Subaru Robin Power Products EHO25A, EHO35A User Manual
R
MODEL
FOREMISSIONCERTIFIEDENGINE
ISSUE EMD-EU1717
2ZZ9020098
WARNING:
The engine exhaust from this product contains
chemicals known to the State of California to
cause cancer, birth defects or other reproductive
harm.
NOTICE
FEDERAL EMISSION COMPONENT DEFECT WARRANTY and CALIFORNIA
EMISSION CONTROL WARRANTY are applicable to only those engines
complied with EPA (Environmental Protection Agency) and CARB (California
Air Resources Board) emission regulations in the U.S.A.
NOTICE
To the engines exported to and used in the countries other than the U.S.A.,
warranty service shall be performed by the distributor in each country in accordance with the standard Robin engine warranty policy as applicable.
AIR INDEX
To show compliance with California emission regulations, a hangtag has been
provided displaying the Air Index level and durability period of this engine.
The Air Index level defines how clean an engine’s exhaust is over a period of
time. A bar graph scaled from “0” (most clean) to “10” (least clean) is used to
show an engine’s Air Index level. A lower Air Index level represents cleaner
exhaust from an engine.
The period of time (in hours) that the Air Index level is measured is known as
the durability period. Depending on the size of the engine, a selection of time
periods can be used to measure the Air Index level (see below).
Descriptive Term Applicable to Emissions Durability Period
Moderate - 50 hours (engine from 0 to 65 cc)
125 hours (engine greater than 65 cc)
Intermediate - 125 hours (engine from 0 to 65 cc)
250 hours (engine greater than 65 cc)
Extended - 300 hours (engine from 0 to 65 cc)
500 hours (engine greater than 65 cc)
Notice : This hangtag must remain on this engine or piece of equipment, and
only be removed by the ultimate purchaser before operation.
FEDERAL EMISSION COMPONENT DEFECT WARRANTY
EMISSION COMPONENT DEFECT WARRANTY COVERAGE
This emission warranty is applicable in all States, except the State of California.
Fuji Heavy Industries Ltd. and Robin America Inc., Wood Dale Illinois, (herein "ROBIN AMERICA")
warrant to the initial retail purchaser and each subsequent owner, that this utility equipment engine
(herein "engine") was designed, built, and equipped to conform at the time of initial sale to all applicable regulations of the U.S. Environmental Protection Agency (EPA), and that the engine is free of
defects in materials and workmanship which would cause this engine to fall to conform with EPA
regulations during its warranty period.
For the components listed under PARTS COVERED, the dealer or service center authorized by
ROBIN AMERICA will, at no cost to you, make the necessary diagnosis, repair, or replacement
necessary to ensure that the engine complies with applicable U.S. EPA regulations.
EMISSISON COMPONENT DEFECT WARRANTY PERIOD
The warranty period for this engine begins on the date of sale to the initial purchaser and continues
for a period of 2 years.
PARTS COVERED
Listed below are the parts covered by the Emission Component Defect Warranty. Some of the parts
listed below may require scheduled maintenance and are warranted up to the first scheduled
replacement point for that part.
(1) Fuel Metering System
(i) Carburetor and internal parts
(ii) Fuel filter, if applicable
(iii) Throttle stopper, if applicable
(iv) Choke System, if applicable
(2) Air Induction System
(i) Air cleaner plate
(ii) Air cleaner case
(iii) Air cleaner element
(3) Ignition System
(i) Spark plug
(ii) Flywheel Magneto
(iii) Ignition Coil
(4) Miscellaneous Items Used in Above Systems
(i) Fuel hoses, clamps and sealing gaskets
OBTAINING WARRANTY SERVICE
To obtain warranty service, take your engine to the nearest authorized ROBIN AMERICA, distributor
or dealer.
Bring your sales receipts indicating date of purchase for this engine. The dealer or service center
authorized by ROBIN AMERICA will perform the necessary repairs or adjustments within a reasonable amount of time and furnish you with a copy of the repair order. All parts and accessories
replaced under this warranty become the property of ROBIN AMERICA.
WHAT IS NOT COVERED
*Conditions resulting from tampering, misuse, improper adjustment (unless they were made by the
dealer or service center authorized by ROBIN AMERICA during a warranty repair), alteration, accident, failure to use the recommended fuel and oil, or not performing required maintenance services.
*The replacement parts used for required maintenance services.
*Consequential damages such as loss of time, inconvenience, loss of use of the engine of equip-
ment, etc.
*Diagnosis and inspection charges that do not result in warranty-eligible service being performed.
*Any non-authorized replacement part, or malfunction of authorized parts due to use of non-autho-
rized parts.
OWNER’S WARRANTY RESPONSIBILITIES
As the engine owner, you are responsible for the performance of the required maintenance listed in
your owner's manual, ROBIN AMERICA recommends that you retain all receipts covering maintenance on your engine, but ROBIN AMERICA can not deny warranty solely for the lack of receipts or
for your failure to ensure the performance of all scheduled maintenance.
As the engine owner, you should however be aware that the ROBIN AMERICA may deny your
warranty coverage if your engine or a part has failed due to abuse, neglect, improper maintenance
or unapproved modifications.
You are responsible for presenting your engine to the nearest dealer or service center authorized
by ROBIN AMERICA when a problem exists.
If you have any questions regarding your warranty rights and responsibilities, you should contact
the Robin America customer service department at 1-630-350-8200 for the information.
THINGS YOU SHOULD KNOW ABOUT THE EMISSION CONTROL SYSTEM WARRANTY
MAINTENANCE AND REPAIRS
You are responsible for the proper maintenance of the engine.
You should keep all receipts and maintenance records covering the performance of regular maintenance in the event questions arise. These receipts and maintenance records should be transferred
to each subsequent owner of the engine. ROBIN AMERICA reserves the rights to deny warranty
coverage if the engine has not been properly maintained.
Warranty claims will not be denied, however, solely because of the lack of required maintenance or
failure to keep maintenance records.
MAINTENANCE, REPLACEMENT OR REPAIR OF EMISSION CONTROL DEVICES AND
SYSTEMS MAY BE PERFORMED BY ANY REPAIR ESTABLISHMENT OR INDIVIDUAL;
HOWEVER , WARRANTY REPAIRS MUST BE PERFORMED BY A DEALER OR SERVICE
CENTER AUTHORIZED BY ROBIN AMERICA. THE USE OF PARTS THAT ARE NOT EQUIVALENT IN PERFORMANCE AND DURABILITY TO AUTHORIZED PARTS MAY IMPAIR THE
EFFECTIVENESS OF THE EMISSION CONTROL SYSTEM AND MAY HAVE A BEARING ON
THE OUTCOME OF A WARRANTY CLAIM.
If other than the parts authorized by ROBIN AMERICA are used for maintenance replacements or
for the repair of components affecting emission control, you should assure yourself that such parts
are warranted by their manufacturer to be equivalent to the parts authorized by ROBIN AMERICA
in their performance and durability.
HOW TO MAKE A CLAIM
All repairs qualifying under this limited warranty must be performed by a dealer or service center
authorized by ROBIN AMERICA. In the event that any emission-related part is found to be defective during the warranty period, you shall notify Robin America customer service department at 1630-350-8200 and you will be given the appropriate warranty service facilities where the warranty
repair can be performed.
CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board and Fuji Heavy Industries Ltd. are pleased to explain the
emission control system warranty on your 2000 and later Small Off-Road engine(herein
"engine"). In California, the engines must be designed, built and equipped to meet the State's
stringent anti-smog standards. Fuji Heavy Industries Ltd. must warrant the emission control
system on your engine for the periods of time described below, provided there has been no
abuse, neglect or improper maintenance of your engine. Your emission control system includes
parts such as the carburetor and the ignition system. Also included may be hoses, connectors
and other emission-related assemblies. Where a warrantable condition exists, Fuji Heavy Industries Ltd. will repair your engine at no cost to you including diagnosis, parts and labor.
MANUFACTURER'S WARRANTY COVERAGE:
The 2000 and later engines are warranted for two (2) years. If any emission-related part on your
engine is defective, the part will be repaired or replaced by Fuji Heavy Industries Ltd..
OWNER'S WARRANTY RESPONSIBILITIES:
-As the engine owner, you are responsible for the performance of the required maintenance listed in your Owner's Manual. Fuji Heavy Industries Ltd. recommends that you
retain all receipts covering maintenance on your engine, but Fuji Heavy Industries Ltd.
cannot deny warranty solely for the lack of receipts or for your failure to ensure the
performance of all scheduled maintenance.
-As the engine owner, you should however be aware that Fuji Heavy Industries Ltd. may
deny you warranty coverage if your engine or a part has failed due to abuse, neglect,
improper maintenance or unapproved modifications.
-Y ou are responsible for presenting your engine manufactured by Fuji Heavy Industries
Ltd. to a dealer, distributor or warranty station authorized by ROBIN AMERICA Inc., 940
Lively Blvd., Wood Dale, IL60191 which is the U.S. importer and/or OEM of the Small
Off-Road Engine as soon as a problem exists. The warranty repairs should be completed
in a reasonable amount of time, not to exceed 30 days.
If you have any questions regarding your warranty rights and responsibilities, you should
contact ROBIN AMERICA Inc., 940 Lively Blvd., Wood Dale, IL60191 at 1-630-350-8200.
LIMITED WARRANTY
on Emission Control Systems
- California Only -
Fuji Heavy Industries Ltd. warrant to the owner of the 2000 and later engine that the engine (1)
has been designed, built and equipped so as to conform at the time of manufacture with the
applicable regulations of the California Air Resources Board, and (2) is free from defects in
materials and workmanship which cause it to fail to conform with those regulations as may be
applicable in the terms and conditions stated below;
A. WARRANTY COMMENCEMENT DATE
The warranty period begins on the date the engine is delivered to a first retail purchaser.
B. LENGTH OF COVERAGE
Fuji Heavy Industries Ltd. warrants to a first retail purchaser and each subsequent purchaser
that the engine is free from defects in materials and workmanship which cause the failure of a
warranted emission-related part for a period of two (2) years after the date of delivery to the first
retail purchaser.
C. WHAT IS COVERED:
1. REPAIR OR REPLACEMENT PARTS
Repairs and replacement of any warranted part will be performed at no charge to you by
an authorized dealer, distributor or a warranty station. You may contact the ROBIN AMERICA Inc., 940 Lively Blvd., Wood Dale, IL60191 at 1-630-350-8200 which is the U.S.
importer/OEM of the Small Off-Road engine manufactured by Fuji Heavy Industries Ltd. to
get the nearest appropriate location where your warranty repairs are performed.
2. WARRANTY PERIOD
This warranty continues for a period of two (2) years and shall apply only to the repair,
replacement or adjustment of the component parts which are not scheduled for replacement as required maintenance. Further, component parts which are scheduled only for
regular inspection to the effect of "repair or replace as necessary" shall be warranted for
the warranty period. Any warranted part which is scheduled for replacement as required
maintenance shall be warranted for the period of time up to the first scheduled replacement point for that part.
3. DIAGNOSIS
You shall not be charged for diagnostic labor, which leads to the determination that a
warranted part is defective, if the diagnostic work is performed at an authorized dealer,
distributor or warranty station.
4. CONSEQUENTIAL DAMAGES
If a warranted part failed causing damage to other engine components, consult a warranty
station.
D. WHAT IS NOT COVERED
1. This limited warranty does not cover any part which malfunctions, fails or is damaged due
to failure to follow the maintenance and operating instructions set forth in the 2000 and
later Owner's Manual including:
(1) improper or inadequate maintenance of any warranted parts.
(2) improper installation, adjustment or repair of the engine or of any warranted part
unless performed by an authorized dealer.
(3) failure to follow recommendations on fuel use contained in the 2000 and later
Owner's Manual.
(4) repairs performed outside of the authorized warranty service facility.
(5) use of parts, which are not authorized by Fuji Heavy Industries Ltd..
2. Add-on or modified parts
This warranty does not cover any part which malfunctions, fails or is damaged due to
alterations by changing, adding to or removing parts from the engine.
3. Expenses incurred by processing warranty claims
ROBIN AMERICA Inc., 940 Lively Blvd., Wood Dale, IL60191, any authorized dealer,
distributors and warranty station shall not be liable for any loss of use of the engine, for
any alternative usage, for any damage to goods, loss of time or inconvenience.
E. HOW TO FILE A CLAIM
All repairs qualifying under this Limited Warranty must be performed by a dealer who sold you
the engine or distributors or warranty stations authorized by ROBIN AMERICA Inc., 940 Lively
Blvd., Wood Dale, IL60191. In the event that any emission-related part is found to be defective
during the warranty period, you shall notify ROBIN AMERICA Inc., 940 Lively Blvd., Wood
Dale, IL60191 at 1-630-350-8200 and you will be given the appropriate warranty service facilities where the warranty repair is performed.
F. WHERE TO GET WARRANTY SERVICE
It is recommended that warranty service be performed by the authorized dealer, who sold you
the engine, although warranty service will be performed by any authorized dealers, distributors
and warranty stations anywhere in the United States. When warranty repair is needed, the
engine must be brought to an authorized dealer, distributorship or warranty station's place of
business during normal business hours.
In all cases, a reasonable time, not to exceed 30 days, must be allowed for the warranty repair
to be completed after the engine is received by the authorized dealer, distributor or service
station.
G. MAINTENANCE, REPLACEMENT AND REPAIR OF EMISSION-RELATED PARTS
Only warranted engine replacement parts approved by Fuji Heavy Industries Ltd. should be
used in the performance of any warranty maintenance or repairs on emission-related parts. If
other than authorized parts are used for maintenance, replacement or repair of components
affecting emission control, you should assure yourself that such parts are warranted by their
manufacturer to be equivalent to authorized parts in performance and durability. Fuji Heavy
Industries Ltd., however, assumes no liability under this warranty with respect to parts other
than authorized parts. The use of non-authorized replacement parts does not invalidate the
warranty on other components unless the non-authorized parts cause damage to warranted
parts.
H. PARTS COVERED UNDER THE CALIFORNIA EMISSIONS WARRANTY
(1) Fuel Metering System
(i) Carburetor and internal parts
(ii) Air cleaner plate (including choke system)
(iii) Air cleaner cover
(iv) Air cleaner element
(v) Fuel Filter
(2) Ignition System
(i) Spark plug
(ii) Flywheel magneto
(iii) Ignition coil
(3) Miscellaneous Items Used in Above Systems
(i) Hoses and sealing gaskets, bolts, connectors, and assemblies.
I. MAINTENANCE STATEMENTS
It is your responsibility to have all scheduled inspection and maintenance services performed at
the times recommended in the 2000 and later Owner's Manual and to retain proof that inspection
and maintenance services are performed at the times when recommended. Fuji Heavy Industries Ltd. will not deny a warranty claim solely because you have no record of maintenance;
however, Fuji Heavy Industries Ltd. may deny a warranty claim if your failure to perform required
maintenance resulted in the failure of warranted part. The proof, which you maintain, should be
given to each subsequent owner of the engine. You are responsible for performing the scheduled maintenance described below based on the procedures specified in the 2000 and later
Owner's Manual. The scheduled maintenance below is based on the normal engine-operating
schedule.
PROCEDURE INTERVAL
1)Clean engine and check bolts and nuts. : Every 8 hours(daily)
Retighten if necessary.
2)Check and refill engine oil (4 stroke). : Every 8 hours(refill daily up to upper limit)
3)Change engine oil (4 stroke). : Initial 20 hours and every 50 hours afterward
4)Check clogging of cooling air passage and : Every 8 hours (daily)
cylinder fins. Remove and clean if necessary.
5)
Clean air cleaner.
6)Check spark plug. Clean and adjust : Every 8 hours (daily)
if necessary.
7) Check muffler exhaust outlet (or port). : Every 50 hours (monthly)
Clean if necessary.
8)Check fuel filter. If clogged, replace : Every 50 hours (monthly)
with new one.
9)Adjust valve clearance, if applicable : Every 200 hours (yearly)
(4 stroke).
10) Replace fuel lines. : Every 200 hours (yearly)
11) Overhaul engine. : Every 200 hours (yearly)
12) Replace packings and gaskets with : Every reassembling
new ones.
: Every 8 hours (daily)
Note: More frequent maintenance may be necessary under dusty, dirty or severe conditions.
FOREWORD
Thank you very much for purchasing a ROBIN ENGINE.
Your ROBIN ENGINE can supply the power to operate various
sorts of machines and equipment.
Please take a moment to familiarize yourself with the proper
operation and maintenance procedures in order to maximize
the safe and efficient use of this product.
Due to constant efforts to improve our products, certain procedures and specifications are subjected to change without
notice.
When ordering spare parts, always give us the MODEL,
SPECIFICATION and SERIAL NUMBER of your engine.
Please fill in the following blanks after checking the specification number on your engine.
SPEC NO.
SERIAL NO.
E H
CONTENTS
1.SAFETY PRECAUTIONS
2. COMPONENTS
3. PRE
4. OPERATING YOUR ENGINE
5. EASY TROUBLESHOOTING
6. MAINTENANCE SCHEDULE
7. "HOW
8. PREPARATIONS FOR STORAGE
9. SPECIFICATIONS
-OPERATION CHECKS
-TO" MAINTENANCE
・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・
・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・
・・・・・・・・・・・・・・・・・・・・・・・・・・・・
・・・・・・・・・・・・・・・・・・・・・・・・・・
・・・・・・・・・・・・・・・・・・・・・・・・・
・・・・・・・・・・・・・・・・・・・・・・・・・
・・・・・・・・・・・・・・・・・・・・・・・・・
・・・・・・・・・・・・・・・・・・・・・・・・・・
・・・・・・・・・・・・・・・・・・・・・
1
4
6
7
9
11
13
17
18
Loading...