sunpower SDX-6200-24 User Manual
SDX-6200-24
C
200W, Six Output
Industrial 1U System
SUNPOWER TECHNOLOGY CORP.
16F.-1, No.150, Jian 1st Rd., Zhonghe Dist., New Taipei City 235, Taiwan (R.O.C.).
TEL: 886-2-8226-3100 FAX: 886-2-8226-3111
http://www.sunpower.com.tw
E-mail: sunpower@sunpower.com.tw
180 x 100 x 40.5 mm
7.09 x 3.94 x 1.60 inch
B
Features:
＊ Input and output isolation
＊ Soft start function, low inrush current
＊ Over voltage protection
＊ Over load & short circuit protection
＊ 100% full load burn-in test
＊ Meet Intel ATX 2.01 / ATX 2.03 / ATX 12V / EPS
＊ Meet LVD standard
＊ UL, cUL, CB, CE approved
＊ 1 year warranty
Specification:
Voltage 19V ~ 32V DC (Typical 24V)
INPUT
OUTPUT
PROTECTION
ELEC. CHAR.
ENVIRONMENT
SAFETY Withstand voltage I/P-O/P:2.0KVAC, I/P-PE:1KVAC, 1minute
Isolation resistance I/P-O/P, I/P-PE, ＞100MΩ/500VDC at 25℃/ 70% RH
EMC EMI
EMS EN 55024：EN 61000-4-2,3,4,6,8；ENV 50204
OTHERS
1 All measurements which not mentioned are based on 24VDC input, output Max at ambient 25 / 70℃ %RH.
2 Output tolerance included set up voltage, line regulation and load regulation.
The regulation is measured at the condition：when any of output is with 20% ~ 100% max load and the rest of each outputs are with
NOTE 60% max load, Each output could work within max load but must under total output max.
3 Ripple & noise are measured at 21～32VDC input with 10～50℃ condition and 20MHz of bandwidth by terminated
using a 10〞～15〞twisted pair-wire with a 0.1uF & a 47uF parallel capacitor.
4 The operating temperature shall follow the de-rating curve in spec
5 The power supply is considered a component of end-equipment. The end-equipment must be re-confirmed whether comply with EMC directives.
Current <16A @ 19V DC input. Protection Ceramic Fuse, 20A/250V OUTPUT V1 V2 V3 V4 V5 V6 Voltage 5V 3.3V 12V -5V -12V 5Vsb Min Load Max Load
Output Tolerance 2 ±5% ±5% ±5% ±5% +8/-5% ±5%
Ripple Noise MAX. 3
Efficiency (TYP.) 68%
Output MAX.
Over Voltage 5.8V~7.0V 3.8V~4.6V 13.8~16.8V --- --- -- Shutdown, it needs re-power on to recover
Over Load ＆ Short Circui t
Rise time <20mS
Power good signal Power ON within 100---500ms, high level TTL Signal release.
Temperature 4 Operating: -10 ~ 70 ; De℃ -rating: 45 ~ 70 : 2.5%/ ; Storage: ℃℃ -20~+85℃
Humidity Operating: 20% ~ 90% (non condensing) RH; Storage: 10% ~ 95% RH (non condensing)
Cooling Forced airflow cooling with DC fan
M.T.B.F. 142K hours
Dimension 180 x 100 x 40.5 mm (L*W*H)
Packing N.W.: 1.98 Kg / 1pc; 6 pcs / 1.44 CUFT / 1 CTN
0.5A 0.1A 0.2A 0A 0A 0A
25A 15A 12A 0.5A 1A 19V~23V: 1A
24V~32V: 1.5A
70mV 70mV 120mV 100mV 200mV 70mV
3.3V & 5V total output maximum 130W, -5V & -12V total output max 12W, Total output maximum 200W.
When power supply over 105%~ 150% max load or short circuit acted, power supply will be shutdown and recover
automatically after the fault is removed.
EN 55022 CLASS B、FCC CFR 47 PART 15 CLASS B、CNS 13438 CLASS B.
Copy Right Sunpower Technology Corp. 2009, All Rights Reserved. SDX-6200-24 Rev 1.1
Specifications subject to change without notice. RS-090156 JULY-20-2009
QR0405-1 Rev,:1.0
SUNPOWER TECHNOLOGY CORP.
16F.-1, No.150, Jian 1st Rd., Zhonghe Dist., New Taipei City 235, Taiwan (R.O.C.).
TEL: 886-2-8226-3100 FAX: 886-2-8226-3111
http://www.sunpower.com.tw
E-mail: sunpower@sunpower.com.tw
SDX-6200-24
De-rating Curve： Output De-rating Vs Input Voltage
Ta=25
100
100
90
80
60
LOAD(%)
40
80
70
60
LOAD(%)
50
20
-10 0 40
10 20 30 50 60
70
(HORIZONTAL)
40
19
24 32
INPUT VOLTAGE (VDC)
AMBIENT TEMPERATURE( )
Dimension: (Unit: mm)
OUTPUT
WI RE
MOLEX 5557-20R
+5V
RED
20
+12V10YELLOW
+5Vs
PINK
9
19
RED
WHITE
BLACK
BLACK
BLACK
GREEN
BLACK
BLUE
BROWN+3.3Vs
YELLOW+12V
8
18
7
17
6
16
5
15
4
14
3
13
2
12
1
11
42
13
PURPLE
+5Vsb
GREY
P.G.
BLACK
COM
+ 5V
RED
BLACK
COM
RED
+ 5V
BLACK
COM
ORANGE
+3.3V
ORANGE
+3.3V
COM
BLACK
BLACKCOM+12V YELLOW
MOLEX 8981-4P
+12V
COM
COM
+5V
MOLEX 8981-4P
+12V
COM
COM
+5V
MOLEX 8981-4P
YELLOW
BLACK
BLACK
RED
MOLEX 8981-4P
YELLOW
BLACK
BLACK
RED
STM-P113914
+12VYELLOW
COM
BLACK
COM
BLACK
+5V
RED
+12VYELLOW
BLACK
COM
BLACK
COM
+5V
RED
+12V
COM
COM
+5V
MOLEX 8981-4P
+12V
COM
COM
+5V
YELLOW
BLACK
BLACK
RED
YELLOW
BLACK
BLACK
RED
+5V
-5V
COM
COM
COM
PS ON
COM
-12V
+3.3V ORANGE
MOLEX 5557-4R
24V IN
-V
+V
Copy Right Sunpower Technology Corp. 2009, All Rights Reserved. SDX-6200-24 Rev 1.1
Specifications subject to change without notice. RS-090156 JULY-20-2009
QR0405-1 Rev,:1.0
Loading...