Subaru Robin Power Products PKV401T User Manual
PKV401T
9ZZ9990043
北米
1
1
4
3
2
4 5
2
3
1
6
2
2
7
1
3
2
1
10 11
19
8
2
1
2
Single
grade
Multi
grade
Ambient
temperature
5W
10W
20W
#20
#30
10W-30
10W-40
-20 -10 0 10 20 30
-4 14 32 50 68 86
#40
40 C
104 F
3
9
3
4
18
12
17
2
1
3
13
1
1416 15
2
20
21
6
22
23
4
1
5
1
2
7
5
2
6
1
1
4
(L)
(L)
(H)
(H)
(L)
1
2
7
1
8
1
2
0.7 - 0.8 mm
1
2
2
2
5
1
3
1
2
1
4
2
3
2
2
1
3
4
6
1
5
1
8
57
64
2
31
2
43
6
4
1
ENGLISHFRANÇAISEESPAÑOL
WARNING :
The engine exhaust from this product contains
chemicals known to the State of California to
cause cancer, birth defects or other reproductive
harm.
NOTICE
FEDERAL EMISSION COMPONENT DEFECT WARRANTY and CALIFORNIA
EMISSION CONTROL WARRANTY are applicable to only those engines/
generators complied with EPA (Environmental Protection Agency) and CARB
(California Air Resources Board) emission regulations in the U.S.A.
NOTICE
To the engines/generators exported to and used in the countries other than the
U.S.A., warranty service shall be performed by the distributor in each country in
accordance with the standard Robin engine/generator warranty policy as applicable.
AIR INDEX
To show compliance with California emission regulations, a hangtag has been
provided displaying the Air Index level and durability period of this engine.
The Air Index level defines how clean an engine’s exhaust is over a period of
time. A bar graph scaled from “0” (most clean) to “10” (least clean) is used to
show an engine’s Air Index level. A lower Air Index level represents cleaner
exhaust from an engine.
The period of time (in hours) that the Air Index level is measured is known as
the durability period. Depending on the size of the engine, a selection of time
periods can be used to measure the Air Index level (see below).
Descriptive Term Applicable to Emissions Durability Period
Moderate - 50 hours (engine from 0 to 80 cc)
125 hours (engine greater than 80 cc)
Intermediate - 125 hours (engine from 0 to 80 cc)
250 hours (engine greater than 80 cc)
Extended - 300 hours (engine from 0 to 80 cc)
500 hours (engine greater than 80 cc)
Notice : This hangtag must remain on this engine or piece of equipment, and
only be removed by the ultimate purchaser before operation.
FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY
EMISSIONS COMPONENT DEFECT WARRANTY COVERAGE – This emission warranty is applicable in all States, except the state
of California.
Fuji Heavy Industries Ltd. and Robin America Inc., Wood Dale Illinois, (herein “ROBIN AMERICA”) warrant(s) to the initial retail purchaser and
each subsequent owner, that this Nonroad engine (herein “engine”) has been designed, built, and equipped to conform at the time of initial sale
to all applicable regulations of the U.S.
Environmental Protection Agency (EPA), and that the engine is free of defects in materials and workmanship which would cause this engine to
fail to conform with EPA regulations during its warranty period.
For the components listed under PARTS COVERED, the service dealer authorized by ROBIN AMERICA will, at no cost to you, make the
necessary diagnosis, repair, or replacement necessary to ensure that the engine complies with applicable U.S. EPA regulations.
ENGLISHFRANÇAISEESPAÑOL
EMISSION COMPONENT DEFECT WARRANTY PERIOD
The warranty period for this engine begins on the date of sale to the
initial purchaser and continues for a period of two years.
PARTS COVERED
Listed below are the parts covered by the Emission Components
Defect Warranty. Some of the parts listed below may require
scheduled maintenance and are warranted up to the first scheduled
replacement point for that part.
(1) Fuel Metering System
(i) Carburetor and internal parts (and/or pressure regulator or
fuel injection system).
(ii) Air/fuel ratio feedback and control system, if applicable.
(iii) Cold start enrichment system, if applicable.
(iv) Regulator assy (gaseous fuel, if applicable)
(2) Air Induction System
(i) Intake manifold, if applicable
(ii) Air filter.
(3) Ignition System
(i) Spark plugs.
(ii) Magneto or electronic ignition system.
(iii) Spark advance/retard system, if applicable.
(4) Exhaust manifold, if applicable
(5) Miscellaneous Items Used in Above Systems
(i) Electronic controls, if applicable
(ii) Hoses, belts, connectors, and assemblies.
(iii) Filter lock assy (gaseous fuel, if applicable)
OBTAINING WARRANTY SERVICE
To obtain warranty service, take your engine to the nearest authorized
Robin America service dealer . Bring your sales receipts indicating date
of purchase for this engine. The service dealer authorized by ROBIN
AMERICA will perform the necessary repairs or adjustments within a
reasonable amount of time and furnish you with a copy of the repair
order. All parts and accessories replaced under this warranty become
the property of ROBIN AMERICA.
OWNER’S WARRANTY RESPONSIBILITIES
As the engine owner, you are responsible for the performance of the
required maintenance listed in your owner’s manual. ROBIN
AMERICA recommends that you retain all receipts covering
maintenance on your engine, but ROBIN AMERICA cannot deny
warranty solely for the lack of receipts or for your failure to ensure
the performance of all scheduled maintenance.
As the engine owner, you should however be aware that ROBIN
AMERICA may deny warranty coverage if your engine or a part has
failed due to abuse, neglect, improper maintenance or unapproved
modifications.
You are responsible for presenting your engine to the nearest service
dealer authorized by ROBIN AMERICA when a problem exists.
If you have any questions regarding your warranty rights and
responsibilities, you should contact the Robin America customer
service department at 1-630-350-8200 for the information.
THINGS YOU SHOULD KNOW ABOUT THE EMISSION
CONTROL SYSTEM WARRANTY MAINTENANCE AND
REPAIRS
You are responsible for the proper maintenance of the engine.
You should keep all receipts and maintenance records covering the
performance of regular maintenance in the event questions arise.
These receipts and maintenance records should be transferred to
each subsequent owner of the engine. ROBIN AMERICA reserves
the right to deny warranty coverage if the engine has not been properly
maintained. Warranty claims will not be denied, however, solely
because of the lack of required maintenance or failure to keep
maintenance records.
MAINTENANCE, REPLACEMENT OR REPAIR OF EMISSION
CONTROL DEVICES AND SYSTEMS MAY BE PERFORMED BY
ANY REPAIR ESTABLISHMENT OR INDIVIDUAL;
HOWEVER, WARRANTY REPAIRS MUST BE PERFORMED BY A
SERVICE DEALER AUTHORIZED BY ROBIN AMERICA. THE USE
OF PARTS THAT ARE NOT EQUIVALENT IN PERFORMANCE AND
DURABILITY TO AUTHORIZED PARTS MAY IMPAIR THE
EFFECTIVENESS OF THE EMISSION CONTROL SYSTEM AND MAY
HAVE A BEARING ON THE OUTCOME OF A WARRANTY CLAIM.
WHAT IS NOT COVERED
*Conditions resulting from tampering, misuse, improper adjustment
(unless they were made by the service dealer authorized by ROBIN
AMERICA during a warranty repair), alteration, accident, failure to
use the recommended fuel and oil, or not performing required
maintenance services.
*The replacement parts used for required maintenance services.
*Consequential damages such as loss of time, inconvenience, loss of
use of the engine or equipment, etc.
*Diagnosis and inspection charges that do not result in warranty-
eligible service being performed.
*Any non-authorized replacement part, or malfunction of authorized
parts due to use of non-authorized parts.
If other than the parts authorized by ROBIN AMERICA are used for
maintenance replacements or for the repair of components affecting
emission control, you should assure yourself that such parts are
warranted by their manufacturer to be equivalent to the parts
authorized by ROBIN AMERICA in their performance and durability.
HOW TO MAKE A CLAIM
All repair qualifying under this limited warranty must be performed by a
service dealer authorized by ROBIN AMERICA. In the event that any
emission-related part is found to be defective during the warranty period,
you shall notify Robin America customer service department at 1-630350-8200 and you will be advised of the appropriate warranty service
d
ealer or service providers where the warranty repair can be performed.
WS2104
CALIFORNIA EMISSIONS CONTROL WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board and Fuji Heavy Industries Ltd. (herein "FUJI") are pleased to explain the emissions control system warranty
on your small off-road engine (SORE). In California, new SOREs must be designed, built and equipped to meet the State's stringent anti-smog
standards. FUJI must warrant the emissions control system on your SOREs for the periods of time listed below provided there has been no
abuse, neglect or improper maintenance of your SOREs.
Your emissions control system may include parts such as the carburetor or fuel-injection system, fuel lines and the ignition system. Also
included may be hoses, clamps , connectors and other associated components.
ENGLISHFRANÇAISEESPAÑOL
Where a warrantable condition exist, Fuji will repair your small off-road engine at no cost to you including diagnosis, parts and labor.
MANUFACTURER'S WARRANTY COVERAGE:
This emissions control system is warranted for two years. If any emissions-related part on your engine is defective, the part will be repaired or
replaced by FUJI.
OWNER'S WARRANTY RESPONSIBILITIES:
-As the SORE owner, you are responsible for performance of the required maintenance listed in your owner's manual. FUJI
recommends that you retain all receipts covering maintenance on your SORE , but FUJI cannot deny warranty solely for the lack of
receipts.
-As the SORE owner, you should however be aware that FUJI may deny you warranty coverage if your SORE or a part has failed due
to abuse, neglect, or improper maintenance or unapproved modifications.
-You are responsible for presenting your SORE to distribution center or service center authorized by ROBIN AMERICA Inc. 940 Lively
Blvd., Wood Dale, IL 60191 (herein ROBIN AMERICA) as soon as the problem exists. The warranty repairs should be completed in a
reasonable amount of time, not to exceed 30 days.
If you have a question regarding your warranty coverage, you should contact the Robin America Inc. Customer Service Department at 1-630350-8200.
GENERAL EMISSIONS WARRANTY COVERAGE
-
California Only
FUJI warrants to the ultimate purchaser and each subsequent purchaser that the SORE (1) has been designed, built and equipped so as to
conform with all applicable regulations; and (2) is free from defects in materials and workmanship that cause the failure of a warranted part to
conform with those regulations as may be applicable to the terms and conditions stated below.
(a) The warranty period begins on the date the engine is delivered to an ultimate purchaser or first placed into service.
The warranty period is two years.
(b) Subject to certain conditions and exclusions as stated below, the warranty on emissions related parts is as follows:
(1) Any warranted part that is not scheduled for replacement as required maintenance in your owner's manual is warranted for the warranty
period stated above. If the part fails during the period of warranty coverage, the part will be repaired or replaced by FUJI according to
subsection (4) below. Any such part repaired or replaced under warranty will be warranted for the remainder of the period.
(2) Any warranted part that is scheduled only for regular inspection in your owner's manual is warranted for the warranty period stated
above. Any such part repaired or replaced under warranty will be warranted for the remaining warranty period.
(3) Any warranted part that is scheduled for replacement as required maintenance in your owner's manual is warranted for the period of time
before the first scheduled replacement date for that part. If the part fails before the first scheduled replacement, the part will be repaired
or replaced by FUJI according to subsection (4) below. Any such part repaired or replaced under warranty will be warranted for the
remainder of the period prior to the first scheduled replacement point for the part.
(4) Repair or replacement of any warranted part under the warranty provisions herein must be performed at a warranty station at no charge
to the owner.
(5) Notwithstanding the provisions herein, warranty services or repair will be provided at all of our distribution centers that are franchised to
service the subject engines.
(6) The owner must not be charged for diagnostic labor that leads to the determination that a warranted part is in fact defective, provided
that such diagnostic work is performed at a warranty station.
(7) FUJI is liable for damages to other engine components proximately caused by a failure under warranty of any warranted part.
(8) Throughout the engine warranty period stated above, FUJI will maintain a supply of warranted parts sufficient to meet the expected
demand for such parts.
(9) Any replacement part may be used in the performance of any warranty maintenance or repairs and must be provided without charge to
the owner. Such use will not reduce the warranty obligations of FUJI.
(10) Add-on or modified parts that are not exempted by the Air Resources Board may not be used. The use of any non-exempted add-on or
modified parts by the ultimate purchaser will be grounds for disallowing a warranty claims. FUJI will not be liable to warrant failures of
warranted parts caused by the use of a non-exempted add-on or modified part.
-
Loading...