according to the CLP regulation.
·
Information concerning particular hazards for human and environment:
The product does not have to be labelled due to the calculation procedure of the "General Classification
guideline for preparations of the EU" in the latest valid version.
·
Classification system:
The classification is according to the latest editions of the EU-lists, and extended by company and
literature data.
The classification is in accordance with the latest editions of international substances lists, and is
supplemented by information from technical literature and by information provided by the company.
·
Additional information:
0 percent of the mixture consists of component(s) of unknown toxicity
There are no other hazards not otherwise classified that have been identified.
·
2.2 Label elements
·
Labelling according to Regulation (EC) No 1272/2008
The product is not classified as hazardous according to OSHA GHS regulations within the United States.
This product does not have a classification according to the CLP regulation.
·
Hazard pictograms
·
Signal word
Not Regulated
Not Regulated
(Contd. on page 2)
40.1.5
Page 2
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Trade name: Super Lube® Grommet Lube
·
Hazard-determining components of labelling:
·
Hazard statements
·
Precautionary statements
·
Additional information:
EUH210 Safety data sheet available on request.
·
Hazard description:
·
WHMIS-symbols:
·
NFPA ratings (scale 0 - 4)
Health = 0
000
·
HMIS-ratings (scale 0 - 4)
Fire = 0
Reactivity = 0
Not Regulated
Not Regulated
Not hazardous under WHMIS.
Page 2/9
Revision: February 9, 2016
(Contd. of page 1)
None.
HEALTH
FIRE
REACTIVITY
·
HMIS Long Term Health Hazard Substances
0
Health = 0
0
Fire = 0
0
Reactivity = 0
None of the ingredients are listed.
·
2.3 Other hazards
·
Results of PBT and vPvB assessment
·
PBT:
Not applicable.
·
vPvB:
Not applicable.
SECTION 3: Composition/information on ingredients
·
3.2 Mixtures
·
Description:
·
Dangerous components:
CAS: 57-55-6
EINECS: 200-338-0
CAS: 99-76-3
EINECS: 202-785-7
·
Additional information:
For the wording of the listed risk phrases refer to section 16.
For the listed ingredients, the identity and exact percentages are being withheld as a trade secret.
Mixture of substances listed below with nonhazardous additions.
Propylene Glycol
substance with a Community workplace exposure limit
methyl 4-hydroxybenzoate
Aquatic Chronic 3, H412
25-50%
2,5%
SECTION 4: First aid measures
·
4.1 Description of first aid measures
·
General information:
·
After inhalation:
40.1.5
No special measures required.
Supply fresh air; consult doctor in case of complaints.
(Contd. on page 3)
Page 3
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Revision: February 9, 2016
Trade name: Super Lube® Grommet Lube
·
After skin contact:
Immediately rinse with water.
If skin irritation is experienced, consult a doctor.
·
After eye contact:
Protect unharmed eye.
Remove contact lenses if worn.
Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor.
·
After swallowing:
Rinse out mouth and then drink plenty of water.
Do not induce vomiting. Seek medical attention.
·
4.2 Most important symptoms and effects, both acute and delayed
·
Hazards
·
4.3 Indication of any immediate medical attention and special treatment needed
No further relevant information available.
No further relevant information available.
Slight irritant effect on eyes.
Page 3/9
(Contd. of page 2)
SECTION 5: Firefighting measures
·
5.1 Extinguishing media
·
Suitable extinguishing agents:
The product is not flammable.
Use fire extinguishing methods suitable to surrounding conditions.
·
For safety reasons unsuitable extinguishing agents:
·
5.2 Special hazards arising from the substance or mixture
None.
Formation of toxic gases is possible during heating or in case of fire.
·
5.3 Advice for firefighters
·
Protective equipment:
Wear self-contained respiratory protective device.
Wear fully protective suit.
·
Additional information
No further relevant information available.
SECTION 6: Accidental release measures
·
6.1 Personal precautions, protective equipment and emergency procedures
Ensure adequate ventilation
Particular danger of slipping on leaked/spilled product.
·
6.2 Environmental precautions:
·
6.3 Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Dispose contaminated material as waste according to item 13.
Send for recovery or disposal in suitable receptacles.
·
6.4 Reference to other sections
See Section 7 for information on safe handling.
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.
Do not allow to enter sewers/ surface or ground water.
(Contd. on page 4)
40.1.5
Page 4
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Trade name: Super Lube® Grommet Lube
SECTION 7: Handling and storage
·
7.1 Precautions for safe handling
·
Information about fire - and explosion protection:
·
7.2 Conditions for safe storage, including any incompatibilities
·
Storage:
·
Requirements to be met by storerooms and receptacles:
·
Information about storage in one common storage facility:
·
Further information about storage conditions:
·
7.3 Specific end use(s)
No further relevant information available.
SECTION 8: Exposure controls/personal protection
Use only in well ventilated areas.
No special measures required.
None.
Page 4/9
Revision: February 9, 2016
(Contd. of page 3)
Store in cool, dry place.
Store away from foodstuffs.
·
Additional information about design of technical facilities:
·
8.1 Control parameters
·
Ingredients with limit values that require monitoring at the workplace:
No further data; see item 7.
57-55-6 Propylene Glycol
WEEL (USA) Long-term value: 10 mg/m³
EV (Canada) Long-term value: 155* 10** mg/m³, 50* ppm
*vapour and aerosol;**aerosol only
·
DNELs
·
PNECs
·
Additional information:
·
8.2 Exposure controls
·
Personal protective equipment:
·
General protective and hygienic measures:
No further relevant information available.
No further relevant information available.
The lists valid during the making were used as basis.
The usual precautionary measures are to be adhered to when handling chemicals.
Keep away from foodstuffs, beverages and feed.
Avoid contact with the eyes.
·
Respiratory protection:
·
Protection of hands:
Not required under normal conditions of use.
Not required under normal conditions of use.
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the
degradation.
·
Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of
quality and varies from manufacturer to manufacturer. As the product is a prepar ation of several
substances, the resistance of the glove material can not be calculated in advance and has therefore to be
checked prior to the application.
·
Penetration time of glove material
The exact break through time has to be found out by the manufacturer of the protective gloves and has to
be observed.
(Contd. on page 5)
40.1.5
Page 5
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Trade name: Super Lube® Grommet Lube
·
Eye protection:
Safety glasses
·
Body protection:
·
Limitation and supervision of exposure into the environment
·
Risk management measures
SECTION 9: Physical and chemical properties
·
9.1 Information on basic physical and chemical properties
·
General Information
·
Appearance:
Form:
Colour:
·
Odour:
·
Odour threshold:
·
pH-value at 20 °C (68 °F):
·
Change in condition
Melting point/Melting range:
Boiling point/Boiling range:
·
Flash point:
·
Flammability (solid, gaseous):
·
Auto/Self-ignition temperature:
·
Decomposition temperature:
·
Self-igniting:
·
Danger of explosion:
·
Explosion limits:
Lower:
Upper:
·
Vapour pressure:
·
Density:
·
Relative density
·
Vapour density
·
Evaporation rate
·
Solubility in / Miscibility with
water:
·
Partition coefficient (n-octanol/water):
Not required under normal conditions of use.
No special requirements.
Liquid
Orange
Mild
Not determined.
7
Not Determined.
Undetermined.
Not applicable.
Not applicable.
Not determined.
Not determined.
Product is not self-igniting.
Product does not present an explosion hazard.
Not determined.
Not determined.
Not determined.
Not determined.
Not determined.
Not determined.
Not determined.
Fully miscible.
Not determined.
Page 5/9
Revision: February 9, 2016
(Contd. of page 4)
No special requirements.
(Contd. on page 6)
40.1.5
Page 6
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Trade name: Super Lube® Grommet Lube
·
Viscosity:
Dynamic:
Kinematic:
·
9.2 Other information
SECTION 10: Stability and reactivity
·
10.1 Reactivity
·
10.2 Chemical stability
·
Thermal decomposition / conditions to be avoided:
No decomposition if used and stored according to specifications.
·
10.3 Possibility of hazardous reactions
Reacts with oxidising agents.
Toxic fumes may be released if heated above the decomposition point.
·
10.4 Conditions to avoid
·
10.5 Incompatible materials:
·
10.6 Hazardous decomposition products:
No further relevant information available.
No further relevant information available.
Not determined.
Not determined.
No further relevant information available.
Carbon monoxide and carbon dioxide
Page 6/9
Revision: February 9, 2016
(Contd. of page 5)
SECTION 11: Toxicological information
·
11.1 Information on toxicological effects
·
Acute toxicity:
·
LD/LC50 values relevant for classification:
·
Primary irritant effect:
·
on the skin:
·
on the eye:
·
Sensitisation:
·
Subacute to chronic toxicity:
·
Additional toxicological information:
No irritant effect.
Slight irritant effect on eyes.
No sensitising effects known.
No further relevant information available.
None.
The product is not subject to classification according to the calculation method of the General EU
Classification Guidelines for Preparations as issued in the latest version.
When used and handled according to specifications, the product does not have any harmful effects to our
experience and the information provided to us.
·
Acute effects (acute toxicity, irritation and corrosivity):
·
Repeated dose toxicity:
·
CMR effects (carcinogenity, mutagenicity and toxicity for reproduction):
No further relevant information available.
None.
None.
SECTION 12: Ecological information
·
12.1 Toxicity
·
Aquatic toxicity:
·
12.2 Persistence and degradability
·
12.3 Bioaccumulative potential
·
12.4 Mobility in soil
The product contains materials that are harmful to the environment.
No further relevant information available.
No further relevant information available.
No further relevant information available.
(Contd. on page 7)
40.1.5
Page 7
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Revision: February 9, 2016
Trade name: Super Lube® Grommet Lube
(Contd. of page 6)
·
Additional ecological information:
·
General notes:
Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage
system.
Water hazard class 1 (German Regulation) (Self-assessment): slightly hazardous for water
·
12.5 Results of PBT and vPvB assessment
·
PBT:
Not applicable.
·
vPvB:
·
12.6 Other adverse effects
SECTION 13: Disposal considerations
·
13.1 Waste treatment methods
·
Recommendation
Smaller quantities can be disposed of with household waste.
The user of this material has the responsibility to dispose of unused material, residues and containers in
compliance with all relevant local, state and federal laws and regulations regarding treatment, storage and
disposal for hazardous and nonhazardous wastes. Residual materials should be treated as hazardous.
·
Uncleaned packaging:
·
Recommendation:
Not applicable.
No further relevant information available.
Disposal must be made according to official regulations.
Page 7/9
SECTION 14: Transport information
·
14.1 UN-Number
·
DOT, ADR, ADN, IMDG, IATA
·
14.2 UN proper shipping name
·
DOT, ADR, ADN, IMDG, IATA
·
14.3 Transport hazard class(es)
·
DOT, ADR, ADN, IMDG, IATA
·
Class
·
14.4 Packing group
·
DOT, ADR, IMDG, IATA
·
14.5 Environmental hazards:
·
Marine pollutant:
·
14.6 Special precautions for user
·
14.7 Transport in bulk according to Annex II of
MARPOL73/78 and the IBC Code
·
UN "Model Regulation":
Not Regulated
Not Regulated
Not Regulated
Not Regulated
No
Not applicable.
Not applicable.
-
(Contd. on page 8)
40.1.5
Page 8
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Revision: February 9, 2016
Trade name: Super Lube® Grommet Lube
(Contd. of page 7)
SECTION 15: Regulatory information
·
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
·
United States (USA)
·
SARA
·
Section 355 (extremely hazardous substances):
None of the ingredients are listed.
·
Section 313 (Specific toxic chemical listings):
None of the ingredients are listed.
·
TSCA (Toxic Substances Control Act):
All ingredients are listed.
·
Proposition 65 (California):
·
Chemicals known to cause cancer:
None of the ingredients is listed.
·
Chemicals known to cause reproductive toxicity for females:
None of the ingredients are listed.
·
Chemicals known to cause reproductive toxicity for males:
None of the ingredients are listed.
·
Chemicals known to cause developmental toxicity:
None of the ingredients are listed.
·
Carcinogenic Categories
·
EPA (Environmental Protection Agency)
None of the ingredients are listed.
·
IARC (International Agency for Research on Cancer)
None of the ingredients are listed.
·
TLV (Threshold Limit Value established by ACGIH)
None of the ingredients are listed.
·
NIOSH-Ca (National Institute for Occupational Safety and Health)
None of the ingredients are listed.
·
Canada
·
Canadian Domestic Substances List (DSL)
All ingredients are listed.
·
Canadian Ingredient Disclosure list (limit 0.1%)
None of the ingredients are listed.
·
Canadian Ingredient Disclosure list (limit 1%)
57-55-6 Propylene Glycol
Page 8/9
·
Other regulations, limitations and prohibitive regulations
This product has been classified in accordance with hazard criteria of the Controlled Products Regulations
and the SDS contains all the information required by the Controlled Products Regulations.
(Contd. on page 9)
40.1.5
Page 9
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Revision: February 9, 2016
Trade name: Super Lube® Grommet Lube
(Contd. of page 8)
·
Substances of very high concern (SVHC) according to REACH, Article 57
None of the ingredients are listed.
·
15.2 Chemical safety assessment:
SECTION 16: Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any
specific product features and shall not establish a legally valid contractual relationship.
·
Relevant phrases
H412 Harmful to aquatic life with long lasting effects.
·
Abbreviations and acronyms:
ADR: Accord européen s ur le transport des m archandises dangereuses par Route (European Agreem ent concerning the
International Carriage of Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods
DOT: US Department of Transportation
IATA: International Air Transport Association
GHS: Globally Harmonised System of Classification and Labelling of Chemicals
ACGIH: American Conference of Governmental Industrial Hygienists
EINECS: European Inventory of Existing Commercial Chemical Substances
ELINCS: European List of Notified Chemical Substances
CAS: Chemical Abstracts Service (division of the American Chemical Society)
DNEL: Derived No-Effect Level (REACH)
PNEC: Predicted No-Effect Concentration (REACH)
LC50: Lethal concentration, 50 percent
LD50: Lethal dose, 50 percent
Aquatic Chronic 3: Hazardous to the aquatic environment - Chronic Hazard, Category 3
·
Sources
SDS Prepared by:
ChemTel Inc.
1305 North Florida Avenue
Tampa, Florida USA 33602-2902
Toll Free North America 1-888-255-3924 Intl. +01 813-248-0573
Website: www.chemtelinc.com
A Chemical Safety Assessment has not been carried out.
Page 9/9
40.1.5
Loading...