Static Solutions AF-5500 User Manual

Safety Data Sheet

Issue Date: 03-Feb-1992

Revision Date: 29-Jan-2015 Version 1

_____________________________________________________________________________________________

Page 1 / 8

1. IDENTIFICATION

Product Identifier

Product Name

AF-5500 Anti Static Floor Finish

Other means of identification

SDS #

DYNI-001

Recommended use of the chemical and restrictions on use

Recommended Use

Floor finish/floor coating.

Details of the supplier of the safety data sheet

Supplier Address

Static Solutions 43 Broad Street Hudson, MA 01749

Emergency Telephone Number

Company Phone Number

Phone: 978-310-7251 Fax: 978-310-7146

Emergency Telephone (24 hr)

INFOTRAC 1-352-323-3500 (International) 1-800-535-5053 (North America)

2. HAZARDS IDENTIFICATION

Appearance White liquid

Physical State Liquid Odor Mild

Classification

Skin corrosion/irritation

Category 2

Serious eye damage/eye irritation

Category 2

Reproductive toxicity

Category 2

Signal Word Warning

Hazard Statements

Causes skin irritation Causes serious eye irritation Suspected of damaging fertility or the unborn child

Precautionary Statements - Prevention

Obtain special instructions before use Do not handle until all safety precautions have been read and understood Use personal protective equipment as required Wash face, hands and any exposed skin thoroughly after handling Wear eye/face protection

- AF-5500 Anti Static Floor Finish

Revision Date: 29-Jan-2015

_____________________________________________________________________________________________

Page 2 / 8

Precautionary Statements - Response

If exposed or concerned: Get medical advice/attention

IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye irritation persists: Get medical advice/attention

IF ON SKIN: Wash with plenty of soap and water Take off contaminated clothing and wash it before reuse If skin irritation occurs: Get medical advice/attention

Precautionary Statements - Storage

Store locked up

Precautionary Statements - Disposal

Dispose of contents/container to an approved waste disposal plant

Other Hazards

Toxic to aquatic life with long lasting effects

3. COMPOSITION/INFORMATION ON INGREDIENTS

Chemical Name

CAS No

Weight-%

Diethylene glycol monomethyl ether

111-77-3

<5

tributoxyethyl phosphate

78-51-3

<3

Zinc Oxide

1314-13-2

<1

Ammonium hydroxide

1336-21-6

<1

**If Chemical Name/CAS No is "proprietary" and/or Weight-% is listed as a range, the specific chemical identity and/or percentage of composition has been withheld as a trade secret.**

4. FIRST-AID MEASURES

First Aid Measures General Advice

If exposed or concerned: Get medical advice/attention.

Eye Contact

Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention.

Skin Contact

Wash with plenty of soap and water. Take off contaminated clothing and wash it before reuse. If skin irritation occurs: Get medical advice/ attention.

Inhalation

Remove to fresh air.

Ingestion

Clean mouth with water and drink afterwards plenty of water.

Most important symptoms and effects

Symptoms

Causes skin irritation. Causes serious eye irritation. Suspected of damaging fertility or the unborn child.

Indication of any immediate medical attention and special treatment needed Notes to Physician

Treat symptomatically.

5. FIRE-FIGHTING MEASURES

Suitable Extinguishing Media

Carbon dioxide (CO2). Dry chemical.

Unsuitable Extinguishing Media

Not determined.

- AF-5500 Anti Static Floor Finish

Revision Date: 29-Jan-2015

_____________________________________________________________________________________________

Page 3 / 8

Specific Hazards Arising from the Chemical

Not determined.

Hazardous Combustion Products Toxic gases may be released.

Protective equipment and precautions for firefighters

As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear.

6. ACCIDENTAL RELEASE MEASURES

Personal precautions, protective equipment and emergency procedures

Personal Precautions

Use personal protective equipment as required.

Methods and material for containment and cleaning up

Methods for Containment

Prevent further leakage or spillage if safe to do so.

Methods for Clean-Up

Halt spill at source and contain or dike spill with inert absorbent material. Transfer liquid to containers for recovery or disposal. Shovel absorbent into drums for disposal in accordance with local, state and federal regulations.

7. HANDLING AND STORAGE

Precautions for safe handling

Advice on Safe Handling

Handle in accordance with good industrial hygiene and safety practice. Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Use personal protective equipment as required. Wash face, hands, and any exposed skin thoroughly after handling. Wear eye/face protection.

Conditions for safe storage, including any incompatibilities Storage Conditions

Store locked up.

Incompatible Materials

None known based on information supplied.

8. EXPOSURE CONTROLS/PERSONAL PROTECTION

Exposure Guidelines

Chemical Name

ACGIH TLV

OSHA PEL

NIOSH IDLH

Zinc Oxide 1314-13-2

STEL: 10 mg/m3 respirable

fraction

TWA: 2 mg/m3 respirable fraction

TWA: 5 mg/m3 fume

TWA: 15 mg/m3 total dust

TWA: 5 mg/m3 respirable fraction

(vacated) TWA: 5 mg/m3 fume

(vacated) TWA: 10 mg/m3 total

dust

(vacated) TWA: 5 mg/m3

respirable fraction

(vacated) STEL: 10 mg/m3 fume

IDLH: 500 mg/m3

Ceiling: 15 mg/m3 dust

TWA: 5 mg/m3 dust and fume

STEL: 10 mg/m3 fume

Appropriate engineering controls

Engineering Controls

Showers. Eyewash stations. Ventilation systems.

- AF-5500 Anti Static Floor Finish

Revision Date: 29-Jan-2015

_____________________________________________________________________________________________

Page 4 / 8

Individual protection measures, such as personal protective equipment Eye/Face Protection

Wear approved safety goggles with side shields.

Skin and Body Protection

Wear rubber gloves. Wear protective work clothing.

Respiratory Protection

None required in well ventilated areas. An approved organic vapor full face respirator is advised for poorly ventilated areas.

General Hygiene Considerations

Handle in accordance with good industrial hygiene and safety practice.

9. PHYSICAL AND CHEMICAL PROPERTIES

Information on basic physical and chemical properties Physical State

Liquid

Appearance

White liquid

Odor

Mild

Color

White

Odor Threshold

Not determined

Property

Values

Remarks • Method

pH

8.0-9.0

Melting Point/Freezing Point

0 °C / 32 °F

Boiling Point/Boiling Range

100 °C / 212 °F

Flash Point

Non flammable

Evaporation Rate

<1 to water

(butyl acetate = 1)

Flammability (Solid, Gas)

Liquid-Not applicable

Upper Flammability Limits

Not available

Lower Flammability Limit

Not available

Vapor Pressure

Not determined

Vapor Density

<1 to water

(Air=1)

Specific Gravity

Not determined

Water Solubility

Infinitely miscible

Solubility in other solvents

Not determined

Partition Coefficient

Not available

Auto-ignition Temperature

Greater than 121.1 °C / 250 °F

Decomposition Temperature

Not determined

Kinematic Viscosity

20

Dynamic Viscosity

Not determined

Explosive Properties

Not determined

Oxidizing Properties

Not determined

VOC Content (%)

Less than 5%

10. STABILITY AND REACTIVITY

Reactivity

Not reactive under normal conditions.

Chemical Stability

Stable under recommended storage conditions.

Possibility of Hazardous Reactions

None under normal processing.

Hazardous Polymerization

Under normal conditions of storage and use, hazardous polymerization will not occur.

Conditions to Avoid

Heat, flames and sparks.

Incompatible Materials

None known based on information supplied.

- AF-5500 Anti Static Floor Finish

Revision Date: 29-Jan-2015

_____________________________________________________________________________________________

Page 5 / 8

Hazardous Decomposition Products

Toxic gases may be released.

11. TOXICOLOGICAL INFORMATION

Information on likely routes of exposure

Product Information

Eye Contact

Causes serious eye irritation.

Skin Contact

Causes skin irritation.

Inhalation

Do not inhale.

Ingestion

Do not ingest.

Component Information

Chemical Name

Oral LD50

Dermal LD50

Inhalation LC50

Diethylene glycol monomethyl ether

111-77-3

= 4 mL/kg ( Rat )

= 2500 µL/kg ( Rabbit )

-

tributoxyethyl phosphate

78-51-3

= 3000 mg/kg ( Rat )

> 5000 mg/kg ( Rabbit )

> 6.4 mg/L ( Rat ) 4 h

Zinc Oxide 1314-13-2

> 5000 mg/kg ( Rat )

-

Ammonium hydroxide

1336-21-6

= 350 mg/kg ( Rat )

-

Information on physical, chemical and toxicological effects

Symptoms

Please see section 4 of this SDS for symptoms.

Delayed and immediate effects as well as chronic effects from short and long-term exposure

Carcinogenicity

Based on the information provided, this product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP.

Reproductive toxicity

Suspected of damaging fertility or the unborn child.

Numerical measures of toxicity

Not determined

12. ECOLOGICAL INFORMATION

Ecotoxicity

Toxic to aquatic life with long lasting effects.

Component Information

Chemical Name

Algae/aquatic plants

Fish

Toxicity to

microorganisms

Crustacea

Diethylene glycol

monomethyl ether

111-77-3

500: 72 h Desmodesmus

subspicatus mg/L EC50

7500: 96 h Lepomis

macrochirus mg/L LC50

static 7500: 96 h Lepomis

macrochirus mg/L LC50

5741: 96 h Pimephales

promelas mg/L LC50

EC50 > 10000 mg/L 17 h

500: 48 h Daphnia magna

mg/L EC50

tributoxyethyl phosphate

78-51-3

10.4 - 12.0: 96 h Pimephales promelas mg/L LC50 flow-

through

- AF-5500 Anti Static Floor Finish

Revision Date: 29-Jan-2015

_____________________________________________________________________________________________

Page 6 / 8

Chemical Name

Algae/aguatic plants

Fish

Toxicity to

microorganisms

Crustacae

Ammonium hydroxide

1336-21-6

8.2: 96 h Pimephales promelas mg/L LC50

0.66: 48 h water flea mg/L EC50 0.66: 48 h Daphnia

pulex mg/L EC50

Persistence/Degradability

Not determined.

Bioaccumulation

Not determined.

Mobility

Chemical Name

Partition Coefficient

Diethylene glycol monomethyl ether

111-77-3

-0.682

tributoxyethyl phosphate

78-51-3

4.78

Other Adverse Effects

Not determined

13. DISPOSAL CONSIDERATIONS

Waste Treatment Methods

Disposal of Wastes

Disposal should be in accordance with applicable regional, national and local laws and regulations.

Contaminated Packaging

Disposal should be in accordance with applicable regional, national and local laws and regulations.

California Hazardous Waste Status

Chemical Name

California Hazardous Waste Status

Zinc Oxide 1314-13-2

Toxic

Ammonium hydroxide

1336-21-6

Toxic

Corrosive

14. TRANSPORT INFORMATION

Note

Please see current shipping paper for most up to date shipping information, including exemptions and special circumstances.

DOT

Not regulated

IATA

Not regulated

IMDG

Marine Pollutant

This material may meet the definition of a marine pollutant

15. REGULATORY INFORMATION

International Inventories

Chemical Name

TSCA

DSL

NDSL

EINECS

ELINCS

ENCS

IECSC

KECL

PICCS

AICS

Diethylene glycol

monomethyl ether

Present

X

Present

X

Present

X

- AF-5500 Anti Static Floor Finish

Revision Date: 29-Jan-2015

_____________________________________________________________________________________________

Page 7 / 8

Chemical Name

TSCA

DSL

NDSL

EINECS

ELINCS

ENCS

IECSC

KECL

PICCS

AICS

tributoxyethyl phosphate

Present

X

Present

X

Present

X

Zinc Oxide

Present

X

Present

X

Present

X

Ammonium hydroxide

Present

X

Present

X

Present

X

Legend:

TSCA - United States Toxic Substances Control Act Section 8(b) Inventory

DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List

EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances

ENCS - Japan Existing and New Chemical Substances

IECSC - China Inventory of Existing Chemical Substances

KECL - Korean Existing and Evaluated Chemical Substances

PICCS - Philippines Inventory of Chemicals and Chemical Substances

AICS - Australian Inventory of Chemical Substances

US Federal Regulations

CERCLA

Chemical Name

Hazardous Substances RQs

CERCLA/SARA RQ

Reportable Quantity (RQ)

Ammonium hydroxide

1336-21-6

1000 lb

RQ 1000 lb final RQ

RQ 454 kg final RQ

SARA 313

Chemical Name

CAS No

Weight-%

SARA 313 - Threshold

Values %

Diethylene glycol monomethyl ether - 111-77-3

111-77-3

<5

1.0

Zinc Oxide - 1314-13-2

1314-13-2

<1

1.0

Ammonium hydroxide - 1336-21-6

1336-21-6

<1

1.0

CWA (Clean Water Act)

Chemical Name

CWA - Reportable

Quantities

CWA - Toxic Pollutants

CWA - Priority Pollutants

CWA - Hazardous

Substances

Zinc Oxide

X

Ammonium hydroxide

1000 lb

X

US State Regulations

California Proposition 65

This product does not contain any Proposition 65 chemicals.

U.S. State Right-to-Know Regulations

Chemical Name

New Jersey

Massachusetts

Pennsylvania

Diethylene glycol monomethyl ether

111-77-3

X

Zinc Oxide 1314-13-2

X

Ammonium hydroxide

1336-21-6

X

- AF-5500 Anti Static Floor Finish

Revision Date: 29-Jan-2015

_____________________________________________________________________________________________

Page 8 / 8

16. OTHER INFORMATION

NFPA

Health Hazards

1

Flammability

0

Instability

0

Special Hazards

Not determined

HMIS

Health Hazards

1

Flammability

0

Physical Hazards

0

Personal Protection

Not determined

Issue Date:

03-Feb-1992

Revision Date:

29-Jan-2015

Revision Note:

New format

Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.

End of Safety Data Sheet