Page: 1/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date: 07 June 2018 Revision: 07 June 2018
SECTION 1: Identific ation of the substance/mixture and of the company/
undertaking
·
1.1 Product identifier
·
Trade name: Rust-Buster
·
Other means of identification:
CAS number:
EC number:
Index number:
Registration number:
·
1.2 Relevant identified uses of the substance or mixture and uses advised against
·
Application of the substance / the mixture:
·
Uses advised against:
·
1.3 Details of the supplier of the Safety Data Sheet
·
Manufacturer/Supplier:
Highside Chemicals, Inc.
11114 Reichold Road
Gulfport, MS 39503 USA
Phone: (228) 896-9220
·
1.4 Emergency telephone number:
ChemTel Inc.
(800)255-3924 (North America)
+1 (813)248-0585 (International)
64742-47-8
265-149-8
649-422-00-2
01-2119484819-18-XXXX
Lubricant
No further relevant information available.
SECTION 2: Hazards identification
·
2.1 Classification of the substance or mixture
·
Classification according to Regulation (EC) No 1272/2008
Asp. Tox. 1 H304 May be fatal if swallowed and enters airways.
·
2.2 Label elements
·
Labelling according to Regulation (EC) No 1272/2008
The product is additionally classified and labelled according to the Globally Harmonized System within the
United States (GHS).
The substance is classified and labelled according to the CLP regulation.
·
Hazard pictograms
GHS08
·
Signal word
·
Hazard-determining components of labelling:
Distillates (petroleum), hydrotreated light
·
Hazard statements
H304 May be fatal if swallowed and enters airways.
·
Precautionary statements
P301+P310 IF SWALLOWED: Immediately call a POISON CENTER/ doctor.
Danger
(Cont'd. on page 2)
47.0.2
Page: 2/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date: 07 June 2018 Revision: 07 June 2018
Trade name:
P331 Do NOT induce vomiting.
P405 Store locked up.
P501 Dispose of contents/container in accordance with local/regional/national/international
·
Additional information:
EUH066 Repeated exposure may cause skin dryness or cracking.
·
2.3 Other hazards
·
Results of PBT and vPvB assessment
·
PBT:
·
vPvB:
Rust-Buster
(Cont'd. from page 1)
regulations.
There are no other hazards not otherwise classified that have been identified.
Not applicable.
Not applicable.
SECTION 3: Composition/information on ingredients
·
3.1 Substances
·
Description
Distillates (petroleum), hydrotreated light
·
Identification number(s)
CAS number:
EC number:
Index number:
Registration number:
64742-47-8
265-149-8
649-422-00-2
01-2119484819-18-XXXX
SECTION 4: First aid measures
·
4.1 Description of first aid measures
·
After inhalation:
Supply fresh air.
Provide oxygen treatment if affected person has difficulty breathing.
Seek medical help for symptoms or if unconscious.
In case of unconsciousness place patient stably in side position for transportation.
·
After skin contact:
Wash with soap and water.
If skin irritation is experienced, consult a doctor.
·
After eye contact:
Remove contact lenses if worn.
Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor.
·
After swallowing:
Rinse out mouth and then drink plenty of water.
Do not induce vomiting; call for medical help immediately.
A person vomiting while lying on their back should be turned onto their side.
·
4.2 Most important symptoms and effects, both acute and delayed
Breathing difficulty
Coughing
Gastric or intestinal disorders when ingested.
Nausea in case of ingestion.
·
Hazards:
May be fatal if swallowed and enters airways.
(Cont'd. on page 3)
47.0.2
Page: 3/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date: 07 June 2018 Revision: 07 June 2018
Trade name:
Danger of impaired breathing.
·
4.3 Indication of any immediate medical attention and special treatment needed
If swallowed, gastric irrigation with added, activated carbon.
If swallowed or in case of vomiting, danger of entering the lungs.
If necessary oxygen respiration treatment.
Later observation for pneumonia and pulmonary oedema.
Rust-Buster
SECTION 5: Firefighting measures
·
5.1 Extinguishing media
·
Suitable extinguishing agents:
Gaseous extinguishing agents
Carbon dioxide
Foam
Fire-extinguishing powder
Water haze or fog
·
For safety reasons unsuitable extinguishing agents:
Water with full jet
Water spray
·
5.2 Special hazards arising from the substance or mixture
Formation of toxic gases is possible during heating or in case of fire.
·
5.3 Advice for firefighters
·
Protective equipment:
Wear self-contained respiratory protective device.
Wear fully protective suit.
·
Additional information:
Cool endangered receptacles with water fog or haze.
(Cont'd. from page 2)
SECTION 6: Accidental release measures
·
6.1 Personal precautions, protective equipment and emergency procedures
Ensure adequate ventilation
Particular danger of slipping on leaked/spilled product.
Use personal protective equipment as required.
·
6.2 Environmental precautions
Do not allow product to reach sewage system or any water course.
Prevent from spreading (e.g. by damming-in or oil barriers).
·
6.3 Methods and material for containment and cleaning up
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Remove from the water surface (e.g. skim or suck off).
Send for recovery or disposal in suitable receptacles.
·
6.4 Reference to other sections
See Section 7 for information on safe handling.
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.
(Cont'd. on page 4)
47.0.2
Page: 4/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date: 07 June 2018 Revision: 07 June 2018
Trade name:
Rust-Buster
SECTION 7: Handling and storage
·
7.1 Precautions for safe handling
Keep out of reach of children.
Avoid splashes or spray in enclosed areas.
Use only in well ventilated areas.
·
Information about fire - and explosion protection:
·
7.2 Conditions for safe storage, including any incompatibilities
·
Requirements to be met by storerooms and receptacles:
Avoid storage near extreme heat.
Store in cool, dry conditions in well sealed receptacles.
·
Information about storage in one common storage facility:
Store away from foodstuffs.
Store away from oxidising agents.
·
7.3 Specific end use(s)
No further relevant information available.
Keep ignition sources away.
SECTION 8: Exposure controls/personal protection
·
8.1 Control parameters
·
Ingredients with limit values that require monitoring at the workplace:
64742-47-8 Distillates (petroleum), hydrotreated light
EL (Canada) Long-term value: 200 mg/m³
Skin
(Cont'd. from page 3)
·
8.2 Exposure controls
·
General protective and hygienic measures:
The usual precautionary measures are to be adhered to when handling chemicals.
Keep away from foodstuffs, beverages and feed.
Wash hands before breaks and at the end of work.
Avoid contact with the eyes.
Avoid breathing mist/vapours/spray.
Avoid close or long term contact with the skin.
·
Respiratory protection:
Not required under normal conditions of use.
Use suitable respiratory protective device when aerosol or mist is formed.
NIOSH or EN approved organic vapour respirator equipped with a dust/mist prefilter should be used.
·
Protection of hands:
Gloves not required under normal conditions of use.
Gloves are advised for repeated or prolonged contact.
Wear protective gloves to handle contents of damaged or leaking units.
·
For the permanent contact gloves made of the following materials are suitable:
Nitrile rubber, NBR
Neoprene gloves
·
Eye protection:
(Cont'd. on page 5)
47.0.2
Page: 5/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date: 07 June 2018 Revision: 07 June 2018
Trade name:
Rust-Buster
Safety glasses
Follow relevant national guidelines concerning the use of protective eyewear.
·
Body protection:
·
Limitation and supervision of exposure into the environment:
·
Risk management measures:
Protection may be required for spills.
No further relevant information available.
SECTION 9: Physical and chemical properties
·
9.1 Information on basic physical and chemical properties
·
Appearance
Form:
Colour:
·
Odour:
·
Odour threshold:
·
pH-value:
·
Melting point/freezing point:
·
Initial boiling point and boiling range:
·
Flash point:
·
Flammability (solid, gas):
·
Auto/Self-ignition temperature:
·
Decomposition temperature:
·
Explosive properties:
·
Explosion limits
Lower:
Upper:
·
Oxidising properties
·
Vapour pressure at 20 °C (68 °F):
·
Density:
Relative density:
Vapour density:
Evaporation rate:
·
Solubility in / Miscibility with
water:
·
Partition coefficient: n-octanol/water:
·
Viscosity
Dynamic:
Kinematic at 40 °C (104 °F):
Liquid
Colourless
Mild
Hydrocarbon.
Not determined.
Not determined.
-49 °C (-56,2 °F)
222,78-245 °C (433-473 °F)
95 °C (203 °F) (PMCC)
Not applicable.
>220 °C (>428 °F)
Not determined.
Product does not present an explosion hazard.
0,6 Vol %
5,5 Vol %
Not determined.
0,027 kPa
0,804
4,5 (air = 1)
0,19 (butyl acetate = 1)
1,5 g/l
Not determined.
Not determined.
0,02 cm²/s
(Cont'd. from page 4)
Avoid release to the environment.
(Cont'd. on page 6)
47.0.2
Page: 6/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date: 07 June 2018 Revision: 07 June 2018
Trade name:
·
9.2 Other information
Rust-Buster
No further relevant information available.
SECTION 10: Stability and reactivity
·
10.1 Reactivity
·
10.2 Chemical stability
·
Thermal decomposition / conditions to be avoided:
No decomposition if used and stored according to specifications.
·
10.3 Possibility of hazardous reactions
Toxic fumes may be released if heated above the decomposition point.
Reacts with strong oxidising agents.
·
10.4 Conditions to avoid
·
10.5 Incompatible materials
·
10.6 Hazardous decomposition products
Under fire conditions only:
Carbon monoxide and carbon dioxide
No further relevant information available.
Stable under normal temperatures and pressures.
No further relevant information available.
Oxidisers
SECTION 11: Toxicological information
(Cont'd. from page 5)
·
11.1 Information on toxicological effects
·
Acute toxicity:
·
LD/LC50 values relevant for classification:
64742-47-8 Distillates (petroleum), hydrotreated light
Oral LD50 >5000 mg/kg (rat)
Dermal LD50 >2000 mg/kg (rabbit)
·
Primary irritant effect
·
Skin corrosion/irritation:
·
Serious eye damage/irritation:
·
Respiratory or skin sensitisation:
·
Carcinogenic categories
·
IARC (International Agency for Research on Cancer):
Substance is not listed.
·
Probable routes of exposure:
Ingestion.
Inhalation.
Eye contact.
Skin contact.
·
Repeated dose toxicity:
·
Germ cell mutagenicity:
·
Carcinogenicity:
·
Reproductive toxicity:
·
STOT-single exposure:
·
STOT-repeated exposure:
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Repeated exposure may cause skin dryness or cracking.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
(Cont'd. on page 7)
47.0.2
Page: 7/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date: 07 June 2018 Revision: 07 June 2018
Trade name:
·
Aspiration hazard:
May be fatal if swallowed and enters airways.
Rust-Buster
(Cont'd. from page 6)
SECTION 12: Ecological information
·
12.1 Toxicity
·
Aquatic toxicity:
·
12.2 Persistence and degradability
·
12.3 Bioaccumulative potential
·
12.4 Mobility in soil
·
Additional ecological information:
·
General notes:
·
12.5 Results of PBT and vPvB assessment
·
PBT:
Not applicable.
·
vPvB:
·
12.6 Other adverse effects
Not applicable.
No further relevant information available.
No further relevant information available.
No further relevant information available.
No further relevant information available.
Avoid release to the environment.
No further relevant information available.
SECTION 13: Disposal considerations
·
13.1 Waste treatment methods
·
Recommendation
Contact waste processors for recycling information.
The user of this material has the responsibility to dispose of unused material, residues and containers in
compliance with all relevant local, state and federal laws and regulations regarding treatment, storage and
disposal for hazardous and nonhazardous wastes.
·
Uncleaned packaging:
·
Recommendation:
Disposal must be made according to official regulations.
SECTION 14: Transport information
·
14.1 UN-Number
·
DOT, ADR, IMDG, IATA
·
14.2 UN proper shipping name
·
DOT, ADR, IMDG, IATA
·
14.3 Transport hazard class(es)
·
DOT, ADR, IMDG, IATA
·
Class
·
14.4 Packing group
·
DOT, ADR, IMDG, IATA
·
14.5 Environmental hazards:
·
Marine pollutant:
47.0.2
Not Regulated
Not Regulated
Not Regulated
Not Regulated
No
(Cont'd. on page 8)
Page: 8/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date: 07 June 2018 Revision: 07 June 2018
Trade name:
·
14.6 Special precautions for user
·
14.7 Transport in bulk according to Annex II
of Marpol and the IBC Code
Rust-Buster
(Cont'd. from page 7)
Not applicable.
Not applicable.
SECTION 15: Regulatory information
·
15.1 Safety, health and environmental regulations/legislation specific for the substance
or mixture
·
United States (USA)
·
SARA
·
Section 355 (extremely hazardous substances):
Substance is not listed.
·
Section 313 (Specific toxic chemical listings):
Substance is not listed.
·
TSCA (Toxic Substances Control Act):
Substance is listed.
·
Proposition 65 (California):
·
Chemicals known to cause cancer:
Substance is not listed.
·
Chemicals known to cause developmental toxicity for females:
Substance is not listed.
·
Chemicals known to cause developmental toxicity for males:
Substance is not listed.
·
Chemicals known to cause developmental toxicity:
Substance is not listed.
·
EPA (Environmental Protection Agency)
Substance is not listed.
·
IARC (International Agency for Research on Cancer)
Substance is not listed.
·
Canadian Domestic Substances List (DSL) (Substances not listed)
Substance is listed.
·
Directive 2012/18/EU
·
Named dangerous substances - ANNEX I
·
Other regulations, limitations and prohibitive regulations
·
Substances of very high concern (SVHC) according to REACH, Article 57
Substance is not listed.
Substance is not listed.
·
15.2 Chemical safety assessment:
47.0.2
A Chemical Safety Assessment has not been carried out.
(Cont'd. on page 9)
Page: 9/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date: 07 June 2018 Revision: 07 June 2018
Trade name:
Rust-Buster
(Cont'd. from page 8)
SECTION 16: Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any
specific product features and shall not establish a legally valid contractual relationship.
·
Abbreviations and acronyms:
ADR: European Agreement concerning the International Carriage of Dangerous Goods by Road
IMDG: International Maritime Code for Dangerous Goods
DOT: US Department of Transportation
IATA: International Air Transport Association
GHS: Globally Harmonised System of Classification and Labelling of Chemicals
EINECS: European Inventory of Existing Commercial Chemical Substances
CAS: Chemical Abstracts Service (division of the American Chemical Society)
LC50: Lethal concentration, 50 percent
LD50: Lethal dose, 50 percent
PBT: Persistant, Bio-accumulable, Toxic
SVHC: Substances of Very High Concern
vPvB: very Persistent and very Bioaccumulative
Asp. Tox. 1: Aspiration hazard – Category 1
·
Sources
Website, European Chemicals Agency (echa.europa.eu)
Website, US EPA Substance Registry Services (ofmpub.epa.gov/sor internet/registry/substreg/home/
overview/home.do)
Website, Chemical Abstracts Registry, American Chemical Society (www.cas.org)
Patty's Industrial Hygiene, 6th ed., Rose, Vernon, ed. ISBN: 978-0-470-07488-6
Casarett and Doull's Toxicology: The Basic Science of Poisons, 8th Ed., Klaasen, Curtis D., ed., ISBN:
978-0-07-176923-5.
Safety Data Sheets, Individual Manufacturers
SDS Prepared by:
ChemTel Inc.
1305 North Florida Avenue
Tampa, Florida USA 33602-2902
Toll Free North America 1-888-255-3924 Intl. +01 813-248-0573
Website: www.chemtelinc.com
47.0.2
Loading...