Sunset Healthcare NEB100-R Instruction Manual
Instruction Manual
Compressor Nebulizer
NEB100
NEB100-R
EN English
ES Español
NEB100-IFU V 4.00
2019-11-07
Instructions for Use
The Sunset Compressor Nebulizer is an AC-powered air nebulizer
compressor system intended to provide a source of compressed air
for medical purposes for use in home healthcare. It is to be used with
a nebulizer kit to produce medicated aerosol particles for respiratory
therapy for both children and adults.
Important Read these instructions carefully before using this device.
Caution
Caution: Federal law restricts this device to sale by or on
the order of a physician
Use the device only for its intended purpose as described in
theseinstructions for use as a compressor nebulizer system for aerosol
therapy. Follow the instructions of your doctor. Any other form of use
constitutes improper use and may be dangerous. The manufacturer
cannot be held liable for any damage caused by improper, incorrect, or
unreasonable use, or if the unit is connected to electrical installations
not complying with safe regulations.
Keep this manual for future reference.
Do not operate the unit in the presence of any anesthetic, ammable
mixtures, or oxygen.
Correct device operation can be affected by electromagnetic
interference. If this device interferes with another electrical apparatus,
remove it and plug it into a different electrical outlet.
In case of failure and/or malfunction, do not open the compressor
housing, as this is not serviceable product.
The proper function of the device can be compromised if original
replacement parts (e.g. lter) are not used.
When using any electrical appliance, certain important safety measures
must always be observed, including the following:
• Never submerge the unit in water, as the device is not protected
against water penetration
• Never touch the unit if hands are wet or moist
• Do not leave the unit outdoors
• Place on stable and horizontal surface when operating
• Make sure the air vent openings area unobstructed
• Do not allow unsupervised children or physically challenged
individuals to use the unit
• Turn the unit off with the power switch. Do not pull plug out from
electrical outlet while the power is on.
Do not leave the unit plugged in when not in use. Unplug the device
from the electrical outlet when not in operation.
Follow the manufacturer’s instructions for installing the device. The
manufacturer cannot be held responsible for any damage caused by
incorrect installation.
The power supply cord cannot be replaced by the user.
The power supply cord should always be fully unwound in order to
prevent dangerous overheating.
Before performing any cleaning operation or lter replacement,
disconnect the device from the main supply by unplugging it or by
turning the main supply switch OFF.
Some parts of the unit are small enough to be swallowed by children.
Do not let unattended children have access to the unit.
If you decide not to use the device, it is recommended to dispose of
it according to local regulations.
Remember to:
• Use this device only with medications prescribed by your doctor
• Use the accessories recommended by your doctor for therapy
Verify that the medications prescribed by your doctor canbe used with
common compressor nebulizer systems for aerosol therapy.
Warranty
Sunset Healthcare Solutions offers a limited 3-year warranty on the
compressor unit to be free from defects in material and workmanship
under normal use and operation for a period of 3 years from date
of original retail purchase. This warranty does not extend to failures
resulting from accidental damage, misuse, negligence, abuse,
alteration, or improper operation. This warranty does not extend to
non-durable components which are subject to normal wear and need
periodic replacement nor does this warranty extend to hospital or clinic
use. All items returned must be properly packaged and shipped in a
manner to avoid shipping damage at the purchaser’s expense.
DO NOT return any product(s) or part(s) to Sunset Healthcare Solutions
without prior consent. For replacement under warranty, please call:
1-877-578-6738 (Monday to Friday, 9 am to 5 pm CST).
Make sure that the electrical rating shown on the rating plate on the
bottom of the unit corresponds to your main voltage and frequency
before plugging in the device.
Do not use electrical adapters including extension cords.
Instructions for Use with T-Piece Kit
Troubleshooting
Examine the unit before the rst use in order to check
for possible shipping damage. When taking a treatment sit
upright and relaxed.
1. After unpacking the device, check the compressor and accessories
for visible damage or defects such as cracks in the plastic housing,
which could expose electrical components. Contact your retailer to
report any damaged product.
2. Before using the device, follow the cleaning instructions as detailed
in this user manual.
3. Attach the supply tube to the compressor and to the bottom of the
nebulizer cup.
4. Open the nebulizer cup by pushing down on the cap and
twisting counter-clockwise.
5. Add prescribed medication into nebulizer cup then turn top on
until secure.
6. Attach T-piece to the nebulizer bottle.
7. Attach mouthpiece and corrugated tube to T-piece.
8. Connect the 7ft tube to the nebulizer bottle and the
nebulizer machine.
9. Ensure connections are secure before turning on the
nebulizer machine.
10. Plug the compressor into the electrical outlet, making sure the
electrical rating shown on the rating plate on the bottom of the unit
corresponds to your main voltage.
If the device does not turn on:
1. Make sure the plug is rmly inserted into the electrical outlet.
2. Make sure the device has been operating within the limits indicated
in this instructional manual (30 minutes ON/30 minutes OFF).
If the device does not nebulize, or the nebulization
is weak:
1. Make sure the ends of the air tube are tted tightly onto the main
unit and onto the nebulizer (see connected kit and unit diagram
below)
2. Check whether the nebulizer mask or mouthpiece kit cup chamber is
empty or overlled with medication.
3. Check whether the nebulizer nozzle is obstructed (see
medicine cup diagram below)
4. Check whether the bafe is inserted properly. The bafe ts over the
medcine cup’s interior cone (see medicine cup diagram below).
Connected kit and unit
Fit tube ends
tightly
11. To start treatment, switch the compressor on by pressing the
ON/OFF switch onto the “I” position.
ATTENTION: This device rated for intermittent use
30 minutes ON / 30 minutes OFF.
12. When mist is visible, begin inhaling with the mouthpiece.
13. When the treatment has been completed, switch the unit OFF by
setting the switch position to “O” and disconnect the plug from the
electrical outlet.
14. Wash the nebulizer and accessories as described in the
cleaning section.
Medicine cup
Exploded view
Closed view
Bafe
Nozzle
Loading...