STEEL HORSE AUDIO ST600 Installation Instructions Manual

ST-600 REV A 1/4/17

ST600 PLATINUM EDITION WITH BLUETOOTH®, AUX-IN | CHROME

ST600

STEELHORSEAUDIO.COM

800-823-5310 | [e-mail]

Steel Horse Audio #237 | 1540 Main St, Bldg 218 | Windsor, CO 80550

INSTALLATION INSTRUCTIONS

THANK YOU FOR CHOOSING STEEL HORSE AUDIO!

Protect yourself and others from possible injur y and property damag e or los s. Pay close at tent ion to all instr uct ions, warning s, caut ions, and notices regarding the ins talla tion, use, and care of this product.

THIS INDICATION ALERTS YOU TO THE FACT THAT IGNORING THE CONTENTS DESCRIBED HEREIN CAN RESULT IN POTENTIAL DEATH OR SERIOUS INJURY.

THIS INDICATION ALERTS YOU TO THE FACT THAT IGNORING THE CONTENTS DESCRIBED HEREIN CAN RESULT IN MINOR OR MODERATE POTENTIAL INJURY.

THIS INDICATION ALERTS YOU TO THE FACT THAT IGNORING THE CONTENTS DESCRIBED HEREIN MAY NEGATIVELY AFFECT PRODUCT PERFORMANCE AND FUNCTIONALITY OR

DAMAGE THE PRODUCT ITSELF OR THE PRODUCT TO WHICH IT IS BEING ATTACHED.

ENSURE THA T THE FOLLOWING PARTS HAVE BEEN INCLUDED IN THE KIT:

1

Rockford Fosgate 600W+ Amp

2

1" Handlebar Clamp

1

Kicker® 4" Speakers in Waterproof housings

1

Complete Wire Kit by Rockford Fosgate

1

MTX® Bluetooth Audio Controller

2

1-1/4" Handlebar Clamp

6

Cable Ties

1

3.5mm (headphone) to RCA (amplifier) cable

ST-600 REV A 1/4/17

ST600 PLATINUM EDITION WITH BLUETOOTH®, AUX-IN | CHROME

ST600

STEELHORSEAUDIO.COM

800-823-5310 | [e-mail]

Steel Horse Audio #237 | 1540 Main St, Bldg 218 | Windsor, CO 80550

INSTALLATION INSTRUCTIONS

-CONTINUED-

THESE INSTALLATION INSTRUCTIONS CONTAIN IMPORTANT INFORMATION. ENSURE THE END USER RECEIVES THIS COPY AND IS AWARE
OF ITS IMPORTANCE FOR FUTURE USE.

WHEN CONNECTING POWER AND GROUND WIRES ENSURE THAT THE RED POWER WIRE IS FUSED AT THE POINT WHERE IT IS
CONNECTED TO THE VEHICLE’S BATTERY. FAILURE TO DO SO CAN RESULT IN DAMAGE TO THE VEHICLE IF A SHORT CIRCUIT DEVELOPS
BETWEEN THE VEHICLE CONNECTION POINT AND THE PRODUCT.

THE END USER’S SAFETY DEPENDS UPON PROPER INSTALLATION OF THIS PRODUCT. IF A STEP IN THESE INSTRUCTIONS IS NOT
WITHIN YOUR CAPABILITIES OR YOU DO NOT HAVE THE CORRECT TOOLS, HAVE YOUR DEALER PERFORM THE PROCEDURE. IMPROPER
INSTALLATION OF THIS PRODUCT COULD RESULT IN DEATH OR SERIOUS INJURY.

ACCIDENTAL VEHICLE START-UP COULD CAUSE DEATH OR SERIOUS INJURY, REMOVE THE MAIN FUSE BEFORE PROCEEDING.

INTRODUCTION

Thank you for purchasing this Steel Horse Audio ST600 Motorcycle Speaker System with Bluetooth or playback from any audio device with a
headphone jack including iPhone® and Android® smartphones. This easy to install and use, all in one unit is capable of transforming any
music into an all in one motorcycle audio experience. Designed to mount on any motorcycle handle bars with a 1" or 1-1/4” diameter (other
sizes available upon request for 7/8", 1-1/8" and 1-1/2"). Congratulations and enjoy the ultimate audio experience!

FE AT U R E S

AMPLIFIER/CONTROLLER SPECS:

• Bluetooth

• Easy to install with simple wiring to speakers and power

• Waterproof handlebar mount controller with Bluetooth

• 1" and 1-1/4" p-clamp mount for controller

• Includes all wiring and installation accessories

4" KICKER SPEAKER SPECS:

• Steel housings with triple plate chrome or satin black finish

• Measures 4.75" Diameter by 3" depth mounting size for easy mounting, even behind a windshield

• Includes two pair of bar mount brackets: 1” and 1-1/4” (1-1/2" available upon request)

• Over 600 Watts Peak Power (typically more than 900 watts tested total) | ~20 amp power draw

®

and a 3.5mm (Headphone) AUX-IN connection

®

control

INSTALLATION

The Steel Horse Audio ST600 Platinum Edition Motorcycle Speaker System can be used with
any 12-volt battery and can be mounted to a variety of bars using the included hardware. Mount
the speakers where they have sufficient clearance, position the speakers so they are directly
facing the rider.

STEP 1

PAGE 2

MOUNT BRACKETS TO HANDLEBAR FIRST, THEN INSTALL SPEAKERS

Determine the diameter of the handlebar and use either the 1” Bracket or the 1-1/4” Bracket

Note: If you have a different diameter handlebar *7/8", 1-1/8" or 1-1/2") you can request that
bracket separately and we will ship them free of charge.