Page 1
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Revision: February 9, 2016
SE CTION 1: Identification of the substance/mixture and of the company/
undertaking
·
1.1 Product identifier
·
Trade name: Super Lube® Air Tool Pneumatic Lubricant
·
Article number:
·
1.2 Relevant identified uses of the substance or mixture and uses advised against
No further relevant information available.
·
Application of the substance / the mixture
·
1.3 Details of the supplier of the Safety Data Sheet
·
Manufacturer/Supplier:
Synco Chemical Corporation
24 DaVinci Dr., P.O. Box 405
Bohemia, NY 11716
Telephone: 631-567-5300
Email: info@super-lube.com
·
1.4 Emergency telephone number:
CHEMTREC
1-800-424-9300 (US/Canada)
+01 703-527-3887 (International)
No other identifiers
Lubricant
Page 1/9
SECTION 2: Hazards identification
·
2.1 Classification of the substance or mixture
·
Classification according to Regulation (EU) No 2015/830
The product is not classified as hazardous according to OSHA GHS regulations within the United States.
The product is not classified as hazardous according to the CLP regulation.
·
Information concerning particular hazards for human and environment:
The product does not have to be labelled due to the calculation procedure of the "General Classification
guideline for preparations of the EU" in the latest valid version.
Classification system:
·
The classification is according to the latest editions of the EU-lists, and extended by company and
literature data.
The classification is in accordance with the latest editions of international substances lists, and is
supplemented by information from technical literature and by information provided by the company.
·
Additional information:
There are no other hazards not otherwise classified that have been identified.
0 percent of the mixture consists of component(s) of unknown toxicity
·
2.2 Label elements
·
Labelling according to Regulation (EC) No 1272/2008
The product is not classified as hazardous according to OSHA GHS regulations within the United States.
This product does not have a classification according to the CLP regulation.
·
Hazard pictograms
·
Signal word
Not Regulated
Not Regulated
(Contd. on page 2)
40.1.5
Page 2
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Trade name: Super Lube® Air Tool Pneumatic Lubricant
·
Hazard-determining components of labelling:
·
Hazard statements
·
Additional information:
Not Regulated
EUH210 Safety data sheet available on request.
·
Hazard description:
·
WHMIS-symbols:
·
NFPA ratings (scale 0 - 4)
Not hazardous under WHMIS.
Health = 1
110
·
HMIS-ratings (scale 0 - 4)
Fire = 1
Reactivity = 0
None.
Page 2/9
Revision: February 9, 2016
(Contd. of page 1)
HEALTH
FIRE
REACTIVITY
·
HMIS Long Term Health Hazard Substances
1
Health = 1
1
Fire = 1
0
Reactivity = 0
None of the ingredients are listed.
·
2.3 Other hazards
·
Results of PBT and vPvB assessment
·
PBT:
Not applicable.
·
vPvB:
Not applicable.
SECTION 3: Composition/information on ingredients
·
3.2 Mixtures
·
Description:
·
Dangerous components:
CAS: 80939-62-4
EINECS: 279-632-6
·
Additional information:
For the listed ingredients, the identity and exact percentages are being withheld as a trade secret.
For the wording of the listed risk phrases refer to section 16.
Mixture of substances listed below with nonhazardous additions.
Amines, C11-14-branched alkyl, monohexyl and dihexyl phosphates
Aquatic Chronic 2, H411
Skin Irrit. 2, H315; Eye Irrit. 2, H319
< 2,
5%
SECTION 4: First aid measures
·
4.1 Description of first aid measures
·
General information:
·
After inhalation:
·
After skin contact:
Immediately wash with water and soap and rinse thoroughly.
40.1.5
No special measures required.
Supply fresh air; consult doctor in case of complaints.
(Contd. on page 3)
Page 3
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Trade name: Super Lube® Air Tool Pneumatic Lubricant
If skin irritation is experienced, consult a doctor.
·
After eye contact:
Rinse opened eye for several minutes under running water.
Remove contact lenses if worn.
Seek medical treatment in case of complaints.
·
After swallowing:
Rinse out mouth and then drink plenty of water.
Do not induce vomiting; call for medical help immediately.
·
4.2 Most important symptoms and effects, both acute and delayed
May cause gastro-intestinal irritation if ingested.
Acne
·
Hazards
May be harmful if swallowed.
May be harmful in contact with skin.
·
4.3 Indication of any immediate medical attention and special treatment needed
No further relevant information available.
Page 3/9
Revision: February 9, 2016
(Contd. of page 2)
SECTION 5: Firefighting measures
·
5.1 Extinguishing media
·
Suitable extinguishing agents:
·
For safety reasons unsuitable extinguishing agents:
·
5.2 Special hazards arising from the substance or mixture
Use fire extinguishing methods suitable to surrounding conditions.
Water with full jet
Formation of toxic gases is possible during heating or in case of fire.
·
5.3 Advice for firefighters
·
Protective equipment:
Wear self-contained respiratory protective device.
Wear fully protective suit.
·
Additional information
No further relevant information available.
SECTION 6: Accidental release measures
·
6.1 Personal precautions, protective equipment and emergency procedures
Ensure adequate ventilation
Particular danger of slipping on leaked/spilled product.
·
6.2 Environmental precautions:
·
6.3 Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Pick up mechanically.
Dispose contaminated material as waste according to item 13.
·
6.4 Reference to other sections
See Section 7 for information on safe handling.
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.
Do not allow to enter sewers/ surface or ground water.
(Contd. on page 4)
40.1.5
Page 4
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Trade name: Super Lube® Air Tool Pneumatic Lubricant
SECTION 7: Handling and storage
·
7.1 Precautions for safe handling
·
Information about fire - and explosion protection:
·
7.2 Conditions for safe storage, including any incompatibilities
·
Storage:
·
Requirements to be met by storerooms and receptacles:
·
Information about storage in one common storage facility:
Store away from foodstuffs.
Do not store together with oxidising and acidic materials.
·
Further information about storage conditions:
·
7.3 Specific end use(s)
No further relevant information available.
Store away from oxidising agents.
No special measures required.
None.
Page 4/9
Revision: February 9, 2016
(Contd. of page 3)
No special requirements.
SECTION 8: Exposure controls/personal protection
·
Additional information about design of technical facilities:
·
8.1 Control parameters
·
Ingredients with limit values that require monitoring at the workplace:
The product does not contain any relevant quantities of materials with critical values that have to be
monitored at the workplace.
·
DNELs
·
PNECs
·
Additional information:
·
8.2 Exposure controls
·
Personal protective equipment:
·
General protective and hygienic measures:
No further relevant information available.
No further relevant information available.
The lists valid during the making were used as basis.
The usual precautionary measures are to be adhered to when handling chemicals.
Keep away from foodstuffs, beverages and feed.
Avoid contact with the eyes and skin.
·
Respiratory protection:
·
Protection of hands:
Not required under normal conditions of use.
Gloves not required under normal conditions of use.
Wear protective gloves to handle contents of damaged or leaking units.
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the
degradation.
·
Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of
quality and varies from manufacturer to manufacturer. As the product is a preparation of several
substances, the resistance of the glove material can not be calculated in advance and has therefore to be
checked prior to the application.
·
Penetration time of glove material
The exact break through time has to be found out by the manufacturer of the protective gloves and has to
be observed.
No further data; see item 7.
(Contd. on page 5)
40.1.5
Page 5
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Trade name: Super Lube® Air Tool Pneumatic Lubricant
·
Eye protection:
Safety glasses
·
Body protection:
·
Limitation and supervision of exposure into the environment
·
Risk management measures
SECTION 9: Physical and chemical properties
·
9.1 Information on basic physical and chemical properties
·
General Information
·
Appearance:
Form:
Colour:
·
Odour:
·
Odour threshold:
·
pH-value:
·
Change in condition
Melting point/Melting range:
Boiling point/Boiling range:
·
Flash point:
·
Flammability (solid, gaseous):
·
Auto/Self-ignition temperature:
·
Decomposition temperature:
·
Self-igniting:
·
Danger of explosion:
·
Explosion limits:
Lower:
Upper:
·
Vapour pressure:
·
Density at 20 °C (68 °F):
·
Relative density
·
Vapour density
·
Evaporation rate
·
Solubility in / Miscibility with
water:
·
Partition coefficient (n-octanol/water):
Not required under normal conditions of use.
No special requirements.
Liquid
Translucent
Mild
Not determined.
Not determined.
Not Determined.
Undetermined.
220 °C (428 °F) (COC)
Not applicable.
Not determined.
Not determined.
Product is not self-igniting.
Product does not present an explosion hazard.
Not determined.
Not determined.
Not determined.
0,89 g/cm³ (7,427 lbs/gal)
Not determined.
Not determined.
Not determined.
Not miscible or difficult to mix.
Not determined.
Page 5/9
Revision: February 9, 2016
(Contd. of page 4)
No special requirements.
(Contd. on page 6)
40.1.5
Page 6
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Trade name: Super Lube® Air Tool Pneumatic Lubricant
·
Viscosity:
Dynamic:
Kinematic:
·
9.2 Other information
SECTION 10: Stability and reactivity
·
10.1 Reactivity
·
10.2 Chemical stability
·
Thermal decomposition / conditions to be avoided:
No decomposition if used and stored according to specifications.
·
10.3 Possibility of hazardous reactions
·
10.4 Conditions to avoid
·
10.5 Incompatible materials:
·
10.6 Hazardous decomposition products:
Avoid acids.
No further relevant information available.
Not determined.
Not determined.
No further relevant information available.
Reacts with strong acids and oxidising agents.
Carbon monoxide and carbon dioxide
Page 6/9
Revision: February 9, 2016
(Contd. of page 5)
SECTION 11: Toxicological information
·
11.1 Information on toxicological effects
·
Acute toxicity:
·
LD/LC50 values relevant for classification:
·
Primary irritant effect:
·
on the skin:
·
on the eye:
·
Sensitisation:
·
Subacute to chronic toxicity:
·
Additional toxicological information:
Slight irritant effect on skin and mucous membranes.
Slight irritant effect on eyes.
No sensitising effects known.
No further relevant information available.
None.
The product is not subject to classification according to the calculation method of the General EU
Classification Guidelines for Preparations as issued in the latest version.
When used and handled according to specifications, the product does not have any harmful effects to our
experience and the information provided to us.
May cause acne.
·
Repeated dose toxicity:
·
CMR effects (carcinogenity, mutagenicity and toxicity for reproduction):
No further relevant information available.
See Section 15.
SECTION 12: Ecological information
·
12.1 Toxicity
·
Aquatic toxicity:
·
12.2 Persistence and degradability
·
12.3 Bioaccumulative potential
·
12.4 Mobility in soil
·
Ecotoxical effects:
·
Remark:
Harmful to fish
The product contains materials that are harmful to the environment.
The product is partially biodegradable. Significant residuals remain.
No further relevant information available.
No further relevant information available.
(Contd. on page 7)
40.1.5
Page 7
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Revision: February 9, 2016
Trade name: Super Lube® Air Tool Pneumatic Lubricant
(Contd. of page 6)
·
Additional ecological information:
·
General notes:
Avoid transfer into the environment.
Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage
system.
Harmful to aquatic organisms
Water hazard class 1 (German Regulation) (Self-assessment): slightly hazardous for water
·
12.5 Results of PBT and vPvB assessment
·
PBT:
Not applicable.
·
vPvB:
·
12.6 Other adverse effects
SECTION 13: Disposal considerations
·
13.1 Waste treatment methods
·
Recommendation
Contact waste processors for recycling information.
Can be burned with household garbage after consulting with the waste disposal facility operator and the
pertinent authorities and adhering to the necessary technical regulations.
The user of this material has the responsibility to dispose of unused material, residues and containers in
compliance with all relevant local, state and federal laws and regulations regarding treatment, storage and
disposal for hazardous and nonhazardous wastes.
·
Uncleaned packaging:
·
Recommendation:
Not applicable.
No further relevant information available.
Disposal must be made according to official regulations.
Page 7/9
SECTION 14: Transport information
·
14.1 UN-Number
·
DOT, ADR, ADN, IMDG, IATA
·
14.2 UN proper shipping name
·
DOT, ADR, ADN, IMDG, IATA
·
14.3 Transport hazard class(es)
·
DOT, ADR, ADN, IMDG, IATA
·
Class
·
14.4 Packing group
·
DOT, ADR, IMDG, IATA
·
14.5 Environmental hazards:
·
Marine pollutant:
·
14.6 Special precautions for user
·
14.7 Transport in bulk according to Annex II of
MARPOL73/78 and the IBC Code
·
UN "Model Regulation":
Not Regulated
Not Regulated
Not Regulated
Not Regulated
No
Not applicable.
Not applicable.
-
(Contd. on page 8)
40.1.5
Page 8
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Revision: February 9, 2016
Trade name: Super Lube® Air Tool Pneumatic Lubricant
(Contd. of page 7)
SECTION 15: Regulatory information
·
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
·
United States (USA)
·
SARA
·
Section 355 (extremely hazardous substances):
None of the ingredients are listed.
·
Section 313 (Specific toxic chemical listings):
None of the ingredients are listed.
·
TSCA (Toxic Substances Control Act):
All ingredients are listed.
·
Proposition 65 (California):
·
Chemicals known to cause cancer:
None of the ingredients is listed.
·
Chemicals known to cause reproductive toxicity for females:
None of the ingredients are listed.
·
Chemicals known to cause reproductive toxicity for males:
None of the ingredients are listed.
·
Chemicals known to cause developmental toxicity:
None of the ingredients are listed.
·
Carcinogenic Categories
·
EPA (Environmental Protection Agency)
None of the ingredients are listed.
·
IARC (International Agency for Research on Cancer)
None of the ingredients are listed.
·
TLV (Threshold Limit Value established by ACGIH)
None of the ingredients are listed.
·
NIOSH-Ca (National Institute for Occupational Safety and Health)
None of the ingredients are listed.
·
Canada
·
Canadian Domestic Substances List (DSL)
All ingredients are listed.
·
Canadian Ingredient Disclosure list (limit 0.1%)
None of the ingredients are listed.
·
Canadian Ingredient Disclosure list (limit 1%)
None of the ingredients are listed.
Page 8/9
·
Other regulations, limitations and prohibitive regulations
This product has been classified in accordance with hazard criteria of the Controlled Products Regulations
and the SDS contains all the information required by the Controlled Products Regulations.
(Contd. on page 9)
40.1.5
Page 9
Safety Data Sheet
according to (EU) 2015 / 830 and OSHA GHS
Revision: February 9, 2016
Trade name: Super Lube® Air Tool Pneumatic Lubricant
(Contd. of page 8)
·
Substances of very high concern (SVHC) according to REACH, Article 57
None of the ingredients are listed.
·
15.2 Chemical safety assessment:
SECTION 16: Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any
ecific product features and shall not establish a legally valid contractual relationship.
sp
·
Relevant phrases
H315 Causes skin irritation.
H319 Causes serious eye irritation.
H411 Toxic to aquatic life with long lasting effects.
A Chemical Safety Assessment has not been carried out.
Page 9/9
Abbreviations and acronyms:
·
ADR: Accord européen s ur le t ransport des m archandises dangereuses par Route (Eu ropean Agreem ent conce rning the
International Carriage of Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods
DOT: US Department of Transportation
IATA: International Air Transport Association
GHS: Globally Harmonised System of Classification and Labelling of Chemicals
ACGIH: American Conference of Governmental Industrial Hygienists
EINECS: European Inventory of Existing Commercial Chemical Substances
ELINCS: European List of Notified Chemical Substances
CAS: Chemical Abstracts Service (division of the American Chemical Society)
DNEL: Derived No-Effect Level (REACH)
PNEC: Predicted No-Effect Concentration (REACH)
LC50: Lethal concentration, 50 percent
LD50: Lethal dose, 50 percent
Skin Irrit. 2: Skin corrosion/irritation, Hazard Category 2
Eye Irrit. 2: Serious eye damage/eye irritation, Hazard Category 2
Aquatic Chronic 2: Hazardous to the aquatic environment - Chronic Hazard, Category 2
·
Sources
SDS created by Environmental Protection Department
40.1.5
Loading...