Speed Queen STB30EG Tumbler-Dryer Parts Diagram

Drying Tumblers

T025C_M414056

30 Pound Capacity (31.5 Inches Wide)

Refer to Page 5 for Model Numbers

Parts

www.comlaundry.com

Part No. M414056R12

February 2012

Table of Contents

Title Page

Parts Ordering Information........................................................................................................................................ 3

Serial Plate Location ................................................................................................................................................. 3

Model Identification ................................................................................................................................................... 5

Control Panel Assembly - Non-CE Manual Timer Models ........................................................................................ 6

Control Panel Assembly - CE Manual Timer Models ................................................................................................ 8

Control Panel Assembly - Non-CE Coin Drop Models ............................................................................................ 10

Control Panel Assembly - CE Coin Drop Models.................................................................................................... 12

Control Panel Assembly - Coin Slide Models.......................................................................................................... 14

OPL 24 Volt Micro Control ...................................................................................................................................... 16

Single Coin Meter ................................................................................................................................................... 18

Dual Coin Meter ...................................................................................................................................................... 20

Coin Vault and Vault Guide Assembly .................................................................................................................... 22

Meter Case ............................................................................................................................................................. 24

Accumulator ............................................................................................................................................................ 26

Control Thermostat, Door Switch, Transformer, Relay and Diode Logic Board...................................................... 28

Door Switch - CE Models ........................................................................................................................................ 30

Loading Door Assembly .......................................................................................................................................... 32

Top and Front Panels ............................................................................................................................................. 34

Lint Panel and Compartment .................................................................................................................................. 36

Cylinder and Trunnion Assemblies ......................................................................................................................... 38

Chain Drive Components ........................................................................................................................................ 40

Belt Drive Components ........................................................................................................................................... 42

Idler Housing Assembly .......................................................................................................................................... 44

Fan and Motor Assembly ........................................................................................................................................ 46

Fan Motors.............................................................................................................................................................. 48

Airflow Switch and Vane Assembly......................................................................................................................... 50

Cabinet High Limit Thermostat (EG), Chain Guard, Damper Vane and Junction Box............................................ 52

Burner Assembly for Standing Pilot Ignition............................................................................................................ 54

Gas Valve Components for Standing Pilot Ignition ................................................................................................. 56

Burner Assembly for Automatic Pilot Ignition .......................................................................................................... 58

Vertical and Horizontal Ignition Systems ................................................................................................................ 60

Gas Valve Components for Automatic Pilot Ignition ............................................................................................... 62

Burner Assembly for Glow-Bar Ignition - Johnson Control...................................................................................... 64

Gas Valve Components for Glow-Bar Ignition - Johnson Control........................................................................... 66

Burner Assembly for Glow-Bar Ignition - White Rodgers Control ........................................................................... 68

Gas Valve Components for Glow-Bar Ignition - White Rodgers Control................................................................. 70

Burner Assembly for Instant Electronic Ignition ...................................................................................................... 72

Gas Valve Assembly for Dungs/B-M System.......................................................................................................... 74

Channel/Johnson Gas System ............................................................................................................................... 76

Burner Assembly for Australian Models.................................................................................................................. 78

Electric Heater Assembly ........................................................................................................................................ 80

© Copyright 2012, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any

means without the expressed written consent of the publisher.

M414056 1

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Electrical Contactor Box Assembly - Models Through Serial No. 9408xxxxx.........................................................82

Electrical Contactor Box Assembly - Models Starting Serial No. 9408xxxxx .......................................................... 84

Solenoid Steam Valve (Asco) ................................................................................................................................. 86

Steam Heater and Valve Assembly (Danfoss)........................................................................................................ 88

Warning Labels - Rear of Tumbler.......................................................................................................................... 90

Warning Labels - Front of Tumbler ......................................................................................................................... 92

Contactor Box Assembly for Electric Manual Timer and Coin Drop Models (Drawing 1 of 3) ................................ 94

Contactor Box Assembly for Electric Manual Timer and Coin Drop Models (Drawing 2 of 3) ................................ 96

Contactor Box Assembly for Electric Manual Timer and Coin Drop Models (Drawing 3 of 3) ................................ 98

Contactor Box Assembly for Gas Manual Timer Models ...................................................................................... 100

Contactor Box Assembly for Gas Coin Drop Models ............................................................................................ 102

Contactor Box Assembly for Steam Manual Timer Models (Drawing 1 of 2) ........................................................ 104

Contactor Box Assembly for Steam Manual Timer Models (Drawing 2 of 2) ........................................................ 106

Contactor Box Assembly for Steam Coin Drop Models ........................................................................................ 108

Burner Orifice........................................................................................................................................................ 110

Wire Harnesses and Wires ................................................................................................................................... 111

Parts Index............................................................................................................................................................ 113

2 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Parts Ordering Information

T294IE3C_M414056

If literature or replacement parts are required, con­tact the source from whom the machine was pur­chased or contact Alliance Laundry Systems at
[phone] for the name and address of the
nearest authorized parts distributor.

Serial Plate Location

When calling or writing about your product, be
sure to mention model and serial numbers. Model
and serial numbers are located on serial plate(s)
as shown.

For technical assistance, call either of the num­bers listed below:

[phone] Ripon, Wisconsin
[phone] Wevelgem, Belgium

M414056 3

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Notes

4 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Model Identification

Information in this manual is applicable to these tumbler models:

DCB30CE
DCB30CG
DCB30CSH
DCB30CSL
DT30CE
DT30CG
DT30CGI
DT30CSH
DT30CSL
DT30EG

DT30EGI
DTB30CE
DTB30CG
DTB30CSH
DTB30CSL
DTB30EG
JCB30CE
JCB30CG
JCB30CSH
JCB30CSL

JT30CE
JT30CG
JT30CGI
JT30CSH
JT30CSL
JT30EG
JT30EGI
JTB30CE
JTB30CG
JTB30CSH

JTB30CSL
JTB30EG
SCB30CE
SCB30CG
SCB30CSH
SCB30CSL
ST30CE
ST30CG
ST30CGI
ST30CSH

ST30CSL
ST30EG
ST30EGI
STB30CE
STB30CG
STB30CSH
STB30CSL
STB30EG

M414056 5

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - Non-CE Manual Timer Models

T019P_M414056

6 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - Non-CE Manual Timer Models

REF PART NO. DESCRIPTION COMMENTS

1 M400527 Resistor Assembly 2 required; 208-240 Volt; Electric models

1 M410992 Resistor Assembly 208-240 Volt machines with Mallory timer

2 N/A Wire Harness Assembly 480 Volt; Electric models

2 M403924P Control Panel Wire Harness Assembly All other models

3 M400785P Timer Cool-down; Greenwald
4 M400793 Timer Motor Greenwald
5 M410900P Timer Kit Cool-down; Mallory; Replaces Robert Shaw timer
6 M400787P Timer Drying; Greenwald; 30 minute

6 M400791P Timer Drying; Greenwald; 60 minute

7 M400794P Motor Greenwald; 30 minute; Replacement

7 M400609 Timer Motor Greenwald; 60 minute

8 M410901P Timer Kit Drying; Mallory; 60 minute; Replaces Robert Shaw timer

9 51780 Screw
10 M400912P Relay Gas models

10 M400911P Relay Electric models

11 M402917 Screw Ground
12 N/A Electrical Components Tray
13 M401302 Control Panel Retainer Right
14 N/A End Cap
15 N/A Control Panel Assembly DT models

15 N/A Control Panel Assembly JT Energy Saver models
15 M402236 Control Panel Assembly JT standard models
15 N/A Control Panel Assembly All other JT models
15 N/A Control Panel Assembly ST gas models; 120 Volt
15 N/A Control Panel Assembly ST gas and electric models; 208-240 Volt
15 N/A Control Panel Assembly ST electric models; 480 Volt
15 N/A Control Panel Assembly All other ST models

16 M411052 Screw
17 M410927 Knob JT models starting Serial No. 9205015887

17 M400773 Knob All other models

18 N/A Light Gas models

18 N/A Pilot Light Electric models

19 M400072 Screw
20 M405750 Pop Rivet
21 33562 Screw
22 M401301 Control Panel Retainer Left
23 44106901P Push-to-Start Switch Kit
24 N/A Terminal Block
25 M400071 Screw
26 N/A Fishpaper

;

N/A = Part no longer available

M414056 7

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - CE Manual Timer Models

T416PZ3B_M414056

5

1

0

1

5

0

0

20

1

0

30

40

50

60

1)

2)

3

)

4)

8 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - CE Manual Timer Models

REF PART NO. DESCRIPTION COMMENTS

1 N/A End Cap

2 M401301 Control Panel Retainer

3 M405750 Pop Rivet

4 N/A Emergency Stop Switch

5 N/A Indicator Light

6 M412230 Contact Block

7 N/A Timer Drying; 60 minute; 24 Volt

8 M412079P Timer Cooling; 15 minute; 24 Volt

9 M401302 Control Panel Retainer Right and center
10 M411052 Screw
11 M400773 Knob DC and SC models

11 M410927 Knob JC models

12 N/A Pushbutton
13 N/A Control Panel Assembly SC models

13 N/A Control Panel Assembly JC models
13 N/A Control Panel Assembly DC models

N/A = Part no longer available

M414056 9

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - Non-CE Coin Drop Models

T020P_M414056

10 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - Non-CE Coin Drop Models

REF PART NO. DESCRIPTION COMMENTS

1 M401301 Control Panel Retainer Left

2 M405750 Pop Rivet

3 M400527 Resistor Assembly 2 required; 208-240 Volt; Electric models

4 N/A Bracket

5 N/A Terminal Block

6 M400071 Screw

7 M402917 Screw Ground

8 44106901P Push-to-Start Switch Kit

9 M403924P Control Panel Wire Harness Assembly
10 M401302 Control Panel Retainer Right and center
11 M402508-12 Coin Meter South Africa; .20

11 M402508-14 Coin Meter Japan; 100 yen
11 N/A Coin Meter Australia; .20
11 N/A Coin Meter France; 2 new francs
11 M402508-34 Coin Meter Denmark; 1 krone
11 M402508-36 Coin Meter Token; STD-118-1
11 N/A Coin Meter Canada; .25; Order M405138P Coin Meter
11 M402508-45 Coin Meter Spain; 25 peseta
11 N/A Coin Meter Token; STD-118-1
11 M405138P Coin Meter USA and Canada; $0.25/10 minutes

12 N/A End Cap
13 M400672 Nut
14 N/A Shadow Box
15 M404151 Run Light
16 M400072 Screw
17 N/A Control Panel Assembly JT Energy Saver models; 120 Volt

17 M402670 Control Panel Assembly JT Energy Saver models; All other voltages
17 N/A Control Panel Assembly JT models starting Serial No. 9205015887
17 N/A Control Panel Assembly All other JT models
17 N/A Control Panel Assembly ST gas models
17 N/A Control Panel Assembly All other ST models; Black
17 N/A Control Panel Assembly All other ST models; Silver

18 33562 Screw

N/A = Part no longer available

M414056 11

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - CE Coin Drop Models

T417PZ3B_M414056

1

)

2)

3)

12 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - CE Coin Drop Models

REF PART NO. DESCRIPTION COMMENTS

1 N/A End Cap

2 M401301 Control Panel Retainer Left

3 M405750 Pop Rivet

4 N/A Indicator Light

5 M412230 Contact Block

6 M400672 Nut

7 M401302 Control Panel Retainer Right and center

8 N/A Shadow Box

9 N/A Pushbutton
10 N/A Control Panel Assembly SC models

10 N/A Control Panel Assembly JC models

N/A = Part no longer available

M414056 13

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - Coin Slide Models

T021P_M414056

14 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Panel Assembly - Coin Slide Models

REF PART NO. DESCRIPTION COMMENTS

1 M401301 Control Panel Retainer Left

2 M405750 Pop Rivet

3 N/A Bracket

4 M402917 Screw Ground

5 N/A Wire Harness Assembly

6 44106901P Push-to-Start Switch Kit

7 M401302 Control Panel Retainer Right

8 M404151 Run Light

9 N/A Control Panel Assembly S models

9 N/A Control Panel Assembly J models

10 33562 Screw
11 N/A End Cap

N/A = Part no longer available

M414056 15

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

OPL 24 Volt Micro Control

T382PZ3D_M414056

OM Models

16 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

OPL 24 Volt Micro Control

REF PART NO. DESCRIPTION COMMENTS

1 M413417 Microprocessor Overlay STB nonreversing models

1 N/A Microprocessor Overlay STB reversing models

1 N/A Microprocessor Overlay DCB and SCB nonreversing models

1 N/A Microprocessor Overlay DCB and SCB reversing models

1 N/A Microprocessor Overlay JT and JTB nonreversing models

1 N/A Microprocessor Overlay JTB reversing models

1 M413423 Microprocessor Overlay JCB nonreversing models

1 N/A Microprocessor Overlay JCB reversing models

1 M413425 Microprocessor Overlay DTB nonreversing models

1 M413426 Microprocessor Overlay DTB reversing models

2 N/A Hole Plug

3 70228401P Control Kit 24 Volt

4 M414104 Fuse 2 Amp; Located on back of control

5 M412645 Jumper Wire Assembly

6 M413677 Micro Harness Assembly

7 M413559P Sensor Cable Harness Nonreversing

7 N/A Sensor Cable Harness Assembly Reversing

8 430497 Screw

9 70054 Nut
10 M413738 Micro Mounting Assembly

N/A = Part no longer available

M414056 17

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Single Coin Meter

T022P_M414056

18 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Single Coin Meter

REF PART NO. DESCRIPTION COMMENTS

1 M402508-12 Coin Meter South Africa; .20

1 M402508-14 Coin Meter Japan; 100 yen

1 N/A Coin Meter Australia; .20

1 N/A Coin Meter France; 2 new francs

1 M402508-34 Coin Meter Denmark; 1 krone

1 M402508-36 Coin Meter Token; STD-118-1

1 N/A Coin Meter $.25

1 M402508-45 Coin Meter Spain; 25 peseta

1 N/A Coin Meter Token; STD-118-1

1 M405138P Coin Meter USA; $.25

2 M405138B Return Spring

3 M402455 Coil Spring

4 M400609 Timer Motor

5 M400947 Switch Heat; Switch “B”

6 N/A Single Throw Switch Run; Switch “A”

7 M400734P Timing Cam 2 pin; 30 minute

7 M400735P Timing Cam 3 pin; 20 minute

7 M400736P Timing Cam 4 pin; 15 minute

7 M400737P Timing Cam 5 pin; 12 minute

7 M400738P Timing Cam 6 pin; 10 minute

7 M400739P Timing Cam 7 pin; 8.5 minute

7 M400740P Timing Cam 8 pin; 7.5 minute

7 M400741P Timing Cam 9 pin; 6.6 minute

7 M400732P Timing Cam 10 pin; 6 minute

7 M400733P Timing Cam 12 pin; 5 minute

8 M406297 Coin Retainer Spring Screw not included

9 M405138A Coin Carrier Spring
10 M400754 Coin Meter Drive

N/A = Part no longer available

M414056 19

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Dual Coin Meter

T023PZ3B_M414056

20 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Dual Coin Meter

REF PART NO. DESCRIPTION COMMENTS

1 M400746 Return Spring

2 N/A Single Throw Switch Run

3 M400947 Switch Heat

4 M400734P Timing Cam 2 pin; 30 minute

4 M400735P Timing Cam 3 pin; 20 minute

4 M400736P Timing Cam 4 pin; 15 minute

4 M400737P Timing Cam 5 pin; 12 minute

4 M400738P Timing Cam 6 pin; 10 minute

4 M400739P Timing Cam 7 pin; 8.5 minute

4 M400740P Timing Cam 8 pin; 7.5 minute

4 M400741P Timing Cam 9 pin; 6.6 minute

4 M400732P Timing Cam 10 pin; 6 minute

4 M400733P Timing Cam 12 pin; 5 minute

5 M400754 Coin Meter Drive

6 M400609 Timer Motor

7 N/A Index Lever Spring

N/A = Part no longer available

M414056 21

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Coin Vault and Vault Guide Assembly

T024P_M414056

22 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Coin Vault and Vault Guide Assembly

REF PART NO. DESCRIPTION COMMENTS

1 N/A Key Order by key code from price list (M401701-M401790)

2 N/A Vault Lock and Key Assembly Order by key code from price list (M401581-M401640)

3 M400972 Shadow Box Clip

4 N/A Coin Chute

5 N/A Coin Vault Guide Assembly Short; Models through Serial No. 9401xxxxx

5 44102801 Coin Vault Assembly Long; Models starting Serial No. 9402xxxx; Uses

M411994 Screw

6 N/A Screw

7 M400974 Clip

8 M400131P Shadow Box and Clip

9 N/A Coin Drawer Assembly

N/A = Part no longer available

M414056 23

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Meter Case

T025P_M414056

Coin Slide Models

24 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Meter Case

REF PART NO. DESCRIPTION COMMENTS

1 27260P Lock Kit Not supplied with meter case

2 54612 Key Not supplied with meter case

3 20274 Nut

4 M400014 Washer

5 35774 Washer

6 35917 Washer

7 503673 Screw

8 52909 Screw

9 03203 Screw
10 35798LP Service Door Assembly Almond

10 35798WP Service Door Assembly White

11 N/A Meter Case Locking Bracket
12 N/A Meter Case Assembly
13 N/A Bolt
14 20279 Washer
15 M405931 Hinge Assembly
16 51780 Screw
17 61031 Coin Slide Extension
18 N/A Screw
19 33562 Screw
20 N/A Coin Slide Escutcheon

N/A = Part no longer available

M414056 25

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Accumulator

T299PZ3A_M414056

Coin Slide Models

26 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Accumulator

REF PART NO. DESCRIPTION COMMENTS

1 M403422P Accumulator Dual switch

2 53261 Spring

3 M400609 Timer Motor 1 hour; 1/60

4 M400947 Switch B switch; Heat

5 N/A Single Throw Switch A switch; Run

6 53240 Timing Cam 3 pin

6 53241 Timing Cam 4 pin

6 M400239 Timing Cam 5 pin

6 53242 Timing Cam 6 pin

6 53243 Timing Cam 9 pin

7 N/A Pawl Spring

8 53239 Ratchet Wheel

N/A = Part no longer available

M414056 27

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Control Thermostat, Door Switch, Transformer,

T027P_M414056

Relay

and Diode Logic Board

28 M414056

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT