Starburst Phantom The Starburst Phantom ULB42-DLP, ULB44-DLP Installation And Instruction Manual
INSTALLATION AND INSTRUCTION MANUAL
The
The
Starburst Phantom
Starburst Phantom
Undercover Interior LED Lightbar
With Generation-4 LED
Takedown and Directional Pursuit Lights
Models
ULB42-DLP ULB44-DLP
(Discrete) (Gen 4 Starburst)
®
IMPORTANT: Please read all of the following instructions before installing your new warning light.
PLIT395 REV. B 4/27/11
-1-
Due to continuous product improvements, we must reserve the right to change any
NOTICE
specifications and information, contained in this manual at any time without notice. Star
Headlight & Lantern Co., Inc. makes no warranty of any kind with regard to this manual,
including, but not limited to, the implied warranties of merchantability and fitness for a particular
purpose. Star Headlight & Lantern Co., Inc. shall not be liable for errors contained herein or for
incidental or consequential damages in connection with the furnishing, performance, or use of
IMPORTANT: Please read all of the following instructions before installing your new
CAUTION: Please be sure to check that your cigarette plug outlet is properly fused. Testing the
WARNING!!!! Care should be taken when positioning this warning light so that the light and/or
Please Note: These instructions are provided as a general guideline only. Specific
mounting and/or wiring, may be necessary and are the sole responsibility of the
installer. Star Headlight & Lantern Co., Inc. assumes no responsibility for the
integrity of the installation for this or any of its products.
light before this fuse is properly installed will void the warranty on the light.
The Starburst Phantom
Starburst Phantom
cord does not interfere with the proper operation of the driver-side or passengerside airbag! Failure to heed this warning may result in serious or fatal injury.
®
uses state-of-the-art Light Emitting Diode
®
LED undercover lightbar.
(LED) technology. This warning light is comprised of ultra-high intensity LEDs
that are operated by a micro-controller to efficiently produce light output with
lifetimes up to 100,000 hours.
CAUTION: All of our DC powered warning lights are polarity
sensitive. These lights are polarity protected only if the
appropriate fuse is used. All wires connected to the positive
terminal of the battery should be fused at the battery for their
rated load. Testing the light before this fuse is properly
installed will void the warranty on the light.
-2-
General Information
ULB42-DLP: Interior undercover discrete LED lightbar with high-power
Generation-4 LED Takedown/Pursuit Lights
ULB44-DLP: Interior undercover high-power Generation-4 LED lightbar with
high-power Generation-4 LED Takedown/Pursuit Lights
•
The ULB42-DLP and ULB44-DLP each consist of 10 LED arrays.
•
Eight of the arrays are used for "warning" purposes.
•
The remaining two arrays utilize high-power Generation-4 LEDs and are
used for takedown/pursuit lights.
Warning Lights
DLP
Lights
Mounting Instructions
The following mounting instructions describe the standard, most common
way to mount this light. This method may or may not apply to your vehicle.
Because vehicles can vary widely in their design, it may be necessary to
configure the brackets differently than described. Some applications may
require you to design your own custom brackets. The installer assumes all
responsibility for the integrity of the installation. It is the sole
responsibility of the owner to ensure the light is secure.
The
Starburst Phantom
on the inside of your vehicle. It is not intended for exterior
applications and is not warranted against water damage.
It is the sole responsibility of the owner to ensure the warning light is
secure. Check your light every time you enter the vehicle to ensure that
it is mounted securely. The manufacturer assumes no responsibility for
the secure mounting of this light.
®
is designed to be mounted
The ULB42-DLP and ULB44-DLP are designed to be mounted in the front
windshield of a vehicle using the pre-existing visor clips.
-3-
The mounting hardware enclosed with your
include the following:
QTY PART# DESCRIPTION
1 P30150-220LP LEFT ATTACHING BRACKET
1 P30150-220RP RIGHT ATTACHING BRACKET
2 P30150-79P FORKED "L" BRACKET (Style 1)
2 P30150-189P FORKED "L" BRACKET (Style 2)
2 P30054-27 #10-32 x 1/2" CARRIAGE BOLT
2 P30094-10 #10-32 SERRATED FLANGE NUT
2 P30076-8 1/4" FLAT WASHER
1 P111-2 RUBBER CHANNEL GASKET
-4-
Starburst Phantom
®
should
Loading...