Stanley Errigal Installation And Operating Instructions Manual
Errigal Woodburning Range
SAFETY NOTICE
PLEASE READ THIS ENTIRE MANUAL BEFORE YOU INSTALL AND USE YOUR NEW COOK STOVE.
FAILURE TO FOLLOW INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE,
BODILY INJURY OR EVEN DEATH. SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.
IF THIS APPLIANCE IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. FOR YOUR SAFETY, FOLLOW THE INSTALLATION DIRECTIONS. CONTACT LOCAL BUILDING OR FIRE OFFICIALS
ABOUT RESTRICTIONS AND INSTALLATION INSPECTION REQUIREMENTS IN YOUR AREA.
THIS APPLIANCE MUST BE CONNECTED TO A LISTED, HIGH-TEMPERATURE RESIDENTIAL TYPE
AND BUILDING HEATING APPLIANCE CHIMNEY OR AN APPROVED MASONRY
CHIMNEY WITH FLUE LINER.
THE COMPLETE INSTALLATION MUST BE DONE IN ACCORDANCE WITH CURRENT STANDARDS AND
LOCAL CODES. IT SHOULD BE NOTED THAT THE REQUIREMENTS AND THESE PUBLICATIONS MAY
BE SUPERSEDED DURING THE LIFE OF THIS MANUAL.
THIS APPLIANCE IS HOT WHILE IN OPERATION AND RETAINS ITS HEAT FOR A LONG PERIOD OF
TIME AFTER USE. CHILDREN, AGED OR INFIRM PERSONS SHOULD BE SUPERVISED ATALL TIMES
AND SHOULD NOT BE ALLOWED TO TOUCH THE HOT WORKING SURFACES WHILE IN USE OR UNTIL
THE APPLIANCE HAS THOROUGHLY COOLED.
MANUFACTURED BY: WATERFORD STANLEY (MARKETING) LTD., BILBERRY, WATERFORD,
IRELAND.
ASSEMBLY INSTALLATION AND OPERATING INSTRUCTIONS
TABLE OF CONTENTS
PAGE
Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Installation Clearances to Combustibles. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Reduced Clearances. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Rear Exit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Floor Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Chimney . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Chimney Types USA. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Chimney Type Canada . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Chimney Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Chimney Connector USA Only . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Connecting to Masonry Chimney . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Thimbles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Chimney Connector Systems, Thimbles & Clearances From Combustible Walls . . . . . 6
Exploded View. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 & 8
Masonry Fireplace. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Ventilation & Combustion Air Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Efficient Economical Use Of Wood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Creosote - Formation & Need For Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Disposal Of Ashes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Hints On Fire Safety. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Fuels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Lighting The Fire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Controlling The Fire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
The Hotplate. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
The Oven . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Overnight Burning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Riddling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Flue Cleaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Chimney Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Use Of Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Vitreous Enamel Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Warming Shelf - Left or Right Hand Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Assembly Instructions - Warming Oven . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
1
1. Remove packing strip from the top of
the range. Place the sheet steel back
plate to one side. Remove all loose
components from the top of the range
and firebox and the oven. Remove the
oven door. Spread the components on
the floor so you can identify them easily.
2. Place cement blocks or other strong
supports about 458mm (13”) high
behind the range. Space the supports
behind it and lay the cooker on its back.
3. Fit the four legs (Part no. 36) to the four
base corners (Part no. 13) using the
hexagon-head bolts and washers. Note
that each of the front legs (No. 36) has
a screw hole in the front.
4. Lift the range off the supports. Stand it
upright without putting any strain on the
legs.
5. Join the two sections of the front skirting
together (Part Nos. 37 and 38) by
screwing the name plate (Part No. 51)
with its back fixing strip (Part No. 54)
into position between the two sections
and secure the two sections tightly to
the name plate.
6. Fit the complete skirting under the front
of the range inside the front legs using a
screw and nut to secure it to each leg.
7. Move the range into position for
installation. CAREFUL: Do not break a
leg!
8. Ensure that the cast iron fire liners (part
nos.44,46,47,48 & 49) are secure in the
firebox at the front, sides and back.
9. Place the oven damper in position (Part No.
63) on top of the oven and place the round
hotplate (Part No. 20) in position above it.
Place the oblong hotplate (Part No. 19) and
the two round cleaning cups (Part No. 15) in
position to complete the cooker top.
10. Place the top flue outlet (Part No. 55) in
position and fit its front cleaning door (Part
no. 56) in position.
11. Screw the towel rail brackets (Part Nos. 25
and 26) to the top front of the range (Part
No. 1) and fix the towel-rail (Part No.78) in
position between the brackets. Tighten up
the screws.
2
ASSEMBLY
Fig.1
Fig.2
Fig.3
12. Hang the fire door (Part No. 57) and the
ashpit door (Part No. 3) on their hinges.
13. Place the oven shelves in position (Part
No.12) the cast iron shelf below the sheet
steel shelf.
14. Place the cleaning door (Part No. 59) in
position beneath the oven door (Part No. 2).
15. Screw the splashback (Part No. 67) to its
two supports (Part Nos. 61 & 62) keeping
the folded end to the bottom. Screw the
plate rack (Part No. 88) to the splashback.
Screw the complete assembly on to the
cooker top (Part No. 18).
The Errigal Woodburning Range is equipped for top
flue connection. Should you wish to vent the range
to the rear the following modifications must be
undertaken:
1. Remove the top flue collar (item 1) and seal
the opening with the blanking plate (item 2)
provided.
2. Remove the small panel (item 3) from the
back of the range and the blanking plate
(item 4) which will now be visible.
3. Screw the rear flue collar (item 5) provided
to the back of the range.
3
Note: Platerack and Splashback is an optional
extra, not supplied as standard.
Fig.4
Fig.5
INSTALLATION
When installing, operating and maintaining a solid
fuel heater, respect basic standards of fire safety.
Read these instructions carefully before commencing the installation. Failure to do so may result in
damage to persons and property. Consult your local
municipal office, Fire Department and your insurance representative to determine what regulations
are in force.
INSTALLATION CLEARANCES TO
COMBUSTIBLES
Front 48” 1220mm
Back 16” 400mm
Oven Side 6” 150mm
Oven Side with Optional
Shelf Fitted 10” 250mm
Firebox Side 12” 300mm
Single Wall Flue Pipe 18” 460mm
REDUCED CLEARANCES
These clearances may be reduced by the application of protection to combustible walls and ceilings.
ULC/UL Labelled Heat Shields installed in accordance with the manufacturers instructions or shields
complying with the requirements of “Installation
Code for Solid Fuel Fired Appliances CAN31336” or
“Standard for Chimneys, Fireplaces and Ve n t s
NFPA No. 211.”
REAR EXIT
Back 6” 150mm
Oven side 6” 150mm
Firebox Side 12” 300mm
4
Fig.6
Fig.7
REAR EXIT
Fig.8
(2130mm)
(2130mm)
(300mm) (150mm)
(400mm)
(300mm)
(150mm)
(150mm)
(100mm)
(150mm) clearance or
less
(2130mm)
(225mm)
(200mm)
(2130mm)
(2130mm)
(460mm)
(300mm)
(250mm)
(300mm)
(150mm)
Loading...