Page 1/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date 30.09.2015 Revision: 30.09.2015
SECTION 1: Identific ation of the substance/mixture and of the company/
undertaking
·
1.1 Product identifier
·
Trade name: Zoom Spout Oiler
·
Article number:
·
CAS Number:
64741-88-4
·
EC number:
265-090-8
·
1.2 Relevant identified uses of the substance or mixture and uses advised against
No further relevant information available.
·
Application of the substance / the mixture
·
1.3 Details of the supplier of the Safety Data Sheet
·
Manufacturer/Supplier:
Highside Chemicals, Inc.
11114 Reichold Road
Gulfport, MS 39503 USA
Phone: (228) 896-9220
·
1.4 Emergency telephone number:
ChemTel Inc.
(800)255-3924, +1 (813)248-0585
14114
Lubricating oil
SECTION 2: Hazards identification
·
2.1 Classification of the substance or mixture
·
Classification according to Regulation (EC) No 1272/2008
The product is not classified as hazardous according to OSHA GHS regulations within the United States.
The substance is not classified as hazardous according to the CLP regulation.
·
Additional information:
There are no other hazards not otherwise classified that have been identified.
0 % of the mixture consists of component(s) of unknown toxicity.
·
2.2 Label elements
·
Labelling according to Regulation (EC) No 1272/2008
This product does not have a classification according to the CLP regulation.
The product is not classified as hazardous according to OSHA GHS regulations within the United States.
·
Hazard pictograms
·
Signal word
·
Hazard-determining components of labelling:
·
Hazard statements
·
Precautionary statements
·
NFPA ratings (scale 0 - 4)
010
Not Regulated
Health = 0
Fire = 1
Reactivity = 0
Not Regulated
None.
Not Regulated
Not Regulated
(Cont'd. on page 2)
41.2.6
Page 2/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date 30.09.2015 Revision: 30.09.2015
Trade name: Zoom Spout Oiler
(Cont'd. from page 1)
·
HMIS-ratings (scale 0 - 4)
HEALTH
FIRE
REACTIVITY
·
2.3 Other hazards
·
Results of PBT and vPvB assessment
·
PBT:
·
vPvB:
0
Health = 0
1
Fire = 1
0
Reactivity = 0
Not applicable.
Not applicable.
SECTION 3: Composition/information on ingredients
·
3.1 Substances
·
CAS No. Description
64741-88-4 Distillates (petroleum), solvent-refined heavy paraffinic
·
Identification number(s)
·
EC number:
·
Index number:
·
Additional information:
265-090-8
649-454-00-7
Note L: The classification as a carcinogen need not apply if it can be shown that the substance contains
less than 3 % DMSO extract as measured by IP 346 ‘Determination of polycyclic aromatics in unused
lubricating base oils and asphaltene free petroleum fractions - Dimethyl sulphoxide extraction refractive
index method’, Institute of Petroleum, London. This product meets these requirements.
SECTION 4: First aid measures
·
4.1 Description of first aid measures
·
General information:
·
After inhalation:
·
After skin contact:
Immediately remove any clothing soiled by the product.
Supply fresh air; consult doctor in case of complaints.
Wash with soap and water.
If skin irritation is experienced, consult a doctor.
·
After eye contact:
Remove contact lenses if worn.
Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor.
·
After swallowing:
Rinse out mouth and then drink plenty of water.
Do not induce vomiting; call for medical help immediately.
·
4.2 Most important symptoms and effects, both acute and delayed
Slight irritant effect on eyes.
Slight irritant effect on skin and mucous membranes.
Gastric or intestinal disorders when ingested.
Nausea in case of ingestion.
·
Hazards
Repeated exposure may cause skin dryness or cracking.
(Cont'd. on page 3)
41.2.6
Page 3/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date 30.09.2015 Revision: 30.09.2015
Trade name: Zoom Spout Oiler
(Cont'd. from page 2)
·
4.3 Indication of any immediate medical attention and special treatment needed
No further relevant information available.
SECTION 5: Firefighting measures
·
5.1 Extinguishing media
·
Suitable extinguishing agents:
Carbon dioxide
Foam
Fire-extinguishing powder
Gaseous extinguishing agents
·
For safety reasons unsuitable extinguishing agents:
·
5.2 Special hazards arising from the substance or mixture
Formation of toxic gases is possible during heating or in case of fire.
·
5.3 Advice for firefighters
·
Protective equipment:
Wear self-contained respiratory protective device.
Wear fully protective suit.
·
Additional information
No further relevant information available.
Water
SECTION 6: Accidental release measures
·
6.1 Personal precautions, protective equipment and emergency procedures
Ensure adequate ventilation
Wear protective equipment. Keep unprotected persons away.
For large spills, use respiratory protective device against the effects of fumes/dust/aerosol.
Particular danger of slipping on leaked/spilled product.
·
6.2 Environmental precautions:
Do not allow to enter sewers/ surface or ground water.
Inform respective authorities in case of seepage into water course or sewage system.
Prevent from spreading (e.g. by damming-in or oil barriers).
·
6.3 Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Remove from the water surface (e.g. skim or suck off).
Dispose of the material collected according to regulations.
Send for recovery or disposal in suitable receptacles.
·
6.4 Reference to other sections
See Section 7 for information on safe handling.
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.
SECTION 7: Handling and storage
·
7.1 Precautions for safe handling
Prevent formation of aerosols.
Avoid splashes or spray in enclosed areas.
(Cont'd. on page 4)
41.2.6
Page 4/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date 30.09.2015 Revision: 30.09.2015
Trade name: Zoom Spout Oiler
(Cont'd. from page 3)
Use only in well ventilated areas.
·
Information about fire - and explosion protection:
·
7.2 Conditions for safe storage, including any incompatibilities
·
Storage:
·
Requirements to be met by storerooms and receptacles:
Avoid storage near extreme heat, ignition sources or open flame.
·
Information about storage in one common storage facility:
Store away from foodstuffs.
Store away from oxidising agents.
·
Further information about storage conditions:
Store in cool, dry conditions in well sealed receptacles.
Keep container tightly sealed.
·
7.3 Specific end use(s)
No further relevant information available.
No special measures required.
SECTION 8: Exposure controls/personal protection
·
Additional information about design of technical facilities:
·
8.1 Control parameters
·
Ingredients with limit values that require monitoring at the workplace:
The product does not contain any relevant quantities of materials with critical values that have to be
monitored at the workplace.
·
DNELs
·
PNECs
·
8.2 Exposure controls
·
Personal protective equipment:
·
General protective and hygienic measures:
No further relevant information available.
No further relevant information available.
The usual precautionary measures are to be adhered to when handling chemicals.
Keep away from foodstuffs, beverages and feed.
Immediately remove all soiled and contaminated clothing.
Wash hands before breaks and at the end of work.
Do not inhale gases / fumes / aerosols.
Avoid contact with the eyes.
Avoid close or long term contact with the skin.
·
Respiratory protection:
Not required under normal conditions of use.
Use suitable respiratory protective device when aerosol or mist is formed.
For spills, respiratory protection may be advisable.
·
Protection of hands:
No further data; see section 7.
Protective gloves
Gloves are advised for repeated or prolonged contact.
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
(Cont'd. on page 5)
41.2.6
Page 5/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date 30.09.2015 Revision: 30.09.2015
Trade name: Zoom Spout Oiler
(Cont'd. from page 4)
·
Eye protection:
Safety glasses
·
Body protection:
·
Limitation and supervision of exposure into the environment
·
Risk management measures
SECTION 9: Physical and chemical properties
·
9.1 Information on basic physical and chemical properties
·
General Information
·
Appearance:
Form:
Colour:
·
Odour:
·
Odour threshold:
·
pH-value:
·
Change in condition
Melting point/Melting range:
Boiling point/Boiling range:
·
Flash point:
·
Flammability (solid, gaseous):
·
Auto/Self-ignition temperature:
·
Decomposition temperature:
·
Self-igniting:
·
Danger of explosion:
·
Explosion limits:
Lower:
Upper:
·
Oxidising properties
·
Vapour pressure at 20 °C (68 °F):
·
Density at 15,6 °C (60 °F):
·
Relative density
·
Vapour density at 20 °C (68 °F)
·
Evaporation rate at 20 °C (68 °F)
·
Solubility in / Miscibility with
water:
·
Partition coefficient (n-octanol/water):
Oil resistant protective clothing
No special requirements.
No special requirements.
Liquid
Clear
Petroleum-like
Not determined.
Not determined.
Not Determined.
Undetermined.
> 150 °C (> 302 °F)
Not applicable.
Not determined.
Not determined.
Not determined.
Product does not present an explosion hazard.
Not determined.
Not determined.
Not determined.
1 hPa (1 mm Hg)
0.86 - 0.87 g/cm³ (7,177 - 7,26 lbs/gal)
Not determined.
> 1 g/cm³ (> 8,345 lbs/gal) (Air =1)
< 1 (Butyl Acetate = 1)
Not miscible or difficult to mix.
4 - 6 log POW
(Cont'd. on page 6)
41.2.6
Page 6/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date 30.09.2015 Revision: 30.09.2015
Trade name: Zoom Spout Oiler
(Cont'd. from page 5)
·
Viscosity:
Dynamic:
Kinematic at 40 °C (104 °F):
·
9.2 Other information
SECTION 10: Stability and reactivity
·
10.1 Reactivity
·
10.2 Chemical stability
·
Thermal decomposition / conditions to be avoided:
No decomposition if used and stored according to specifications.
To avoid thermal decomposition do not overheat.
·
10.3 Possibility of hazardous reactions
Toxic fumes may be released if heated above the decomposition point.
Reacts with strong acids and oxidising agents.
·
10.4 Conditions to avoid
Keep away from heat and direct sunlight.
Store away from oxidising agents.
·
10.5 Incompatible materials:
·
10.6 Hazardous decomposition products:
Carbon monoxide and carbon dioxide
Hydrocarbons
No further relevant information available.
Stable under normal temperatures and pressures.
No further relevant information available.
Not determined.
30 - 110 cSt
No further relevant information available.
SECTION 11: Toxicological information
·
11.1 Information on toxicological effects
·
Acute toxicity
·
LD/LC50 values relevant for classification:
·
Primary irritant effect:
·
Skin corrosion/irritation
·
Serious eye damage/irritation
·
Respiratory or skin sensitisation
·
Repeated dose toxicity:
·
CMR effects (carcinogenity, mutagenicity and toxicity for reproduction):
·
Germ cell mutagenicity
·
Carcinogenicity
·
Reproductive toxicity
·
STOT-single exposure
·
STOT-repeated exposure
·
Aspiration hazard
Based on available data, the classification criteria are not met.
Slight irritant effect on skin and mucous membranes.
Slight irritant effect on eyes.
Based on available data, the classification criteria are not met.
Repeated exposure may cause skin dryness or cracking.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
Based on available data, the classification criteria are not met.
None.
SECTION 12: Ecological information
·
12.1 Toxicity
·
Aquatic toxicity:
No further relevant information available.
(Cont'd. on page 7)
41.2.6
Page 7/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date 30.09.2015 Revision: 30.09.2015
Trade name: Zoom Spout Oiler
(Cont'd. from page 6)
·
12.2 Persistence and degradability
·
12.3 Bioaccumulative potential
·
12.4 Mobility in soil
·
Ecotoxical effects:
·
Remark:
No further relevant information available.
Due to mechanical actions of the product (e.g. agglutinations) damages may occur.
The product is oxygen-consuming. The declared action may be partly caused by lack of oxygen.
·
Additional ecological information:
·
General notes:
Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage
system.
·
12.5 Results of PBT and vPvB assessment
·
PBT:
Not applicable.
·
vPvB:
·
12.6 Other adverse effects
Not applicable.
No further relevant information available.
The product is partially biodegradable. Significant residuals remain.
No further relevant information available.
SECTION 13: Disposal considerations
·
13.1 Waste treatment methods
·
Recommendation
Contact waste processors for recycling information.
Can be burned with household garbage after consulting with the waste disposal facility operator and the
pertinent authorities and adhering to the necessary technical regulations.
The user of this material has the responsibility to dispose of unused material, residues and containers in
compliance with all relevant local, state and federal laws and regulations regarding treatment, storage and
disposal for hazardous and nonhazardous wastes.
·
Uncleaned packaging:
·
Recommendation:
Disposal must be made according to official regulations.
SECTION 14: Transport information
·
14.1 UN-Number
·
DOT, ADR, IMDG, IATA
·
14.2 UN proper shipping name
·
DOT, ADR, IMDG, IATA
·
14.3 Transport hazard class(es)
·
DOT, ADR, IMDG, IATA
·
Class
·
14.4 Packing group
·
DOT, ADR, IMDG, IATA
·
14.5 Environmental hazards:
·
14.6 Special precautions for user
·
14.7 Transport in bulk according to Annex II of
Marpol and the IBC Code
Not Regulated
Not Regulated
Not Regulated
Not Regulated
Not applicable.
Not applicable.
Not applicable.
(Cont'd. on page 8)
41.2.6
Page 8/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date 30.09.2015 Revision: 30.09.2015
Trade name: Zoom Spout Oiler
(Cont'd. from page 7)
·
UN "Model Regulation":
SECTION 15: Regulatory information
·
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
·
United States (USA)
·
SARA
·
Section 355 (extremely hazardous substances):
Substance is not listed.
·
Section 313 (Specific toxic chemical listings):
Substance is not listed.
·
TSCA (Toxic Substances Control Act):
Substance is listed.
·
Proposition 65 (California):
·
Chemicals known to cause cancer:
Substance is not listed.
·
Chemicals known to cause reproductive toxicity for females:
Substance is not listed.
·
Chemicals known to cause reproductive toxicity for males:
Substance is not listed.
·
Chemicals known to cause developmental toxicity:
Substance is not listed.
·
Carcinogenic Categories
·
EPA (Environmental Protection Agency)
Substance is not listed.
·
IARC (International Agency for Research on Cancer)
Substance is not listed.
·
TLV (Threshold Limit Value established by ACGIH)
Substance is not listed.
·
NIOSH-Ca (National Institute for Occupational Safety and Health)
Substance is not listed.
·
Canada
·
Canadian Domestic Substances List (DSL)
Substance is listed.
·
Canadian Ingredient Disclosure list (limit 0.1%)
Substance is not listed.
·
Canadian Ingredient Disclosure list (limit 1%)
Substance is not listed.
Not Regulated
(Cont'd. on page 9)
41.2.6
Page 9/9
Safety Data Sheet
according to 1907/2006/EC (REACH), 1272/2008/EC (CLP), and OSHA
GHS
Printing date 30.09.2015 Revision: 30.09.2015
Trade name: Zoom Spout Oiler
(Cont'd. from page 8)
·
Directive 2012/18/EU
·
Named dangerous substances - ANNEX I
Substance is not listed.
·
Other regulations, limitations and prohibitive regulations
·
Substances of very high concern (SVHC) according to REACH, Article 57
Substance is not listed.
·
15.2 Chemical safety assessment:
SECTION 16: Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any
specific product features and shall not establish a legally valid contractual relationship.
·
Sources
Website, European Chemicals Agency (http://http://echa.europa.eu/)
Website, US EPA Substance Registry Services (http://http://ofmpub.epa.gov/sor_internet/registry/substreg/
home/overview/home.do)
Website, Chemical Abstracts Registry, American Chemical Society (https://www.cas.org)
Patty's Industrial Hygiene, 6th ed., Rose, Vernon, ed. ISBN: ISBN: 978-0-470-07488-6
Casarett and Doull's Toxicology: The Basic Science of Poisons, 8th Ed., Klaasen, Curtis D., ed., ISBN:
978-0-07-176923-5.
Safety Data Sheets, Individual Manufacturers
SDS Prepared by:
ChemTel Inc.
1305 North Florida Avenue
Tampa, Florida USA 33602-2902
Toll Free North America 1-888-255-3924 Intl. +01 813-248-0573
Website: www.chemtelinc.com
A Chemical Safety Assessment has not been carried out.
41.2.6
Loading...