Star Manufacturing 9B-SWB7R1, SWB7R1 Installation Manual

WAFFLE

BAKERS

NON-ELECTRONIC MODELS

9B-SWCB, 9B-SWB7R1

9B-SWB7R2, 9B-SWB7RB

9B-SWB7RBS, 9B-SWB8SQ

9B-SWB8RBD, 9B-SWB8RBL

Installation and

Operation

Instructions

2M-Z1736 Rev. J 1/30/06

9B-SWB7R2

1

SAFETY SYMBOL

Using any part other than genuine Star factory supplied parts relieves the
manufacturer of all liability.

Star reserves the right to change specifi cations and product design without
notice. Such revisions do not entitle the buyer to corresponding changes,
improvements, additions or replacements for previously purchased
equipment.

Due to periodic changes in designs, methods, procedures, policies and
regulations, the specifi cations contained in this sheet are subject to change
without notice. While Star Manufacturing exercises good faith efforts to provide
information that is accurate, we are not responsible for errors or omissions
in information provided or conclusions reached as a result of using the
specifi cations. By using the information provided, the user assumes all risks in
connection with such use.

These symbols are intended to alert the user to the presence of
important operating and maintenance instructions in the manual
accompanying the appliance.

RETAIN THIS MANUAL FOR FUTURE REFERENCE

NOTICE

MAINTENANCE AND REPAIRS

Contact your local authorized service agent for service or required maintenance. Please record the model
number, serial number, voltage and purchase date in the area below and have it ready when you call to

ensure a faster service.

Model No.

Serial No.

Voltage

Purchase Date

Authorized Service Agent

Reference the listing provided with the unit

or

for an updated listing go to:

Website: www.star-mfg.com
E-mail [e-mail]
Telephone: [phone] Local [phone]

The Star Service Help Desk

Business 8:00 am to 4:30 p.m. Central Standard Time
Hours:

Telephone: [phone] Local [phone]

Fax: [phone] Local [phone]

E-mail [e-mail]

[e-mail]
[e-mail]

Website: www.star-mfg.com

Mailing Address: Star Manufacturing International Inc.

10 Sunnen Drive
St. Louis, MO 63143
U.S.A

2

2

GENERAL INFORMATION

CAUTION

This equipment is designed and sold for commercial use only by personnel trained and

experienced in its operation and is not sold for consumer use in and around the home nor for
use directly by the general public in food service locations.

Before using your new equipment, read and understand all the instructions & labels

associated with the unit prior to putting it into operation. Make sure all people associated
with its use understand the units operation & safety before they use the unit.

All shipping containers should be checked for freight damage both visible and concealed.

This unit has been tested and carefully packaged to insure delivery of your unit in perfect
condition. If equipment is received in damaged condition, either apparent or concealed, a
claim must be made with the delivering carrier.

Concealed damage or loss - if damage or loss is not apparent until after equipment is

unpacked, a request for inspection of concealed damage must be made with carrier within
15 days. Be certain to retain all contents plus external and internal packaging materials for

inspection. The carrier will make an inspection and will supply necessary claim forms.

GENERAL INSTALLATION DATA

For your protection, we recommend that a qualifi ed electrician install this appliance. The
electrician should be familiar with electrical installations and your local electrical requirements.
Proper connections and power supply are essential for effi cient performance. The supply circuit
should be properly fused as required by electrical code. Plug the unit into a proper A.C. voltage
wall outlet only. A three-prong plug is provided with the unit. If an adapter is used be sure a

good ground is provided.

LOAD

The rated load is on the nameplate. The line in the wall outlet must be heavy enough to carry
this load, or the waffl e baker will be slow in performance.

WARNING

DO NOT CONNECT TO DIRECT CURRENT (DC).

TEFLON® COATED WAFFLE BAKERS

CAUTION
DO NOT USE METAL UTENSILS TO REMOVE WAFFLE FROM THE TEFLON®
COATED WAFFLE BAKER. THIS WILL VOID THE WARRANTY.

CAUTION
DO NOT CLEAN TEFLON® GRIDS WITH ABRASIVES. THIS WILL VOID THE
WARRANTY.

CORD, PLUG AND GROUND INSTRUCTIONS

For your protection, this appliance is equipped with a 3-conductor load cord, having a grounding
type plug. It should only be used with a properly grounded 3-prong receptacle. Do not modify.
If you use an adapter be sure your system is grounded. Connect the green wire to a mounting
screw of the receptacle. For ungrounded electrical systems, connect the green wire of the

adapter to a known permanent ground.

3

RELEASE AGENT CAUTION

If you fi nd it necessary to use a release agent to keep waffl es from sticking, you should brush it
on. Spraying may oversaturate the grids and the excess has the possibility of building up inside
the baker and causing damage. If you only have a spray type release agent, try spraying it into

a container and using the contents with a pastry brush.

SEASONING WAFFLE GRIDS
(Not applicable to Tefl on ® coated grids)

With a pastry brush, apply vegetable oil, butter, or grid release agent on both grids. Turn power
on and allow to preheat for twenty minutes. Lift the lid and re-apply vegetable oil, butter, or grid

release agent. Allow the unit to heat for fi ve more minutes. The baker is now ready for use.

CAUTION
GRIDS AND CUPS HAVE VERY HIGH TEMPERATURES. DO NOT COME IN DIRECT
CONTACT WITH THESE PARTS WHEN THE WAFFLE BAKER IS IN OPERATION.
DO NOT ALLOW CORD TO COME INTO CONTACT WITH HOT GRIDS.

GENERAL OPERATING INSTRUCTIONS

WAFFLES

Turn the unit on and allow to pre-heat for 15 minutes with the grids closed.
Once the baker has reached proper temperature you can proceed as follows:

1. Lift the lid, pour in mix and close.

2. Rotate grids 180o. (Belgian units only)

3. Start timer by pressing the start/stop pad.

4. When timer beeps, depress the start/ stop pad.

5. Rotate grids 180o (Belgian units only)

6. Remove waffl e. (Do not use metal utensils on tefl on coated waffl e bakers.)

7. For next waffl e repeat steps 1 through 6.

Setting the Time:

If necessary, the factory pre-set timer can be adjusted to satisfy individual preferences.

To increase time, depress and hold the "up" button. The start/ stop
button can now be used to increase baking time.

To decrease time, depress and hold the “down” button. The “start/
stop” button can now be used to decrease baking time.

4

HELPFUL HINTS

1. During long slack periods of the day, turn off the baker. During short slack periods, leave unit
on with the grids closed. This will help minimize carbon buildup.

2. Do not store batter in the refrigerator and expect the same speed in baking. Cold batter will
take longer to bake.

3. For proper release of waffl es it is important that the batter contain the proper amount of
shortening.

CLEANING

For non-coated grids: Clean outside of baker every day that it is in use. Clean grids with hot water
and mild detergent and a nylon brush to prevent a buildup of carbon from forming. In order to
remove carbon from grids, unplug the unit, place ammonia soaked cloth over bottom grid, close
and leave overnight. A nylon brush may then be used to remove the carbon buildup. If you use
a commercial carbon remover, make sure that it is safe for aluminum.

CAUTION

DO NOT CLEAN USING A WATER JET OR SIMILAR DEVICE FOR CLEANING. DO
NOT IMMERSE IN WATER AT ANY TIME.

CAUTION

DO NOT CLEAN TEFLON® GRIDS WITH ABRASIVES. THIS WILL VOID THE
WARRANTY.

For cleaning the baker outside use only a soft cloth and mild soap to keep the exterior surfaces
bright and shining. Do not use detergents, strong abrasives or metal scouring pads on the exterior
surfaces of the waffl e baker.

5

Visit our Website at: www.star-mfg.com Email: [e-mail]

THOROUGHLY INSPECT YOUR UNIT ON ARRIVAL

This unit has been tested for proper operation before leaving our plant to insure delivery of your unit in perfect condition. However, there are instances in
which the unit may be damaged in transit. In the event you discover any type of damage to your product upon receipt, you must immediately contact the
transportation company who delivered the item to you and initiate your claim with same. If this procedure is not followed, it may affect the warranty
status of the unit.

LIMITED EQUIPMENT WARRANTY

All workmanship and material in Star products have a one (1) year limited warranty on parts & labor in the United States and Canada. Such warranty is
limited to the original purchaser only and shall be effective from the date the equipment is placed in service. Star's obligation under this warranty is limited
to the repair of defects without charge, by the factory authorized service agency or one of its sub-agencies. Models that are considered portable (see below)
should be taken to the closest Star service agency, transportation prepaid.

> Star will not assume any responsibility for loss of revenue.

> On all shipments outside the United States and Canada, see International Warranty.

* The warranty period for the JetStar series six (6) ounce popcorn machines is two (2) years.

* The warranty period for the Chrome-Max Griddles is five (5) years on the griddle surface. See detailed warranty provided with unit.

* The warranty period for Teflon/Dura-Tec coatings is one year under normal use and reasonable care. This warranty does not apply if damage occurs to

Teflon/Dura-Tec coatings from improper cleaning, maintenance, use of metallic utensils, or abrasive cleaners. This warranty does not apply to the
“non-stick” properties of such materials.

> This warranty does not apply to "Special Products" but to regular catalog items only. Star's warranty on "Special Products" is six (6) months on parts

and ninety (90) days on labor.

> This warranty does not apply to any item that is disassembled or tampered with for any purpose other than repair by a Star Authorized Service Center or

the Service Center's sub-agency.

> This warranty does not apply if damage occurs from improper installation, misuse, wrong voltage, wrong gas or operated contrary to the Installation and

Operating instructions.

> This warranty is not valid on Conveyor Ovens unless a "start-up/check-out" has been performed by a Factory Authorized Technician.

PARTS WARRANTY

Parts that are sold to repair out of warranty equipment are warranted for ninety (90) days. The part only is warranted. Labor to replace the part is
chargeable to the customer.

SERVICES NOT COVERED BY WARRANTY

1. Travel time and mileage rendered beyond the 50 mile radius limit

2. Mileage and travel time on portable equipment (see below)

3. Labor to replace such items that can be replaced easily during a daily cleaning
routine, ie; removable kettles on fryers, knobs, grease drawers on griddles, etc.

4. Installation of equipment

5. Damages due to improper installation

6. Damages from abuse or misuse

7. Operated contrary to the Operating and Installation Instructions

8. Cleaning of equipment

9. Seasoning of griddle plates

PORTABLE EQUIPMENT

Star will not honor service bills that include travel time and mileage charges for servicing any products considered "Portable" including items listed below.
These products should be taken to the Service Agency for repair:

* The Model 510FD Fryer.
* The Model J4R, 4 oz. Popcorn Machine.
* The Model 518CMA & 526CMA Cheese Melter.
* The Model 12MC & 15MC & 18MCP Hot Food Merchandisers.
* The Model 12NCPW & 15NCPW Nacho Chip/Popcorn Warmer.
* All Hot Dog Equipment except Roller Grills & Drawer Bun Warmers.
* All Nacho Cheese Warmers except Model 11WLA Series Nacho Cheese Warmer.
* All Condiment Dispensers except the Model HPDE, & SPDE Series Dispenser.
* All Specialty Food Warmers except Model 130R, 11RW Series, and 11WSA Series.
* All QCS/RCS Series Toasters except Model QCS3 & RCS3 Series.

The foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty.

FOR ASSISTANCE

Should you need any assistance regarding the Operation or Maintenance of any Star equipment; write, phone, fax or email our Service Department.

In all correspondence mention the Model number and the Serial number of your unit, and the voltage or type of gas you are using.

6

10 . Voltage conversions
11 . Gas conversions
12 . Pilot light adjustment
13 . Miscellaneous adjustments
14 . Thermostat calibration and by-pass adjustment
15 . Resetting of circuit breakers or safety controls or reset buttons
16 . Replacement of bulbs
17 . Replacement of fuses
18 . Repair of damage created during transit, delivery, &

installation OR created by acts of God

ALL:
* Pop-Up Toasters
* Butter Dispensers
* Pretzel Merchandisers
* Pastry Display Cabinets
* Nacho Chip Merchandisers
* Accessories of any kind
* Sneeze Guards
* Pizza Ovens
* Heat Lamps
* Pumps

Part# 2M-4497-2 10/05 RB

789