Star 6136RCBB-LP Operators Manual

Star
Manufacturing
International Inc.

10 Sunnen Drive
St. Louis, MO 63143

Phone: [phone]
Fax: [phone]

Installation and

Operating Instructions

Instructions d’installation

et d’opération

2M-Z5137 Rev. - 12/21/01

STAR-MAX GAS CHARBROILER

MODELS

6015CBB-LP, 6024CBB-LP,
6036CBB-LP, 6048CBB-LP,

6115RCBB-LP, 6124RCBB-LP,

6136RCBB-LP, and 6148RCBB-LP

BARBECUE A GAZ STAR-MAX

MODELES

6015CBB-LP, 6024CBB-LP,
6036CBB-LP, 6048CBB-LP,

6115RCBB-LP, 6124RCBB-LP,

6136RCBB-LP, et 6148RCBB-LP

GENERAL INSTALLATION DATA

CAUTION

This equipment is designed and sold for
commercial use only by personnel trained and
experienced in its operation and is not sold for
consumer use in and around the home nor for
use directly by the general public in food service
locations. For equipment to be used by the
general public, please contact the factory.

The Star-Max series gas charbroiler is equipped
for the type of gas indicated on the nameplate
mounted on the front panel. All units are shipped
from the factory for use with natural gas. The unit
can easily be converted for use with propane gas:
see propane gas.

-IMPORTANT-

INSTALLATION: INSTALL IN NON­COMBUSTIBLE LOCATIONS ONLY! Clearance
from non-combustible construction must be 6"
from back and sides.

FOR YOUR SAFETY

DO NOT STORE OR USE GASOLINE OR

OTHER FLAMMABLE VAPORS AND LIQUIDS

IN THE VICINITY OF THIS OR ANY OTHER

APPLIANCE. KEEP THE APPLIANCE AREA
CLEAR AND FREE FROM COMBUSTIBLES.

This appliance, its pressure regulator and its
individual shutoff valve must be disconnected from
the gas supply piping system during any pressure
testing of that system at test pressures in excess
of 1/2 PSIG. This appliance and its pressure
regulator must be isolated from the gas supply
piping system by closing its individual manual
shutoff valve during any pressure testing of the gas
supply piping system at test pressures equal to or
less than 1/2 PSIG. For your protection, we
recommend a qualified installing agency install this
appliance. They should be familiar with gas
installations and your local gas requirements. In
any case, your gas company should be called to
approve the final installation. In addition, there
should be posted, in a prominent location,
detailed instructions to be followed in the event
the operator smells gas. Obtain the instructions
from the local gas supplier.

The installation of the Appliance must
conform to the NATIONAL FUEL GAS CODE
"ANSI Z223.1 - LATEST EDITION" AND ALL
LOCAL GAS COMPANY RULES AND
REGULATIONS.

IN CANADA INSTALLATION SHALL BE IN
ACCORDANCE WITH THE CURRENT CAN/
CGA-B149.1 NATURAL GAS INSTALLATION
CODE OR CAN/CGA-B149.2 PROPANE

INSTALLATION CODE AND LOCAL

CODES WHERE APPLICABLE.

WARNING: Improper installation,
adjustment, alteration, service or maintenance
can cause property damage, injury or death.
Read the installation, operating and
maintenance instructions thoroughly before
installing or servicing the equipment.

LEVELING UNIT

This charbroiler is supplied with 4 feet which must
be screwed into the body. Level unit by adjusting
the (4) feet which have an adjustment of 1-3/4" for
accurate and perfect line-up with other units.
CAUTION: DO NOT INSTALL WITHOUT
ATTACHING FEET - DO NOT REMOVE FEET.

GAS INPUT TO CHARBROILER:

Models 6015CBB and 6115RCBB 35,000 BTU/HT, PROP
Models 6024CBB and 6124RCBB 70,000 BTU/HR, PROP
35,000 BTU/HR/BURNER, PROP
Models 6036CBB and 6136RCBB 105,000 BTU/HR, PROP
35,000 BTU/HR/BURNER, PROP
Models 6048CBB and 6148RCBB 140,000 BTU/HR, PROP
35,000 BTU/HR/BURNER, PROP

3