Stanley LIONLEDS Instruction Manual
116
Lithium LED SpotLight
iNStructioN maNuaL
LiNtErNa DE LED DEL Litio
maNuaL DE iNStruccióN
SAVE THIS INSTRUCTION MANUAL FOR FUTURE REFERENCE.
CONSERVE ESTE MANUAL PARA FUTURAS CONSULTAS.
© 2013 Baccus Global LLC
Boca Raton, FL 33432
Customer Service: (877) 571-2391
LIONLEDS
English page 3
Español página 9
BC
LIONLEDS_ManualENSP_073013.indd 16-1 7/30/2013 11:49:07 AM
2 3
This device complies with part 15 of the FCC rules. Operation is subject to the following two conditions: (1) this device may not cause
harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.
This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules.
These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment
generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause
harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation.
If equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and
on, the user is encouraged to try to correct the interference by one or more of the following measures:
Reorient or relocate the receiving antenna.
Increase the separation between equipment and receiver.
Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
Consult the dealer or an experienced radio/TV technician for help.
Changes or modifications not approved by the party responsible for compliance could void user’s authority to operate the equipment.
GENERAL SAFETY WARNINGS AND INSTRUCTIONS
READ ALL INSTRUCTIONS
WARNING: Read all instructions before operating spotlight. Failure to follow all instructions listed below may
result in electric shock, fire and/or serious injury.
SAFETY GUIDELINES / DEFINITIONS
DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.
WARNING: Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
CAUTION: Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.
CAUTION: Used without the safety alert symbol indicates potentially hazardous situation which, if not avoided, may result in
property damage.
RISK OF UNSAFE OPERATION. When using tools or equipment, basic safety precautions should always be followed to reduce the
risk of personal injury. Improper operation, maintenance or modification of tools or equipment could result in serious injury and
property damage. There are certain applications for which tools and equipment are designed. Manufacturer strongly recommends
that this product NOT be modified and/or used for any application other than for which it was designed. Read and understand all
warnings and operating instructions before using any tool or equipment.
IMPORTANT SAFETY INSTRUCTIONS
WARNING: This product or its power cord contains lead, a chemical known to the State of California to cause cancer and birth
defect or other reproductive harm. Wash hands after handling.
INSTRUCTIONS PERTAINING TO A RISK OF FIRE, ELECTRIC SHOCK, EXPOSURE TO EXCESSIVE
UV RADIATION, OR INJURY TO PERSONS
Lighted lamp is HOT.
WARNING TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, EXPOSURE TO EXCESSIVE UV RADIATION, OR INJURY
TO PERSONS:
•5 watt LED gets HOT quickly!
•Do not touch the bulb at any time when operating.
•Only contact switch/plug when turning on.
•Do not touch hot lens or enclosure.
•Do not remain in light if skin feels warm.
•Do not operate the spotlight with a missing or damaged lens or enclosure.
WARNING – WHEN USING ELECTRICAL APPLIANCES, BASIC PRECAUTIONS SHOULD ALWAYS BE FOLLOWED, INCLUDING
THE FOLLOWING:
•To reduce the risk of injury, close supervision is necessary when the spotlight is used near children.
•Use only attachments recommended or sold by the manufacturer.
WARNING: TO REDUCE THE RISK OF ELECTRIC SHOCK:
•Do not put spotlight in water or other liquid. Do not place or store appliance where it can fall or be pulled into a tub or sink.
•Charge indoors only. Do not expose charger to water or any other liquid.
•Do not clean this appliance with a water spray or the like.
FEATURES
CARACTERÍSTICAS
FEATURES
1. Light Mode Select Button
2. 12VDC Power and Charging Port (for use of 12 volt DC
Adapter)
3. Battery/Charge Status LED Indicator
4. AC to DC Charging Port (for use with AC Charging Adapter)
5. Pistol Grip Handle
6. On/Off Trigger
7. Rubber Bezel
8. Swing-up Stand
9. Ventilation Slot
10. Trigger Lock
11. 120 Volt AC Adapter
12. 12 Volt DC Adapter (optional accessory)
CARACTERÍSTICAS
1. Botón de selección de modo de luz
2. Puerto de recarga e poder de CC (para usar con adaptador
de 12 voltios de CC)
3. Indicador LED del estado de la batería/de la carga
4. CA a CC puerto de carga (para su uso con adaptador de
carga de CA)
5. Mango tipo pistola
6. Disparador de encendido/apagado
7. Bezel de goma
8. Sopor te plegable
9. Ranura de ventilación
10. Cerradura del disparador
11. Adaptador de 120 voltios CA
12. Adaptador de 12 voltios CC (accesorio opcional)
8
6
10
1
7
11
12
5
2 4
3
9
LIONLEDS_ManualENSP_073013.indd 2-3 7/30/2013 11:49:07 AM
5
•Charge after each use.
•Always charge at least once every 3-6 months if not in frequent use to prevent overdischarge.
Transportation of Lithium-Ion Batteries
•Always check all applicable local, national, and international regulations before transporting a unit containing a Lithium-Ion
battery.
•Transporting an end-of-life, damaged, or recalled battery may, in certain cases, be specifically limited or prohibited.
SAVE THESE INSTRUCTIONS
INTRODUCTION
Congratulations on purchasing your new Stanley LED spotlight. Read this Instruction Manual and follow the instructions
carefully before using your new spotlight.
READING THE BATTERY/CHARGE STATUS LED INDICATOR
The battery and charging status LED indicator is located on the back of the unit. It lights or flashes in three colors to indicate the
following:
When charging:
Green: Battery is in a fully charged state.
Orange (flashing): Battery is in a partially charged state.
Red (flashing): Battery needs to be recharged.
Green & Red (flashing alternately):
1. The battery of the unit is overheated due to extensive use or recharging. The charging process will stop at this stage and will
automatically resume after a cool down period.
2. The battery voltage of your vehicle or other 12 volt DC power source has dropped to a level that is too low when charging
using the 12 volt DC adapter. The charging process will stop at this stage and will automatically resume after the battery level
of the 12 volt DC power source returns to normal.
When operating:
Green: Battery is operating at full voltage.
Orange: Battery is operating at partial voltage.
Red: Battery is operating at low voltage, and should be recharged.
Green & Red (flashing alternately): The battery of the unit is overheated due to extensive use or recharging. The operation will
stop at this stage and will automatically resume after a cool down period.
CHARGING/RECHARGING THE SPOTLIGHT
This unit is shipped in a partially charged state. Charge unit after purchase and BEFORE first use using the 120 Volt AC Adapter for
6 hours or until the battery/charge status LED indicator lights green.
Recharge after each use until the battery/charge status LED indicator lights green.
IMPORTANT: When the unit is not in use, we recommend that the battery is charged at least every 3 to 6 months.
CAUTION: TO REDUCE THE RISK OF INJURY OR PROPERTY DAMAGE:
•Never place the light face down on any surface when charging.
•Failure to keep the battery charged will cause permanent damage and result in poor performance.
Charging/recharging using the 120 Volt AC Adapter
•Make sure the spotlight is off (the trigger lock is in the off position and the trigger is not depressed).
•Insert the barrel connector of the AC Adapter into the AC to DC Charging Port on the back of the unit. Insert the plug end into a
(powered) standard North American 120 volt 60Hz outlet.
•Charge until the battery/charge status LED indicator lights green (approximately 6 hours).
Charging/recharging using the 12 Volt DC Adapter (optional accessory)
•Make sure the spotlight is off (the trigger lock is in the off position and the trigger is not depressed).
•Insert the barrel tip of the supplied 12 Volt DC Adapter into the 12 Volt DC Power and Charging Port on the back of the unit.
•Inser t the 12 volt DC plug end into the accessory outlet of your vehicle or other 12 volt DC power source.
•Charge until the battery/charge status LED indicator lights green (approximately 4 hours).
Notes:
When using a vehicle’s 12 volt DC accessory outlet as a charging source, be aware that some vehicles require you to turn on the ignition to power the
accessory outlet.
WARNING:TO AVOID THE RISK OF PROPERTY DAMAGE:
•NEVER CONNECT THE UNIT TO A POSITIVE GROUNDED VEHICLE.
•The 12 Volt DC Adapter must only be connected to batteries with a nominal output voltage of 12 volts. The unit will not operate
from a 6 volt battery and will sustain permanent damage if connected to a 24 volt battery.
4
•Use only the chargers supplied by the manufacturer to charge and recharge.
•When an extension cord is used:
– The marked rating of the detachable power supply cord or extension cord should be at least as great as the electrical rating of
this appliance.
– The cord should be arranged so that it will not drape over the countertop or tabletop where it can be tripped over, snagged, or
pulled on unintentionally (especially by children).
– The extension cord should be kept dry and off the ground.
WARNING: NEVER ATTEMPT TO USE THE AC TO DC CHARGING PORT AND THE 12 VOLT DC POWER AND CHARGING PORT
SIMULTANEOUSLY.
WARNING: FIRE HAZARD: Never contact combustible material to the lens and never tape or tie the switch in the on position.
CAUTION: TO REDUCE THE RISK OF INJURY OR PROPERTY DAMAGE:
•All lights give off heat:
– Do not touch lens while operating.
– Keep combustibles away from spotlight lens. Extreme heat can cause fires.
– Never place the light face down on any surface when lit, charging or not in use. Never store the light face down on any surface.
• Never look directly into the light or shine the light into another person’s eyes.
• Keep sharp objects away from lens — it is glass and can break.
• Do not immerse spotlight in water.
•Do not expose this unit to extremely high temperatures.
•Do not drop or throw spotlight. It contains glass and a lithium-ion battery.
•Use only with the charging adapter provided with unit. Plug in the charging adapter at the spotlight first, then plug into the
charging source.
•Do not overcharge: Recharge up to 6 hours maximum using the AC charging method; up to 4 hours maximum using the DC
charging method.
•After charging/recharging, disconnect charging adapter or extension cord and wait 5 minutes before use.
•Do not crush, cut, pull or expose charging adapter cords to extreme heat.
•Position charging adapter cords so they do not become entangled or become a safety hazard. Keep charging adapter cords away
from sharp edges.
•Use in a dry location only.
•There are no user-serviceable parts inside. Do not attempt to disassemble any other parts of the unit.
•To reduce risk of damage to electric plug and cord, pull by plug rather than cord when disconnecting.
•Do not attempt to charge the unit if the charger is damaged – return the charger to manufacturer for repair or replacement.
SPECIFIC SAFETY INSTRUCTIONS FOR LITHIUMION BATTERIES
WARNING: TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, BURST HAZARD, OR INJURY TO PERSONS OR PROPERTY:
Lithium-ion batteries are small, compact and ideal for providing long-lasting power to this unit. However, they must be used and
charged properly. Improper use can result in serious injury, fire, or death.
•Lithium-ion batteries can explode in the presence of a source of ignition. Do not use the product in the presence of an open
flame.
•Do not place this lithium-ion battery powered unit in fire or apply heat to it.
•Do not subject this lithium-ion battery powered unit to strong impacts or shocks. The battery in this unit contains safety and
protection devices which, if damaged, may cause the battery to generate heat, rupture or ignite.
•Do not expose this lithium-ion battery powered unit to water or salt water, or allow the battery to get wet.
•Avoid storing this lithium-ion battery powered unit in the basement, bathroom or other areas of the house that are or may become
wet.
•Do not leave this lithium-ion battery powered unit in direct sunlight, or use or store the unit inside cars in hot weather. Doing
so may cause the battery to generate heat, rupture, or ignite. Using the battery in this manner may also result in a loss of
performance and a shortened life expectancy.
•Never charge this unit near heat or flammable objects.
•NEVER THROW WATER ON A BURNING LI-ION BATTERY! If a lithium-ion battery does catch on fire, it will burn even
more violently if it comes in contact with water or even moisture in the air. A fire extinguisher must be used.
Battery Charging and Capacity
This unit is delivered in a partially charged state – you must fully charge it before using it for the first time.
When stored at room temperature with a full charge, Li-ion batteries will will begin to discharge from the time they are
manufactured, even when unused. Deep discharges also decrease their capacity. Battery life can be extended by the following:
•Charge battery to full capacity before storage.
•Store this unit at temperatures between 5°C and 20°C (41°F and 68°F).
•Never discharge the battery fully.
LIONLEDS_ManualENSP_073013.indd 4-5 7/30/2013 11:49:08 AM
Loading...