STEVAL-IFP019V1
Quad high-side smart-power solid-state relay demonstration board based on the VNI4140K-32
Data brief
Features
■Output current: 1 A per channel
■Shorted load protections
■Junction overtemperature protection
■Case overtemperature protection for thermal independence of the channels
■Thermal case shutdown non-simultaneous restart for the various channels
■Protection against loss of ground
■Current limitation
■Undervoltage shutdown
■Open drain diagnostic outputs
■3.3 V CMOS/TTL compatible inputs
■Fast demagnetization of inductive loads
■Conforms to IEC 61131-2
■RoHS compliant
Description
The STEVAL-IFP019V1 demonstration board shows the features of the VNI4140K-32 quad high-side smart-power solid-state relay.
The application offers robustness and complies with EMC industrial standards. It implements short-circuit/overload protection and also thermal management, achieving best-in-class MTBF values. The reference design is suitable for use in programmable logic controllers (PLCs) as well as to drive generic loads which require up to 1 A of nominal current (the typical current limitation is
1.1 - 2.6 A). Thanks to the very low RDS(on) (only 80 mΩ typical @ 25 °C per channel) the device
allows very low power consumption during operation and for this reason it offers an ideal solution for IP65 / IP67 requirements. The VNI4140K-32 is compliant with IEC 61131-2 (international standard for programmable controllers).
December 2011 |
Doc ID 022565 Rev 1 |
1/5 |
For further information contact your local STMicroelectronics sales office. |
www.st.com |
2/5 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
1 |
Schematic |
|
|
|
|
|
|
|
|
|
6$$ |
|
|
|
|
|
|
|
|
|
|
# |
|
# |
circuit Schematic |
-STEVAL circuit |
|
|
|
|
|
|
|
|
|
). |
|
|
|
|
|
). |
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
N& |
N& |
|||||||||
|
|
|
34!4 |
|
|
|
|
|
). |
|
|
|
|
|
). |
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
|
|
|
|
|
|
34!4 |
|
|
|
|
34!4 |
|
|
|
|
|
|
|
|||
). |
|
|
|
|
|
|
|
|
34!4 |
|
|
|
|
34!4 |
|
|
|
|
|
|
|
|||
6$$ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
). |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
). |
|
|
|
|
|
|
|
|
|
|
|
* |
|
|
|
|
|
|
|
|
|
|
||
). |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
#!. |
|
|
|
|
|
|
|
|
|
|
|||||
34!4 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
34!4 |
|
|
|
|
|
|
22 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
+ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
34!4 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
/0%. |
|
|
|
|
|
|
||
|
* |
|
|
|
|
|
|
|
!! |
|
|
* |
|
|
|
|
!! |
* |
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
&/2 |
|
|
|
|
||||||||
|
|
|
|
|
|
|
|
" |
|
|
|
|
|
|
" |
|
|
|||||||
|
%6!,#/--"/!2$ |
|
|
|
|
|
|
|
|
|
|
# |
# |
/6, 4%34 |
|
6DC |
||||||||
|
|
|
|
|
|
|
|
|
|
6CC $)3# 4%34 |
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
'.$ |
SchematicFigurecircuit1. |
||||||
|
|
|
|
|
|
|
|
|
|
|
|
/2 |
|
N& |
U& |
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
4!" |
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
#522%.402/"% |
|
|
|
|
$ |
|
- |
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||
). |
|
|
|
|
|
|
|
|
|
|
|
)# |
|
|
|
3-4!# |
-6)4%" |
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
6CC |
|
6CC |
|
|
|
|
|
|
|
|
|
|
|
||||||
). |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
4 |
|
|
|
|
|
|
|
|
|
|
|
|
4 |
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
). |
|
|
|
/54?A |
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
). |
|
|
|
|
|
|
|
|
|
/54?B |
|
|
|
|
|
|
|
|||||||
|
|
|
|
4 |
|
|
|
|
|
|
|
# |
|
|
|
|
|
|
||||||
|
|
|
|
|
|
). |
|
|
|
/54?C |
|
|
|
4 |
|
|
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
N& ,6 |
|
|
|
|
|
||||||
). |
|
|
|
|
|
|
). |
|
|
|
/54?A |
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||
|
22 |
|
|
|
4 |
|
|
|
|
|
|
/54?B |
|
|
|
|
|
|
|
|||||
|
|
|
|
). |
|
|
|
|
# |
|
|
|
|
|
|
|||||||||
|
+ |
|
|
|
|
|
|
6.)+ |
/54?C |
|
|
4 |
|
|
|
|||||||||
|
|
/04 |
|
|
|
|
|
|
|
|
N& ,6 |
|
|
|
|
|||||||||
|
|
|
|
4 |
|
|
|
|
|
|
/54?A |
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||
|
|
|
4,0 |
|
|
|
|
|
|
|
|
/54?B |
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
# |
|
|
|
|
|
||||||
|
|
|
|
|
|
|
34!4 |
|
|
|
/54?C |
|
|
|
|
/54 |
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
N& ,6 4 |
|
|
|
|
/54 |
||||
|
|
|
|
|
|
|
34!4 |
|
|
|
/54?A |
|
|
|
|
|
|
/54 |
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||
34!4 |
|
|
|
|
|
|
|
|
|
/54?B |
|
|
|
|
|
/54 |
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
34!4 |
|
|
|
/54?C |
|
|
|
|
|
- |
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
34!4 |
|
|
|
|
|
|
|
34!4 |
|
$.' |
|
|
|
|
|
|
|
|
|
-6)4%" |
||||
|
|
|
|
4 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
34!4 |
|
|
|
|
|
|
|
|
|
|
|
6.)+ |
|
$, $, $, $, |
|
|||||||||
|
|
|
|
|
4 |
|
|
|
|
|
|
|||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
,%$ |
|
,%$ |
,%$ |
,%$ |
|
||||||
|
|
|
|
|
|
!!" |
|
|
|
|
|
|
|
|
||||||||||
34!4 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
22 |
|
||||
|
|
|
|
|
|
4 |
|
|
|
* |
|
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
+ |
|
||||||
|
|
|
|
|
|
|
|
|
|
|
'.$ $)3# 4%34 |
|
|
|
|
|
|
|
|
|||||
22 |
|
|
/04 |
|
22 |
|
4 |
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
4,0 |
|
+ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
+ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
Rev022565IDDoc1 |
|
|
|
|
|
|
|
|
|
|
|
|
|
#,6N& |
|
|
|
|
|
|
||||
6$$ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
IFP019V1 |
V-! |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|