ST VT5366 User Manual

Page 1
December 2006 Rev 1 1/21
UM0257
User manual
VT5366 wireless reference design mouse
Introduction
This user manual, along with the VT5366 datasheet will enable you to evaluate the 27MHz VT5366 Reference Design mouse and assist you in the design of your own VT5366 wireless mouse. If you have any questions, support can be obtained through the normal regional sales/support groups.
Kit contents
Reference design mouse, plus receiver
5 x VT5366V032 optical mouse sensor
3 x Lens/Aperture - see
Section 3
5 x LED
USB cable
CD containing datasheet and user manual s
www.st.com
Page 2
Contents UM0257
2/21
Contents
1 Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
1.1 27MHz Wireless mouse schematics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
1.2 Receiver schematics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
2 Bill of materials - Mouse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
2.1 Bill of materials - Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3 Optics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3.1 Manufacturers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3.2 Drawings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
4 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
4.1 How to us e the VT5366 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
4.2 RX/TX firmware . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
5 Revision history . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Page 3
UM0257 Hardware
3/21
1 Hardware
1.1 27MHz Wireless mouse schematics
Figure 1. Wireless mouse - VT5366 sensor
Page 4
Hardware UM0257
4/21
Figure 2. Wireless mouse - Microcontroller
Page 5
UM0257 Hardware
5/21
Figure 3. Wireless mouse - Power management
Page 6
Hardware UM0257
6/21
Figure 4. Wireless mouse - 27MHz transmitter
Page 7
UM0257 Hardware
7/21
1.2 Receiver schematics
Figure 5. Receiver - Microcontroller
5
5
4
4
3
3
2
2
1
1
D D
C C
B B
A A
To ICP - Mono-8
Connector
To ICP - MONO 8
AGND DGND
To ICP - MONO 8
MOUNTING HOLES
To ICP - MONO 8
In Circuit Programming (ICP) Interface
OPEN
OPEN
OPEN
SPA1005 B
DONGLE - JB16 & MC3361 21
B
TS
MC68HC908JB16
Tuesday, April 26, 2005
001
STMicroelectronics
SPA Marketing Application Center
This drawing is the property of STMicroelectronics and m ust
not be copied or reproduced in any way without the written
permission of STMicroelectronics
Design Name:
Sheet Name:
Drawn By:
Dwg. No:
Date:
Ver: Sheet Size:Rev:
SHEET OF
D+
D-
PTA0
PTA1
PTA2
PTA3
notRST
RF_DATA
notIRQ
PTE3
PTA6
PTA6
VREG
SLEEP
TG_NOTIRQ
RF_OFF
D+
PTA2
notIRQ
PTA3
notRST
PTA1
TG_NOTIRQ
PTA0
PTE3
RF_DATA
5VDD
5VDD
5VDD VDDA
5VDD
5VDD
U1
MC68HC908JB16_28pin
1
2
3
4
5
678
9
10
11
12
13
141516
17
181920
21
22
23
242526
27
28
VSS
OSC1
OSC2
VREG
VDD
PTD0
PTD1
PTD2
PTD3
PTD4
PTE1
PTE3/D+
PTE4/D-
PTC0
notIRQ
PTC1/RxD
PTD5
PTA7
PTA6
PTA5
PTA4
PTE2
PTE0
PTA3
PTA2
PTA1
PTA0
notRST
M2
R31 0
R5 10
R8
1M
C4
56pF
Q1
MMBT3906
EBC
R1
0
C6
0.56uF
R9
OPEN
SW1
1 2
M3
C5 22pF
R32 OPEN
R6 10
1
235
4
J1
miniUSB_5PIN_female
14523
AB
VBUS
GND
GND
D-
D+
AB
R12
10K
M4
C10
1nF
R10
OPEN
C7 22pF
C9
0.1uF
J3
ICP Mon o-8
16
2468101214
13579
111315
C2
0.1uF
R24
0
Y1
12 MHz
13
2
+
C8
4.7uF
Q2
MMBT3904
EBC
R2
10K
R13 10
R14 10k
R7
1M
J6
1
2
C3
56pF
M1
R11
1M
R4
1K5
Q3
MMBT3906
E
B
C
R3 10K
+
C1
10uF
R15 0
Page 8
Hardware UM0257
8/21
Figure 6. Receiver - MC3361
5
5
4
4
3
3
2
2
1
1
D D
C C
B B
A A
AGND
AGND
AGND
AGND
AGND
AGND
AGND
OPTION 1 OPTION 2
R25 - 0
R27 - 5.1K
C28 - 30pF
C23 - 100pF
C22 - 10nF
L2 - 10uH
R28, C21, L3, OPEN
R27 - 5.1K
R28 - 0
C21 - 270pF
C23 - 47pF
C28 - 82pF
L3 - 2.2uH
R25, C22, L2, OPEN
SPA1005 B
DONGLE - JB16 & MC3361 22
B
TS
MC3361
Tuesday, April 26, 2005
001
STMicroelectronics
SPA Marketing Application Center
This drawing is the property of STMicroelectronics and m ust
not be copied or reproduced in any way without the written
permission of STMicroelectronics
Design Name:
Sheet Name:
Drawn By:
Dwg. No:
Date:
Ver: Sheet Size:Rev:
SHEET OF
ANTENNA
RF_DATA
RF_DATA
VDDA
VDDA
VDDA
VDDA
VDDA
VDDA
VDDA
VDDA
U3
CFWS455B
12
3
45
R30
OPEN
C12
36pF
L2
10uH
C25 OPEN
R21 2k2
R27
5.1K
R25 0
TP0
1
C21
OPEN
R23
OPEN
C27
0.1uF
C17 100nF
R26 0
C19
22nF
C13
82pF
R18
39K
TP2
1
R29
OPEN
R28 OPEN
C22
10nF
C24
OPEN
R19 0
C18 100nF
L3
OPEN
C14 82pF
R20
680K
L1
7MC-8182Z
123
4
5
67
C11
470pF
+
C26
10uF
R16
0
R22
OPEN
C23
100pF
Y2
26.590MHz
1 2
C20
2.7nF
TP1
1
C15 470pF
TP4
1
J4
12
J5
12
C28
30pF
U2
MC3361BD_SO16
4
5
3
2
1
678
161514
13
12
11
10
9
VCC
LimiteInput
MixO ut
OSC_E
OSC_B
DECOUP_1
DECOUP_2
QuadCoil
MixInput
GND
MUTE
SCAN_CTL
SquelchInput
FilterOut
FilterIn
RecoAudio
R17 OPEN
TP3
1
C16
OPEN
Page 9
UM0257 Bill of materials - Mouse
9/21
2 Bill of materials - Mouse
Table 1. Bill of materials - Mouse
Reference Description Manufacturer Part number
U5 Optical mouse sensor STMicroelectronics VT5366V032 C1 1uF Ceramic Capacitor 0805 Standard component - many suppliers C25 10pF Ceramic Capacitor 0603 Standard component - many suppliers C29 15pF Ceramic Capacitor 0603 Standard component - many suppliers C28,C40,C41,C50 22pF Ceramic Capacitor 0603 Standard component - many suppliers C27 51pF Ceramic Capacitor 0603 DigiKey 511-1131-1-ND C24 56pF Ceramic Capacitor 0603 Standard component - many suppliers C22 82pF Ceramic Capacitor 0603 Standard component - many suppliers C20 100pF Ceramic Capacitor 0603 Standard component - many suppliers C21,C26 150pF Ceramic Capacitor 0603 Standard component - many suppliers C23 300pF Ceramic Capacitor 0603 DigiKey 511-1149-1-ND C16,C17,C1 8 1nF Ceramic Capacitor 0603 Standard component - many s uppliers C19 4n7F Ceramic Capacitor 0603 Standard component - many suppliers C4 47nF Ceramic Capacitor 0603 Standard component - many suppliers C5,C10,C11,C14 100nF Ceramic Capacitor 0603 Standard component - many suppliers C31,C32 0.1uF Tantalum Capacitor Case A Standard component - many suppliers C12,C13,C30,C33 10uF Tantalum Capacitor Case B Standard component - many suppliers C9 47uF Tantalum Capacitor Case D Standard component - many suppliers C8 100uF Tantalum Capacitor Case D Standard component - many suppliers Q1,Q3,Q4,Q5,Q8 NPN Small Sign al Transistor, SOT23 STMicroe le ctro nic s BC847B Q7 PNP Small Signal Transistor SOT23 STMicroelectronics MMBT3906 D3 5mm high brightness Red LED Avago HLMP-ED27-TW000 D2 BAR63J Pin Diode, SOD-323 Standard component - many suppliers U3 1V Synchronous Step Up Convertor STMicroelectronics L6920 U1 Microcontroller, 28 pin Wide SOIC FreeScale MC68HC908JL3ECDW U4 1v8 Regulator, SOT23-5L STMicroelectronics LD2980CM18TR Y2 6MHz 3 pin resonator, internal caps Farnell 116-1706 Y1 16Mhz 3 pin resonator, internal caps Rapid Electronics 90-0680
L1
15µH Surface Mount Inductor DO1608 Series
Standard component - many supp liers
L2 0.33µH Axial Inductor C30 - 0.25W Farnell 117-3896
TX1
13.5225MHz Low Profile HS49 Crystal
Standard component - many supp liers
Page 10
Bill of materials - Mouse UM0257
10/21
R1,R2,R6,R14, R15,R27,R28,R29, R30,R40,R44,R50, R51,R55
0R Resistor 0603 1/16W 5% Standard component - many suppliers
R9,R16,R17,R18, R19,R20
10R Resistor 0603 1/16W 5% Standard component - many suppliers
R32 27R Resistor 0603 1/16W 5% Standard component - many suppliers R26 680R Resistor 0603 1/16W 5% Standard component - many suppliers R3,R4,R23,R33,
R46,R54
4K7 Resistor 0603 1/16W 5% Standard component - many suppliers
R53 10K Resistor 0603 1/16W 5% Standard component - many suppliers R21 33K Resistor 0603 1/16W 5% Standard component - many suppliers R10,R22 100K Resistor 0603 1/16W 5% Standard component - many suppliers R25 150K Resistor 0603 1/16W 5% Standard component - many suppliers R11 200K Resistor 0603 1/16W 5% Standard component - many suppliers R5,R13 470K Resistor 0603 1/16W 5% Standard component - many suppliers R12 680K Resistor 0603 1/16W 5% Standard component - many suppliers R7,R8,R31 1M Resistor 0603 1/16W 5% Standard component - many suppliers
S6
Subminiature PCB mounted Slide Switch, SPDT vertical 2.54mm pitch
Farnell 674-345
SW4,SW5 Sealed Key Switch (SMD) B3S1000 Farnell 177-807 SW1,SW2,SW3 Miniature Micro switch Standard component - many suppliers SW6 Mechanical encoder (scroll-wheel) Alps EC10E Series
J1
2 x 8 Double Row PCB 0.1 ” header plug
Rapid Electronics 22-0595
C2,C3,C6,C7,R34, R35,R36,R43,C45, C46,R47,R52,R56, J6
NOT FITTED
Table 1. Bill of materials - Mouse (continued)
Reference Description Manufacturer Part number
Page 11
UM0257 Bill of materials - Mouse
11/21
2.1 Bill of materials - Receiver
Table 2. Bill of materials - Receiver
Reference Description Manufacturer Part number
C28 30pF Ceramic Capacitor 0603 DigiKey 511-1125-1-ND C12 36pF Ceramic Capacitor 0603 DigiKey 511-1127-1-ND C3,C4 56pF Ceramic Capacitor 0603 Standard component - many suppliers C13,C14 82pF Ceramic Capacitor 0603 Standard component - many suppliers C23 100pF Ceramic Capacitor 0603 Standard component - many suppliers C11,C15 470pF Ceramic Capacitor 0603 Standard component - many suppliers C10 1nF Ceramic Capacitor 0603 Standard component - many suppliers C20 2n7F Ceramic Capacitor 0603 DigiKey 511-1167-1-ND C22 10nF Ceramic Capacitor 0603 Standard component - many suppliers C19 22nF Ceramic Capacitor 0805 Standard component - many suppliers C9 100nF Ceramic Capacitor 0805 Standard component - many suppliers C2,C17,C18,
C27
100nF Ceramic Capacitor 0603 Standard component - many suppliers
C6 0.56uF Ceramic Capacitor 0603 DigiKey PCC1912CT-ND C8 4.7uF Miniature electrolytic cap Standard component - many suppliers C1,C26 10uF 16V Miniature electrolytic cap Standard component - many suppliers
Q2
MMBT3904 NPN Small Signal Transistor SOT23
STMicroelectronics MMBT3904
Q1,Q3
MMBT3906 PNP Small Signal Transistor SOT23
STMicroelectronics MMBT3906
U1
68HC908JB16 Microcontrol ler, 28 pin Wide SOIC
FreeScale MC68HC908JB16DWE
U2
MC3361BD Low power narrowband FM IF
Toko TK83361M-G
U3 CFWS455B Filter Toko BLFYS455B Y1 12Mhz 3 pin resonator, internal caps Rapid Electronics 90-0645 Y2 26.590Mhz Low Profile HS49 Crystal Standard component - many suppliers L1 7MC-8128Z Inductor Toko 7MC-8128Z L2 10uH Axial Inductor C30 - 0.25W Farnell 106-222 R1,R15,R16,R19,
R24,R25,R26,R31
0R Resistor 0603 1/16W 5% Standard component - many suppliers
R5,R6,R13 10R Resistor 0603 1/16W 5% Standard component - many suppliers R4 1K5 Resistor 0603 1/16W 5% Standard component - many suppliers R21 2K2 Resistor 0603 1/16W 5% Standard component - many suppliers R27 5K1 Resistor 0603 1/16W 5% Standard component - many suppliers
Page 12
Bill of materials - Mouse UM0257
12/21
R2,R3,R12,R14 10K Resistor 0603 1/16W 5% Standard component - many suppliers R18 39K Resistor 0603 1/16W 5% Standard component - many suppliers R9,R10 100K Resistor 0603 1/16W 5% Standard component - many suppliers R20 680K Resistor 0603 1/16W 5% Standard component - many suppliers R7,R8,R11 1M Resistor 0603 1/16W 5% Standard component - many suppliers
J6
2 way single row PCB 0.1 header plug
Farnell 102-2263
J3 2x8 double row PCB 0.1” header plug Farnell 973-3680
J1
Mini USB connector type B PCB (T/H)
Farnell 978-6465
SW1 B3S1000 Sealed Ke y switch (SMD) Fa rnell 177-807 C5,C7,C16,C21,
C24,C25,R17,R22, R23,R28,R29,R30, R32,L3,J4,J5
Not Fitted
Table 2. Bill of materials - Receiver (continued)
Reference Description Manufacturer Part number
Page 13
UM0257 Optics
13/21
3 Optics
3.1 Manufacturers
STMicroelectronics has worked with optical component suppliers to produce a single piece light guide with integrated lens. The kit contains 3 pieces. For more information please contact the individual supplier.
MaxEmil Photonics Corporation 7F, 135, Lane 235, Bao Chiao Road, Hsintien City, Taipei, Taiwan Tel: 886-2-89191179 Fax: 886-2-89191178 http://www.maxemil.com.tw
Note: STMicroelectronics supply MaxEmil optics with their reference design mice.
3.2 Drawings
Note: Optics footprint in the base is available in IGES format
Page 14
Optics UM0257
14/21
Figure 7. Exploded view
A
B
C
D
E
F
A
B
C
D
E
F
Sheet
Scale
RevNo
Revision note Date Checked
2
1 345
6
78
1
3
2 768
Title
Material
Finish
Tolerances, unless otherwise stated
Linear
0 Place Decimals 0 ±1.0
1 Place Decimals 0.0 ±0.10
2 Place Decimals 0.00 ±0.07
Angular ±0.25 degrees
Diameter +0.10/-0.00
Position 0.10
Surface Finish 1.6 microns
Interpret drawing per BS308, 3RD Angle Projection
All dimensions in mm
This drawing is the property of STMicroelectronics
and will not be copied or loaned without the
written permission of STMicroelectronics.
Drawn
Checked
Appd. Mech.
Appd. Elect.
Appd. Prod.
Appd. Q.A.
Sig. Date
Part No.
All dimensions
in mm
Do Not Scale
ECN No.
Home, Personal Communication Sector - Imaging Division
Mouse Base
Sensor Package
LED
PCB
Aperture
Exploded View
4 of 4
Lens and Light Guide
STMicroelectronics
Page 15
UM0257 Optics
15/21
Figure 8. MaxEmil optics
Page 16
Optics UM0257
16/21
Figure 9. MaxEmil aperture
Page 17
UM0257 Optics
17/21
Figure 10. Cross section
C
SECTION J-J
SCALE 4 : 1
LED
The distance from the LED lens surface
and the light pipe lens surface must
always be between 0.1 and 0.4mm
PCB
Package
Aperture
Lens Set
Mouse Base
OTQFP
Mouse Mat
D
7.50
8.60
1
2.20
DETAIL C
SCALE 8 : 1
1.50
±0.08
±0.06
7
±0.141.02
0
.
0
5
0
.
0
5
9
0.60
0.86
0.42 ±0.085
1
6
°
DETAIL D
SCALE 8 : 1
A
B
Datum A is the PCB Surface
All dimensions
A
B
C
D
E
F
A
B
C
D
E
F
Sheet
Scale
RevNo
Revision note Date Checked
2
1
3
4
5
6
78
1
3
2
7
6
8
Title
Material
Finish
Tolerances, unless otherwise stated
ECN No.
Do Not Scale
in mm
Appd. Prod.
Part No.
Position
Sig. Date
Appd. Q.A.
This drawing is the property of STMicroelectronics
+0.10/-0.00
Surface Finish 1.6 microns
Interpret drawing per BS308, 3RD Angle Projection
All dimensions in mm
0.10
written permission of STMicroelectronics.
and will not be copied or loaned without the
Linear
0 Place Decimals 0 ±1.0
1 Place Decimals 0.0 ±0.10
2 Place Decimals 0.00 ±0.07
Angular ±0.25 degrees
Diameter
Drawn
Checked
Appd. Mech.
Appd. Elect.
Home, Personal & Communication Sector - Imaging Division
STMicroelectronics
Page 18
Optics UM0257
18/21
Figure 11. Sensor package
16
L
R
Keepout Area
DBS 190204
Top View
Sensor LED mounted on the underside of the PCB.
Detail E
E
9.80
15
3
.
2
0
10
1.40 Typ2
42.75
4.90
Package Centre
SCALE 8 : 1
3 of 4
DETAIL E
Array centre verses package centre
Top View
Array Centre
0.2430
0.2150
All dimensions
A
B
C
D
E
F
A
B
C
D
E
F
Sheet
Scale
RevNo
Revision note Date Checked
2
1
3
4
5
6
78
1
3
2
7
6
8
Title
Material
Finish
Tolerances, unless otherwise stated
ECN No.
Do Not Scale
in mm
Appd. Prod.
Part No.
Position
Sig. Date
Appd. Q.A.
This drawing is the property of STMicroelectronics
+0.10/-0.00
Surface Finish 1.6 microns
Interpret drawing per BS308, 3RD Angle Projection
All dimensions in mm
0.10
written permission of STMicroelectronics.
and will not be copied or loaned without the
Linear
0 Place Decimals 0 ±1.0
1 Place Decimals 0.0 ±0.10
2 Place Decimals 0.00 ±0.07
Angular ±0.25 degrees
Diameter
Drawn
Checked
Appd. Mech.
Appd. Elect.
Home, Personal & Communication Sector - Imaging Division
STMicroelectronics
Page 19
UM0257 General
19/21
4 General
4.1 How to use the VT5366
1. Turn the mouse on using the black sliding switch located on the bottom of the mouse.
2. Connect the receiver to the PC via USB cable provided.
3. Press the connect button on the receiver (SW1) and the connect button on the mouse (at the same time). The mouse will now be connected.
4. The reset button on the mouse cycles the power of the mouse i.e., has the same affect as turning the mouse off/on.
Figure 12. Connect/reset and power
4.2 RX/TX firmware
The VT5366 mouse/receiver firmware is available on request, please contact your normal regional sales/support group.
Page 20
Revision history UM0257
20/21
5 Revision history
Table 3. Document revision history
Date Revision Changes
06-Dec-2006 0.1 Initial release.
Page 21
UM0257
21/21
Please Read Carefully:
Information in this document i s provided solely in connecti on with ST product s. STMicroelec tronics NV and it s subsidiari es (“ST”) res erve the right to make changes, c or recti ons , modif icat ions or improveme nt s, t o this documen t, and the prod ucts an d s ervices desc rib ed herein a t an y time, without notice.
All ST products are sold pursuan t to ST’s terms and conditions of sale. Purchasers are solely responsible for the choice, selection and use of the ST products and services described herein, and ST assumes no
liability whatsoever relating to the choice, selection or use of the ST products and services described herein. No license, express or impl ied, by estoppel or otherwise, t o any intellectual property righ ts is granted under this document. If any part of this
document refers to any third party products or services it shall not be deemed a license grant by ST for the use of such third party products or services, or any intellectual property contained therein or considered as a warranty covering the use in any manner whatsoever of such third party products or services or any intellectual property contained therein.
UNLESS OTHERWISE SET FORTH IN ST’S TERMS AND CONDITIONS OF SALE ST DISCLAIMS ANY EXPRESS OR IMPLIED WARRANTY WITH RESPECT TO THE USE AND/OR SALE OF ST PRODUCTS INCLUDING WITHOUT LIMITATION IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE (AND THEIR EQUIVALENTS UNDER THE LAWS OF ANY JURISDICTION), OR INFRINGEMENT OF ANY PATENT, COPYRIGHT OR OTHER INTELLECTUAL PROPERTY RIGHT.
UNLESS EXPRESSLY APPROVED IN WRITING BY AN AUTHORIZED ST REPRESENTATIVE, ST PRODUCTS ARE NOT RECOMMENDED, AUTHORIZED OR WARRANTED FOR USE IN MILITARY, AIR CRAFT, SPACE, LIFE SAVING, OR LIFE SUSTAINING APPLICATIONS, NOR IN PRODUCTS OR SYSTEMS WHERE FAILURE OR MALFUNCTION MAY RESULT IN PERSONA L INJURY, DEATH, OR SEVERE PROPERTY OR ENVIRONMENTAL DAMAGE. ST PRODUCTS WHICH ARE NOT SPECIFIED AS "AUTOMOTIVE GRADE" MAY ONLY BE USED IN AUTOMOTIVE APPLICATIONS AT USER’S OWN RISK.
Resale of ST products with prov isions differen t from the statem ents and/or technic al features set forth in this document shall i mmediately void any warranty granted by ST for the ST product or service described herein and shall not create or extend in any manner whatsoever, any liability of ST.
ST and the ST logo are trademarks or r egistered trademarks of ST in various countries.
Information in this document supers edes and replaces all information previously supplied.
The ST logo is a registered trademark of STMicroelectronics. All other names are the property of their respective owners.
© 2006 STMicroelectronics - All rights reserved
STMicroelectronics group of companies
Australia - Belgium - Brazil - Canada - China - Czech Republic - Finland - France - Germany - Hong Kong - India - Israel - Italy - Japan -
Malaysia - Malta - Morocco - Singapore - Spain - Sweden - Switzerland - United Kingdom - United States of America
www.st.com
Loading...