MODEL#MSC-3782-BM
Rosemead Metal Swing Set
OWNER’S MANUAL
ASSEMBLY INSTRUCTIONS, CARE, MAINTENANCE AND USER’S GUIDE
FOR RESIDENTIAL USE ONLY
WARNING
⚫ This product is designed to be used simultaneously by up to 7 children between ages 3 to 8.
⚫ Maximum weight of each user is 100lbs(45.5kg). Combined weight of all users must not exceed
700lbs(318.5kg).
⚫ Carefully read this entire instruction manual before you start to assemble or use this swing set.
⚫ You must follow all instructions and warnings while using this equipment.
⚫ Constant adult supervision required.
⚫ Do not use this swing set on hard packed soil, concrete, or any kind of hard surface.
⚫ This equipment must be anchored (anchors not included). You should consult your local contractor
regarding the best way to anchor the product in your location of installation.
⚫ Assembly requires at least two adults.
Save this instruction manual for future reference
For Customer Service, please call 1-866-370-2131 or visit www.sportspowerltd.net
Monday – Friday 9:00 AM – 5:00 PM Eastern Time
Sportspower Ltd.
Flat M, Kaiser Estate Phase 3, 11 Hok Yuen Street, Hunghom, Kowloon, Hong Kong
Corporate Office 1-800-497-6106
2
INTRODUCTION
Dear Valued Customer,
Congratulations on your Sportspower play set purchase! Please read and completely understand the
contents of this owner’s manual. This manual contains specific instructions and warnings that must be followed
to prevent injuries.
This play set is for residential use only. This play set is NOT intended for public or commercial use. The
warranty will be voided if the play set is used in a commercial application.
The product is designed for children between the ages of 3-8. Children must NOT play on this set until it is
properly assembled and inspected by an adult. Adult supervision is required at all times while children are
playing on the equipment. Do not allow children under six (6) years old to be near during the assembly of this
product due to choking hazards of small parts.
The equipment must be installed on level ground. Uneven ground must be leveled prior to installation.
Installation on sloping or uneven ground will put stress on the joints, causing the unit to become loose and
unstable which may result in serious injuries. You must ensure there are no obstructions or structures (e.g.
electrical wires, branches, house, fence, garage, etc) within six (6) feet from the equipment.
The Consumer Product Safety Commission’s Outdoor Home Playground Safety Handbook recommend to
install and maintain the playground equipment over at least 9 inches of wood chips, mulch or shredded rubber (for
equipment up to 8 feet high) or sand or pea gravel (for equipment no more than 5 feet high) as shock absorbing
material. Dirt and grass, which are the most prevalent surfaces under home playground equipment, do not
adequately protect children from serious head injuries. Install protective surfacing at least six feet in all
directions from play equipment. For swings, the surface should extend, in back and front, twice the height of the
suspending bar. Do not install your play set over hard surface, e.g. asphalt, concrete, packed earth, tile or brick
floor. Please refer to extracts from the CONSUMER PRODUCT SAFETY COMMISSION’S OUTDOOR HOME
PLAYGROUND SAFETY HANDBOOK contained in this manual for further details.
Do not allow children to use the product during windy or wet weather conditions. It is highly recommended the
product be anchored into the ground to prevent movement and to make the swing set more stable during use.
You should consult a local contractor about ways to anchor the product in your location.
The equipment must be checked before each use and maintained regularly. This includes, but is not limited
to inspecting the play set for cracks, excess wear, missing parts, loose connections and for overall integrity.
When the equipment shows any signs of weakness or damage, you must stop using the play set immediately,
properly store the set or restrict access by users until the condition is resolved.
Your product is warranted against defects in material and workmanship. Extended warranty is also
offered to those customers registering their products at www.sportspowerltd.net within 14 days from the
date of purchase. Please refer to our warranty policy at the back of this manual for details.
If you experience any problems with your product, do not return to the store. For customer service,
please call 1-866-370-2131 Monday-Friday 9:00am-5:00pm Eastern Time. If you are unable to reach us at
this number for any reason, please visit www.sportspowerltd.net.
3
IMPORTANT INSTRUCTIONS AND WARNINGS
WARNING
READ ALL INSTRUCTIONS BEFORE ASSEMBLING OR USING THIS EQUIPMENT
AGE LIMIT
⚫ This product is designed to be used by up to seven (7) children between the ages of 3 to 8. Maximum user
weight is 100 pounds (45.5kg) each with a combined maximum weight of 700 pounds (318.5kg).
⚫ The play set is designed for children over three (3) years of age. Use by smaller children can result in
entrapment.
⚫ On-site adult supervision is required at all times for children of all ages.
⚫ Do not allow use by children with any physical condition that may affect his/her ability to use this equipment
safely.
BEFORE YOU BEGIN
⚫ Carefully read all instructions in this manual before assembling and using this product.
⚫ The unit must be assembled by adults. Heavy duty working gloves must be worn to avoid injuries during
assembly.
⚫ Children must not use the equipment until it is properly assembled and anchored.
⚫ Adult supervision is required during the use of this equipment at all times.
⚫ Unpack all parts. Take a complete inventory of all parts and hardware using the parts and hardware lists in the
following pages. If any parts are missing, do not return to the store. Please call customer service toll-free
number listed on the cover page for assistance. Store the product back in the original box and do not begin to
install until all parts are obtained.
LOCATION OF PLAY SET
⚫ The equipment must be placed more than six(6) feet(1.8 meter) from any structures or obstructions, including
but not limited to buildings, fence, garage, trees, laundry lines, electrical wires. Children can be seriously
injured running or swinging into obstacles.
⚫ The play set must be installed on level ground. Uneven ground must be leveled prior to installation.
Installation on sloping or uneven ground will put stress on the joints, causing the unit to become loose and
unstable which may result in serious injuries.
⚫ Remove any tripping hazards from the safe play area, such as roots, tree stumps, rocks, landscaping,
sprinkler heads, railroad ties, plumbing and electrical connections.
4
Do not install your play set over hard surface, e.g. asphalt, concrete, packed earth, tile or brick floor. A fall
onto a hard surface can result in serious injury or death to the user. The following is a list of recommended
ground covers from the Consumer Product Safety Commission:
SUGGESTED MATERIAL UNCOMPRESSED DEPTH
Double Shredded Bark Mulch 9”
Uniform Wood Chips 12”
Fine Gravel 12”
Fine Sand 12”
The Consumer Product Safety Commission’s Outdoor Home Playground Safety Handbook recommend to
install and maintain the playground equipment over at least 9 inches of wood chips, mulch or shredded
rubber (for equipment up to 8 feet high) or sand or pea gravel (for equipment no more than 5 feet high) as
shock absorbing material. Dirt and grass, which are the most prevalent surfaces under home playground
equipment, do not adequately protect children from serious head injuries. Install protective surfacing at least six
feet in all directions from play equipment. For swings, the surface should extend, in back and front, twice the
height of the suspending bar. You should consult a local contractor about ways to secure the product in your
location. Do not install your play set over hard surface, e.g. asphalt, concrete, packed earth, tile or brick floor.
Please refer to the CONSUMER PRODUCT SAFETY COMMISSION’S OUTDOOR HOME PLAYGROUND
SAFETY HANDBOOK for detailed guidelines to prevent injuries from falls and other hazards on public and
home playgrounds.
WARNINGS ON ANCHORING
It is highly recommended the product be anchored into the ground to prevent movement and to make the swing
set more stable during use.
Some consumers want an anchoring system that allows the product to be moved to different locations. Other
consumers want to keep their swing set in a permanent location.
There are different types and different methods of anchoring this product. Sportspower does not make a specific
anchoring recommendation as each consumers need and conditions can vary.
It is highly recommended that you seek the opinion from a local licensed contractor on the best way to secure the
swing set in your location. The best way to anchor a product is to create a concrete footing and use that as a base
for an anchor. Whatever method you prefer for your location, an anchoring system for this product should be used
at all times.
WEATHER CONDITIONS
⚫ DO NOT use this equipment if the swing seat, slide or any parts are wet. Use the play set only when the parts
are clean and dry. If the equipment is wet, the user could slip and suffer injuries.
⚫ Please be aware of weather conditions when using the equipment. If it is too windy, users could lose control
and suffer injuries. The playground equipment must be properly anchored, stored away or restricted from use
during inclement weather such as heavy winds or severe weather storms. You should consult a local
contractor about ways to anchor the product in your location.
PLAY SUPERVISION
⚫ DO NOT allow more than one child to play on the individual swing or slide component at any one time. The
maximum user limit for the flying saucer and glide ride is two persons.
⚫ DO NOT allow children to stand on the slide, swing seats, flying saucer or glide ride.
⚫ DO NOT allow children to walk too close to moving parts. ALWAYS keep a safe distance to avoid being
struck by other children while playing on swings, slides, trampolines etc.
5
⚫ DO NOT allow children to twist the swing chains or ropes, or loop them over the top support bar as this may
reduce the strength of the chain or rope.
⚫ DO NOT swing empty seats as this may cause injuries.
⚫ ALWAYS guide children to sit in the center of swinging parts, with their full weight placed in the seat center
and holding on to the swing chains.
⚫ DO NOT allow children to jump off the equipment while it is in motion. ALWAYS come to a full stop before
dismounting.
⚫ ALWAYS dress children appropriately for proper play, e.g. wear well-fitted rubber sole shoes, and remove
loose or sharp items such as jewelry, hair accessories, scarves which may become entangled in the
equipment or cause injuries.
⚫ ALWAYS make sure children remove their bike or other sports helmets before playing on the playground.
⚫ DO NOT allow children to slide down the slide head first.
⚫ DO NOT allow children to climb onto swing or jump to/from different play areas of the equipment.
⚫ ALWAYS return safely to the ground before approaching another play area.
⚫ DO NOT allow children to climb on structural parts (e.g. legs, top bar). These are structural components
and are not designed for play.
⚫ ALWAYS check the slide or other parts exposed to the body for extreme heat from the sun before allowing
children to use the equipment.
⚫ ALWAYS prevent access and secure from any unauthorized use when there is no adult supervision.
⚫ DO NOT allow pets or other animals near the equipment to prevent damage or injuries.
INSPECTION PRIOR TO EACH USE OR DAILY INSPECTION
⚫ DO NOT use the equipment if any bolts or nuts are missing or loose. ALWAYS check to ensure the
equipment and all parts are well secured and stable before each use.
⚫ ALWAYS clear the play area of any rocks, sharp objects, or any materials that could be potentially hazardous
to users.
⚫ DO NOT attach items to the equipment that are not specifically designed for use with the equipment,
including, but not limited to, jump ropes, clothesline, pet leashes, cables and chains as they may cause
choke hazards.
⚫ The steel and plastic parts used in your product are subject to normal wear. Gradual deterioration of the
material will occur, the speed of which will depend on the level of exposure to UV rays, airborne pollution,
outdoor weather conditions such as rain and wind and the amount of use. You must inspect the equipment
prior to every use. This includes, but is not limited to inspecting the set for cracks, excess wear, missing
parts, loose connections, and for overall integrity. When the set shows any signs of weakness, you must
stop using the play set immediately, properly store the set or restrict access by users until the condition is
resolved.
⚫ Verify that the suspended climbing ropes, chain or cable are secured at both ends and tightened, so that
there is no loose ropes, chain or cable hanging that can result in choking hazard.
When conducting inspections, it is recommended that you use the Suggested General Maintenance
Checklist and Routine Inspection and Maintenance Issues checklists provided by the US Consumer
Product Safety Commission, a copy of which is contained in this user manual.
CARE & MAINTENANCE INSTRUCTIONS
⚫ Inspect all nuts and bolts twice monthly during the usage season for tightness and tighten as required. It is
particularly important that this procedure is followed at the beginning of each season.
⚫ Oil all metallic moving parts monthly during the usage period.
⚫ Sand rusted areas on metal tubing and repaint using a nonlead-based paint meeting the requirements of Title
6
16 CFR Part 1303.
⚫ Check swing seats, ropes, cables and chains monthly during usage season for deterioration. Replacements
should be made in accordance with the manufacturer’s instructions.
⚫ Check all coverings for bolts and sharp edges twice monthly during usage season to be certain that they are
in place and replace when necessary. It is especially important to do this at the beginning of each new
season.
⚫ Do not use when the temperature drops below 32 degrees F (0 degrees C); remove and store the plastic
swing seats and slides indoors.
⚫ Owners shall be responsible for maintaining the legibility of the warning labels.
7
IMPORTANT
CONSUMER INFORMATION SHEET
The Consumer Product Safety Commission estimates there are more than 200,000 playground related injuries
involving children each year. Injuries involving this hazard pattern tend to be among the most serious of all playground
injuries and have the potential to be fatal, particularly when the injury is to the head. The surface under and around
playground equipment can be a major factor in determining the injury-causing potential of a fall. It is self evident that a
fall onto a shock absorbing surface is less likely to cause a serious injury than a fall onto a hard surface. Playground
equipment should never be placed on hard surfaces such as concrete or asphalt and while grass may appear to be
acceptable it may quickly turn to hard packed earth in areas of high traffic. Shredded bark, mulch,,wood chips, fine sand
or fine gravel are considered to be acceptable shock absorbing surface when installed and maintained at a sufficient
depth under and around playground equipment.
Table below lists the maximum height from which a child would not be expected to sustain a life-threatening head injury
in a fall onto four different loose-fill surfacing materials if they are installed and maintained at depths of 6” (15.25CM), 9”
(22.9CM), and 12” (30.5CM).
However,it should be recognized that all injuries due to falls cannot be prevented no matter what surfacing material is
used.
We recommend that a shock absorbing material should extend a minimum of 6ft in all directions from the perimeter of
stationary equipment such as climbers and slides. However, because children may deliberately jump from a moving
swing, the shock absorbing material should extend in the front and rear of a swing a minimum distance of 2 times the
height of the pivot point measured from a point directly beneath the pivot on the supporting structure.
This information is intended to assist in comparing the relative shock-absorbing properties of various materials. No
particular material is recommended over another. However, each material is only effective when Properly maintained.
Materials should be checked periodically and replenished to maintain correct depth as determined necessary for your
equipment. The choice of a material depends on the type and height of the playground equipment, the availability of the
material in your area and its cost.
Note: The maximum fall height for this product is 6 feet. The minimum ground Clearance between the bottom of the
suspended plays and the playing or ground service must be 8 inches.
This information has been extracted from the CPSC publication on" Playground Safety". You can obtain more information by sending a postcard to
the: Office of public Affairs，U.S. Consumer Product Safety Commission，Washington，D.C.20207
8
ANCHORING
(NOTE:ANCHORS ARE NOT INCLUDED-MUST BE PURCHASED SEPARATELY)
There are different ways of anchoring the equipment, depending on the type of ground on which the
equipment is to be installed. Make sure that all anchors are below ground level to prevent tripping.
You should consult your local contractor to decide the most appropriate way to anchor the
equipment in your location.
The following anchoring options may be considered:
Corkscrew Anchoring (Corkscrew Anchors not included)
⚫ If your soil is hard (clay, etc.), the corkscrew method may be suitable.
⚫ Be sure that the swing set is located on level ground.
⚫ Twist the corkscrew anchor into the ground until only the end with the hook is above the ground
and next to the leg. Insert the hook into the bottom opening of the leg.
Ensure that the hook is secured onto the leg opening.
Concrete Anchoring (Materials not included)
● If the swing set is set up on grounds with sandy soil (soft) condition, it must be anchored
with concrete footing (concrete not included)
● Be sure that the swing set is assembled and placed on level ground
● Dig holes around swing leg tube, as shown in drawing in the next page. As you dig
deeper, enlarge the diameter of the hole to fix the cement
● Place 2 inches of brick or gravel underneath the leg, as shown in drawing in the next
page
● Use about 45 lbs. of concrete per leg
● Cover the concrete with dirt and protective surface material
● Allow 6-7 days for the concrete to dry properly
9
Note: The maximum fall height for this product is 6 feet. The minimum ground
clearance between the bottom of the suspended plays and the playing or
ground surface must be 8 inches.
You must maintain a minimum of 8 inches of ground clearance.
WARNING
Please properly anchor the swing set to minimize the risk of injury or death.
If the swing set is used without proper anchoring, it may be dangerous and
may tilt over.
Loading...