HVLED815PF
Offline LED driver with primary-sensing and high power factor up to 15 W
Features
■High power factor capability (> 0.9)
■800 V, avalanche rugged internal 6 Ω Power MOSFET
■Internal high-voltage startup
■Primary sensing regulation (PSR)
■+/- 5% accuracy on constant LED output current
■Quasi-resonant (QR) operation
■Optocoupler not needed
■Open or short LED string management
■Automatic self supply
Datasheet − production data
SO16N
Applications
■AC-DC LED driver bulb replacement lamps up to 15 W, with high power factor
■AC-DC LED drivers up to 15 W
Table 1. |
Device summary |
|
||
Order code |
Package |
Packaging |
||
|
|
|
||
HVLED815PF |
SO16N |
Tube |
||
|
|
|
||
HVLED815PFTR |
Tape & Reel |
|||
|
||||
|
|
|
|
Description
The HVLED815PF is a high-voltage primary switcher intended for operating directly from the rectified mains with minimum external parts and enabling high power factor (> 0.90) to provide an efficient, compact and cost effective solution for LED driving. It combines a high-performance lowvoltage PWM controller chip and an 800 V, avalanche-rugged Power MOSFET, in the same package. There is no need for the optocoupler thanks to the patented primary sensing regulation (PSR) technique. The device assures protection against LED string fault (open or short).
July 2012 |
Doc ID 023409 Rev 1 |
1/17 |
This is information on a product in full production. |
www.st.com |
Contents |
HVLED815PF |
|
|
Contents
1 |
Principle application circuit and block diagram . . . . . . . . . . . . . . . . . . |
. 3 |
|
|
1.1 |
Principle application circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
3 |
|
1.2 |
Block diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
5 |
2 |
Pin description and connection diagrams . . . . . . . . . . . . . . . . . . . . . . . |
6 |
|
|
2.1 |
Thermal data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
6 |
3 |
Electrical specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
7 |
|
|
3.1 |
Absolute maximum ratings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
7 |
|
3.2 |
Electrical characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
7 |
4 |
Device description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
12 |
|
5 |
Package information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
13 |
|
6 |
Revision history . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
16 |
2/17 |
Doc ID 023409 Rev 1 |
1 |
Principle application circuit and block diagram |
HVLED815PF |
|
1.1 |
Principle application circuit |
||
|
|
|
|
|
|
Lin (330uH - 820uH) |
|
|
|
T1 |
|
O utpout D iode |
Vout |
|
|
|
|
|
|
|
|
|
|
VIN |
|
1 |
10 |
|
J1 |
|
|
|
|
|
3 |
|
|
|
|
|
2 |
9 |
|
CON1 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
Bridge Diode |
|
|
|
|
|
|
|
|
R12 |
|
|
|
|
|
|
+ |
|
|
|
|
|
3 |
8 |
C12 |
C13 |
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
F1 |
1A_DIP |
2 |
|
1 |
|
|
|
|
4 |
|
|
Minimum Load |
|
|
J2 |
|
|
|
|
|
|
|
|
Cout Bulk |
Cout SMD |
|
||
|
CON1 |
|
|
|
Cin47nF)(22nF- / |
Cin47nF)(22nF- / |
Csn(1nF)ubber |
Rsn(120k)ubber |
|
|
7 |
|
|
|
Doc |
|
|
|
- |
|
5 |
6 |
|
J3 |
|
||||
|
|
|
|
TRANSFORMER |
CON1 |
|
||||||||
ID |
|
|
|
4 |
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
||
1 Rev 023409 |
J4 |
|
|
|
|
|
|
S nubber D iode |
|
|
|
|
|
|
CON1 |
|
|
|
|
|
|
|
C10 |
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|||
VIN |
|
|
Rsense |
|
U1 |
|
|
|
|
|
|
Principle |
||
|
|
|
HVLED8xxPF |
|
Y1 - SAFETY |
|
|
|||||||
|
|
|
Rsense |
|
1 |
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|||||
RA |
|
|
|
SOURCE |
16 |
|
|
|
|
|
||||
|
|
|
|
R1 (1k8-2k2) |
|
DRAIN |
|
|
|
|
|
|||
|
|
|
|
CS 2 |
|
|
|
|
|
|
||||
|
|
|
220pF-330pF |
CS |
15 |
|
|
|
|
|
||||
|
|
|
|
|
DRAIN |
|
|
|
|
|
|
application |
||
|
RB |
C_Vcc (10uF) |
VCC |
3 |
14 |
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
VCC |
DRAIN |
|
|
|
|
|
|
|
|
COS Filter (1uF) |
|
|
|
|
4 |
13 |
|
|
|
|
|
|
|
|
|
|
|
|
|
GND |
DRAIN |
|
|
|
|
|
|
|
|
ROS |
C_ILED |
(10uF) |
|
5 |
|
CS |
RPF |
D 4 |
|
|
|
||
|
|
|
|
|
|
ILED |
|
|
|
|
|
|
|
|
|
|
CS |
|
Rf b |
DMG 6 |
|
DMG |
|
Rdmg |
|
|
|
circuit |
|
|
|
|
|
|
|
DMG |
|
|
|
|
|
|
|
|
|
|
|
Rf (8.2k-15k) |
Cf (330nF/680nF) |
7 |
|
|
|
|
|
|
|
||
|
|
|
|
|
|
COMP |
|
VCC |
|
D 2 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
and |
||
|
|
|
|
|
NA 8 |
|
|
1N 4148 |
|
|
|
|||
|
|
|
|
|
|
|
|
R-VCC (10ohm) |
|
|
|
|||
|
|
|
|
Cp (1nF/10nF) |
N.A. |
|
C_VCC (470nF) |
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
block |
3/17 |
|
|
|
|
|
|
|
|
|
|
|
|
AM13207v1 |
diagram |
|
|
|
|
|
|
|
|
|
|
|
|
|
4/17 |
Figure 2. |
Principle application circuit for standard LED driver |
|
|
|
|
|
|
Principle |
||||
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
VIN |
|
T2 |
10 |
O utpout D iode1 |
Vout |
application |
|
|
|
|
|
|
|
|
1 |
|
J5 |
and circuit |
||
|
|
|
3 |
|
|
|
|
|
2 |
9 |
|
CON1 |
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
|
|
Bridge Diode |
|
|
|
|
|
|
8 |
|
R16 |
|
|
|
|
+ |
|
|
snubber (1nF) |
|
nubber (120k) |
3 |
C15 |
C23 |
||
|
|
|
|
|
|
|
|||||||
|
|
F2 |
1A_DIP |
|
C22 |
|
4 |
|
|
Minimum Load |
|||
|
J7 |
|
2 |
1 |
|
|
|
7 |
Cout Bulk |
Cout SMD |
|||
|
CON1 |
|
|
|
Cin |
|
|
|
|
||||
|
|
|
- |
|
|
|
5 |
6 |
|
J6 |
|||
|
|
|
|
|
|
C |
|
Rs |
|
|
|
CON1 |
diagram block |
|
|
|
|
|
|
|
|
TRANSFORMER |
|||||
|
|
|
4 |
|
|
|
|
|
|||||
|
J8 |
|
|
|
|
|
S nubber D iode |
|
|
|
|
||
023409 ID Doc |
CON1 |
|
|
|
|
|
C21 |
|
|
|
|||
|
|
|
|
|
|
|
|
|
|||||
|
|
Rsense |
|
U2 |
|
|
|
|
|
||||
|
|
|
HVLED8xxPF |
Y1 - SAFETY |
|
|
|||||||
|
|
Rsense |
|
1 |
|
|
|
||||||
|
|
|
|
|
|
|
|
||||||
|
|
|
|
SOURCE |
16 |
|
|
|
|
||||
|
|
|
|
|
DRAIN |
|
|
|
|
||||
|
|
|
|
2 |
|
|
|
|
|
||||
|
|
|
|
CS |
15 |
|
|
|
|
||||
|
|
|
|
|
DRAIN |
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
||||
1 Rev |
|
|
C_Vcc (10uF) |
VCC |
3 |
14 |
|
|
|
|
|
|
|
|
|
|
|
VCC |
DRAIN |
|
|
|
|
|
|
|
|
|
|
|
|
4 |
13 |
|
|
|
|
|
|
|
|
|
|
|
|
|
GND |
DRAIN |
|
|
|
|
|
|
|
|
|
|
C_ILED (10uF) |
|
5 |
|
|
|
|
|
|
|
|
|
|
|
|
|
ILED |
|
|
|
|
|
|
|
|
|
|
|
Rf b |
DMG 6 |
|
DMG |
Rdmg |
|
|
|
|
||
|
|
|
|
|
DMG |
|
|
|
|
|
|
|
|
|
|
|
Rf (8.2k-15k) |
Cf (330nF/680nF) |
7 |
|
|
|
|
|
|
|
|
|
|
|
|
|
COMP |
|
VCC |
|
D 6 |
|
|
|
|
|
|
|
|
NA 8 |
|
|
|
1N 4148 |
|
|
|
|
|
|
|
|
|
|
|
|
R-VCC (10ohm) |
|
|
|
|
||
|
|
|
Cp (1nF/10nF) |
N.A. |
|
C_VCC (470nF) |
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
AM13208v1 |
HVLED815PF |
|
|
|
|
|
|
|
|
|
|
|
|
|
1 Rev 023409 ID Doc
5/17
+ VIN
VCC |
HV start-up & |
|
|
|
Supply Logic |
DRAIN
LED
Vref
PROTECTION &
FEEDFORWARD
LOGIC
|
|
DEMAG |
|
|
|
|
|
LOGIC |
|
DRIVING |
|
RDMG |
|
|
|
|
|
DMG |
CONSTANT |
LOGIC |
|
||
|
|
||||
|
|
|
|
||
|
|
CURRENT |
|
|
|
|
|
REGULATION |
|
|
|
RFB |
|
3.3 V |
|
|
|
|
VILED |
VCS |
|
|
|
|
|
Vref |
|
OCP |
1 V |
|
|
|
|
|
|
|
|
Constant Voltage |
|
|
RA |
|
|
Regulation |
|
|
|
COMP |
ILED |
GND |
CS |
R1 |
SOURCE |
|
|||||
RCOMP |
CLED |
|
|
|
|
|
|
|
|
|
|
CCOMP |
|
|
|
|
RSENSE |
|
|
|
|
|
|
|
|
RPF |
|
ROS |
|
AM13209v1
HVLED815PF
diagram block and circuit application Principle
Pin description and connection diagrams |
HVLED815PF |
|
|
SOURCE |
11 |
16 |
|
|
DRA |
|
INN |
|
|
|
|
|
|||||
|
|
|
|
|||||
CS |
2 |
15 |
|
|
DRA |
|
INN |
|
|
|
|
|
|||||
|
2 |
15 |
|
|
|
|
|
|
VCC |
3 |
14 |
|
|
DRA |
|
INN |
|
|
3 |
14 |
|
|
|
|
|
|
GND |
4 |
13 |
|
|
DRA |
|
INN |
|
|
4 |
13 |
|
|
|
|
|
|
ILED |
5 |
12 |
|
N.C. |
||||
|
5 |
12 |
|
|
|
|
|
|
DMG |
6 |
11 |
|
N.A. |
||||
|
6 |
11 |
|
|
|
|
|
|
COMP |
7 |
10 |
|
N.A. |
||||
|
7 |
10 |
|
|||||
N.A. |
88 |
9 |
|
N.A. |
AM13210v1
2.1Thermal data
Table 2. |
Thermal data |
|
|
Symbol |
Parameter |
Max. value |
Unit |
|
|
|
|
RthJP |
Thermal resistance, junction-to-pin |
10 |
°C/W |
RthJA |
Thermal resistance, junction-to-ambient |
110 |
°C/W |
PTOT |
Maximum power dissipation at TA = 50 °C |
0.9 |
W |
TMAX |
Maximum junction temperature |
150 |
°C |
TSTG |
Storage temperature range |
-55 to 150 |
°C |
TJ |
Junction temperature range |
-40 to 125 |
°C |
6/17 |
Doc ID 023409 Rev 1 |